Summary of Contents for Mountain Man ESS MBP 2.5
- Page 1 Owner’s Manual Owner’s Manual ESS MBP 2.5/4.0 ESS MBP 2.5/4.0 Mountain Man Sprayer Mountain Man Sprayer Electrostatic Spraying Systems...
- Page 2 Owner’s Manual ess MBP 2.5 ess MBP 4.0 MOuntain Man sPrayer electrostatic spraying systems, inc. 62 Morrison st. · watkinsville, Ga 30677-2749 Ce certification applied for Copyright © 2009, electrostatic spraying systems, inc. – all rights reserved this manual last updated May 28, 2014...
- Page 3 MBP 2.5 sprayer™, ess MBP 4.0 sprayer™, MBP 2.5™, MBP 4.0™, MaxCharge™, Mountain Man™ and the ess logo are copyrights or registered trademarks of electrostatic spraying systems, inc.
- Page 4 Notes ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual...
-
Page 5: Table Of Contents
OF COntents Overview of the ess MBP 2.5 / 4.0 air-assisted electrostatic sprayer 1 safe operation of the MBP sprayer ............... 2 Operator’s responsibility ................2 safety precautions ..................2 Chemical safety precautions ..............2 about the low-voltage system of the MaxCharge spray gun ..... 3 safety decals ...................... - Page 6 Notes ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual...
-
Page 7: Overview Of The Ess Mbp 2.5 / 4.0 Air-Assisted Electrostatic Sprayer
MBP Mountain Man sprayer is the patented MaxCharge™ nozzle. air and liquid enter separately at the rear of the nozzle. Just before leaving the nozzle, the air hits the liquid stream to make many thou- sands of tiny spray droplets that pass through the charging ring. -
Page 8: Safe Operation Of The Mbp Sprayer
Be aware of poisoning symptoms and know the appropriate first aid. Know the length of time needed to pass before allowing people and pets to go back into the sprayed area. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 9: About The Low-Voltage System Of The Maxcharge Spray Gun
“tingle” or a slight stinging sensation when the spray from the nozzle falls on their bare skin. location of 9-volt rechargeable battery pack in the handle of the spray gun. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 10: Safety Decals
There will be a small shock when using our sprayers. To avoid this shock place your thumb on the bolt at the top of the spraygun. This label is placed on the charger of all sprayguns. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 11: Features Of The Mbp Mountain Man Sprayer
9.5 ltr./hr. (2.5 gal./hr.) Drop size 40 microns spray range 4.6 m. to 6.1 m. (15 to 20 ft.) available options Dual-headed spray gun additional hose up to 76.2 meters (250 ft.) max. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 12: Operating Instructions
MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 13: Before Use
9. aim spray gun and engage the trigger; lock trigger if desired. spray with even, sweeping strokes. nOte: it may take about a few moments for air to clear the lines before liquid sprays regularly without air bubbles. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 14: After Spraying
18. Clean the nozzle assembly. Sil-Glyde is an excellent silicone-based 19. record application in spray log. protective lubricant. You may purchase it directly from ESS. S/N # 3174 ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 15: Mbp Maintenance Schedule
Clean spark plug in engine every 100 operational hours Or every season** Change compressor oil every 100 operational hours Or if dirty** Check and tighten bolts every month ** whichever comes first ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 16: Reference Section
1. Move throttle speed control towards the turtle icon (slow) at the left. 2. turn On/OFF switch to OFF. note: Do not use choke to stop engine, as a backfire or engine damage may result. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 17: Compressor
Do not operate the sprayer when the tank lid is not securely can be purchased from ESS. closed. Chemicals may splash out onto the operator if the tank is open Order s/n#1566. during operation. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 18: Quick Connects
MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 19: Spray Gun
2. Check inside each part for debris. Clean any dirt out with compressed air or warm, soapy water. 3. reassemble the air filter, making sure to put it together as shown above. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 20: Trigger
2. Check inside the trigger for blockage. Clean out any debris with compressed air or warm, soapy water. 3. replace the spring and plunger; rethread the brass bolt into the top of the spray gun until tight. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 21: Liquid Filter Assembly
6. replace the strainer in the 1/8” nPt body. 7. rethread the 1/8” nPt body and the cap. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 22: Nozzle Assembly
The electrode cover should be hand tight. Never use pliers or other tools to tighten it. The insulating ring should be loose. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 23: Pre-Spray Check
(black portion of nozzle) and nozzle hoods be cleaned with soapy water at this time. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 24: The Batteries
4. replace the battery cover. screw the two 6-32 x 1/2” Phillips head machine screws back in to secure the battery cover. 5. Charge the spray gun before attempting to use it. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 25: Yearly Spray Gun Service
COD, or return shipping costs may be invoiced, contingent upon credit approval. ess also accepts Visa and MasterCard. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 26: Spraying With Your Ess Sprayer
Just engage the trigger lock and concentrate on the regular pattern of spraying. 9. Periodically check to make sure the red light is illuminated on the spray gun. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 27: Preparing A Tank Mix
6 ounces of chemical in. Depending on the crop sprayed, you will use approximately 1to 2 gallons of water with the ESS sprayer to cover 10,000 square feet. This applies to all chemicals, even wettable powders. 10,000 square feet ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 28: Chemical Compatibility
10° C (50° F). ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 29: Spraying With Optional Spray Guns
Please let your ess sales representative recommend the nozzle cover/flow disk combination that will be best for your particular crop. * all spray distance tests are conducted with no wind blowing. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 30: Siphoning
MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 31: Troubleshooting Guide
· Dirty nozzle · Clean nozzle according to instructions Gasoline engine will not Please see the Briggs & stratton Owner’s Manual start ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 32: Mbp Spray Gun Service Parts (Drawing)
MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 33: Mbp Spray Gun Service Parts (Key)
MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 34: Back Pack Exploded View (Drawing)
Backpack exploded view Air to Spray Gun Liquid to Spray Gun ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 35: Back Pack Service Parts
HHCs — 1/4” - 2O × 11/4” - ss 6835 sCrew — #10-32 × 3/4” - PHilliPs- rH- ss 8419 HeX nut — #6-32 K-l - ss 8663 HeX nut - #10-32 nylOC - ss ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 36: Chassis Service Parts
PluG — HeX HeaD - 1/8” MPt - Brass 17204 QuiCK Fist 1-PieCe ruBBer ClaMP (sMall) PP242 raDiatOr — 5/8” Dia tuBe × 6 Pass Belt GuarD - DeVil Bliss air POwer * nOt sHOwn ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... -
Page 37: Warranty
CHanGe tHis warranty in any way Or Grant any OtHer warranty unless suCH CHanGe is MaDe in writinG anD is siGneD By a COrPOrate OFFiCer OF eleCtrOstatiC sPrayinG systeMs, inC. ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual... - Page 38 MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual...
-
Page 39: Spray Gun Repair/Yearly Service Return Form
Method of Payment: account (must be an approved account) COD Credit Card: Visa MasterCarD Card number: ________________________________ expiration Date: ________________________________ Card Holder’s name: ________________________________ Print ________________________________ siGn ess MBP 2.5 / MBP 4.0 MOuntain Man Owner’s Manual...
Need help?
Do you have a question about the ESS MBP 2.5 and is the answer not in the manual?
Questions and answers