Summary of Contents for JBJ Submariner UVF-5W
- Page 1 OWNER’S MANUAL 5 Watt & 7 Watt Models TRANSWORLD AQUATIC ENTERPRISES INC...
- Page 2 Table of Contents Important Safety Instructions 3—5 Parts Introduction Installation Operation Maintenance Procedures 11-14 Maintenance Log...
- Page 3 WARNING To guard against injury, basic safety precautions should be ob- served, including the following: READ ALL SAFETY INSTRUCTIONS BEFORE USE. DANGER UV EXPOSURE: Do not operate lamp outside housing, direct exposure to UV rays can cause temporary reddening and irrita- tion of eyes and skin.
- Page 4 To avoid the possibility of the ap- pliance plug or receptacle getting wet, position aquarium stand and tank to one side of a wall mounted receptacle to prevent water from dripping onto the receptacle or plug. A “drip loop”, shown in the Figure at the right should be arranged by the user for each cord connecting an aquarium appliance to a receptacle.
-
Page 5: Operation
Make sure an appliance mounted within the tank is securely installed before operating it. Read and observe all the important notices on the appliance. This Appliance has a polarized plug (one blade is wider than the other). As a safety feature, this plug will fit in a polarized out- let only one way. - Page 6 PARTS EXPLODED VIEW & IDENTIFICATION Description Part # Pump Motor + Swivel UVF-1 Spout Adjustable Flow Valve UVF-2 Magnetic Impeller UVF-3 Ceramic Shaft UVF-4 Impeller Housing Cap UVF-5 Suction Cup Mounting UVF-6 Bracket Remote Ballast UVF-7 ON/OFF Switch UVF-8 Power Cord UVF-9 UV Lamp Connection UVF-10...
- Page 7 Innovative Algae & Disease Control Thank you for purchasing the proactive solution to eradicating harmful mi- cro-organisms and unattractive green free-floating algae in fresh & saltwater aquariums. This revolutionary UV sterilizer/clarifier is completely submersible, which can be placed either in the main body of the aquarium or positioned horizontally in a sump for a clutter free set-up.
- Page 8 CAUTION: Inspect UV Lamp & Quartz Sleeve Prior to Installation. Do not allow children to operate this aquarium appliance. Do not operate if appliance has a damaged cord or plug. Initial Inspection - For breakage Upon receiving this product please unsnap pump and pull out quartz sleeve and thoroughly inspect for breakage from shipping.
-
Page 9: Choosing A Location
Adjusting Flow Rate + Swivel Spout Nozzle Swivel Spout Nozzle: Adjust according to your desired flow direction. Adjustable Flow Valve: Adjust slower for parasites (left position) & faster for bacteria and (74-132 GPH) free-floating algae (right position). The ability to adjust flow rates puts you in total control of what you intend to eradicate. -
Page 10: Operation Mode
Operation Mode The Submariner UV-C sterilizer/clarifier is preassembled for quick operation. Once installed and positioned securely, you will gain instant germicidal bene- fits against parasites and bacteria. No need for tubes, purchasing pumps sepa- rately, or messy attachments. Operation –Principle The first step to long-term consistent sterilization is an adequate mechanical pre-filter to trap particulate matter and debris. - Page 11 Maintenance Made Simple Regular maintenance is the key to consistent disease control. Please perform routine maintenance on your UV for peak performance: • Replacement of Pre-Filter Sponge / Monthly • Cleaning of the Quartz Sleeve / Monthly • Cleaning of the pump Impeller/ Every other Month •...
- Page 12 Replacing the UV-C Lamp—Yearly The UV-C lamp has an average life span of 8000 hours of operation. Al- though the lamp may illuminate, it will not perform effectively for disease control. Lamp should be replaced before it expires. Unsnap the pump from the UV (page 11) and remove the quartz sleeve. Your kit includes our Lamp Removal Tool for disassembling the UV-C lamp from the Quartz Sleeve.
-
Page 13: Replacing The Uv-C Lamp
Replacing the UV-C Lamp STEP 4: Align Quartz Sleeve Cap within the notched grooves of the Lamp Removal Tool. STEP 5: Firmly grasp. Lamp Removal Tool and Quartz Sleeve and pull apart. STEP 6: Firmly grasp the base of the UV- C lamp and pull apart from Quartz Cap. - Page 14 Recommended Maintenance Model UVF-5W UVF-7W UV Lamp PL- 5 Watt PL-7 Watt Volts/Hz AC110V/60Hz AC110V/60Hz Pump Flow: Min/Max 74-132 GPH 74-132 GPH Aquarium Capacity 40 Gallons Up to 75 Gallons Life Of UV Lamp Approx. 8000 hrs Approx. 8000 hrs Avg.
- Page 16 TransWorld Aquatic Enterprises, Inc 3730 W. Century Blvd #3 Inglewood, CA 90303 Phone: (310) 672-4099 Visit us at www.jbjlighting.com...