Sony HDR-CX6EK Service Manual

Digital hd video camera recorder

Hide thumbs Also See for HDR-CX6EK:

Operating manual (36 pages)

Handbook (109 pages)

Read this first (2 pages)

Table of Contents

Quick Links

Need help?

Do you have a question about the HDR-CX6EK and is the answer not in the manual?

Questions and answers

Summary of Contents for Sony HDR-CX6EK

Page 1 0 are critical for safety. sécurité. Replace only with part num- Ne les remplacer que par une pièce ber specified. portant le numéro spécifié. DIGITAL HD VIDEO CAMERA RECORDER 2007K0500-1 HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 © 2007.11 Sony EMCS Co. 9-852-210-32 Published by Kohda TEC...
Page 2: Specifications
(ohms) information at the time of recording. Audio signal: 327 mV (at load impedance 47 k (kilohms)), Output impedance with less The unique pixel array of Sony’s ClearVid than 2.2 k (kilohms) CMOS sensor and image processing system (new Enhanced Imaging...
Page 3 Luminance signal: 1 Vp-p, 75 (ohms) information at the time of recording. Chrominance signal: 0.286 Vp-p, 75 The unique pixel array of Sony’s ClearVid (ohms) CMOS sensor and image processing Audio signal: 327 mV (at load impedance 47 system (new Enhanced Imaging k (kilohms)), Output impedance with less than 2.2 k (kilohms)
Page 4 AC 100 V 240 V 50/60 Hz 18 W DC 8.4 V * A/V OUT 1 Vp-p 75 1 Vp-p 75 0.286 Vp-p 75 327 mV 47 k 48 29 81 mm 2.2 k HDMI OUT HDMI 170 g HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 — 4 —...
Page 5 Model information table Model HDR-CX6EK HDR-CX7 HDR-CX7E HDR-CX7K HDR-CX7EK Destination AEP, UK US, CND, J E, KR, JE AEP, E, AUS, HK, JE Color system NTSC NTSC CAM → PC Data copy PC → CAM × Supplied accessory × ×...
Page 6: Safety Check-Out
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU PUBLISHED BY SONY.
Page 7 ENGLISH JAPANESE ENGLISH JAPANESE • • • • • • • • HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 — 7 —...
Page 8: Self-Diagnosis Function
C : Corrected by customer Refer to “1-3-3. Self-diagnosis Code Table”. Indicates the appropriate H : Corrected by dealer step to be taken. E : Corrected by service E.g. engineer 31 ..Reload the tape. 32 ..Turn on power again. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 9 Fault of writing to or erasing the Inspect the flash memory (IC2201 on the VC-493 board). flashmemory (Note 2) Note 1: After repair, be sure to perform “1-5. PROCESS AFTER FIXING FLASH ERROR”. Note 2: Refer to Service Manual, ADJ (“1-3. DESTINATION DATA WRITE”). HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 10: Method Of Coping With Shift Lens Error
Note: The length of low section will vary a little depending on the conditions. Fig. 2 Change in output voltage of R5792 on the LD-222 board VC-493 BOARD (SIDE A) R5737 IC5703 R5721 IC1803 Fig. 1 Measurement points on the LD-222 board R1846 Fig. 3 Measurement points on the VC-493 board HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 11 (IC1803 of VC-493 board) periphery. Note 2: When the lens block was replaced, execute the necessary adjustment items referring to Service Manual, ADJ. After the adjustment, make sure with the STEADYSHOT turned ON that the steadyshot functions appropriately in the hand- held operation. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 12: Process After Fixing Flash Error
After fixing, this setting needs to be deactivated. Flash error code can be initialized by execution of “Clear All record-data”. Note: For “Clear All record-data”, refer to Service Manual, ADJ (“6. Record Data” of “3-2. SERVICE MODE”). HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 13 Part No. Description Part No. Description A-1334-455-A HOLDER (CX7-U2), SERVICE (MS) A-1334-458-A (CX7K-E23), SERVICE (MS) A-1334-461-A HOLDER (CX7KE-CEN), (MS) HDR-CX7 (CND) HDR-CX7K (KR) HDR-CX6EK (AEP, UK) Serial No. Serial No. Serial No. Part No. Description Part No. Description Part No.
Page 14 The date of manufacture on the labels should be the same as the previous Holder (MS) (circled portions shown on the below). Example: For the figure below, attach the “2007.5” label. * The replacement label and “inset (how to affix)” are supplied together with holder (MS) for service. * Affix the label Manufacturing year HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 15: Service Note
ENGLISH JAPANESE ENGLISH JAPANESE 1. SERVICE NOTE C : 3 1 : 1 1 HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 16 ENGLISH JAPANESE ENGLISH JAPANESE qh qk HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 17 ENGLISH JAPANESE ENGLISH JAPANESE R5737 IC5703 R5721 IC1803 R1846 HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 1-10...
Page 18 ENGLISH JAPANESE ENGLISH JAPANESE HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 1-11...
Page 19 ENGLISH JAPANESE ENGLISH JAPANESE Ω Ω HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 1-12...
Page 20 ENGLISH JAPANESE ENGLISH JAPANESE HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 1-13...
Page 21 ENGLISH JAPANESE ENGLISH JAPANESE HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 1-14E...
Page 22: Note For Repair
(Part code: 1-215-869-11) Wrap insulating tape. C5206 NOTE FOR DISCONNECTING THE HARNESS (COAXIAL CABLE) When disconnecting the harness (Coaxial Cable), do not pull the harness part but pull off the connector body with tweezers etc. Harness (Coaxial Cable) Tweezers etc. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 23: Identifying Parts
⋅ MS-363 Board Section ⋅ Cabinet R Section ⋅ Cabinet L Section 2-2-3. CABINET R SECTION ⋅ Hinge Block 2-2-5. LENS/BT SECTION ⋅ Lens Section ⋅ CK-178 Board ⋅ BT Panel Section ⋅ Loud Speaker ⋅ VC-493 Board ⋅ Flash Unit Section HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 24: Lcd Panel
(See Page 2-6) 1-8 (#2) 2 Front Panel Section 2-2 (Claw) HELP 2-5 (#2) 1-10 (#2) 1-13 1 LCD Panel Section 1-14 (See Page 2-4) 2-4 (#2) (Open) 1-4 (Claw) (#1) (#2) 1-11 (#2) 1-9 (#2) 1-12 (#2) 2-1 (#2) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 25 2-2-2. LCD PANEL SECTION EXPLODED VIEW HARDWARE LIST Follow the disassembly in the numerical order given. 1 LCD Panel Section (1-1 to 1-6) (#2) Cabinet R Section (#2) (See Page 2-5) (Claw) (#2) - 3 2 1 LCD Panel Section HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 26 2 CK-178 Board HELP Note: On installation of the CK-178 board, adjust the position of the Night Shot switch and the Night Shot nob. 3 Loud Speaker - 1 7 3-1 (#3) 2-6 (#3) HELP HELP HELP (#2) 1 Hinge Block HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 27 ST-165 Board R:1 kΩ/1 W (Part code: 1-215-869-11) 1 Top Cabinet Section 1-1 (#2) 3-3 (#2) LENS/BT Section (See Page 2-7) 3-4 (Claw) 1-2 (#2) 3-1 (#2) 3 Cabinet L 2 MS-363 Section Board Section 2-1 (#2) 3-2 (#2) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 28 2-1 (#3) 2 BT Panel Section (#3) 1-12 (Claw) 1-11 (#3) 2-2 (#3) (Note) (#2) (Claw) 1-2 (Claw) 1-10 (#3) 1 VC-493 Board Block (#3) (#3) Note: Refer to page 2-1 “Note for disconnecting the harness (coaxial cable)”. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 2-7E...
Page 29 2 Pass FP-737 flexible board through the flexible clamp 3 Install the flexible clamp in the hinge assy as shown in figure. as shown in figure. Stopper of FP-737 flexible board Flexible clamp Concave side of hinge Flexible clamp HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 HELP...
Page 30 6 Install the FP-744 flexible board in the hinge cover (rear) as shown in figure. FP-744 flexible board Hinge cover (rear) Switch 7 Install the hinge cover (rear) in the hinge assy as shown in figure. Hinge cover (rear) Switch FP-737 flexible board Plate of hinge HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 HELP...
Page 31 Cabinet R section CK-178 board Tape Loud speaker Harness arrangement Front panel section Barrier sheet HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 HELP...
Page 32: Block Diagrams
3. BLOCK DIAGRAMS Link Link OVERALL BLOCK DIAGRAM (1/5) OVERALL BLOCK DIAGRAM (5/5) OVERALL BLOCK DIAGRAM (2/5) POWER BLOCK DIAGRAM (1/3) OVERALL BLOCK DIAGRAM (3/5) POWER BLOCK DIAGRAM (2/3) OVERALL BLOCK DIAGRAM (4/5) POWER BLOCK DIAGRAM (3/3) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 33: Overall Block Diagram
EEP_SI, EEP_SO, EEP_SCK YAW_OUT± YAW_HALL± 128k EEPROM XCS_EEP (4/18) IC_2701_SYSCLK YAW_IN± YAW_HALLBIAS± OVERALL (2/5) (PAGE 3-2) ENO, CN5301 IC5801 DIRA0, X1802 L_EN0,L_DIRA0,L_DIRB0 20MHz DIRB0 SHUTTER_A,XA,SHUTTER_B,XB LENS BARRIER DRIVE(3/4) Q5301 LENS LENS_COVER_LED_ON LENS_COVER_LED_ON BARRIER AB16 DRIVE LENS_COVER_OPEN LENS_COVER_OPEN UNIT : VIDEO SIGNAL HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 34 MS_DATA1 – 3 CN7402 MSDATA0 – MSDATA3 MSX_BIO0 – MSX_BIO3 MEMORY MSX_BIO0 – MSX_BIO3 STICK MSX_BS MS_BS MSX_BS MSBS AM31 MS_SCLK MS_SCLK MSX_CLK MSX_CLK : VIDEO SIGNAL AR32 MS_O/C MS_O/C S7401 : AUDIO SIGNAL (MS COVER OPEN/CLOSE) : VIDEO/AUDIO SIGNAL HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 35 HOT SHOE SHOE_MIC_RL MIC_RL MicRL SHOE_MIC_RL MIC_RR SHOE_MIC_RR MicRR SHOE_MIC_RR CN7602 Q7603 INT_MIC_F INT_MIC_F INT_MIC_F FRONT BUFFER Q7602 MIC901 INT_MIC_L INT_MIC_L INT_MIC_L MICROPHONE BUFFER UNIT Q7601 INT_MIC_R INT_MIC_R INT_MIC_R BUFFER : VIDEO SIGNAL : AUDIO SIGNAL : VIDEO/AUDIO SIGNAL HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 36 EMC_CLK1_OUT S004 CN6103 S6004 EMC_CLK1_IN HOME_SW HOME FILM ROLL INDEX S001 2ND_S/S_SW START/STOP EMC_XRESET_OUT S6009 AF16 NIGHTSHOT S003 2ND_ZOOM(W) (ZOOM) XFLASH_RST OVERALL (5/5) 2ND_ZOOM(T) S6002 (PAGE 3-5) S002 XBATT_VIEW DISP/ BATT INFO XRESET S6001 RESET MS_ACCESS_LED XMS_ACC_LED D6005 (ACCESS) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 37 A_1.2V_2, D_1.2V_2 Q4603 FAST_CHARGE D_1.5V INIT_CHARGE_ON Q4604, EP_2.8V, A_2.8V, AU_2.8V, D_2.8V Q4610(1/2) A_4.6V, AU_4.6V, EP_4.6V D_1.8V CN1004 D4601 D_3.3V BATT_UNREG BATT_UNREG D_2.5V BH001 BATT_SIG BATT_SIG MT_5.0V BATTERY TERMINAL CMOS_4.1V − CAM_-1.0V D4702 D4_-2.8V BL_-V FP-733 EP_8.5V FLEXIBLE LANC_DC BOARD EVER_3.0V HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 38: Power Block Diagram
B8 A8 OUT10-1 C15 +INE10 C14 BL_CONT -INE10 D14 Q4702, 4703 XFL_RST BACKLIGHT SD1 N9 XSYS_RST CONTROL HI_XRESET D4702 POWER (2/3) IC4705 VCH R2 VTR_DD_ON (PAGE 3-7) BATT_LI_3V DC CONTROL, VBATT R1 RESET, LANC DRIVE (17/18) EP_8.5V VOUT3 B2 HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 39 L3203 IC_2701_D_1.2V HDMI D_2.5V MS_PWR_ON L3202 TRANSMITTER D_3.3V (13/18) POWER (3/3) D_1.8V D_1.8V CN7402 RESET# (PAGE 3-8) FP-735 MS-363 BOARD A_4.6V MEMORY FLEXIBLE D_1.5V STICK DUO BOARD D_2.8V CN1002 CN7401 A_2.8V IC1005 D_3.3V MS_VCC A_1.2V 2.9V REG D_1.2V (18/18) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 40 D1002 (1/4) (NIGHTSHOT) IC5703 OPTICAL IMAGE L5701 STABILIZATION DRIVE FP-734 FLEXIBLE BOARD (2/4) XRST_IC_5703_CPU A6 XDL XSYS_RST A7 RESET_N IC6503 CN1009 VST_C_RESET SIRCS_VDD D5 CPU_PIO_0 REMOTE COMMANDER RECEIVER TALLY_VDD IC5801 L5801 LENS BARRIER DRIVE D6502 (3/4) (CAMERA RECORDING) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 3-8E...
Page 41: Frame Schematic Diagram
LEVEL3 LD-222 BOARD LEVEL3 (SIDE A) LD-222 BOARD CN7401 MS-363 BOARD (SIDE B) CN6601 (SIDE A) MS-363 BOARD (SIDE B) CN7402 MEMORY STICK LENS BLOCK CONNECTOR CN001 A/V OUT CN7303 LENS BARRIER MULTI CONNECTOR UNIT FP-738 FLEXIBLE BOARD HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FRAME...
Page 42: Schematic Diagrams
FP-741 FLEXIBLE BOARD (MIC, HOT SHOE, PS EXTENSION BOARD) (VC-ST CONNECTION) FLASH UNIT FP-740 FLEXIBLE BOARD (HOT SHOE) FP-734 FLEXIBLE BOARD CONTROL SWITCH BLOCK (SB25970) (REMOTE COMMANDER RECEIVER) CONTROL SWITCH BLOCK (PS25970) ST-165 BOARD (FLASH DRIVE) COMMON NOTE FOR SCHEMATIC DIAGRAMS HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 43: This Note Is Common For Schematic Diagrams
In addition, ensure that the receiver is not covered with Replace only with part number specified. dusts nor exposed to strong light. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifie. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 44 ENGLISH JAPANESE 4-2. SCHEMATIC DIAGRAMS ENGLISH JAPANESE 4-2. SCHEMATIC DIAGRAMS (JAPANESE) Pattern box PTB-450 For PTB-450: J-6020-250-A J-6082-200-A For PTB-1450: Small pattern box J-6082-559-A PTB-1450 J-6082-557-A L = 1 m (PTB-450) L = 40 cm (PTB-1450) Ω HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 45 Schematic diagrams of the CM-077, VC-493 and LD-222 boards are not shown. Pages from 4-4 to 4-28 are not shown. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 46 REG_GND FP-744 REG_GND FLEXIBLE Page 4-31 N.C. D6009 of Level 2 REG_GND N.C. PANEL_NOR/REV PANEL_NOR/REV PANEL_NOR/REV CN6001 CN6004 SP(+) SP901 SPEAKER SP(-) D6004 S6007 (PANEL OPEN/CLOSE) REG_GND REG_GND PANEL_O/C D6010 CK-178 BOARD CONTROL SWITCH XX MARK:NO MOUNT HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 CK-178 4-29...
Page 47 DRIVE R6134 DRIVE ±0.5% BL_CONT R6130 C6127 R6138 R6132 100k ±0.5% REG_GND REG_GND R6143 100k -9.5 Q6113 UP04601008S0 BACKLIGHT PD-324 BOARD BL_L DRIVE R6144 R6141 LCD DRIVE ±0.5% -10.3 ±0.5% BL_-V XX MARK:NO MOUNT NO MARK:REC/PB MODE HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 PD-324 4-30...
Page 48 R7413 R7407 MS_BS MSBS REG_GND CN7402 MS_O/C CN7401 LND001 SH_GND_A FP-735 MS COVER FLEXIBLE OPEN/CLOSE LND002 Page 4-39 of Level 2 SH_GND_B S7401 D001 MS-363 BOARD FP-744 FLEXIBLE BOARD MS CONNECTOR PANEL REVERSE XX MARK:NO MOUNT HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FP-744, MS-363 4-31...
Page 49 Vin6 13 14 15 16 17 18 19 20 21 22 23 24 XCS_DDRA XBB_SCK BB_SO C3008 R3024 D_2.8V CR-084 BOARD (1/2) COMPONENT OUT, D-TERMINAL DRIVER XX MARK:NO MOUNT NO MARK:REC/PB MODE R:REC MODE P:PB MODE HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 CR-084 (1/2) 4-32...
Page 50 REG_GND LANC_SIG LANC_SIG FP-738 MULTI_JACK_IN JACK_AD FLEXIBLE REG_GND_AV REG_GND Page 4-34 of Level 2 LANC_DC LANC_DC REG_GND_AV REG_GND R7311 VIDEO_I/O VIDEO_I/O CR-084 BOARD (2/2) REG_GND_AV REG_GND S_C_I/O S_C_I/O REG_GND_AV CONNECTOR REG_GND S_Y_I/O S_Y_I/O XX MARK:NO MOUNT HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 CR-084 (2/2) 4-33...
Page 51 LANC_SIG REG_GND_AV 13 DDC_CEC_GND AUDIO_L AUDIO_R_I/O 14 CEC CN001 A/V OUT REG_GND_AV 15 SCL AUDIO_L_I/O +5V_POWER 16 SDA +5V_POWER 17 RESERVED 18 +5V_POWER 19 HPD HDMI FP-738 FLEXIBLE BOARD FP-745 FLEXIBLE BOARD A/V CONNECTOR HDMI CONNECTOR HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FP-738, FP-745 4-34...
Page 52 KEY_AD1(PHOTO_REC) SHOE_UNREG KEY_AD1(PHOTO_FREEZE) SHOE_UNREG R7619 REG_GND 1200 SHOE_UNREG XPOWER_SW XMODE_SW LND001 SHOE_GND CN7604 CHISSIS_GND SHOE_GND SHOE_GND SHOE_GND D7608 D7609 D7610 D7611 D7612 CN7601 PH-002 BOARD MIC, HOT SHOE, PS EXTENSION BOARD XX MARK:NO MOUNT NO MARK:REC/PB MODE HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 PH-002 4-35...
Page 53 Level 3 MIC_FR REG_GND IC6503 SHOE_GND F_TALLY_LED RS-770 TALLY LED REMOTE COMMANDER D6502 SML-512UWT86 RECEIVER (CAMERA RECORDING) FP-740 FLEXIBLE BOARD FP-734 FLEXIBLE BOARD HOT SHOE REMOTE COMMANDER RECEIVER (PRINTED WIRING BOARD is omitted.) NO MARK:REC/PB MODE HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FP-740, FP-734 4-36...
Page 54 ST_GND REG_GND REG_GND BATT_LI_3V MT_5V R5207 BH5301 D5307 C5301 BATTERY HOLDER D5308 C5302 BT901 LITHIUM BATTERY Note: BT901 (lithium battery) is not included in ST-165 complete board. ST-165 BOARD FLASH DRIVE XX MARK:NO MOUNT NO MARK:REC/PB MODE HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 ST-165 4-37...
Page 55 Level 3 BATT_UNREG BATT_UNREG BATT_UNREG BH001 BATT_UNREG BATTERY TERMINAL BATT_UNREG Note: BH001 is not included in FP-733 flexible board. BATT_UNREG FP-742 FLEXIBLE BOARD FP-733 FLEXIBLE BOARD LD-VC CONNECTION BATTERY TERMINAL (PRINTED WIRING BOARD is omitted.) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FP-731, FP-733, FP-742 4-38...
Page 56 EP_2.8V EP_2.8V LND024 LND301 1pin EP_8.5V EP_8.5V 1pin FP-735 FLEXIBLE BOARD FP-737 FLEXIBLE BOARD CK-178 CN6003 VC-MS CONNECTION Page 4-29 CK-PD CONNECTION of Level 2 (PRINTED WIRING BOARD is omitted.) (PRINTED WIRING BOARD is omitted.) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FP-736, FP-737, FP-735 4-39...
Page 57 USB_D+ USB_D+ USB_D- REG_GND USB_D- REG_GND USB_VBUS USB_GND USB_GND REG_GND USB_VBUS CR-084 VC-493 (2/2) (18/18) CN7301 CN1010 Page 4-33 Page 4-24 of Level 2 of Level 3 FP-743 FLEXIBLE BOARD VC-CR CONNECTION (PRINTED WIRING BOARD is omitted.) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FP-743 4-40...
Page 58 LND208 LND133 SHOE_UNREG SHOE_UNREG LND207 LND134 SHOE_UNREG SHOE_UNREG LND206 LND135 LND205 LND136 SHOE_GND SHOE_GND LND204 LND137 SHOE_GND SHOE_GND LND203 LND138 SHOE_GND SHOE_GND LND202 LND139 SHOE_GND SHOE_GND LND201 FP-739 FLEXIBLE BOARD VC-PH CONNECTION (PRINTED WIRING BOARD is omitted.) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FP-739 4-41...
Page 59: Control Switch Block
R001 13PIN N.C. 14PIN 1/8W XE_A LND014 15PIN XE_A LND015 16PIN XE_A XE_A LND016 17PIN XE_A LND017 18PIN LND051 FLASH UNIT FLASH UNIT is replaced as block, so that PRINTED WIRING BOARD is omitted. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FP-741, FLASH UNIT, SB25970 4-42...
Page 60 START/STOP START/STOP S5311 KEY_AD1(STROBE SW) FLASH REG_GND D_2.8V ZOOM_VR PH-002 CN7604 RV103 Page 4-35 (ZOOM) of Level 2 CONTROL SWITCH BLOCK (PS25970) CONTROL SWITCH BLOCK (PS25970) is replaced as block, so that PRINTED WIRING BOARD is omitted. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 PS25970 4-43...
Page 61: Printed Wiring Boards
PH-002 BOARD PD-324 BOARD (SIDE A) FP-734 FLEXIBLE BOARD PD-324 BOARD (SIDE B) ST-165 BOARD FP-744 FLEXIBLE BOARD FP-731 FLEXIBLE BOARD MS-363 BOARD FP-733 FLEXIBLE BOARD FP-736 FLEXIBLE BOARD CR-084 BOARD FP-738 FLEXIBLE BOARD COMMON NOTE FOR PRINTED WIRING BOARDS HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 62: This Note Is Common For Printed Wiring Boards
: pattern of the rear side (The other layers’ patterns are not indicated) • Through hole is omitted. • There are a few cases that the part printed on diagram isn’t mounted in this model. • C: panel designation (JAPANESE) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 4-44...
Page 63 Printed wiring boards of the CM-077, VC-493 and LD-222 boards are not shown. Pages from 4-45 to 4-48 are not shown. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 64 CK-178 (4 layers) : Uses unleaded solder. CK-178 BOARD (SIDE A) CN6002 CN6003 1-871-820- CN6004 S6009 D6004 NIGHTSHOT D6009 HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 CK-178 (SIDE A) 4-49...
Page 65 CK-178 (4 layers) : Uses unleaded solder. CK-178 BOARD (SIDE B) PANEL R6006 OPEN/CLOSE S6007 BACK LIGHT DISP/ FILM ROLL INDEX BATT INFO R6009 R6005 R6008 RESET EASY 1-871-820- (ACCESS) D6005 HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 CK-178 (SIDE B) 4-50...
Page 66 R6152 R6118 R6146 R6117 C6118 Q6108 C6115 C6114 R6123 C6113 R6121 C6122 C6119 Q6109 R6131 L6103 C6120 LD6102 C6124 L6102 LD6105 R6104 R6145 R6101 R6105 C6125 CN6103 C6101 C6102 D6103 D6105 CN6104 CN6105 CN6102 1-871-779- HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 PD-324 (SIDE A) 4-51...
Page 67 PD-324 (2 layers) : Uses unleaded solder. PD-324 BOARD ( SIDE B ) D6108 D6107 (BACK LIGHT) D6106 1-871-779- HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 PD-324 (SIDE B) 4-52...
Page 68 FP-744 (1 layer), MS-363 (4 layers) : Uses unleaded solder. FP-744 FLEXIBLE BOARD >PI< FP-744 1-873-343 S001 (PANEL REVERSE) S001 1-873-343- 11 MS-363 BOARD (SIDE A) MS-363 BOARD (SIDE B) MS COVER OPEN/CLOSE S7401 CN7401 CN7402 LND002 LND001 1-871-818- 1-871-818- HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FP-744, MS-363 4-53...
Page 69 1-873-448- (INTERFACE CONNECTOR) Note: CN7303 (interface connector) is not supplied, HDMI but this is included in CR-084 complete board. 1-873-344- 11 Note: CN1001 is not supplied, but this is included in FP-745 flexible complete board. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 CR-084, FP-738, FP-745 4-54...
Page 70 PH-002 BOARD (SIDE B) PH-002 BOARD (SIDE A) R7615 CN7602 CN7603 R7601 R7607 R7602 R7608 R7603 R7609 D7611 D7612 D7609 D7610 R7623 R7622 LND001 CN7604 1-873-350- 1-873-350- FP-734 FLEXIBLE BOARD FP734 D6502 (CAMERA RECORDING) IC6503 1-873-333- 11 >PI< HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 PH-002, FP-734 4-55...
Page 71 When mounting these parts, mount new battery CAUTION holder first and attach new lithium battery next. Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type. Note: HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 ST-165 4-56...
Page 72 Note: BH001 is not included in BATTERY FP-733 flexible board. TERMINAL J001 DC IN FP-731 1-873-330- Note: J001 is not included in FP-731 flexible board. 1-873-332- 11 FP-736 FLEXIBLE BOARD FP-736 1-873-335 >PI< 1-873-335- 12 HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 FP-731, FP-733, FP-736 4-57E...
Page 73: Repair Parts List
ELECTRICAL PARTS LIST Link Link ACCESSORIES PD-324 BOARD CK-178 BOARD FP-736 FLEXIBLE BOARD PH-002 BOARD CR-084 BOARD FP-738 FLEXIBLE BOARD FP-731 FLEXIBLE BOARD ST-165 BOARD FP-744 FLEXIBLE BOARD FP-733 FLEXIBLE BOARD FP-745 FLEXIBLE BOARD FP-734 FLEXIBLE BOARD MS-363 BOARD HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 74 : Argentine model AUS : Australian model : Brazilian model : Chinese model CND : Canadian model : East European model HK : Hong Kong model : Japanese model : Tourist model : Korea model : North European model HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 75: Overall Section
(See Page 5-6) Front Panel Section (See Page 5-3) LCD Panel Section (See Page 5-4) Ref. No. Part No. Description Ref. No. Part No. Description 3-215-117-01 PLATE, L ORNAMENTAL 2-635-562-11 SCREW (M1.7) (Black) 3-215-111-01 COVER, HC 2-635-562-31 SCREW (M1.7) (Black) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 76: Front Panel Section
3-215-068-01 RING, F CAUTION SHEET, BARRIER X-2178-953-1 PANEL ASSY, F * 57 3-219-855-01 SHEET, FR A-1283-814-A FP-734 FLEXIBLE BOARD, COMPLETE 2-660-401-01 SCREW (M1.7), NEW TRU-STAR, P2 (Red) * 54 3-215-067-01 PLATE (F), GROUND 3-078-890-11 SCREW, TAPPING (Silver) A-1217-971-A LENS BARRIER UNIT HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 77: Lcd Panle Section
3-272-529-01 CUSHION (P (3)) 2-666-802-01 PRISM SHEET V (2.7) * 118 3-272-530-01 CUSHION (P (2)) 2-887-999-01 FRONT FRAME (2.7J) 2-666-807-02 AG SHEET (2.7) LCD901 A-1202-059-A TP BLOCK ASSY (27ESTMG07) 2-635-562-31 SCREW (M1.7) (Black) CAUTION SHEET, FLEXIBLE GUARD 3-078-890-11 SCREW, TAPPING (Silver) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 78 3-215-090-01 COVER (REAR), HINGE 2-635-562-11 SCREW (M1.7) (Black) X-2178-955-1 CABINET (R) ASSY (J) 2-635-562-31 SCREW (M1.7) (Black) X-2178-972-1 CABINET (R) ASSY (E) (EXCEPT J) 2-660-401-01 SCREW (M1.7), NEW TRU-STAR, P2 (Red) 2-589-376-01 FOOT (395), RUBBER A-1283-815-A FP-744 FLEXIBLE BOARD, COMPLETE HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 79: Main Body Section
A-1334-462-A HOLDER (CX6EK-CEH), (MS) (CX6EK: AEP, UK) A-1334-456-A HOLDER (CX7-CA2), SERVICE (MS) (CX7: CND) (Note) (Note) 2-635-562-31 SCREW (M1.7) (Black) A-1334-457-A HOLDER (CX7E-CN2), SERVICE (MS) 3-078-890-11 SCREW, TAPPING (Silver) (CX7E: CH) (Note) A-1334-458-A HOLDER (CX7K-E23), SERVICE (MS) (CX7K: E, JE) (Note) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 80: Top Cabinet Section
(EXCEPT J) CN901 1-818-890-11 CONNECTOR, EXTERNAL (HOT SHOE) 1-873-339-11 FP-740 FLEXIBLE BOARD MIC901 1-542-711-11 MICROPHONE UNIT 2-635-562-11 SCREW (M1.7) (Black) * 255 3-215-073-01 FRAME, SHOE 2-660-401-01 SCREW (M1.7), NEW TRU-STAR, P2 (Red) A-1283-811-A PH-002 BOARD, COMPLETE 3-078-890-11 SCREW, TAPPING (Silver) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 81: Cabinet L Section
3-215-108-01 RETAINER, TRIPOD X-2178-973-1 CABINET (L) ASSY (E) (EXCEPT J) 3-215-107-01 SCREW, TRIPOD 2-589-376-01 FOOT (395), RUBBER * 309 3-215-105-01 BRACKET (FRONT), BELT * 304 3-215-106-01 BRACKET (REAR), BELT 2-635-562-31 SCREW (M1.7) (Black) 3-096-396-01 SHEET, TRIPOD 3-078-890-11 SCREW, TAPPING (Silver) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 82 3-215-116-01 SHEET, VC RADIATION 1-756-134-12 BATTERY, STORAGE, LITHIUM (Note) 0 J001 A-1283-995-A VC-493 BOARD, COMPLETE (SERVICE) 1-815-792-11 CONNECTOR, DC-IN (7.2V) (CX7/CX7K) 2-635-562-31 SCREW (M1.7) (Black) A-1283-996-A VC-493 BOARD, COMPLETE (SERVICE) 2-660-401-01 SCREW (M1.7), NEW TRU-STAR, P2 (Red) (CX7E/CX7EK) 3-078-890-11 SCREW, TAPPING (Silver) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...
Page 83: Lens Section
A-1209-688-A CMOS BLOCK ASSY (CMOS IMAGER) * 408 X-2178-951-1 HEAT SINK ASSY, CM (Note 2,3) A-1237-309-A CM-077 BOARD, COMPLETE (SERVICE) 2-660-401-01 SCREW (M1.7), NEW TRU-STAR, P2 (Red) 1-965-256-11 HARNESS (COAXIAL CABLE) (Note 1) 3-078-890-11 SCREW, TAPPING (Silver) * 411 3-217-389-01 GASKET (MC) HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 5-10...
Page 84 1-780-064-21 BATTERY TERMINAL BOARD A-1283-817-A FP-738 FLEXIBLE BOARD, COMPLETE 2-635-562-31 SCREW (M1.7) (Black) * 459 3-219-758-01 SHEET, AV FLEXIBLE 2-660-401-01 SCREW (M1.7), NEW TRU-STAR, P2 (Red) A-1283-809-A CR-084 BOARD, COMPLETE 3-078-890-11 SCREW, TAPPING (Silver) 1-873-342-11 FP-743 FLEXIBLE BOARD HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 5-11...
Page 85: Electrical Parts List
1-786-148-11 SWITCH, PUSH (1 KEY) (PANEL OPEN/CLOSE) S6009 1-771-731-21 SWITCH, SLIDE (NIGHTSHOT) S6010 1-771-138-21 SWITCH, KEY BOARD (N) S6011 1-771-138-21 SWITCH, KEY BOARD (EASY) Electrical parts list of CM-077 board is not shown. Pages 5-13 is not shown. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 5-12...
Page 86 (J001 is not included in FP-731 flexible board.) Electrical parts list of LD-222 board is not < CONNECTOR > shown. Pages 5-15 and 5-16 are not shown. 0 J001 1-815-792-11 CONNECTOR, DC-IN (7.2V) • Refer to page 5-1 for mark 0. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 5-14...
Page 87 * CN6101 1-785-905-51 FFC/CONNECTOR, FPC (ZIF) 24P R6152 1-218-990-81 SHORT CHIP * CN6102 1-794-322-51 FFC/CONNECTOR, FPC (ZIF) 6P * CN6103 1-794-322-51 FFC/CONNECTOR, FPC (ZIF) 6P R6153 1-218-990-81 SHORT CHIP * CN6105 1-785-905-51 FFC/CONNECTOR, FPC (ZIF) 24P R6154 1-218-990-81 SHORT CHIP R6155 1-216-864-11 SHORT CHIP HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 5-17...
Page 88 When mounting these parts, mount new battery holder first < IC > and attach new lithium battery next. 0 IC5201 6-707-554-01 IC TPS65552DGQR Note: • Refer to page 5-1 for mark 0. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 5-18...
Page 89 (DCRA-C191) 1-770-783-21 Component Video Cable A/V Connecting Cable 1-821-282-21 (AEP, UK) 1-829-414-61 1-823-156-51 Memory Stick PRO Duo (4GB) USB Cable Wireless Remote Commander (HDR-CX6EK/CX7K/CX7EK) (Note) 1-829-868-31 (RMT-835) 1-479-275-41 DVD-ROM “ENJOY HANDYCAM” 3-093-691-01 (KR) ENGLISH/KOREAN/JAPANESE 3-093-691-11 (US, CND) ENGLISH/FRENCH/SPANISH/PORTUGUESE 3-093-691-21 (UK)
Page 90 “Handycam Application Software” order it with the part number below. (“Picture Motion Browser (Software)”/ (Only for destination Japanese model) “Picture Motion Browser Guide”/ “Handycam Handbook (PDF)”) 3-214-682-02 HDR-CX7 HDR-CX6EK/CX7E/CX7EK 3-214-656-01 (JAPANESE) 3-214-657-11 (ENGLISH) 3-214-657-21 (FRENCH) HDR-CX7/CX7K 3-214-657-31 (GERMAN) 3-214-656-11 (ENGLISH) 3-214-657-41 (DUTCH)
Page 91 Ver. 1.2 2007.11 • J MODEL DVD-ROM AC-L200/L200B 1-792-549-41 (DCRA-C190) * L200 L200B 3-093-691-01 1-821-282-11 0 1-479-285-21 1-823-156-51 1-829-414-11 1-829-868-31 RMT-835 1-479-275-31 CD-ROM Handycam Application Software NP-FH60 0 A-1201-665-A 3-214-682-02 • 0 HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 5-28E...
Page 92 8 Install the hinge cover (front) in the hinge cover (rear). Note: Avoid it so as not to nip the flexible board, and lock four claws while covering with the hinge cover (front) straight. 2007K0500-1 HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 © 2007.11 Sony EMCS Co. 9-852-210-81 Published by Kohda TEC...
Page 93 When mounting these parts, mount new battery holder first specified. portant le numéro spécifié. and attach new lithium battery next. Note: CAUTION Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type. HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2 — 2 —...
Page 94 HARDWARE LIST (1/4) #1: M1.7 X 2.5 #2: M1.7 X 4.0 #3: M1.7 X 2.5 #4: M1.4 X 2.5 (Tapping) (Black) (Black) (Red) (Dark Silver) 2-635-562-11 2-635-562-31 2-660-401-01 3-348-998-81 #5: M1.7 X 3.5 (Tapping) #6: M1.4 X 1.7 #7: M1.7 X 1.6 #8: M1.7 X 3.5 (Tapping) (Black) (Silver)
Page 95 HARDWARE LIST (2/4) #21: M1.4 X 3.0 #22: M1.7 X 5.0 (Tapping) #23: M1.7 X 4.0 (Tapping) #24: B1.7 X 5.5 (Tapping) (Black) (Silver) (Black) (Black) 2-662-396-21 3-083-261-01 3-080-204-11 4-679-805-11 #25: M1.7 X 3.0 #26: M1.4 X 2.0 #27: M1.4 X 2.0 #28: M1.4 X 4.0 (Tapping) (Black) (Silver)
Page 96 HARDWARE LIST (3/4) #41: M3.0 X 8.0 (Tapping) #42: M2.0 X 4.0 (Tapping) #43: M1.7 X 4.0 #44: M1.7 X 3.0 (Tapping) (Silver) (Silver) (Red) (Silver) 3-065-748-01 7-628-253-00 2-660-401-31 3-078-890-61 #45: M1.4 X 2.5 #46: M1.7 X 3.0 #47: M1.4 X 3.0 (Tapping) #48: M1.7 X 2.5 (Silver) (Red)
Page 97 HARDWARE LIST (4/4) #64: M1.7 X 5.0 (Tapping) #61: M3.0 X 10.0 #62: M2.0 X 3.0 #63: M5.0 X 12.5 (Silver) (Black) (Silver) (Black) 2-666-551-21 7-682-549-09 3-080-202-21 3-060-811-21 12.5 10.0 #65: M1.4 X 3.5 #66: M1.4 X 1.4 #67: M1.4 X 2.0 #68: M1.7 X 4.0 (Silver) (Silver)
Page 98: Revision History
S.M. correction:Page 4-37, Page 4-38, Page 5-10, Page 5-27, Page 5-28 2007.11 Supplement-1 • Addition of Attention Sentence of HELP (S1 DI07-196) • Change of Repair Parts • Revision of Accessories S.M. revised: Page 5-26, Page 5-27, Page 5-28 HDR-CX6EK/CX7/CX7E/CX7K/CX7EK_L2...

This manual is also suitable for:

Hdr-cx7 Hdr-cx7e Hdr-cx7k Hdr-cx7ek

Sony HDR-CX6EK Service Manual

Quick Links

Need help?

Questions and answers

Related Manuals for Sony HDR-CX6EK

Summary of Contents for Sony HDR-CX6EK

This manual is also suitable for:

Table of Contents