Do you have a question about the Sun Dolphin and is the answer not in the manual?
Questions and answers
william jackson
May 13, 2025
i have a pro 120 and when i go fishing i can drain about 5-8 gallons of water everytime i go how isthat much water getting into the bottom
1 comments:
Mr. Anderson
May 21, 2025
Water could be accumulating in the bottom of a KL Outdoor Sun Dolphin Pro 120 during fishing trips due to a clogged pump intake or spray head, which would prevent proper livewell drainage. Another possible cause is if the livewell drain plug is not removed to allow drainage. Periodically checking and cleaning the pump parts and ensuring the drain plug is removed when needed can prevent water buildup.
Page 1
O W N E R ’ S M A N U A L Sun Dolphin Fishing Boats 1790 Sun Dolphin Drive Muskegon, Michigan 49444 phone 231-733-2725 231-739-4502 email klsales@kloutdoor.com website www.sundolphin.com...
Page 2
Flotation is provided by closed cell foam located between the deck and hull. The foam is strategically placed to provide flotation under normal loading conditions. All Sun Dolphin Pro models meet U.S. Coast Guard safety standards and are CE certified.
Page 3
Manufacturer’s Statement of Origin (MSO) Each boat comes with a document called a Manufacturer’s Statement of Origin (MSO). Think of it like the title to your car. It’s your proof, along with your sales receipt, of ownership. You’ll need both the MSO completed and signed by the retailer and your sales receipt to register the boat with your state licensing bureau.
Page 4
Installing the Seats Follow seat installation instructions provided with seats. Note: the American 12 Jon Boat does not come with seats. Installing Drain Plugs Just like any boat, your boat may take on some water. Because of its flexible nature, a polyethylene boat is prone to accumulate a small amount of water between the deck and hull.
Page 5
Oarlock Kit. Note: that if the installation instructions are not followed, the oarlocks may come loose and the boat may be damaged. You will also need oars, which are available from KL Outdoor. Please call our Customer Support Department or order online www.sundolphin.com.
Page 6
1. Cut the trolling motor power wires just behind the alligator clips or ring connectors and strip about ½” of the insulation from the end of these wires. 2. Connect the trolling motor power wires to the plug wires using the connectors included in the accessory packet or by soldering. Note: Be sure to connect the same color wires together: the RED wire on the plug is positive (+) the BLACK wire is negative (-).
Page 7
The Pro 102 uses 3 amp. in-line fuses for the lights and aerator and a 50 amp. for the trolling motor. If any of your electrical systems are not working, check the in-line fuses located next to the battery terminals in the wire. Replace if necessary. INSTALLING ACCESSORIES Fish Finders/Depth Finders Pro 120 and American 12 Jon 1.
Page 8
SECURITY MEASURES WARNING Read the following information before using your fishing boat. Failure to follow the warning precautions below may lead to serious injury including the possibility of death. Review the maximum capacities on the capacity plate, located on the rear starboard side of the deck. Ensure you are safely within these limits.
Page 9
OPERATING THE BOAT Launching Tips • When launching the boat from shore it is better to enlist the help of a bystander or passenger to help lift the boat and carry it to the water. You can drag the boat but carrying it will prevent excessive hull abrasion over time. •...
Page 10
Traveling Across the Water Do not be concerned if you notice a slight hull flexing during use. The boat is designed to flex and absorb minor bumps without damage. This flexing is one of the great advantages of polyethylene. Trim/Planing (all models) The Pro 120 is designed with a planing hull.
Page 11
CARE AND MAINTENANCE • With minimal care and maintenance, your boat has been designed to provide you with many years of enjoyment. • HDPE is very impact resistant but it is vulnerable to excess abrasion. Avoid dragging the boat across gravel, asphalt or concrete. If you wear a hole in the boat below the waterline HDPE is very difficult to repair.
Page 12
For best results we suggest a mooring cover, which prevents water and debris from accumulating. Custom fit boat covers are available from KL Outdoor. Please call our Customer Support Department or order online at www.sundolphin.com. If possible store your boat in a garage or barn.
Please Choose Your Model Sportsman Pro 120 Battery Two padded compartment Built-in rear Aerated swivel seats motor mount Adjustable and removable livewell Carpeted casting decks swivel seats holders over pressure treated Cooler or storage 3/4” plywood compartments Recessed drink and Protective tackle holders vinyl...
Page 14
Please Choose Your Model Pro 94 Pro 102 Twin swivel Twin padded swivel fishing chairs Livewell with fishing chairs aerator Livewell with drain Trolling motor plug-in socket Built-in trolling Bow navigation motor mount light Built-in trolling motor mount Thru-transom drain Battery compartment Battery box (battery not included)
Page 15
American 12 Jon Boat Recessed drink and Oarlock Fuel tank Four rod tackle storage sockets holder holders locations Large seating area Battery storage locations fore/aft Built-in front electric motor mount Recessed grip wells for easy transport Protective vinyl rubrail Exclusive mold Rugged UV-stabilized Stainless design ensures...
Page 16
TERMS OF LIMITED LIFETIME WARRANTY KL Outdoor warrants to the original owner of any KL Outdoor boat. Any part of the deck or hull which is defective in material or workmanship will be repaired or replaced, without charge, at the purchasers’ local authorized dealer or at KL Outdoor. This warranty is non-transferable.
Need help?
Do you have a question about the Sun Dolphin and is the answer not in the manual?
Questions and answers
i have a pro 120 and when i go fishing i can drain about 5-8 gallons of water everytime i go how isthat much water getting into the bottom
Water could be accumulating in the bottom of a KL Outdoor Sun Dolphin Pro 120 during fishing trips due to a clogged pump intake or spray head, which would prevent proper livewell drainage. Another possible cause is if the livewell drain plug is not removed to allow drainage. Periodically checking and cleaning the pump parts and ensuring the drain plug is removed when needed can prevent water buildup.
This answer is automatically generated