COBHAM SAILOR 60 GX Communication System Manuals

Manuals and User Guides for COBHAM SAILOR 60 GX Communication System. We have 3 COBHAM SAILOR 60 GX Communication System manuals available for free PDF download: Installation Manual

COBHAM SAILOR 60 GX Installation Manual (192 pages)

Brand: COBHAM | Category: Antenna | Size: 9 MB

Table of Contents
8
Chapter 1 About this Manual

14
- Intended Readers
  
  14
- Manual Overview
  
  14
- Software Version
  
  14
- Typography
  
  15
- Precautions
  
  15
Chapter 2 Introduction

16
- SAILOR 600 VSAT Ka System
  
  16
  - Overview
    16
  - Above Deck Unit (ADU)
    18
  - Antenna Control Unit (ACU)
    21
  - VSAT Modem
    22
  - Satellite Type Approvals
    23
  - Service Activation
    23
- Part Numbers and Options
  
  23
Chapter 3 Installation

24
- What's in the Box
  
  24
  - To Unpack
    24
  - Initial Inspection
    24
  - Tools Needed
    25
  - Transport of the Antenna
    25
- Site Preparation
  
  26
- Installation of the ADU
  
  40
  - Prerequisites
    40
  - Overview
    40
  - To Install the ADU
    42
  - To Ground the ADU
    44
  - Alternative ADU Cable
    45
- Installation of the ACU
  
  46
  - To Install the ACU
    46
  - To Ground the ACU
    46
- Installation of the Modem
  
  47
- To Connect the ADU, ACU and Modem
  
  47
  - ACU with AC Power (SAILOR 7016C)
    47
Chapter 4 Interfaces

49
- Interfaces of the ACU
  
  49
  - Leds, Display, Keypad and Connectors
    49
  - AC Input Connector
    49
  - ADU Connector
    50
  - Rx in and Tx out Connectors
    50
  - NET-H (NMEA 0183 Connector, for Future Use)
    51
  - And RS-422 Connectors
    52
  - LAN1 - 4 Connectors
    53
Chapter 5 Power and Start up

54
- Power-Up Procedure
  
  54
  - Initialisation Steps in Daily Use
    55
  - SAILOR 600 VSAT Ka Operational
    55
Chapter 6 Configuration

56
- Introduction to the Built-In Web Interface
  
  56
  - Overview
    56
  - Connecting to the Web Interface
    56
- Heading Input and Position System
  
  59
- Calibration
  
  62
- Operation in Gyro-Free Mode
  
  70
  - Fixed TX if Principle
    70
- Configuration with the Web Interface
  
  71
  - Overview and Dashboard
    71
Satellite Profiles and Modem Profiles

76
- Satellite Profiles
  76
- Modem Profiles
  77
- To Set up Blocking Zones (RX and TX)
  78
- To Configure the LAN Network
  81
- E-Mail Setup
  84
- Setup of Reports, Syslog and SNMP Traps
  85
- Administration
  91
Keypad and Menus of the ACU

95
- ACU Display and Keypad
  95
- Navigating the Menus
  96
- The Menu Tree
  96
- Brightness of the Display
  100
- Power-Cycle of the ACU and ADU
  100
SNMP Support

101
Chapter 7 Installation Check

102
Installation Check List: Antenna

102
Installation Check List: ACU, Modem, Connectors and Wiring

103
Installation Check List: Functional Test in Harbor

104
Chapter 8 Service

105
To Get Support

106
Software Update

113
- Prerequisites
  113
- Software Update (ADU, ACU)
  113
Status Signalling with Leds and Status Messages

117
- Built-In Test Equipment
  117
- Means of Signalling
  117
- Leds of the ADU Modules
  117
- Leds in the ACU
  118
- Leds of the Modem
  118
Removal and Replacement of the ACU

119
Removal and Replacement of ADU Modules

120
Troubleshooting Basics

122
- Overview
  122
- Event List for Troubleshooting
  122
- Diagnostics Report for Troubleshooting
  122
To Return Units for Repair

122
Appendix A Technical Specifications

123
SAILOR 600 VSAT Ka System Components

123
- General Specifications
  123
- Adu
  124
- Acu
  126
- Patents
  127
Outline Drawings

128
- Adu
  128
- Acu
  129
X7 Modem BUC & Console to ACU Cable

130
Appendix B Antenna Diversity Solution (ADS)

131
Introduction

131
Installation of the Dual-Antenna Mode

132
Configuration of the Dual Antenna Mode

135
- Dual Antenna Mode
  135
- To Configure the Master ACU
  136
- To Configure the Slave ACU
  137
- To Set up Blocking Zones for Dual Antenna Setup
  138
- To Make an OTC for ADS Systems
  139
Flow Chart for Dual Antenna Mode

140
Cable for Antenna Diversity System

141
Appendix C Ground and RF Protection

142
Why Is a Ground Connection Required

142
- Safety
  142
- ESD Protection
  142
Recommendations

142
- To Ground the ACU
  143
- To Ground the ADU
  144
Alternative Ground for Steel Hulls

145
- To Ground the ACU
  145
- To Ground the ADU
  145
Alternative Ground for Aluminum Hulls

147
- To Ground the ACU
  147
- To Ground the ADU
  147
Alternative Ground for Fibre Glass Hulls

149
- To Ground the ACU
  149
- To Ground the ADU
  149
Separate Ground Cable

150
- To Make a Ground Cable
  150
- Ground Cable - Connection
  150
- Isolation of the ADU from the Mounting Base
  151
RF Interference

152
Jumper Cable for Grounding

153
Appendix D System Messages

154
Event Messages - Overview

154
List of ADU Events

155
List of ACU Events

160
Appendix E Command Line Interface

166
Introduction

166
- Telnet Connection
  166
- Help
  167
- Conventions
  167
Supported Commands

167
- Config
  168
- Demo
  168
- Dual_Antenna
  168
- Exit
  169
- Help
  169
- Modem
  169
- Satellite
  169
- Status
  169
- System
  173
- Track
  174
- Zone
  175
Appendix F SAILOR VSAT - Curl Commands

176
Introduction

176
Supported Commands

176
- To Get Started
  176
- Use Cases
  176
- Statistic Download
  177
- Upload Software
  177
Appendix G Approvals

178
Ce (Red

178
Telenor Antenna Approval

180
Glossary

182
Index

186

COBHAM SAILOR 60 GX Installation Manual (180 pages)

Brand: COBHAM | Category: Antenna | Size: 8 MB

Table of Contents
9
About this Manual
15
Intended Readers
15
Manual Overview
15
Software Version
15
Precautions
16
Typography
16
Chapter 2 Introduction

17
- SAILOR 60 GX System
  17
- Overview
  17
- Above Deck Unit (ADU)
  19
- Antenna Control Unit (ACU)
  22
- GX Modem Unit (Modem)
  23
- Satellite Type Approvals
  23
- Service Activation
  23
- Part Numbers and Options
  24
- Applicable Model and Part Numbers
  24
- Options for SAILOR 60 GX
  24
- Installation
  25
- What's in the Box
  25
- To Unpack
  25
- Initial Inspection
  26
- Tools Needed
  26
- Transport of the Antenna
  26
- Site Preparation
  27
- General Site Considerations
  27
- Obstructions (ADU Shadowing)
  28
- Blocking Zones with Azimuth and Elevation
  29
- Safe Access to the ADU (Radiation Hazard)
  30
- Ship Motion and Offset from the Ship's Motion Centre
  31
- Mast Foundation and Height
  32
- Interference from Radar, GPS and Other Transmitters
  35
- Condensation, Water Intrusion and Deposits
  38
- Installation of the ADU
  39
- Overview
  39
- To Install the ADU
  40
- To Ground the ADU
  43
- Alternative ADU Cable
  44
- Installation of the ACU
  45
- To Install the ACU
  45
- To Ground the ACU
  45
- Installation of the Modem
  46
- To Install the Modem
  46
- To Ground the Modem
  46
- Provisioning Key and Terminal Type
  46
- To Connect the ADU, ACU and Modem
  47
- Interfaces of the ACU
  49
- Leds, Display, Keypad and Connectors
  49
- DC Input Connector
  50
- ADU Connector
  50
- Rx in and Tx out Connectors
  51
- NMEA 0183 Connector
  51
- And RS-422 Connectors
  52
- LAN1 - 4 Connectors
  53
- Interfaces of the Modem
  54
- Connector Panel
  54
- Rx in and Tx out Connectors
  54
- And RS-422 Connectors
  55
- LAN Connectors (8 + 2)
  56
- I/O Connector for Tx Mute and Rx Lock
  56
- Rx in and Tx out Connectors
  56
- Power and Startup
  57
- Power Source
  57
- Power Cables
  57
- Power Cable Selection (ACU)
  57
- Power Cable of the Modem
  59
- Power up
  59
- To Connect the Power Cable to the ACU and GMU
  59
- Power-Up Procedure
  59
- Initialisation Steps in Daily Use
  60
- SAILOR 60 GX Operational
  60
Chapter 6 Configuration

61
- Introduction to the Built-In Web Interface
  61
- Overview
  61
- Connecting to the Web Interface
  61
- Heading Input and Position System
  64
- Calibration
  67
- Azimuth Calibration
  67
- Service Profile for Calibration
  70
- Cable Calibration
  71
- Manual One Touch Commissioning (BUC Calibration)
  71
- Operation in Gyro-Free Mode
  73
- Fixed TX if Principle
  73
- Configuration with the Web Interface
  74
- Overview and Dashboard
  74
- To Set up Blocking Zones (RX and TX)
  79
- To Configure the LAN Network
  81
- E-Mail Setup
  83
- Reports, Syslog and SNMP Traps
  84
- Administration
  89
- Keypad and Menus of the ACU
  93
- ACU Display and Keypad
  93
- Navigating the Menus
  94
- The Menu Tree
  95
- Brightness of the Display
  98
- Power-Cycle of the ACU and ADU
  98
- SNMP Support
  99
Chapter 7 Installation Check

101
Chapter 8 Service

105
- To Get Support
  106
- Help Desk and Diagnostic Report
  106
- Reset to Factory Default
  109
- Reset to Factory Default - GMU
  110
- Software Update
  111
- Prerequisites
  111
- Software Update (ADU, ACU)
  111
- Software Update (GMU)
  114
- Satellite Profiles and Modem Profiles
  115
- Satellite Profiles
  115
- Modem Profiles
  116
- Status Signalling with Leds and Status Messages
  118
- Leds of the ADU Modules
  118
- Leds in the ACU
  119
- Leds of the Modem
  119
- Removal and Replacement of the ACU
  120
- Removal and Replacement of ADU Modules
  121
- Troubleshooting
  123
- Overview
  123
- Event List for Troubleshooting
  123
- Diagnostics Report for Troubleshooting
  123
- To Return Units for Repair
  124
Appendix A Technical Specifications

125
- SAILOR 60 GX System Components
  125
- General Specifications
  125
- Adu
  126
- Acu
  127
- Gmu
  128
- Patents
  129
- Adu
  130
- Acu
  131
- Gmu
  132
Appendix B Ground and RF Protection

133
- Why Is a Ground Connection Required
  133
- Safety
  133
- ESD Protection
  133
- Recommendations
  134
- To Ground the ACU
  134
- To Ground the ADU
  135
- Alternative Ground for Steel Hulls
  136
- To Ground the ACU
  136
- To Ground the ADU
  136
- Alternative Ground for Aluminum Hulls
  138
- To Ground the ACU
  138
- To Ground the ADU
  138
- Alternative Ground for Fibre Glass Hulls
  139
- To Ground the ACU
  139
- To Ground the ADU
  139
- Separate Ground Cable
  140
- To Make a Ground Cable
  140
- Ground Cable - Connection
  140
- Isolation of the ADU from the Mounting Base
  141
- RF Interference
  142
- Jumper Cable for Grounding
  143
Appendix C System Messages

145
- Event Messages - Overview
  145
- List of ADU Events
  146
- List of ACU Events
  152
Appendix D Command Line Interface

157
- Introduction
  157
- Telnet Connection
  157
- Help
  158
- Conventions
  158
- Supported Commands
  158
- Config
  159
- Demo
  159
- Dual_Antenna
  159
- Exit
  159
- Help
  160
- Modem
  160
- Satellite
  161
- Status
  163
- System
  164
- Track
  164
- Zone
  165
Appendix E Approvals

167
- Ce (R&Tte
  167
- Glossary
  169
- Index
  173

COBHAM SAILOR 60 GX Installation Manual (190 pages)

Brand: COBHAM | Category: Antenna | Size: 5 MB

Table of Contents
8
Chapter 1 About this Manual

11
- Intended Readers
  11
- Manual Overview
  11
- Software Version
  12
- Typography
  12
- Precautions
  12
- Introduction
  13
- SAILOR 60 GX System
  13
- Part Numbers and Options
  22
Chapter 3 Installation

23
- What's in the Box
  23
- Site Preparation
  25
- Installation of the ADU
  38
- Installation of the ACU
  44
- Installation of the Modem
  45
- To Connect the ADU, ACU and Modem
  46
Chapter 4 Interfaces

47
- Interfaces of the ACU
  47
- Interfaces of the Modem
  52
Chapter 5 Power and Start up

55
- Power-Up Procedure
  55
Chapter 6 Configuration

57
- Introduction to the Built-In Web Interface
  57
- Heading Input and Position System
  60
- Calibration
  64
- Configuration with the Web Interface
  73
- Keypad and Menus of the ACU
  94
- SNMP Support
  100
Chapter 7 Installation Check

101
Chapter 8 Service

104
- To Get Support
  105
- Software Update
  112
- Satellite Profiles and Modem Profiles
  116
- Status Signalling with Leds and Status Messages
  119
- Removal and Replacement of the ACU
  121
- Removal and Replacement of ADU Modules
  121
- Troubleshooting Basics
  122
- Frequently Asked Questions
  123
- To Return Units for Repair
  135
Appendix A Technical Specifications

136
- SAILOR 60 GX Specifications
  137
- SAILOR 60 GX-R2 4.5W or 9.0W Specifications
  139
- Patents
  141
- Outline Drawings
  142
- X7 Modem BUC & Console to ACU Cable
  145
Appendix B Ground and RF Protection

146
- Why Is a Ground Connection Required
  146
- Recommendations
  146
- Alternative Ground for Steel Hulls
  149
- Alternative Ground for Aluminum Hulls
  151
- Alternative Ground for Fibre Glass Hulls
  153
- Separate Ground Cable
  154
- RF Interference
  156
- Jumper Cable for Grounding
  157
Appendix C System Messages

158
- Event Messages - Overview
  158
- List of Events
  159
Appendix L Command Line Interface

170
- Introduction
  170
- Supported Commands
  171

COBHAM Categories

Antenna Marine Equipment Radio Touch terminals Receiver

More COBHAM Manuals

COBHAM SAILOR 60 GX Communication System Manuals

COBHAM SAILOR 60 GX Installation Manual (192 pages)

Table of Contents

Chapter 1 About this Manual

Intended Readers

Manual Overview

Software Version

Typography

Precautions

Chapter 2 Introduction

SAILOR 600 VSAT Ka System

Part Numbers and Options

Chapter 3 Installation

What's in the Box

Site Preparation

Installation of the ADU

Installation of the ACU

Installation of the Modem

To Connect the ADU, ACU and Modem

Chapter 4 Interfaces

Interfaces of the ACU

Chapter 5 Power and Start up

Power-Up Procedure

Chapter 6 Configuration

Introduction to the Built-In Web Interface

Heading Input and Position System

Calibration

Operation in Gyro-Free Mode

Configuration with the Web Interface

Satellite Profiles and Modem Profiles

Keypad and Menus of the ACU

SNMP Support

Chapter 7 Installation Check

Installation Check List: Antenna

Installation Check List: ACU, Modem, Connectors and Wiring

Installation Check List: Functional Test in Harbor

Chapter 8 Service

To Get Support

Software Update

Status Signalling with Leds and Status Messages

Removal and Replacement of the ACU

Removal and Replacement of ADU Modules

Troubleshooting Basics

To Return Units for Repair

Appendix A Technical Specifications

SAILOR 600 VSAT Ka System Components

Outline Drawings

X7 Modem BUC & Console to ACU Cable

Appendix B Antenna Diversity Solution (ADS)

Introduction

Installation of the Dual-Antenna Mode

Configuration of the Dual Antenna Mode

Flow Chart for Dual Antenna Mode

Cable for Antenna Diversity System

Appendix C Ground and RF Protection

Why Is a Ground Connection Required

Recommendations

Alternative Ground for Steel Hulls

Alternative Ground for Aluminum Hulls

Alternative Ground for Fibre Glass Hulls

Separate Ground Cable

RF Interference

Jumper Cable for Grounding

Appendix D System Messages

Event Messages - Overview

List of ADU Events

List of ACU Events

Appendix E Command Line Interface

Introduction

Supported Commands

Appendix F SAILOR VSAT - Curl Commands

Introduction

Supported Commands

Appendix G Approvals

Ce (Red

Telenor Antenna Approval

Glossary

Index

COBHAM SAILOR 60 GX Installation Manual (180 pages)

Table of Contents