Lance 1130 Owner's Manual

Truck camper
Hide thumbs Also See for 1130:
Table of Contents

Advertisement

Quick Links

TABLE OF CONTENTS

5
5
5
5
7
9
10
11
11
11
12
12
12
13
®
15
15
16
17
18
21
21
21
21
22
22
23
23
23
23
25
25
26
26
27
27
27
27
27
27
27
28
28
28
29
29
30
30
31
31
31
32
35
35
35
36
36
36
37
37
37
38
38
38
38
39
39
39
39
40
40
40
40
40
41
41
41
41
41
41
42
42
42
42
45
45
45
45
45
46
46
46
47
47
47
47
1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 1130 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Lance 1130

  • Page 1: Table Of Contents

    TABLE OF CONTENTS CARBON MONOXIDE GAS EFFECTS OF PROLONGED OCCUPANCY LIMITED WARRANTY VENTILATION AND MOISTURE CONTROL COVERAGE PROVIDED DRIPPING CEILING VENTS OWNER’S OBLIGATION INTERIOR ODORS EXCLUSIONS FIRE AND SAFETY A FEW IMPORTANT WORDS ON SAFETY FIRE EXTINGUISHER SMOKE DETECTOR WELCOME CARBON MONOXIDE AND PROPANE LEAK DETECTOR CUSTOMER RELATIONS INFORMATION...
  • Page 2 FRESH WATER SYSTEM FUSES INTERIOR LIGHTING WATER PUMP SOLAR PANEL PRE-WIRE WATER TANK FILL SOLAR PANEL CITY WATER CONNECTION MOMENTARY LIGHT WATER SYSTEM DRAIN DOCKING LIGHTS SANITIZING FRESH WATER SYSTEM TELEPHONE JACK WATER FILTER PARK CABLE INLET SHOWER TV/SATELLITE ANTENNA PRE-WIRE EXTERIOR WASH STATION ROOF MOUNTED ANTENNA AND TV OUTLET TV ANT/SAT DISH COMBO...
  • Page 3 MAINTENANCE CHART 2 WINTERIZATION OPERATING IN FREEZING CONDITIONS STORAGE SHORT-TERM STORAGE LONG-TERM STORAGE STORAGE BELOW FREEZING WINTERIZING METHOD WATER HEATER BYPASS REACTIVATION CAMPER AFTER STORAGE OUTSIDE AREA 12-VOLT SYSTEM FRESH WATER SYSTEM PROPANE SYSTEM GENERAL 120-VOLT SYSTEM MAINTENANCE CAMPER LOADING AND CHECKOUT TYPICAL BULBS AND FUSES EXTERIOR SEALANT CHART SCHEMATICS...
  • Page 4 This page intentionally blank.
  • Page 5: Limited Warranty

    As the manufacturer of the Camper that you purchased, Lance does not know the purpose you have in mind for your truck and camper, nor does Lance know the Gross Vehicle Weight Rating (“GVWR”) of your truck. Therefore, Lance makes no warranties or representations, express or implied, as to the performance of your truck with the Camper or whether the match up of your truck and Camper exceeds the GVWR as specified by your truck’s manufacturer.
  • Page 6: Identification Information

    IDENTIFICATION INFORMATION For identification purposes it is recommended that you write the camper serial number inside your camper. Pick a spot behind a drawer or inside a cabinet. Protect yourself from possible theft and be able to identify your property. You should keep a copy of this information at home.
  • Page 7: A Few Important Words On Safety

    Fire or explosion may be the result. Lance Camper Manufacturing is required to furnish the following consumer information as provided by the National Fire Protection Association and the American The following label has been placed near the front on National Standards Institute.
  • Page 8 A warning label has been located near the propane The following label has been placed in the vehicle near container. This label reads: the range area: WARNING DANGER DO NOT FILL PROPANE CONTAINERS) TO MORE IF YOU SMELL PROPANE: THAN 80 PERCENT OF CAPACITY. FAILURE TO 1.
  • Page 9: Welcome

    Your selection of a Lance was a wise investment. included in this publication were as accurate as Lance Camper is confident that it will give you years of possible at the time of publication. For the most current camping pleasure.
  • Page 10: Customer Relations Information

    43120 Venture Street www.lancecamper.com, under the dealer locator Lancaster, California 93535-4510 USA heading, or by contacting the Lance Customer Service 661 949-3322 Department at 661 949-3322, who can direct you to a dealer in your area.
  • Page 11: Information About This Manual

    This Owner’s Manual is of a general nature only and does not cover every aspect of all models manufactured by the Lance Camper Mfg. Corp. Each owner should read this manual thoroughly and heed the warnings given herein, as well as those warnings given in the component instruction manuals contained in the Owner’s Information Package.
  • Page 12: Dealer Responsibility

    If • Owner’s Information Package you are not sure, call your Lance dealer for help! Also, • Two sets of keys for entry door, exterior access alterations or modifications to your camper may void doors and slideout control switch your warranty.
  • Page 13: Reporting Safety Defects

    However, NHTSA cannot become involved in individual problems between you, your dealer, or Lance Camper Manufacturing Corporation. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-888-327-4236, or write to: NHTSA, 400 Seventh St., S.W., Washington, D.C.
  • Page 14 This page intentionally blank.
  • Page 15: Camper And Truck

    Selecting the right combination requires understanding that weight from the GVWR. a few guidelines. Your Lance dealer can be a valuable source of information when matching a camper to your truck. The truck bed is mounted to the frame of the truck with mounts that allow for some movement.
  • Page 16: Tires

    RV’s become overloaded when people put too many When loading the camper, store heavy gear first, things into them. There is no easy way to determine keeping it on or close to the camper floor. Place heavy the weight you’ve loaded, so there’s a temptation to things far enough forward to keep the loaded keep loading until every available space if filled.
  • Page 17: Electrical Connection To Truck

    Lance Dealer to your truck wiring system. With the refrigerator. wiring and connectors hooked-up, your truck will supply 12-volt DC power to charge your camper To protect your truck’s 12-volt system from overload, a...
  • Page 18: Truck/Camper Load Worksheet

    TRUCK/CAMPER LOAD WORKSHEET The truck must be weighed with occupants and full of fuel. Drive onto the scales and get the weight of the total truck. Next pull forward until the front axle is off the scale and get the weight on the rear axle. Subtract the weight on the rear axle from the total truck weight to get the weight on the front axle.
  • Page 19 TRUCK/CAMPER LOAD WORKSHEET TRUCK WEIGHT: INDIVIDUAL AXLE AND GROSS VEHICLE WEIGHTS STEP 1A = GVW STEP 1B = GAW STEP 1C GAW = (1A – 1B) SCALE WEIGHT LBS. LBS. LBS. GVWR GAWR REAR GAWR FRONT FROM FEDERAL CERT. LABEL LBS.
  • Page 20 This page intentionally blank.
  • Page 21: Support Equipment

    Rear turnbuckles should quality tiedowns and turnbuckles. The front NEVER be used on the front of the camper. The rear turnbuckles must be spring or shock loaded. Lance turnbuckles are the pair with the shorter (8") barrels. recommends Happijac tiedowns and turnbuckles.
  • Page 22: Cabover Truck Struts

    EXCLUSIVE LANCE CABOVER TRUCK STRUTS (Shock Absorbers) To dampen the vertical movements of the camper cabover, it is advisable to install the optional Lance Cabover Struts. The length of the vertical movement built into the strut will allow them to remain connected to the truck and camper under all but the most rough travel conditions.
  • Page 23: Loading And Unloading

    12-volt electrical MANUAL BALL SCREW JACKS connector extension (available from your Lance Dealer) To extend or retract a jack, push handle onto alignment can be used to connect the camper to the tube and depress the release bar with plastic push truck to power the jacks.
  • Page 24 Before operating the remote control electric camper jacks, be sure to read and understand the operating instructions that were provided with your camper pertaining to their safe operation. The power relay (receiver) for your remote jacks is located on the driver’s side forward most cabinet, usually in the cabover step.
  • Page 25: Loading/Removing Camper

    If the jacks still fail to operate, consult your Lance service center for more information and help. Manual Override Operation: To manually extend or retract jack, unplug the jack from the camper.
  • Page 26: Removing Camper From Truck

    1. process until the camper will clear the truck body bed Your camper is designed to be used while standing on by approximately 4". the jacks in a lowered position without damage to the 2. Slowly back truck under camper making sure to clear camper.
  • Page 27: On The Road

    5. Always keep tires in good condition and when ON THE ROAD replacing, be certain that the new tires have the L OADING load carrying capacity of your truck’s G.V.W.R. When loading camper gear, store heavy items first and 6. Check that access doors are securely closed. place down low.
  • Page 28: Riding In Camper While Traveling

    increases, driving stability, stopping ability, and ability CAMPGROUND REGULATIONS to make emergency maneuvers are greatly reduced. You should always check the campground regulations on arrival. This will avoid any unnecessary conflict with Reduce speed before starting down hills - even the campground management and/or other short ones - and avoid heavy braking on downgrades.
  • Page 29: Effects Of Prolonged Occupancy

    ventilation may increase furnace-heating load during EFFECTS OF PROLONGED cold weather, it will greatly reduce water condensation. OCCUPANCY Even when it is raining or snowing, ventilation air from outside will be far drier than interior air and will Your camper was designed primarily for recreational effectively reduce condensation inside the camper.
  • Page 30: Dripping Ceiling Vents

    Follow the preceding steps to control moisture condensation. Insulated hatch and vent covers are available. Consult your Lance Dealer. INTERIOR ODOR New units may have a strong odor and even cause eye and lung irritation when closed up in hot weather.
  • Page 31: Fire And Safety

    FIRE AND SAFETY The hazard and possibility of fire exists in all areas of life, and the recreational lifestyle is no exception. Your camper is a complex device made up of many materials - some of them flammable. But like most hazards, the possibility of fire can be virtually eliminated by recognizing the danger and practicing common sense safety and maintenance habits.
  • Page 32: Carbon Monoxide And Propane Leak Detector

    not light see the section, “Trouble-Shooting Guide” in COMBINATION CARBON MONOXIDE AND the User’s Manual for this alarm provided in the PROPANE LEAK DETECTOR Owner’s Information Package. A permanently installed detector is located near the floor in the forward portion of the main camper floor This alarm will operate normally down to 7v DC.
  • Page 33 If the alarm sounds a second time after the propane is turned back on, leave the propane off and have a Lance Service Center make the necessary repairs to the source of the propane leak. Be aware of the difference between a propane leak versus propane escaping from an unlit, open burner.
  • Page 34 This page intentionally blank.
  • Page 35: Equipment

    ROOF All Lance models have a fully decked and laminated roof that may be walked on from front to rear and are The Propane Tank Compartment Door provides rated at 2,000 lbs.
  • Page 36: Vents

    FANTASTIC ROOF VENT The Exterior Service Center is accessed by lifting up on the driver side skirt door. This door has a gas assisted two position strut which opens to 90 degrees. This position will allow access to the compartment when the slideout is in the extended (out) position.
  • Page 37: Cabover Skylight/Vent

    CABOVER VENT HEKI MIDI The cabover vent is operated from inside and has a This skylight is dual pane and opens to three positions. built-in screen. It can be cranked open to allow for It has a sliding screen and insulated shade. ventilation or by pulling on the red lever opened fully to allow access to the roof.
  • Page 38: Roof Rack

    Be sure to write down the key number on the Identification Information Page located in the front of this manual. Your Lance dealer can obtain duplicates with this number.
  • Page 39: Saf-T-Vue ® Window

    AWNINGS The emergency exit window is located in the cabover or dinette area of the camper and is identified by the red handle(s) and EXIT label. Read and understand these instructions before you need to use them. The emergency exit window provides an escape route in case the camper must be evacuated under emergency conditions and the path An operating and maintenance guide for your...
  • Page 40: Camper Bumper/Step

    The mating harness and monitor are available from your Lance Dealer. INTERIOR STORAGE Interior storage areas may be found in a number of places in your camper: overhead compartments, wall closets, under the dinette, under the bed, lavy and galley cabinets.
  • Page 41: Cabover Area

    sink. Information on the toilet plumbing can be found in DAY/NIGHT SHADES the “Waste System” section. The day/night shades are dual-purpose window covering that provides privacy at night and light CABOVER AREA control during the day. Do not allow anyone, children especially, to ride in the To operate, pull down on the lower bar to expose the cabover area while traveling.
  • Page 42: Folding Divider Door

    FOLD-DOWN TENT FOLDING DIVIDER DOOR The divider allows you to separate the cabover area from the main camper. It glides on nylon rollers. It is held closed by a catch. When the divider is open for traveling, be sure to attach the hold back latch to keep it from sliding back and forth.
  • Page 43 G rab the tent flap along the bed door and pull it over the edge of the door. From the inside of the tent, disconnect the over-center lever arms on each side of the bed door, insert into the tent bows and lock into position.
  • Page 44 This page intentionally blank.
  • Page 45: Electrical Systems

    BATTERY TERMINOLOGY ELECTRICAL SYSTEMS Deep Cycle Batteries The electrical system consists of a primary 12-volt DC The term “deep cycle” refers to a battery that has the system and a 120-volt AC system. The 12-volt system capability of deeply discharging hundreds of times. uses battery power similar to that used in automobiles.
  • Page 46: Battery Storage Precautions

    Use care when connecting or disconnecting booster Check that the battery liquid level is correct (weekly in leads or cables while charging. Poor connections are a warm climate, monthly in cold climate). Don’t forget to common cause of electrical arcs that can cause also check the condition of your truck battery.
  • Page 47: Battery Disconnect Switch

    Have the system checked by your Lance dealer. MONITOR PANEL - LEVEL INDICATOR SWITCH CAMPER FUSE PANEL 12-volt Interior Circuits...
  • Page 48: Fuses

    If the replacement fuse of the same rating blows in a short time, there is probably an electrical problem with your camper. Leave the blown fuse in that circuit and have your camper checked by your Lance dealer. The solar panel is mounted on the roof beside the INTERIOR LIGHTING cabover skylight over the cabover bed area.
  • Page 49: Momentary Light

    TV/SATELLITE ANTENNA PRE-WIRE All Lance Camper models are pre-wired with (2) RG6 cables installed that run from the roof antenna location to the primary TV location. Two cables are run so that...
  • Page 50: Tv Ant/Sat Dish Combo

    STEREO/SPEAKER PRE-WIRE NOTE: The 12-volt outlet is intended for a TV only and All Lance campers are pre-wired for a future stereo rated for 7.5 amps. DO NOT USE FOR HIGHER system. The speakers or speaker wiring are located in RATED APPLIANCES.
  • Page 51: A/B Switch

    120-VOLT POWER CORD Your camper is equipped with a heavy-duty power cord for connection to an external 120-volt, 30 amp rated service. The cord is commonly called the “shore cord”. The cord and plug are molded together to form a weatherproof assembly. Do not cut or alter the cord in any way.
  • Page 52: Power Converter

    15 minutes which helps prevent trips repeatedly, reduce the load on that circuit and problems with battery sulfation which leads to have the system checked by your Lance dealer. premature battery failure. POWER CONVERTER GROUND FAULT CIRCUIT INTERRUPTER A Ground Fault Circuit Interrupter (GFCI) protects the bathroom, galley, and patio 120-volt receptacles.
  • Page 53: Power Generator

    To start the generator: Press the START/STOP switch Do not use this compartment for the operation of a to the start position and hold until the unit starts. Make portable generator. sure that all electrical equipment is turned off prior to Generator ready condition includes: the vented starting and that the propane valve is opened on the compartment door (see caution note), 12-volt pre-wired...
  • Page 54: Generator Maintenance And Service

    Outside air movement can carry exhaust gases inside of the loads exceeds the generator’s power. Allow the the vehicle through windows or other openings remote air conditioner to operate on the thermostat setting. If from the exhaust opening. Operate the engine (s) only manually operated, it may cause an overload condition.
  • Page 55: Propane Gas System

    Always check fitting for leaks after tightening. 10. Be sure the tanks are securely fastened whenever they are mounted on the camper. 11. Go to a Lance dealer for any propane system repairs. 12. Always think safety.
  • Page 56: Filling Propane Tanks

    FILLING PROPANE TANK USING PROPANE SYSTEM It is normal to have a slight gas odor when initially All new propane tanks must be purged of air and opening the outlet valve. Fully open and seat valve by moisture before filling for the first time. The propane tanks should be filled according to the instructions on hand only to prevent leakage past the valve stem.
  • Page 57: Propane At Low Temperature

    Some portable BBQ’s open. can be converted to low-pressure by changing the propane valve to a low-pressure valve. Lance Camper When this water freezes, the ice can build-up and offers low-pressure propane BBQ’s, which are available partially or totally block the propane supply.
  • Page 58 This page intentionally blank.
  • Page 59: Appliances

    Pre-cool food and drinks before putting them into the appliance. If you have a problem, see your local Lance camper refrigerator. service center or call the appliance manufacturer listed For off-truck use, some refrigerator models must have in the back of this manual.
  • Page 60: Convection Or Microwave Oven

    6. Turn on the water supply. asphyxiation. It is especially important that cooking 7. Close the faucet when water flows continuously appliances not be used for comfort heating as the without sputtering. danger of asphyxiation is greater when the appliance 8.
  • Page 61: Combination Furnace/Air Conditioner Thermostat

    Shut off gas to the appliance. conditioner to your camper, Lance recommends that Extinguish any open flame. you consult your Lance dealer for specific models of Open Lid. power saver, easy start units. Lance recommends that If odor continues, immediately call your gas you have your dealer install the air conditioner unit on supplier or your fire department.
  • Page 62 This page intentionally blank.
  • Page 63: Fresh Water System

    approximately 4 amps. A fuse in the power center FRESH WATER SYSTEM protects the water pump circuit. Your Camper is outfitted with a system designed to provide fresh (potable) water service from an onboard When traveling, always turn OFF the water pump. water tank or a city water connection with a fresh water This will reduce the possibility of water flowing during tank fill located on the roadside of the camper.
  • Page 64: City Water Connection

    7. Replace cap and lock the access door. CITY WATER CONNECTION SANITIZING FRESH WATER SYSTEM Sanitize the fresh water system and piping at initial use, at least once a year and whenever the camper sits for a prolonged period. This will help keep the The city water inlet connection is located under the tank and lines fresh and will discourage the growth of roadside overhang.
  • Page 65: Shower

    The exterior wash station is located in the service An in-line water filter attached to the inlet side of the center on the roadside compartment for exterior use. It water pump filters dirt, mineral scale, or organic matter uses water from the fresh water tank or when out of the fresh water system.
  • Page 66 This page intentionally blank.
  • Page 67: Waste System

    WASTE SYSTEM DUMPING THE HOLDING TANKS The holding tanks terminate in a valve arrangement The waste holding system in your camper is made up that permits each tank to be dumped separately or of sinks, shower, toilet plumbing drain and vent lines, together.
  • Page 68: Holding Tank Care/Maintenance

    5. Allow enough time for the tank to drain completely. If the drain system does get clogged: Rinse and flush the tank and drain hose through Use a hand-operated probe to loosen the toilet with a bucket of water or a hose. stubborn accumulations.
  • Page 69: Slide-Out Room System

    If the When the room is retracted, material clinging to the breaker continues to trip, contact your Lance Dealer. exterior surfaces may be brought into the camper. Always check the exterior surfaces of the slide-out MANUAL OVERRIDE OPERATION room before retracting it.
  • Page 70: Electrical System Maintenance

    When fully retracted, engage travel locks and contact box and proper battery maintenance. Contact your you Lance dealer for service, if required. When the Lance dealer for any other service requirements. motor is disengaged, the slideout room WILL NOT lock in place.
  • Page 71: General Maintenance

    does not harm the finish. Remember to re-wax these GENERAL MAINTENANCE areas, even if the rest of the camper does not need This section explains why it is important to keep your waxing. When you have washed and rinsed the whole camper well maintained, how to preserve the exterior, dry it with a chamois or soft towel.
  • Page 72: Damage Checks

    Acrylic If areas on the roof need to be resealed, remove any Cleaning Kits are available from your Lance dealer. loose or cracked sealant being careful not to damage the roof. Use a wooden or plastic scraper that will not...
  • Page 73: Jack Brackets

    WARNING: It is important that the turnbuckles be kept clean and Never use abrasive, caustic cleaners, alcohol or protected from corrosive agents, such as salt spray, solvents as they can cause permanent damage to the acid rain, etc. This is best done by cleaning and finish.
  • Page 74: Interior Maintenance

    fabric and MicroMesh™. This allows moisture to Cleaning escape, so condensation will be on the waterproof Cleaning your tent is not necessary unless it has an rainfly, not inside the tent. Unfortunately, no tent offensive odor or becomes heavily soiled. If heavily design will totally eliminate condensation in all soiled, the pressure from a regular garden hose will conditions, but providing good ventilation using any of...
  • Page 75: Wall And Ceiling Panels

    chemicals can harm the plastic in your waste system. spots. Your can also use commercially-available spray A standard wire drain cleaner is recommended. or foam-type vinyl cleaners. WARNING Do not use lacquer thinner, nail polish SHOWER CARE remover, carbon tetrachloride, gasoline, or naphtha for For routine cleaning use a non-abrasive cleaner.
  • Page 76 This page intentionally blank.
  • Page 77: Maintenance Chart 1

    MAINTENANCE CHART 1 Before Use Start of At Setup Service to be performed Each Trip or Weekly Monthly For details, see respective section. Inspect wiring, connector plug & receptacles Check exterior lighting Inspect and tighten mounting bolts on each jack corner bracket. Trim excess putty Check that camper anchors are secure Check that cabover stabilizers are secure and lubricate Inspect propane system compartment for leaks and kinked lines...
  • Page 78: Maintenance Chart 2

    MAINTENANCE CHART 2 Annualy or Service to be performed Every 6 After Long For details, see respective section. Months Storage Inspect camper jacks and lubricate per manufacturer’s recommendations Inspect roof sealants (required maintenance) Inspect compartment and access doors, moldings and window sealants (required maintenance) Inspect all hot, cold and drain plumbing Sanitize fresh water tank Complete propane pressure check &...
  • Page 79: Winterization

    Recharge as necessary. camper yourself. Many owners prefer to have a Lance Clean terminals, top and sides of battery and Dealer Service Center perform this service.
  • Page 80: Winterizing Method

    6. Turn the winterize valve to “Winterize” position. may have occurred, please consult your Lance Dealer 7. Turn ON the water pump switch. Service Center for advise.
  • Page 81: 12-Volt System

    120-VOLT SYSTEM 1. Inspect the 120-volt electrical system - power cord, converter, and outlets. If defects are found, refer service to a Lance Dealer Service Center. Happy Camping 2. Prepare the AC generator (if equipped) for operation following instructions in the generator...
  • Page 106: Suppliers Service Phone And Internet Listing

    This phone listing is provided to assist you in case of emergencies, if you are stranded somewhere not close to a Lance service center or qualified RV repair facility. Due to continual product development, some suppliers, phone numbers and web sites may change from those shown.

This manual is also suitable for:

2008 1130

Table of Contents

Save PDF