Page 1
RX-6020VBK SERVICE MANUAL AUDIO/VIDEO CONTROL RECEIVER RX-6020VBK Area suffix J ---------------------- U.S.A. C ------------------- Canada RX-6020V AUDIO/VIDEO CONTROL RECEIVER FM/AM TUNING FM/AM PRESET FM MODE STANDBY MASTER VOLUME MEMORY PTY–PTY SEARCH–PTY STANDBY/ON D I G I T A L S U R R O U N D...
Page 2
RX-6020VBK 1. This design of this product contains special hardware and many circuits and components specially for safety purposes. For continued protection, no changes should be made to the original design unless authorized in writing by the manufacturer. Replacement parts must be identical to those used in the original circuits. Services should be performed by qualified personnel only.
Page 3
RX-6020VBK Importance administering point on the safety LVA1029-C9 B110 PW104 TA201 B109 B108 B106 Primary part PW105 PW102 TA202 B105 B107 B104 FC211 PW103 B103 6.3A-125V F 201 B102 PW101 B101 FC212 B192 B191 FC232 FC222 B159 Secondary parts F 203...
Page 4
RX-6020VBK Disassembly method Top cover Removing the top cover (See Fig.1) Remove the four screws A attaching the top cover on both sides of the body. Remove the three screws B on the back of the body. Remove the top cover from behind in the direction of the arrow while pulling both sides outward.
Page 5
RX-6020VBK Removing the digital signal board / audio input board / DVD board / video board and tuner board on the audio board (See Fig.5 to 8) Prior to performing the following procedure, remove Audio board the top cover and the rear panel.
Page 6
RX-6020VBK Removing the audio board (See Fig.9) Relay board Prior to performing the following procedure, remove the top cover and the rear panel. power supply board Disconnect the card wire from connector CN402 on CN473 CN291 the audio board. Disconnect the relay board from the audio board and Power the power supply board.
Page 7
RX-6020VBK Removing the power transformer (See Fig.13) Power supply Prior to performing the following procedures, remove board the top cover. Solder points Cut off the tie band fixing the harness. FW201 Tie band Unsolder the two harnesses connected to the power...
Page 8
RX-6020VBK Removing the system control board / Operation switch panel Front panel assembly power switch board (See Fig.16 to 18) Prior to performing the following procedure, remove the top cover and the front panel assembly. Pull out the volume knob on the front side of the front panel and remove the nut attaching the system control board.
Page 9
RX-6020VBK Adjustment method Tuner section 1.Tuner range 87.5MHz~108.0MHz AM(MW) 530kHz~1710kHz Power amplifier section Adjustment of idling current Measurement location TP301(Lch) , TP302(Rch) Adjustment part VR301(Lch) , VR302(Rch) Attention This adjustment does not obtain a correct adjustment value immediately after the amplifier is used (state that an internal temperature has risen).
Page 10
RX-6020VBK Description of major ICs AK4527BVQP (IC601) : A/D,D/A converter 1.Pin layout Top View 2. Pin function (1/2) Symbol Function SDOS SDTO Source Select Pin (Note 1) "L" : Internal ADC output, "H" : DAUX input OSKS Control Mode Select Pin "L"...
Page 11
RX-6020VBK Pin function (2/2) AK4527 Symbol Function Connect to GND ICKS No internal bonding. Analog Input Format Select Pin, Digital Power Supply ADIF "H" : Full-differential input, "L" : Single-ended input Chip Address 1 Pin, Connect to GND CAD1 Chip Address 0 Pin, Connect to GND...
Page 13
RX-6020VBK 2.Pin Function M62446FP Pin No. Symbol Function OUT4 BASS BOOST control terminal SURROUND control terminal OUT3 VIDEO 2 control terminal OUT2 VIDEO 1 control terminal OUT1 Analog positive power supply terminal AVDD SUB Woofer volume signal input terminal SW IN Analog ground terminal A.GND...
Page 14
RX-6020VBK MN101C35DJW (IC701) : System controller 1. Pin layout 2. Pin function (1/2) Symbol Function Pin No. VOL.JOG IN_1 VOL.JOG IN_1 VOL.JOG IN_2 VOL.JOG IN_2 DATA (PLL) DATA (PLL) (PLL) (PLL) (PLL) (PLL) VIDEO S/C DVD VIDEO S/C DVD VIDEO S/C VCR...
Page 15
RX-6020VBK Pin function (2/2) MN101C35DJW Symbol Function Pin No. CLK DSP (DSP) READY READY (DSP) RESET RESET (DSP) RY S RELAY SURRUND RY C RELAY CENTER RY L/R1 RELAY FRONT 1 RY L/R2 RELAY FRONT 2 RY HP RELAY HEADPHONE...
Page 16
RX-6020VBK UPD784215AGC167 (IC671) : Dital signal controller 1.Pin layout 2.Pin function (1/2) Pin No. Symbol Function Non connect Power supply terminal Connecting the crystal oscillator for system main clock Connecting the crystal oscillator for system main clock Connect to GND...
Page 17
RX-6020VBK Pin function (2/2) UPD784215AGC167 Pin No. Symbol Function Interface I/O terminal with microcomputer MILP Interface I/O terminal with microcomputer MIACK Non connect Non connect Reset signal output of DSP DSPRST Non connect 54~63 Interface I/O terminal with microcomputer CODEC OUT...
Page 18
RX-6020VBK LA1838 (IC102) : FM AM IF amp. & Detector, FM MPX decoder 1. Block Diagram DECODER RF.AMP ANIT-BIRDIE MUTE BUFF STEREO P-DET AM IF PILOT 384KHz COMP S-METER AM/FM S-CLRVE S-METER IF-BUFF TUNING STEREO DRIVE DRIVE FM IF 2. Pin Function...
Page 23
RX-6020VBK IMX9-W (IC652, IC662, IC682) : Driver TC7SET32FU (IC672) : Z-Input or gate 1. Pin layout / Block diagram 1. Pin layout / Block diagram IN B IN A OUT Y TC74HCU08AF (IC611) : Inverter 1. Pin layout / Block diagram 2.The truth value table...
Page 24
RX-6020VBK W24L010AJ-12 (IC641) : SRAM 1. Pin layout 2. Block diaglam DECODER CORE ARRAY I/O1 CONTROL DATA I/O I/O8 3. Pin function Pin No. Symbol Function Symbol Pin No. Function No Connection I/O4 Data Input/Output Address Input I/O5 Data Input/Output...
Page 26
RX-6020VBK VICTOR COMPANY OF JAPAN, LIMITED AUDIO & COMMUNICATION BUSINESS DIVISION PERSONAL & MOBILE NETWORK BUSINESS UNIT. 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.21063) 200202(V)
RX-6020VBK Block diagram VIDEO MONITOR DVD FRONT IC451 SELECTOR DVD IN CENTER TUNER IC501 RF101 IC121 OUT VCR REC DVD REAR/ SUB WOOFER AM/FM DET MW RF&OSC IN VCR P.B. SUB WOOFER IC102 T111 AV COMPU LINK CN451 PLL CLK, PLL DATA, PLL CE,...
Page 28
RX-6020VBK RX-6020VBK Standard schematic diagrams Power supply section Audio / Video signal input terminal section PW311 PW101 CN251 QGA3901F2-03 To sheet 6/7 G-3 F202 C441 C443 C445 QGF1205C1-14 4.7/50 0.022 CN201 2A-125V RY_HP 4.7/50 RY_LR2 C419 F203 0.022 IC403 RY_LR1...
Page 34
RX-6020VBK RX-6020VBK Tuner section FM/TUNER Signal Parts are safety assurance parts. When replacing those parts make sure to use the specified one. CN411 To sheet 4/7 B-5 SHEET 7/7...
RX-6020VBK PARTS LIST [ RX-6020VBK ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix J ----------------------------- U.S.A. C -------------------------- Canada - Contents - 3- 3 Exploded view of general assembly and parts list (Block No.M1) 3- 5 Electrical parts list (Block No.01~05)
Page 41
RX-6020VBK Exploded view of general assembly and parts list Block No. Power trans board Power trans board Speaker board Power/Fuse board Relay board Main board Audio board Power supply board power switch board System control board...
Page 42
RX-6020VBK RX-6020VBK Parts list (General assembly) Parts list (General assembly) Block No. M1MM Block No. M1MM Item Parts number Parts name Q'ty Description Area Item Parts number Parts name Q'ty Description Area LV10457-019A FRONT PANEL QYSBSGY3008M SPECIAL SCREW 4 INPUT...
Page 43
RX-6020VBK Electrical parts list (Power amp board) Block No. 01 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area C 201 QFLC2AJ-104Z M CAPACITOR .10MF 5% 100V C 813 QFLC1HJ-103Z M CAPACITOR .010MF 5% 50V...
Page 44
RX-6020VBK Electrical parts list (Power amp board) Block No. 01 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area D 221 1SS133-T2 SI DIODE IM Q 311 KTC3200/GL/-T TRANSISTOR D 301 1SS133-T2 SI DIODE IM...
Page 45
RX-6020VBK Electrical parts list (Power amp board) Block No. 01 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area R 314 QRE141J-563Y C RESISTOR 56K 5% 1/4W R 804 QRE141J-563Y C RESISTOR 56K 5% 1/4W...
Page 46
RX-6020VBK Electrical parts list (Power amp board) Block No. 01 Item Remarks Parts number Parts name Area R 913 QRE141J-563Y C RESISTOR 56K 5% 1/4W R 915 QRJ146J-331X UNF C RESISTOR 330 5% 1/4W R 921 QRJ146J-100X UNF C RESISTOR...
Page 47
RX-6020VBK Electrical parts list (Main board) Block No. 02 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area C 400 QCBB1HK-223Y C CAPACITOR .022MF 10% 50V D1301 30DF2-FC DIODE C 419 QCBB1HK-223Y C CAPACITOR .022MF 10% 50V...
Page 48
RX-6020VBK Electrical parts list (Main board) Block No. 02 Item Remarks Parts number Parts name Area R 445 QRE141J-104Y C RESISTOR 100K 5% 1/4W R 446 QRE141J-104Y C RESISTOR 100K 5% 1/4W R 449 QRJ146J-271X UNF C RESISTOR 270 5% 1/4W...
Page 49
RX-6020VBK Electrical parts list (System control & Audio board) Block No. 03 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area BK701 LV42093-001A FL HOLDER(L) C1438 QETN0JM-477Z E CAPACITOR 470MF 20% 6.3V BK702 LV42092-001A FL HOLDER(R)
Page 50
RX-6020VBK Electrical parts list (System control & Audio board) Block No. 03 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area Q1408 KTA1271/OY/-T TRANSISTOR R 724 NRSA63J-122X MG RESISTOR Q1413 2SC3576-JVC-T TRANSISTOR I/M R 725...
Page 51
RX-6020VBK Electrical parts list (System control & Audio board) Block No. 03 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area R1404 QRJ146J-272X UNF C RESISTOR 2.7K 5% 1/4W S 725 QSW0683-001Z PUSH SWITCH FM MODE...
Page 52
RX-6020VBK Electrical parts list (DSP board) Block No. 04 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area C 601 NCB31HK-102X C CAPACITOR C2508 NCS31HJ-330X C CAPACITOR C 602 NCB31HK-102X C CAPACITOR C2512 NCF31CZ-104X C CAPACITOR...
Page 53
RX-6020VBK Electrical parts list (DSP board) Block No. 04 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area IC661 BA15218F-XE R 676 NRSA63J-432X MG RESISTOR IC662 IMX9-W R 677 NRSA63J-822X MG RESISTOR IC671 UPD784215AGC167 IC(MICRO C ROM)
Page 54
RX-6020VBK Electrical parts list (DSP board) Block No. 04 Item Remarks Parts number Parts name Area R2564 NRSA63J-103X MG RESISTOR R2565 NRSA63J-202X MG RESISTOR R2566 NRSA63J-202X MG RESISTOR R2567 NRSA63J-103X MG RESISTOR R2568 NRSA63J-103X MG RESISTOR R2569 NRSA63J-122X MG RESISTOR...
Page 55
RX-6020VBK Electrical parts list (Tuner board) Block No. 05 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area AT101 QNB0014-001 ANT TERMINAL R 115 NRSA02J-104X MG RESISTOR BK 1 LV31618-001A SHIELD BKT R 119 NRSA02J-103X...
Page 56
RX-6020VBK Packing materials and accessories parts list Block No. Block No. A2~A9 3-18...
Page 57
RX-6020VBK Parts list (Packing) Block No. M3MM Item Parts number Parts name Q'ty Description Area QPA02503505P POLY BAG LV20983-029A CARTON BOX LV20925-001A PACKING PAD LV20926-001A PACKING PAD QPC06507015P POLY BAG Parts list (Accessories) Block No. M5MM Item Description Parts number...