Page 1
Operator's Manual HPS09 Pellet Stove Warning Caution Caution do not discard! contact local building Please read this entire or fire officials about re- manual before installa- strictions and installa- tion and use of this Pellet • Important operatIng and tion insPection require- fuel-burning room heater.
Page 2
Operator's Manual HPS09 Pellet Stove Warning Warning Please read this entire manual before hot! do not touch. severe burns may installation and use of this Pellet result. clothing ignition may result. glass and other surfaces are hot dur- fuel-burning room heater. failure to ing oPeration and cool down.
Operator's Manual HPS09 Pellet Stove registration, service and maintenance log Record the model number and serial number in the space provided for easy reference. Fill out and mail the registration card located in the parts packet or register online at www.castlepelletstoves.com. Warranty is valid only if the completed registration is received by Ardisam, Inc.
Page 6
Operator's Manual HPS09 Pellet Stove safety Danger owner’s resPonsibility danger indicates a serious injury or Accurate assembly and safe and effective use of the fatality will result if the safety in- rototiller is the owner’s responsibility. structions that follow this signal • Read and follow all safety instructions.
• do not burn garbage in this unit. The burning of other solid fuels such as cord wood or wood chips in this stove is not permitted. Any fuels not certified by Castle Pellet Stoves which are burned in this stove will void the warranty. • do not route power cord in high traffic areas. A power surge protector plugged into a grounded 110 volt power source is required.
Page 8
Power outages da. aPProved for installation in mo- and periodic maintenance will result in a total bile homes. loss of heat. castle Pellet stoves, Producer of this • Do not leave hopper door open while unat- aPPliance, reserves the right to alter tended. its Products, sPecifications and/or Price without notice.
Operator's Manual HPS09 Pellet Stove introduction Warning Congratulations on your investment in quality. Thank you for your purchase on a Castle Pellet Stove from if the electrical Power fails any time Ardisam, Inc. We have worked to ensure that this pellet when the stove is hot, keeP all stove stove meets the highest standards for usability and doors closed. durability. With proper care, your stove will provide the automatic safety features must many years of dependable service.
Heating Capacity (2) 1,700 Sq. Ft. e1509, (um) 84-hud, ulc/ord-c-1482. Electrical Rating (3) 110-120 volts, 4.5 Amp, castle Pellet stoves, manufacturer of 60 Hz this aPPliance, reserves the right to Power Consumption 520 Watts ignition, alter its Products and/or their sPeci- 200 Watts operating fications without notice.
Operator's Manual HPS09 Pellet Stove installation Warning It is recommended the stove be installed and serviced by read this entire manual before you authorized professionals who are certified by the National install and use this stove. failure to Fireplace Institute (NFI) as NFI Pellet Specialists. follow the instructions may result Proper installation of this stove is necessary for safe and in ProPerty damage, bodily injury, or efficient operation. Installing this product improperly may...
Operator's Manual HPS09 Pellet Stove clearances to combustibles NOTE: These are minimum clearances to combustible walls established by the asTM testing lab. 4” 5” 5” 4” Figure 3: Straight installation through wall Figure 4: Corner installation through the wall vents 2”...
Operator's Manual HPS09 Pellet Stove venting Warning consult vent manufacturer’s specifications and do not connect this unit to a chimney recommendations for all venting installations. flue serving another aPPliance. The following installation guidelines must be followed to do not install a flue damPer in the ensure conformity with both the safety listing of this stove exhauSt ventIng SyStem of thIS unIt.
Operator's Manual HPS09 Pellet Stove vent termination clearances IntaKe & exhauSt poSItIonS clearance Clearance below or beside any door or 4 feet window that opens. Clearance above any door or window that 1 foot opens. 3 feet Clearance from any adjacent building. Clearance from any adjacent public 7 feet walkways. Clearance above any grass, plants, or other 2 feet combustible materials.
Operator's Manual HPS09 Pellet Stove outside air connection Warning Connection from the intake pipe (2” diameter pipe in rear of stove) to the outside of the house is REQUIRED for mobile do not connect to any air distribution home installation. It is recommended in tightly sealed duct or system. homes with exhaust fans such as kitchen or bathroom do not install in a sleePing room.
Operator's Manual HPS09 Pellet Stove oPerating stove Warning Once the stove has been properly installed and plugged into a grounded surge protector you are ready to begin never use flammable liquids such as operation. gasoline, gasoline tyPe lighter fuel, charcoal lighter fuel or fire starting start uP Procedure gels in or around this stove. keeP all Turn on the main power switch located on the back of the such liquids well away from the stove stove.
Operator's Manual HPS09 Pellet Stove shut down Procedure Warning Press the button on the control pad to initiate the shut down mode. Once this is done the auger will stop never shut the stove down by unPlug- feeding pellets, but the room air distribution blower and ging it from the Power source. exhaust fan will continue to operate. When the internal never shut the stove down by switch-...
Operator's Manual HPS09 Pellet Stove maintenance Warning Due to differences in fuel stove cleaning intervals will vary. The cleaner the stove is, the more efficiently it will burn. never Perform cleaning or maintenance on a hot stove. Remove and clean the burn pot periodically. Make sure all holes in the burn pot are unobstructed. Use a small allow unit to cool for a minimum of metal pick or drill bit to keep these holes clean. see two hours.
Operator's Manual HPS09 Pellet Stove end of season shut down Warning Make sure hopper and feed system are clear of all pellets. Vacuum the interior of the hopper and spray with a silicone w h e n P e r f o r m i n g a n y i n t e r n a l protector to avoid any rusting in high humidity areas.
Operator's Manual HPS09 Pellet Stove troubleshooting guide Warning unplug stove before performing any maintenance. never test or check electrical comPo- never service or touch the feed auger nents unless stove is unPlugged from with the stove Plugged in. Power suPPly.
Operator's Manual HPS09 Pellet Stove Problem cause solution Stove beeps three times Proof of fire has not been note the stove may have trouble reaching POF if during ignite cycle. met during allowed time the room temp is below 40 degrees Fahrenheit. At- frame. tempt to reignite first, then check spayed terminals Caution light comes on on the POF switch to be sure they are tight.
Operator's Manual HPS09 Pellet Stove Check for parts online at www.castlestoves.com or call 800-345-6007 M-F 8-5 CST...
Page 23
Operator's Manual HPS09 Pellet Stove key # Part # descriPtion key # Part # descriPtion 720259 dOOR ASSeMBLY 720219 WeLd ASSeMBLY AugeR 720260 ASH PAn COveR 720220 AugeR BeARIng LOWeR 720261 ASH PAn 720221 AugeR BeARIng uPPeR 720262 gRILL BOTTOM...
Page 24
Castle Stoves™, Division of Ardisam, Inc. 1160 8th Avenue, PO Box 666 Cumberland, WI 54829 800-345-6007 | Fax 715-822-2223 Email: info@ardisam.com Check for parts online at www.castlestoves.com or call 800-345-6007 M-F 8-5...
Need help?
Do you have a question about the HPS09 and is the answer not in the manual?
Questions and answers