air & water solutions CAP2500 Owner's Manual

Clean air plant biooxidizer

Hide thumbs

CAP™ Clean Air Plant BioOxidizer

Model CAP2500

for Odor Control in Plants

Owner's Manual

Pre-Loaded With BioOx

With BioStack

Cartridge inside

PLEASE MAKE SURE THESE INSTRUCTIONS ARE CAREFULLY READ AND

UNDERSTOOD BEFORE STARTING OR OPERATING YOUR CAP.

Air & Water Solutions, Inc.

P.O. Box 627

Nutley, New Jersey 07110

U. S. A.

Tel. : (973) 661-5192

Fax : (973) 661-3713

www.cleanairplant.com

email: awsi@cleanairplant.com

Table of Contents

Need help?

Do you have a question about the CAP2500 and is the answer not in the manual?

Questions and answers

Summary of Contents for air & water solutions CAP2500

Page 1 CAP™ Clean Air Plant BioOxidizer Model CAP2500 for Odor Control in Plants Owner’s Manual ® Pre-Loaded With BioOx ® With BioStack Cartridge inside PLEASE MAKE SURE THESE INSTRUCTIONS ARE CAREFULLY READ AND UNDERSTOOD BEFORE STARTING OR OPERATING YOUR CAP. Air & Water Solutions, Inc.
Page 2 Congratulations! Your ne w CAP Clean Air Plant is the most advanced biological oxidation technology for indoor and outdoor odor control. CAP2500 BioOxidizer Figure 1. General Layout. Flow Indicator Flush/Cleanout Fitting Fan Housing Pump Sump Drain...
Page 3 A. Safety guidelines READ SAFETY GUIDELINES BEFORE OPERATING UNIT. Call Air & Water Solutions if you have any questions. • Do not operate unit as shipped in explosive atmospheres. Hazardous location pumps and fans are available should you require them. Do not operate your equipment at a level greater than 10% Lower Explosivity Limit (LEL).
Page 4 B. General information Your CAP™ Clean Air Plant (CAP) consists of: • A fan housing, consisting of a fan motor, fan, an air distribution manifold, fittings, a control valve, and ducts, • ® ® A BioStack cartridge with BioOx enzymes installed, •...
Page 5 D. Layout of the CAP UNIT . CAP2500 Figure2. Pump discharge line Pump and Sump Automatic water level float switch E. Start-up and Operating Procedure 1. Fill reservoir with water and BioOx at the levels indicated. ® F. Cleaning the Reservoir and Adding BioOx enzymes ®...
Page 6 1. Unplug the water pump and fan. 2. Close the automatic water inlet valve. 3. Disconnect the pump discharge water line. 4. Clean or replace the line and pump as needed. 5. This should clear any blockage in the CAP. 6.
Page 7 BioOx® Air & Water Solutions, Inc. Material Safety Data Sheet (MSDS) Section 1 – Chemical Product and Company Identification BioOx® Air & Water Solutions, Inc., P.O. Box 627, Nutley, New Jersey 07110. 973-661-5192. Section 2 – Composition, Information on Ingredients Water: 95% Biomass: 5% Section 3 –...
Page 8 Acute effects: none Chronic effects: none Section 12 – Ecological Information Naturally found in the environment. Section 13 – Disposal Conside rations Non-hazardous, non-toxic, non-flammable liquid. Consult with state and local regulations Section 14 – Transport Information Not regulated Section 15 – Regulatory Information Not listed.