Table of Contents
Advertisement
Advertisement
Table of Contents
Summary of Contents for LAUER EPC PM 1700tc Nautic
-
Page 1: User Manual
EPC PM 1900tc Nautic EPC PM 1700tc Nautic 21“ TFT Monitor + PC-Box: 19“ 17“ MT 221 Nautic MT 219 Nautic MT 217 Nautic EPC PM box Nautic CiS-Nr.: 360.610.0120 Reg 10509/0805 Version 2/03.06 © Elektronik-Systeme LAUER GmbH & Co. KG... - Page 2 The above terms in this documentation can be brands, whose use by third parties can breach the rights of the proprietor. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 3: User Tips
The test and aptitude of the intended usage by the user res. the usage under operational conditions is the responsibility of the user. Therefore Elektronik-Systeme LAUER does not assume liability. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 4 LAUER GmbH & Co. KG. The efficient and safe operation of the appliance presupposes appropriate transport, storage, assembly and installation as well as accurate handling and maintenance. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 5: Table Of Contents
MT 217 Nautic ............55 5.1.5 MT 219 Nautic ............59 5.1.6 MT 221 Nautic ............63 5.1.7 EPC PM Box Nautic ..........67 © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 6: Preamble
... not only demo-appliances but also specialists who will personally ass- ist you when you first take your appliance into operation.. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 7: Certificates And Guide Lines
Assembly directives Please note the assembly directives and safety instructions mentioned in this documentation, when putting into operation and during operation. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 8 Det norske veritas (DNV) • American Bureau of Shipping (ABS) These products are also tested in accordance with EN 60945 for „Bridges“! © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 9: Preparation
8 Stainless steel screws with washers/nuts and O-ring seals are contained in the parcel of each EPC PM 1700, 1900, 2100 Nautic, MT 217, 219 and MT 221 Nautic. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 10: Organisation Driver-Cd
After removing the appliance from the parcel, lay the parts on a suitable clean and open surface (for example a table. Workbench etc.). Follow exactly the instructions described in the following chapters. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 11: Description
The installation of the EPC PM Nautic is independent of the display size, shown as follows: 1 front unit 2 PC-unit © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 12 Monitor solution The installation of the Monitors is independent of the display size, shown as follows: 1 front unit 2 PC-unit © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 13: Display
2.2 Display Display sizes of 17" and 19" are available. Front with USB-port, ON/OFF-switches and dimmer switches to regulate the brightness. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 14: Ports
Description 2.3 Ports PC-Module © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 15: Motherboard - Slots, Memory Module
(earth) have to be considered during assembly/ disassembly. ESD-protective measures to be considered when opening and working on the appliance. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 16 Description © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 17: Putting In To Operation
VPC is shut down. The computer must not be switched while with the operating system is still running! © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 18 Supply connection 24 VDC Earth screw VGA-connection 2x USB, Power Remote connection Supply connection 115/230 VAC Earth screw VGA-connection 2x USB, Power Remote connection © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 19: Earthing System
Protection class IP65 to the front panel is only guaranteed with a perfect fitting seal. Pay attention to the torque when fixing the front panel! © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 20: Operating System
EPC has booted from the hard disk. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 21: Bios-Settings
Select the menu item „Load Optimised Default“ and affirm the selected operation. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 22 Integrated Peripherals/ Super IO Device Serial Port 3 Use IRQ IRQ4 Integrated Peripherals/ Super IO Device Serial Port 4 Use IRQ IRQ3 © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 23: Important Items Regarding Software Installation
Start i.e. Emergency discs. These might be needed to restore an operational system. Additionally you should make backup copies of your own data and applications! © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 24: Touch Installation 6.10 Windows 2000 / Xp (Only If Required)
IRQ 4 • 9600 bps Carry out the SETUP.EXE under • drive E:\Driver\Driver-EPC-PM\Touch\Touch (with the ordered operation system) • CD-ROM: (D:) E:\EPC-PM\Touch © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 25 Putting in to operation • follow the instructions on the monitor. press [CONTINUE]. • accept the license provisions © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 26 Putting in to operation Drücken Sie [WEITER]. • select the „Auto detect Function“ or manually select the technical connection data. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 27 „Hampshire Control Panel“. • Calibrate the touch screen with your finger or with a rounded pointed touch pen. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 28: Graphic Board Installation
After conclusion the installation and restart the PPC the following entries can be seen in the Control Panel or in the display properties. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 29: Installation Lan-/Network Card
„connection PING“. Herewith you can then test your connections to the server and other PC’s. (for example: C:\ping 192.168.5.100). © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 30 Putting in to operation © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 31: Service
Therefore cautionary measures have to be taken from the moment the appliance is opened. These can be consulted in the guidelines for electrostatic endangered components (EGB-guidelines). © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... -
Page 32: Changing The Fan
To open the enclosure remove the marked screws with an Allen key. Then lift the enclosure and pull out the fan cable. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 33 Remove the protective cover of the fan and remove the fan with a Phillips head screw driver. After changing the fan, assemble the appliance in the reverse order. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 34: Pci-Board Installation
To open the enclosure remove the marked screws with an Allen key After removing 7 screws the enclosure can be lifted easily. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 35 A look at the opened appliance shows the 2 PCI-slots and the board holder. Remove the slot cover of the desired slot to insert your PCI-board. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 36 Unscrew the board holder. Insert your PCI-board. Please ensure a correct fit at the lower edge of the slot. Screw your PCI-board tight. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 37 Following picture shows this once more in detail. The short support can be removed with boards of the same design. Otherwise the two supports can be individually adjusted. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 38: Memory Expansion, -Change
Please note the correct location of the cable prior to pulling the cable out so that it can be plugged in correctly. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 39 If a memory expansion is carried out the memory module is positioned vertically and pushed in, the fixing brackets snap shut. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 40 Bend back and plug in the ribbon cable. Subsequently plug in the fan cable and reposition the enclosure. Re-fix the enclosure. © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 41: Technical Data
EPC PM 1700/1900/2100 Nautic: IP 54 Front side; IP 20 Back side Approvals GL, ABS, DNV, BV, LR, Prepared for IEC 60945 © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 42 800 x 600 (including 720 x 400) 1024 x 768 SXGA 1280 x 1024* UXGA 1600 x 1200 *Recommended for optimum picture quality © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 43: Detailed Drawings
Technical data 5.1 Detailed drawings 5.1.1 EPC PM 1700 Nautic frontal view overall measurement: 430,0 x 390,0 mm © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 44 Front panel assembly aperture Aperture size: 396,0 x 264,0 mm Fixing with 8 off M6 x 25.screws. Max. 5 mm thick mounting frame © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 45 Technical data view of the appliance’s underneath 230V view of the appliance’s underneath © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 46 Technical data Rear view of the appliance lateral view © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 47: Epc Pm 1900 Nautic
Technical data 5.1.2 EPC PM 1900 Nautic frontal view overall measurement: 483,2 x 444,0 mm © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 48 Front panel assembly aperture Aperture size: 466,0 x 416,0 mm Fixing with 8 off M6 x 25.screws. Max. 5 mm thick mounting frame © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 49 Technical data view of the appliance’s underneath 230V view of the appliance’s underneath © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 50 Technical data Rear view of the appliance lateral view © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 51: Epc Pm2100 Nautic
Technical data 5.1.3 EPC PM2100 Nautic frontal view overall measurement: 534,0 x 481,0 mm © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 52 Front panel assembly aperture Aperture size: 500,0 x 443,0 mm Fixing with 4 off M6 x 25.screws. Max. 5 mm thick mounting frame © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 53 Technical data 24V DC view of the appliance’s underneath 23V0 AC view of the appliance’s underneath © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 54 Technical data Appliance’s rear view lateral view © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 55: Mt 217 Nautic
Technical data 5.1.4 MT 217 Nautic frontal view overall measurement: 430,0 x 390,0 mm © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 56 Front panel assembly aperture Aperture size: 396,0 x 364,0 mm Fixing with 8 off M6 x 25.screws. Max. 5 mm thick mounting frame © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 57 Technical data 24V-Monitor view of the appliance’s underneath lateral view © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 58 Technical data 230V-Monitor view of the appliance’s underneath lateral view © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 59: Mt 219 Nautic
Technical data 5.1.5 MT 219 Nautic frontal view overall measurement: 483,2 x 444,0 mm © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 60 Front panel assembly aperture Aperture size: 438,0 x 416,0 mm Fixing with 4 off M8 x 25.screws. Max. 5 mm thick mounting frame © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 61 Technical data 24V-Monitor view of the appliance’s underneath lateral view © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 62 Technical data 230V-Monitor view of the appliance’s underneath lateral view © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 63: Mt 221 Nautic
Technical data 5.1.6 MT 221 Nautic frontal view overall measurement: 534,2 x 481,0 mm © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 64 Front panel assembly aperture Aperture size: 500,0 x 443,0 mm Fixing with 8 off M6 x 25.screws. Max. 5 mm thick mounting frame © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 65 Technical data 24V-Monitor view of the appliance’s underneath Appliance’s rear view lateral view © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
- Page 66 Technical data 230V-Monitor view of the appliance’s underneath Appliance’s rear view lateral view © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
-
Page 67: Epc Pm Box Nautic
Technical data 5.1.7 EPC PM Box Nautic view of the appliance’s underneath 230V view of the appliance’s underneath © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103... - Page 68 Technical data Rear view of the appliance lateral view © Elektronik-Systeme LAUER GmbH & Co. KG • Kelterstr. 59 • 72669 Unterensingen • Tel. 07022/9660-0 • Fax 07022/9660-103...
Need help?
Do you have a question about the EPC PM 1700tc Nautic and is the answer not in the manual?
Questions and answers