Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for home diesel power 7500W
Summary of Contents for home diesel power 7500W
- Page 1 Owners Manual 7500W HOME DIESEL POWER WWW.HOMEDIESELPOWER.COM...
-
Page 2: Safety Guidelines - Definitions
Owner’s Manual Safety Guidelines - Definitions This manual contains important information that you need to know and understand in order to protect YOUR SAFETY and to PREVENT EQUIPMENT PROBLEMS. The following symbols help you recognize this information. Please read the manual and pay attention to these sections. Save These Important Safety Instructions! Read and understand all of these safety instructions. -
Page 3: Personal Safety
Owner’s Manual General Precautions (cont’d) Electrical Safety (cont’d) • All connections and conduits from the generator to the load must only be installed by trained and licensed electricians, and in compliance with all relevant local, state, and federal electrical codes and standards, and other regulations where applicable. •... - Page 4 Noise • Prolonged exposure to noise levels above 68 DBA is hazardous to hearing. Always wear ANSI approved ear protection when operating or working around the generator when it is running. 7500W Generator Battery Assembly To start generator with electric start you will need a battery (not included). You can use a 12v lawn Unpacking tractor battery with the following specifications: The dimensions are Wx7.5”...
- Page 5 Control Panel Choke lever Handle Battery Oil plug Air filter Recoil Start...
-
Page 6: Inspection, Cleaning, And Maintenance
Owner’s Manual Operation (cont’d) Powering 12 Volt DC tools and Equipment: 1. Prior to powering tools and equipment, make sure the generator’s rated voltage, and amperage capacity (12V DC) is adequate to supply all electrical loads that the unit will power. If powering exceeds the generator’s capacity, it may be necessary to group one or more of the tools and/or equipment for connection to a separate generator. - Page 7 Owner’s Manual Maintenance Guide Periodic maintenance and adjustment is necessary to keep the generator in good operating condition. WARNING! Exhaust gas contains poisonous carbon monoxide. Shut off the engine before performing any maintenance. If the engine must be run, make sure the areas is well ventilated. •...
-
Page 8: Installation
Owner’s Manual Installation NOTE: PRIOR TO POWERING TOOLS AND EQUIPMENT MAKE SURE THE GENERATOR’S RATED VOLTAGE, WATTAGE AND AMPERAGE CAPACITY IS ADEQUATE TO SUPPLY ALL ELECTRICAL LOADS THAT THE UNIT WILL POWER. IF POWERING EXCEEDS THE GENERATOR’S CAPACITY, IT MAY BE NECESSARY TO GROUP ONE OR MORE OF THE TOOLS AND/OR EQUIPMENT FOR CONNECTION TO A SEPARATE GENERATOR. -
Page 9: Cylinder Barrel
7500W Generator 7500W Generator Cylinder head system assy. Cylinder barrel APA Part No. Description APG3075-B-01-JD FLANGE BOLT (M6X 14) Description APA Part No. APG3075-B-02-JD OIL LEVEL SWITCH ASSY APG3075-A-01-JD HEAD COVER COMP. BOLT APG3075-B-03-JD O-RING (14mm) APG3075-A-02-JD HEAD COVER WASHER COMP... - Page 10 7500W Generator 7500W Generator Piston & Connecting Rod Assy. Recoil Starter Assy. Description Description APA Part No. APA Part No. APG3075-E-01-JD COMPRESSION RING A APG3075-F-01-JD PIVOT ADJUSTING NUT APG3075-E-02-JD COMPRESSION RING B APG3075-F-02-JD ROCKER ARM PIVOT APG3075-F-03-JD ROCKER ARM APG3075-E-03-JD...
-
Page 11: Ignition System Assy
7500W Generator 7500W Generator Carburetor Assy. Flywheel Assy. Description Description APA Part No. APA Part No. APG3075-I-01-JD TUBE CLIP APG3075-J-01-JD FLYWHEEL APG3075-I-02-JD TUBE A APG3075-J-02-JD SPECIAL WOODRUFF KEY APG3075-I-03-JD TUBE B APG3075-J-03-JD COOLING FAN APG3075-I-04-JD WIPE HARNESS CLIP APG3075-J-04-JD STARTER PULLEY... - Page 12 7500W Generator 7500W Generator Control Assy. Muffler Assy. Description APA Part No. APG3075-N-01-JD FLANGE BOLT (M8 X 16) APG3075-N-02-JD FLANGE BOLT (M6 X 12) APG3075-N-03-JD MUFFLER STAY COMP APG3075-N-04-JD MUFFLER PROTECTOR SEAL APG3075-N-05-JD MUFFLER SIDE PROTECTOR Description APA Part No.
- Page 13 7500W Generator 7500W Generator Control Box Assy. Frame Comp Assy. Description APA Part No. Description APA Part No. APGG7500-Q-01-JD CONTROL PANEL COMP APGG7500-R-01-JD BOLT APGG7500-Q-02-JD ENGINE SWITCH ASSY APGG7500-R-02-JD REAR COVER APGG7500-Q-03-JD DC 12V OUTPUT APGG7500-R-03-JD APGG7500-Q-04-JD HOURS METER APGG7500-R-04-JD...
- Page 14 7500W Generator Wheel & Hand Assy. 10 11 Description APA Part No. APGG7500-T-01-JD PIN SPLIT APGG7500-T-02-JD WSHER PLAIN APGG7500-T-03-JD WHEEL APGG7500-T-04-JD BAFFLE APGG7500-T-05-JD SHAFT APGG7500-T-06-JD FLANGE BOLT (M6X 35) APGG7500-T-07-JD FLANGE NUT (M6) APGG7500-T-08-JD RUBBER BOLT APGG7500-T-09-JD FLANGE NUT APGG7500-T-10-JD...
Need help?
Do you have a question about the 7500W and is the answer not in the manual?
Questions and answers