HomeDieselPower 10,000W Owner's Manual

Hide thumbs

Table Of Contents

Table of Contents

Quick Links

Download this manual

Owners Manual

10,000W

HOME DIESEL

POWER

WWW.HOMEDIESELPOWER.COM

Table of Contents

Need help?

Do you have a question about the 10,000W and is the answer not in the manual?

Questions and answers

Summary of Contents for HomeDieselPower 10,000W

Page 1 Owners Manual 10,000W HOME DIESEL POWER WWW.HOMEDIESELPOWER.COM...
Page 2: Table Of Contents
10000W Generator Topic Page Safety Guidelines General Precautions Battery Assembly Operation Spark Plug Service Inspection, Cleaning, Maintenance and Storage Installation Compliance Speci fications General Parts Listing WARNING! READ AND UNDERSTAND ALL SAFETY PRECAUTIONS IN THIS MANUAL BEFORE OPERATING. FAILURE TO COMPLY WITH INSTRUCTIONS IN THIS MANUAL COULD RESULT IN PERSONAL INJURY, PROPERTY DAMAGE, AND/ OR VOIDING OF YOUR WARRANTY.
Page 3: Safety Guidelines
Owner’s Manual Safety Guidelines - Definitions This manual contains important information that you need to know and understand in order to protect YOUR SAFETY and to PREVENT EQUIPMENT PROBLEMS. The following symbols help you recognize this information. Please read the manual and pay attention to these sections. Save These Important Safety Instructions! Read and understand all of these safety instructions.
Page 4: General Precautions
Owner’s Manual General Precautions (cont’d) Electrical Safety (cont’d) • All connections and conduits from the generator to the load must only be installed by trained and licensed electricians, and in compliance with all relevant local, state, and federal electrical codes and standards, and other regulations where applicable. •...
Page 5: Battery
Owner’s Manual General Precautions (cont’d) Mechanical (cont’d) • Do not operate the generator with safety guards removed. While the generator is running, do not attempt to reach around the safety guard for maintenance or any other reason. • Keep hands, arms, long hair, loose clothing, and jewelry away from moving parts. Be aware that when engine parts are moving fast they cannot be seen clearly.
Page 6: Operation
Owner’s Manual Operation Control Panel Choke lever Handle Battery Oil plug Air filter Recoil Start NOTE: THE PARTS LISTED ABOVE ARE HELPFUL FOR LOCATING THE CONTROLS MENTIONED BELOW. CAUTION: PRIOR TO FIRST USING THE GENERATOR, THE ENGINE MUST BE FILLED WITH OIL OF A HIGH QUALITY SAE 10W-30 GRADE ENGINE OIL. TO DO SO, UNSCREW AND REMOVE THE ENGINE’S OIL DIPSTICK LOCATED AT THE BOTTOM OF THE ENGINE CRANKCASE.
Page 7: Inspection, Cleaning, Maintenance And Storage
Owner’s Manual Operation (cont’d) Powering 12 Volt DC tools and Equipment: 1. Prior to powering tools and equipment, make sure the generator’s rated voltage, and amperage capacity (12V DC) is adequate to supply all electrical loads that the unit will power. If powering exceeds the generator’s capacity, it may be necessary to group one or more of the tools and/or equipment for connection to a separate generator.
Page 8 Owner’s Manual Maintenance Guide Periodic maintenance and adjustment is necessary to keep the generator in good operating condition. WARNING! Exhaust gas contains poisonous carbon monoxide. Shut off the engine before performing any maintenance. If the engine must be run, make sure the areas is well ventilated. •...
Page 9: Installation
Owner’s Manual Installation NOTE: PRIOR TO POWERING TOOLS AND EQUIPMENT MAKE SURE THE GENERATOR’S RATED VOLTAGE, WATTAGE AND AMPERAGE CAPACITY IS ADEQUATE TO SUPPLY ALL ELECTRICAL LOADS THAT THE UNIT WILL POWER. IF POWERING EXCEEDS THE GENERATOR’S CAPACITY, IT MAY BE NECESSARY TO GROUP ONE OR MORE OF THE TOOLS AND/OR EQUIPMENT FOR CONNECTION TO A SEPARATE GENERATOR.
Page 10: Parts Listing
10000W Generator Cylinder head system assy. PARTS LISTING APA Part No. Description ( 1 × 1 10000W Generator 10000W Generator Crankcase cover system assy. Cylinder barrel APA Part No. Description APA Part No. Description APG3090-B-01-JD FLANGE BOLT APG3090-C-01-JD DUCT COVER APG3090-B-02-JD OIL LEVEL SWITCH ASSY APG3090-C-02-JD...
Page 11 10000W Generator 10000W Generator Crankshaft system assy. Piston and connecting rod system assy. Description Description APA Part No. APA Part No. APG3090-E-01-JD COMPRESSION RING A APG3090-D-01-JD CRANKSHAFT COMP APG3090-E-02-JD COMPRESSION RING B APG3090-D-02-JD BALANCER WEIGHT APG3090-E-03-JD OIL RING A APG3090-E-04-JD OIL RING B APG3090-E-05-JD PISTON PIN CLIP (20 mm)
Page 12 10000W Generator 10000W Generator Fan cover system assy. Carburetor system assy. Description Description APA Part No. APA Part No. APG3090-I-01-JD TUBE CLIP APG3090-H-01-JD SHROUD APG3090-H-02-JD FLANGE BOLT (M6 X 14) APG3090-I-02-JD TUBE A APGG10000-H-03-JD FAN COVER COMP APG3090-I-03-JD TUBE B APG3090-H-04-JD WIRE HARNESS CLIP APG3090-I-04-JD...
Page 13: Air Cleaner
10000W Generator 10000W Generator Starter motor System assy. Control System Assy. APA Part No. Description Description APA Part No. APG3090-01-JD STARTER MOTOR APG3090-M-01-JD CONTROL ASSY APG3090-02-JD SOLENOID APG3090-M-02-JD CONTROL BASE COMP APG3090-03-JD FLANGE BOLT (M8×35) APG3090-M-03-JD CONTROL ADJUSTING APG3090-M-04-JD PAN SCREW (M5 X 34) APG3090-M-05-JD FLANGE BOLT (M6 X 14) APG3090-M-06-JD...
Page 14: Control Box Assy
10000W Generator 10000W Generator Fuel tank system assy. Control box assy. Description APA Part No. APGG10000-P-01-JD FUEL FILLER CAP COMP APGG10000-P-02-JD FUEL FILTER APGG10000-P-03-JD FUEL TANK COMP Description APA Part No. APGG10000-P-04-JD FUEL METER ASSY APGG10000-Q-01-JD CONTROL PANEL COMP APGG10000-P-05-JD FLAT SCREW APGG10000-Q-02-JD ENGINE SWITCH ASSY...
Page 15 10000W Generator 10000W Generator Generator Wheel and hand assy. APA Part No. Description APG3090-S-16-JD HEX.BOLT (M5 X 20) APG3090-S-17-JD VOLT CHANGE TERMINAL BR-AC-W APG3090-S-18-JD PLAIN WASHER (5mm) APG3090-S-19-JD HEX. NUT (M5) APG3090-S-20-JD SPRING WASHER (5mm) 10 11 Description APA Part No. APGG10000-T-01-JD PIN SPLIT APGG10000-T-02-JD...