2. ASSEMBLY OF YOUR NEW BICYCLE ......................2 3. GENERAL WARNING ..........................2 4. OWNER’S RESPONSIBILITY ........................3 5. FIGURE OF THE YUBA BODA BODA AND PARTS DESCRIPTION ..............4 6. ASSEMBLY AND ADJUSTMENT ........................ 4 Assembly of the front wheel ........................5 7.
“Maintenance” sections of this booklet (on page 11) in order to keep the bicycle in good operating condition. Yuba Bicycles LLC does not warrant damage or injury resulting from negligence, improper operation, improper or unauthorized repair or from maintenance, environmental influences, and improper use. Yuba excludes incidental and consequential damages.
5. FIGURE OF THE YUBA BODA BODA AND PARTS DESCRIPTION 6. ASSEMBLY AND ADJUSTMENT Although your YUBA bike is 85% assembled, there are a few steps that must be completed before it is ready to ride. If you have questions or concerns about any of these steps, please see a bicycle dealer or contact YUBA toll free at 877 889-YUBA.
Pick up the bike and sharply hit the top of the tire. The wheel must not come off, be loose, or move from side to side. Yuba Bicycles LLC Boda Boda Cargo Cruiser [ Owner’s Manual v1.1] Page 5...
If you are experiencing a shimmy, slow down your dealer for inspection and repair. immediately. Take your bicycle directly to a dealer for inspection and repair. Yuba Bicycles LLC Boda Boda Cargo Cruiser [ Owner’s Manual v1.1] Page 6...
Consult your local bike can fail suddenly, causing loss of control, or serious injury. shop to find accessories appropriate for your riding needs. Yuba Bicycles LLC Boda Boda Cargo Cruiser [ Owner’s Manual v1.1] Page 7...
Cable stretching could affect the function after some time, so that synchronization may no longer be assured. Check and adjust as follows: Yuba Bicycles LLC Boda Boda Cargo Cruiser [ Owner’s Manual v1.1] Page 8...
Page 10
If the tension is adjusted according to the above steps, the chain should follow all shifting commands on the twist shifters. If the gear system still does not function properly, please contact a bicycle retailer for assistance. Yuba Bicycles LLC Boda Boda Cargo Cruiser [ Owner’s Manual v1.1] Page 9...
Damaged units should be promptly replaced. CONTROL CABLES: Replace worn or damaged cables. Do not kink cables. Cables stretch with use; adjust accordingly. Keep control cable lubricated. Yuba Bicycles LLC Boda Boda Cargo Cruiser [ Owner’s Manual v1.1] Page 11...
Page 13
SPOKES: Check spoke tension regularly. Approximately the same tension should be applied to all spokes. If there is minor loosening of the spokes, you may tighten the nipples, but it is recommended that you take Yuba Bicycles LLC Boda Boda Cargo Cruiser [ Owner’s Manual v1.1] Page 12...
Page 14
The front derailleur should shift smoothly and easily between the chainwheels. If the front derailleur does not shift correctly, it can be adjusted as follows: Yuba Bicycles LLC Boda Boda Cargo Cruiser [ Owner’s Manual v1.1] Page 13...
Page 15
Adjust limiting screw “L” to allow for this and position it to bottom against the derailleur housing to prevent any additional inward travel of the rear derailleur. This will stop the chain from running off the inside of the large rear sprocket. Yuba Bicycles LLC Boda Boda Cargo Cruiser [ Owner’s Manual v1.1] Page 14...
Children incapable of riding a bike on their own or under the age of four should not ride on the Boda Boda as passengers, unless it's equipped with an approved Child Seat accessory. Children should not ride as passengers without an adult operating the Boda Boda Bicycle.
Carrying long loads (ladder, surfboard, solar panels…) Long loads up to 5m (or 15 ft) can be carried on the lovehandles platform(s) of the Boda Boda Cruiser bike. In some cases a block (foam for example) might be needed to keep the load(s) away from the pedal(s).
Third, go on-line. The companies that make the parts of your bike offer information and help is just a click away. Limited Warranty The Boda Boda frame including carrier and lovehandles platforms are warranted against breakage for two years from date of purchase to be free from defects in materials and workmanship subject to the conditions Yuba Bicycles LLC Boda Boda Cargo Cruiser [ Owner’s Manual v1.1]...
Page 19
A partial list of preventable damage not covered by this warranty: rusting of the Boda Boda frame; bending of the Boda Boda 's chainstays by overloading behind the dropouts; failure of the Boda Boda 's rear wheel; bending of the carrier or the love handles.