1. Manuals
  2. Brands
  3. american flame Manuals
  4. Gas Heater
  5. AFVK-SP-SPLIT
  6. Installation and operating instruction

american flame AFVK-SP-SPLIT Installation And Operating Instruction

Hide thumbs
1
2
3
4
5
6
7
8
9

Advertisement

Table of Contents

A M E R I C A N F L A M E
!
!
IF YOU CANNOT READ OR UNDERSTAND THESE INSTALLATION INSTRUCTIONS DO NOT
This intermittent pilot ignition (IPI) gas valve (Safety Pilot) kit is set up for Natural gas only and designed to be used with
18 to 30-inch gas log sets. Optional LP conversions kits LPK-18 or LPK-24 are available.
DUE TO HIGH TEMPERATURES THESE MODELS ARE NOT RECOMMENDED FOR
Warning: Improper installation, adjustment,
alteration, service or maintenance can cause
injury or property damage. Refer to this manual
for assistance or for additional information consult
a qualified installer, service agency or gas
supplier.
FOR YOUR SAFETY
WHAT TO DO IF YOU SMELL GAS
- Do not try to light the appliance.
- Do not touch any electrical switch.
- Do not use any phone in your building.
- Immediately call you gas supplier from a
neighbor's phone. Follow the gas suppliers
instructions.
- If you cannot reach your gas
supplier call the fire department.
Notice:
Please leave these instructions for the consumer. Retain for future reference
American Flame AFVK-SPLIT VALVE KITS
Electronic Safety Pilot System for Vented Gas Logs
AFVK-SP-SPLIT
AFVK-SP-H/L-SPLIT
AFVK-SP-MH/L-SPLIT
ATTEMPT TO INSTALL OR OPERATE
INSTALLATION AND OPERATING INSTRUCTION
INSTALLATION IN SEE THROUGH FIREPLACES
Models:
Important: Read these instructions carefully
before starting installation of your log set.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
Be sure Flue Damper and Glass Doors are
fully open when operating any vented gas
log set.
Young children should be carefully
supervised when they are in same room as
the appliance.
A F
REV 12-27-13 Page 1 of 9

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the AFVK-SP-SPLIT and is the answer not in the manual?

Questions and answers

Summary of Contents for american flame AFVK-SP-SPLIT

  • Page 1 Follow the gas suppliers the appliance. instructions. - If you cannot reach your gas supplier call the fire department. Notice: Please leave these instructions for the consumer. Retain for future reference American Flame AFVK-SPLIT VALVE KITS REV 12-27-13 Page 1 of 9...

  • Page 2: Installation Precautions

    CAUTION: When installing logs on basket grate ensure no logs lay across and touch the valve or switch boxes. Some logs, depending on material, can transfer heat through the metal boxes and cause damage to internal components. American Flame AFVK-SPLIT VALVE KITS REV 12-27-13 Page 2 of 9...
  • Page 3 Locate the Valve Box on the left front corner and the Switch Box in the right front corner of the firebox as far forward as possible (See Figure 4). American Flame AFVK-SPLIT VALVE KITS REV 12-27-13 Page 3 of 9...
  • Page 4 Connector Pilot Ass’y Continuous Pilot Off/On Remote/Off MAIN Pilot “S” Sensor MAIN 2-Pin Connector & “I” Ignitor Wires (Red/White Wires) Fig. 6 Module Identification Fig. 5 Gas Valve Identification American Flame AFVK-SPLIT VALVE KITS REV 12-27-13 Page 4 of 9...
  • Page 5 DC MOTOR DRIVE position to operate the HI/LO feature of the DC Motor Drive. This switch is located on the face of the battery pack (See figure 11). NOTE: On the AFVK-SP-SPLIT the battery pack switch can be placed in either Latching Solenoid...
  • Page 6 PILOT ON this switch is turned to the Continuous pilot position the pilot will immediately spark to light the pilot and the pilot will remain ON. Fig. 15 Module Switches American Flame AFVK-SPLIT VALVE KITS REV 12-27-13 Page 6 of 9...
  • Page 7 INSIDE SWITCH BOX Fig. 17 Learn button on module MAINTENANCE OF YOUR AFVK-SP-SPLIT SERIES VALVE KIT SYSTEM Your system should be checked once a year (at the start of the heating season) for proper operation by a qualified service representative.

  • Page 8: Troubleshooting

    OPERATING PROCEDURE After installation is completed follow these steps to operate the AFVK-SP-SPLIT. Turn ON the main gas supply and check all fittings and connections for leaks with soap and water solution. Move the OFF/REMOTE slide switch on the front of Switch Box to the REMOTE position (See figure 15).

  • Page 9: Optional Accessories

    Limited Warranty American Flame warrants the AFVK-SP-SPLIT VALVE KIT SYSTEMS for 12 months from the date of purchase or installation to the original purchaser to be free from defects in materials and workmanship. Damage to the AFVK-SP-SPLIT VALVE KIT SYSTEMS caused by accident, misuse, abuse, or installation error, whether preformed by a contractor, Service Company, or owner, is not covered by this warranty.

This manual is also suitable for:

Afvk-sp-h/l-splitAfvk-sp-mh/l-split

Table of Contents