Table of Contents
Advertisement
Advertisement
Table of Contents
Summary of Contents for Tahoe TI6521
- Page 1 - 1 -...
- Page 2 PREFACE PREFACE PREFACE PREFACE This manual is only a guide to assist you and is not a complete or comprehensive manual of all aspects of maintaining and repairing your engine. The equipment you have purchased is a complex piece of machinery . We recommend that you consult with a dealer if you have doubts or concerns as to your expensive or ability to properly maintain or repair your engine.
- Page 3 TABLE TABLE CONTENTS CONTENTS TABLE TABLE OF OF THE THE CONTENTS CONTENTS Page number Page Page Page number number number CHAPTER CHAPTER CHAPTER 1. 1. 1. 1. TECHNICAL TECHNICAL TECHNICAL SPECIFICATIONS SPECIFICATIONS DATA DATA 1 1 1 1 CHAPTER TECHNICAL SPECIFICATIONS SPECIFICATIONS AND AND DATA DATA...
- Page 4 CHAPTER CHAPTER 1.TECHNICAL 1.TECHNICAL SPECIFICATION SPECIFICATION DATA DATA CHAPTER CHAPTER 1.TECHNICAL 1.TECHNICAL SPECIFICATION SPECIFICATION AND AND DATA DATA Technical specifications in S1 units Item Model TA011 Speed (rpm) 1100 Max. pressure (MPa) Air flow rate (m³/min) 0.34 Air tank capacity (L) Engine Model 168F Type...
- Page 5 CHAPTER CHAPTER 2.EQUIPMENT 2.EQUIPMENT DESCRIPTION DESCRIPTION DESCRIPTION & & & & KNOWING KNOWING KNOWING CHAPTER CHAPTER 2.EQUIPMENT 2.EQUIPMENT DESCRIPTION KNOWING YOUR COMPRESSOR YOUR YOUR YOUR AIR AIR COMPRESSOR COMPRESSOR COMPRESSOR Please read this manual and follow the procedures covered in this manual. Become familiar with the air compressors functions, applications and limitations.
- Page 6 CHAPTER CHAPTER 3.SAFETY 3.SAFETY PRECAUTIONS PRECAUTIONS CHAPTER CHAPTER 3.SAFETY 3.SAFETY PRECAUTIONS PRECAUTIONS In order to ensure safety for the consumer, please carefully follow instruction on being careful with the air compressor. Never operate the air compressor without the belt guard. Failing to do so can lead to serious injuries as objects may get caught in the belt.
- Page 7 After the air compressor has been run, the engine produces heat. The temperatures of the muffler and nearby area can reach or exceed 160°F.Severe burns will occur on contact with skin. Do not modify the air compressor in any way. The air compressor supplies the rated pressure and rated airflow at its governed speed.
-
Page 8: Air Cleaner
● Make sure the air compressor is on a level surface and make sure the oil dipstick is on tight. FUEL FUEL FUEL FUEL ● Add gasoline and never fill the fuel tank indoors. Also, be sure to install the fuel tank cap on tight after filling. - Page 9 CHAPTER CHAPTER 5.STARTING 5.STARTING COMPRSSOR COMPRSSOR CHAPTER CHAPTER 5.STARTING 5.STARTING THE THE AIR AIR COMPRSSOR COMPRSSOR Turn the fuel valve to the ON position Turn the engine switch to the ON position. With the recoil starter, pull the handle fast. Move the choke lever to the CLOSED Gradually move the choke lever to position.
-
Page 10: Engine Oil
CHAPTER CHAPTER 6.STOPPING 6.STOPPING ENGINE ENGINE CHAPTER CHAPTER 6.STOPPING 6.STOPPING THE THE ENGINE ENGINE In the event of an emergency, turning the engine switch to the “off” position can stop the engine. Under regular conditions, follow these procedures ● Shift the throttle lever fully to the right. ●... - Page 11 Refill with the recommended oil and check the oil level. Install the oil filler cap. The engine oil capacity is .60 liters or .16 gallons. The gear oil capacity of the 1/2 reduction is .50 liters or .13 gallons. The gear oil capacity of the 1/6 reduction is .15 liters or .03 gallons. Note: Do not touch motor oil for long periods of time.
- Page 12 FILTER FILTER SERVICE SERVICE AIR FILTER FILTER SERVICE SERVICE A dirty or clogged air filter will prevent air fro, flowing freely in to the carburetor assembly. Always keep the air filter clean or replace if necessary. Also, if the air filter is dirty or clogged, the performance of the engine goes down.
- Page 13 CLEANING COMPRESSOR CLEANING CLEANING CLEANING THE THE AIR AIR COMPRESSOR COMPRESSOR COMPRESSOR Air compressor maintenance consists of keeping the unit clean and dry. Be sure to store the unit in a clean and dry environment, where it will not be exposed to excessive dust, dirt, moisture or any corrosive vapors.
- Page 14 ● After the spark plug has seated, tighten the spark plug with a spark plug wrench to compress the washer. Note: For new spark plugs, tighten an extra1/2 turn after the spark plugs seats to compress the washer. If installing a used spark plug; tighten 1/8-1/2 turn. The spark plug must be securely tightened, or the spark plug can become very hot and damage the engine.
- Page 15 CHAPTER CHAPTER 8.TROUBLESHOOTING 8.TROUBLESHOOTING CHAPTER CHAPTER 8.TROUBLESHOOTING 8.TROUBLESHOOTING Symptom Probable cause Corrective Action discharge demand exceeds pump 1. Decrease air demand or use a larger pressure capacity. capacity air compressor Leaking air 2. Listen for high pitched escaping air. Apply soap solution to all fittings and connections.
- Page 16 Large quantities 1. Worn piston rings. 1. Replace with new rings. of oil in air 2. Air intake clogged 2. Clean air filter supply 3. Oil level in compressor head to 3. Drain some of the oil. high 4. Wrong oil viscosity 4.
- Page 17 CHAPTER CHAPTER 9.PART 9.PART LISTINGS LISTINGS CHAPTER CHAPTER 9.PART 9.PART LISTINGS LISTINGS - 15 -...
- Page 18 Number Part Description Part Number Number Number Number Part Part Part Description Description Description Part Part Part Number Number Number Gasoline engine 011TA1 Compressor 011TA2 Copper tube assembly 011TA3 Pressure control Valve 011TA4 Throttle cable 011TA5 Battery carrier 011TA6 Gas plug and socket 011TA7 Antihunting pressure guage 011TA8...
- Page 19 Number Part Description Part Number Number Number Number Part Part Part Description Description Description Part Part Part Number Number Number Spring washer 8 011TA33 Pain washer 8 011TA34 Shock absorption mat 011TA35 Bolt M8×25 011TA36 Bolt 7/16”×25 011TA37 Spring washer 011TA38 Pain washer 011TA39...