(MFR’S VERSION A) SERVICE MANUAL LCD TV/DVD COMBINATION 23HLV86 The above model is classified as a green product (*1), as indicated by the underlined serial number. This Service Manual describes replacement parts for the green product. When repairing this green product, use the part(s) described in this manual and lead-free solder (*2).
Hazardous Substances. From July 1, 2006, the RoHS Directive will prohibit any marketing of new products containing the restricted substances. Increasing attention is given to issues related to the global environmental. Toshiba Corporation recognizes environmental protection as a key management tasks, and is doing its utmost to enhance and improve the quality and scope of its environmental activities.
• Place the unit on a workstation equipped to protect against static electricity, such as conductive mat. • Soldering iron with ground wire or ceramic type is used. • A worker needs to use a ground conductive wrist strap for body. A1-2 23HLV86...
(Reading should not be above 0.5mA) Leakage Current Tester 1.5K ohm 0.15 µF PRODUCT UNDER TEST TEST PROBE Test all exposed KNOWN EARTH 2-Blade polarized metal surfaces GROUND type cord set Fig. 1 AC Leakage Test A1-3 23HLV86...
18) Do not push objects through any openings in this unit, as they may touch dangerous voltage points or short out parts that could result in fire or electric shock. Never spill or spray any type of liquid into the unit. A1-4 23HLV86...
Page 6
24) Reduce the volume to the minimum level before you turn on the product. Otherwise, sudden high volume sound may cause hearing or speaker damage. A1-5 23HLV86...
Page 7
If the liquid gets in your mouth, immediately gargle and consult with your doctor. Also, if the liquid gets in your eyes or touches your skin, consult with your doctor after rinsing for at least 15 minutes or longer in clean water. A1-6 23HLV86...
• Soldering combination: Sn-3.0Ag-0.5Cu • When Soldering/Removing of solder, use the draw in equipment over the Pick Up Unit to keep the Flux smoke away from it. Pick Up PCB Short circuit using a soldering iron. Fig. 1 A1-7 23HLV86...
Set the DVD to the Stop Mode. Press it in order of ‘SETUP’, ‘SUBTITLE’, ‘3’, ‘AUDIO’ and ‘0’ key of a remote control unit. The On Screen Display message ‘ ‘ will appear. The Tray Lock has now been cleared. A1-8 23HLV86...
TABLE OF CONTENTS GREEN PRODUCT PROCUREMENT ............... A1-1 LEAD-FREE SOLDER ....................A1-1 CAUTION ........................A1-2 IMPORTANT SERVICE SAFETY INFORMATION ............. A1-3 IMPORTANT SAFEGUARDS ..................A1-4~A1-6 WHEN REPLACING DVD DECK ................A1-7 DISC REMOVAL METHOD AT NO POWER SUPPLY ..........A1-8 PARENTAL CONTROL - RATING LEVEL ..............
1W at 120V 60Hz Energy Star Per Year -- kWh/Year Protector Power Fuse Safety Circuit IC Protector(Micro Fuse) Regulation Safety Radiation Laser DHHS Temperature Operation +5oC ~ +40oC Storage -20oC ~ +60oC Operating Humidity Less than 80% RH A3-1 23HLV86(FOR USA)
Page 12
RIGHT / FAV + DOWN TV MENU/SETUP EXIT / CANCEL GAME PIC SIZE PAUSE PLAY STOP CH RTN /<SKIP SEARCH - SEARCH + Closed Caption / SKIP> < SLOW ANGLE Marker SLOW > TOP MENU RETURN REPEAT A-B A3-2 23HLV86(FOR USA)
Page 14
UM size x pcs UM-4 x 2 pcs OEM Brand AC Adapter AC Cord (for AC Adapter) AV Cord (2Pin-1Pin) Registration Card (NDL Card) 300ohm to 75ohm Antenna Adapter Sheet Information (Return) Sheet Information (HDMI) Screw for wall hanging A3-4 23HLV86(FOR USA)
Page 15
Container Stuffing (40' container) Sets G-17 Material Cabinet Front PS 94V0 DECABROM Rear PS 94V0 DECABROM Non-Halogen Demand Eyelet Demand G-18 Environment Environmental standard requirement (by buyer) Green PROCUREMENT of TOSHIBA Pb-Free Phase 3 (Phase 3A) Measures for Whisker A3-5 23HLV86(FOR USA)
Page 16
1W at 120V 60Hz Energy Star Per Year -- kWh/Year Protector Power Fuse Safety Circuit IC Protector(Micro Fuse) Regulation Safety UL/CSA Radiation FCC/IC Laser DHHS Temperature Operation +5oC ~ +40oC Storage -20oC ~ +60oC Operating Humidity Less than 80% RH A3-6 23HLV86(FOR CANADA)
Page 17
RIGHT / FAV + DOWN TV MENU/SETUP EXIT / CANCEL GAME PIC SIZE PAUSE PLAY STOP CH RTN /<SKIP SEARCH - SEARCH + Closed Caption / SKIP> < SLOW ANGLE Marker SLOW > TOP MENU RETURN REPEAT A-B A3-7 23HLV86(FOR CANADA)
Page 19
UM size x pcs UM-4 x 2 pcs OEM Brand AC Adapter AC Cord (for AC Adapter) AV Cord (2Pin-1Pin) Registration Card (NDL Card) 300ohm to 75ohm Antenna Adapter Sheet Information (Return) Sheet Information (HDMI) Screw for wall hanging A3-9 23HLV86(FOR CANADA)
Page 20
Container Stuffing (40' container) Sets G-17 Material Cabinet Front PS 94V0 DECABROM Rear PS 94V0 DECABROM Non-Halogen Demand Eyelet Demand G-18 Environment Environmental standard requirement (by buyer) Green PROCUREMENT of TOSHIBA Pb-Free Phase 3 (Phase 3A) Measures for Whisker A3-10 23HLV86(FOR CANADA)
Remove the Stand Angle in the direction of arrow (B). Remove the Angle Handle-DVD in the direction of arrow. Remove the 4 screws 3. Remove the Hinge Ass'y in the direction of arrow (C). Angle Handle-DVD Stand Stand Angle Hinge Ass'y Fig. 1-4 Fig. 1-2 B1-1 23HLV86...
Page 22
Pick Up Unit to keep the Flux smoke away from it. When installing the DVD Deck, remove all the soldering on the short circuit position after the connection of Pick Up PCB and DVD MT PCB connector. B1-2 23HLV86...
Page 23
Remove the 4 screws 3. Remove the Plate Jack-1 and Shield Jack-1 in the direction of arrow (B). Remove the 7 screws 4. Remove the AV PCB in the direction of arrow (C). Holder PCB-DVD Operation 2 PCB CP2251 Fig. 1-10 B1-3 23HLV86...
Page 24
Remove the 8 screws 3. Remove the LCD Cover in the direction of arrow (B). Remove the 4 screws 4. Remove the LCD Panel in the direction of arrow (C). Angle Hinge LCD Cover LCD Panel Front Cabinet Fig. 1-11 B1-4 23HLV86...
Shield Wire. (Refer to Fig. 3-4.) NOTE Do not move the Braided Shield Wire in the vertical Blower type IC direction towards the IC pattern. desoldering machine Braided Shield Wire Soldering Iron Fig. 3-2 IC pattern Fig. 3-4 B3-1 23HLV86...
Page 28
Fig. 3-6 3. Absorb the solder left on the lead using the Braided Shield Wire. (Refer to Fig. 3-7.) NOTE Do not absorb the solder to excess. Soldering Iron Braided Shield Wire Fig. 3-7 B3-2 23HLV86...
Releasing of PARENTAL LOCK. DVD mode STOP 2 sec. Refer to the “PARENTAL CONTROL - RATING LEVEL”. (No disc) Method Press the following remocon keys The disk cannot be taken out. continuously. Refer to the “TRAY LOCK”. SETUP SUBTITLE AUDIO 23HLV86...
A A E J B 6 4 1 7 A AAEJB6417A Fixed Released times on the same date Release date (Example: 2006.4.17) When the changed version displays, the Re-write will be completed. A = October B = November C = December Turn off the power 23HLV86...
Press both VOL. DOWN button on the set and Channel button (1) on the remote control for more than 2 seconds. After the finishing of the initializing of shipping, the unit will turn off automatically. The unit will now have the correct DATA for the new MEMORY IC. 23HLV86...
Activate the adjustment mode display of Fig. 1-1 and press the channel button (36) on the remote control to select "CONTRAST MAX". Press the LEFT/RIGTH button on the remote control until the contrast step No. becomes "170". Check if the picture is normal. 23HLV86...
Page 33
R CUT OFF(N), B DRIVE(N), B CUT OFF(N), R DRIVE(C), R CUT OFF(C)", B DRIVE(C), B CUT OFF(C), R DRIVE(W), R CUT OFF(W), B DRIVE(W) or B CUT OFF(W) at each step tone sections equally. Perform the above adjustments 5 and 6 until the white achieved. 23HLV86...
Page 34
*215 *215 *222 *150 *150 *150 *170 *170 *170 *170 *170 *205 *140 CONTRAST MIN COLOR CENT COLOR MAX COLOR MIN NOT For the step no. with * mark, please adjust it according to the situation of the set. 23HLV86...
SP301 Q301 MUTE SW MUTE SW SPEAKER TONE CONTROL SP302 IC301 AN5891SA-E1V MIXER SOUND AMP IC303 NJM4580V(TE1) IC302 LA42052-E L IN 30 R IN L OUT 2 IN1 OUT1 HEADPHONE JACK 18 SDA R OUT OUT2 J301 17 SCL 23HLV86...
RAMCAS# SD_BA0 BOOTSEL2 RAMDQM RAMWE# RAMCLK (D_GND) PCB130 DMF066 NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME NOTE:THE DC VOLTAGE EACH PART WAS OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. 23HLV86...
Page 48
P.CON+3.3V_D MMZ1608R102CT D_GND FROM AUDIO/VIDEO RESET PCB130 DMF066 MEMCS0 NOTE:THE DC VOLTAGE EACH PART WAS NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME MEASURED WITH THE DIGITAL TESTER OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DURING PLAYBACK. 23HLV86...
DVD_AUDIO_R SPDIF-134 D8510 SYS_MUTE DVD_AUDIO_L 1SS355 DVD_AUDIO_R PCB130 DMF066 NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME NOTE:THE DC VOLTAGE EACH PART WAS OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. 23HLV86...
CRITICAL FOR SAFETY,USE ONES DANGEREUSES AN POINT DE VUE SECURITE OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DESCRIBED IN PARTS LIST ONLY N’UTILISER QUE CELLS DECRITES MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. DANS LA NOMENCLATURE DES PIECES 23HLV86...
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE MEASURED WITH THE DIGITAL TESTER DESCRIBED IN PARTS LIST ONLY N’UTILISER QUE CELLS DECRITES DURING PLAYBACK. CAUTION DANS LA NOMENCLATURE DES PIECES :F3001 IS MANUFACTURED BY COOPER INDUSTRIES INC., TYPE 1206FA-T. G-10 23HLV86...
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-11 G-12 23HLV86...
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-13 G-14 23HLV86...
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST CRITICAL FOR SAFETY,USE ONES DANGEREUSES AN POINT DE VUE SECURITE WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. DESCRIBED IN PARTS LIST ONLY N’UTILISER QUE CELLS DECRITES DANS LA NOMENCLATURE DES PIECES G-15 G-16 23HLV86...
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-17 G-18 23HLV86...
Page 56
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST DANGEREUSES AN POINT DE VUE SECURITE CRITICAL FOR SAFETY,USE ONES WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. N’UTILISER QUE CELLS DECRITES DESCRIBED IN PARTS LIST ONLY DANS LA NOMENCLATURE DES PIECES G-19 G-20 23HLV86...
MEASURED WITH THE DIGITAL TESTER OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DANGEREUSES AN POINT DE VUE SECURITE CRITICAL FOR SAFETY,USE ONES DURING PLAYBACK. N’UTILISER QUE CELLS DECRITES DESCRIBED IN PARTS LIST ONLY DANS LA NOMENCLATURE DES PIECES G-21 G-22 23HLV86...
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-23 G-24 23HLV86...
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-25 G-26 23HLV86...
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED 4SI_CHIP_SE OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-27 G-28 23HLV86...
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-29 G-30 23HLV86...
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DESCRIBED IN PARTS LIST ONLY N’UTILISER QUE CELLS DECRITES WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. DANS LA NOMENCLATURE DES PIECES G-31 G-32 23HLV86...
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-33 G-34 23HLV86...
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-35 G-36 23HLV86...
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME DESCRIBED IN PARTS LIST ONLY N’UTILISER QUE CELLS DECRITES WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DANS LA NOMENCLATURE DES PIECES G-37 G-38 23HLV86...
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-39 G-40 23HLV86...
NOTE:THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. G-41 G-42 23HLV86...
DANGEREUSES AN POINT DE VUE SECURITE IS NON POLAR ONE. CAUTION WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL. N’UTILISER QUE CELLS DECRITES :F502 AND F503 ARE MANUFACTURED BY SKYGETE CO.,LTD TYPE 20N DANS LA NOMENCLATURE DES PIECES G-43 G-44 23HLV86...
Page 69
PICK UO INNER LIMIT SWITCH FEED MOTOR(-) M2602 BCZ3B05 FEED MOTOR(+) SPINDLE MOTOR(-) M2601 SPINDLE MOTOR(+) JCV9B12 PCB640 DED020 NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE G-45 G-46 23HLV86...
:SINCE THESE PARTS MARKED BY OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DANGEREUSES AN POINT DE VUE SECURITE CRITICAL FOR SAFETY,USE ONES REMOCON PCB N’UTILISER QUE CELLS DECRITES DESCRIBED IN PARTS LIST ONLY PCBDA0 DANS LA NOMENCLATURE DES PIECES CEF203 G-47 G-48 23HLV86...
SCALER 2.0ms 20µs 20µs 500mV 500mV 500mV TUNER 20µs 20µs 2.0ms 500mV 500mV 2.0V STEREO 2.0ms 20µs 2.0ms 2.0V 500mV 500mV The following waveforms were measured at the point of the corresponding NOTE: balloon number in the schematic diagram. 23HLV86...
Page 72
5µs 5µs 500mV 2.0V 10ns 100mV LVDS 10ms 5µs 100mV 500mV 20mV JACK INTERFACE_HDMI IC 1.0ms 20µs 1.0V 1.0V 20ns 1.0V The following waveforms were measured at the point of the corresponding NOTE: balloon number in the schematic diagram. 23HLV86...
Page 73
WAVEFORMS 10µs 200ns 200mV 1.0V MEMORY REGULATOR 2 2µs 2.0V 500mV AUDIO/VIDEO 500µs 2µs 500mV 2.0V 500µs 500mV 10µs 200mV The following waveforms were measured at the point of the corresponding NOTE: balloon number in the schematic diagram. 23HLV86...
If the repair is needed, replace the DVD MECHA ASS'Y. PCB640 (SW PCB ASS'Y) CD2301 NOTE: Applying positions AA for the grease are displayed for this section. CLASS MARK Check if the correct grease is applied for each position. GREASE I2-1 23HLV86...