Advertisement
Quick Links
OPERATION & CAR E MAN UAL
MODELS:
COOK/HOLD SERVE SYSTEMS by
W 1 6 4 N 9 2 2 1 W a t e r S t r e e t
PHONE: 262.251.3800
800.558.8744
.
.
./
U
S
A
CANADA
.
.
.
P R I N T E D I N U
S
A
VPE-30F
VENTILATOR HOOD
VPE-30F, VAE-30F, VAE-55F(S)
G
P . O . B o x 4 5 0
FAX: 262.251.7067 - 800.329.8744
262.251.1907
VAE-30F
G
M e n o m o n e e F a l l s , W i s c o n s i n 5 3 0 5 2 - 0 4 5 0
.
.
./
U
S
A
CANADA
INTERNATIONAL
®
VAE-55FS
U . S . A .
WEBSITE:
www.alto-shaam.com
# 8 4 5 2 / 5 3 / 5 5 • 3 / 0 0
®
Advertisement
Summary of Contents for Alto-Shaam VPE-30F
- Page 1 VAE-30F VAE-55FS VENTILATOR HOOD MODELS: VPE-30F, VAE-30F, VAE-55F(S) COOK/HOLD SERVE SYSTEMS by ® W 1 6 4 N 9 2 2 1 W a t e r S t r e e t P . O . B o x 4 5 0 M e n o m o n e e F a l l s , W i s c o n s i n 5 3 0 5 2 - 0 4 5 0 U .
- Page 2 14.3-L1, 13-L2&L3 This manual must be read and understood by all people using or VAE-55F(S) 17.0 47.8 per line installing this unit. Contact your local Alto-Shaam distributor if 17.0 41.0 per line you have any questions concerning installation, operation, and 308-415 17.4...
- Page 3 SAFETY PROCEDURES This equipment is made in the USA and has American size hardware. Knowledge of proper procedures is essential to the safe operation Any trouble shooting guides, component views or parts lists of electrically energized equipment. In accordance with generally included in this manual are for general reference only, and accepted product safety labeling guidelines for potential hazards, the following signal words and symbols are used throughout this...
- Page 4 NOTE: Wire gauge, insulation type and temperature rating, as The fire suppression system is comprised of a pressurized well as type, size, and construction of conduit, must meet container of Ansulex R-102 liquid fire suppression media, ® or exceed applicable specifications of local codes of the with associated plumbing and controls.
- Page 5 FEATURES & OPERATING CONTROLS NOTE: Items beginning with "f.." are part of the fryer. Items beginning with "v.." are part of the ventilator. Power Switch Fryer position turns ON the ventilator power light and blower. v.10 Ventilator Exhaust Collar If, within 10 seconds, there is sufficient air flow for proper Allows for ventilator discharge.
- Page 6 GREASE CUP & DRIP PAN 1. Install the grease cup into the brackets below the grease baffle. NOTE: Failure to install the grease cup will allow grease and moisture from the grease baffle to drop into the frypot, creating both a safety hazard (hot oil splatter) and a health hazard (contamination of the cooking oil).
- Page 7 CONTROLS • FUNCTIONS • OPERATION ❷ ❸ ❹ ❺ ❶ This manual is to be used in conjunction with the Located on Fryer fryer manual supplied with this product. Control Panel ❶ ITEM ❹ ITEM POWER SWITCH (FRYER-OFF-FILTER) Fryer position turns on the ventilator, REPLACE FILTER LIGHT (AMBER) power light and the blower for 10 seconds.
- Page 8 VENTILATOR CLEANING INSTRUCTIONS R E Q U I R E D M A I N T E N A N C E DAILY CLEANING Use and maintenance shall be in accordance with the Exterior: At least once a day, wash the exterior with Standard for Ventilation Control and Fire Protection of warm water, mild soap or detergent and a clean non- Commercial Cooking Operations, NFPA 96 (current...
-
Page 9: Troubleshooting
Fryer or Ventilator or an authorized Ansul Use only a factory authorized service parts and replacement distributor for the fire suppression system. filters. Contact the Alto-Shaam factory for advice. Normal Maintenance Items PROBLEM REMEDY Charcoal Filter Unit will not operate. - Page 10 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 9...
- Page 11 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 10...
- Page 12 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 11...
- Page 13 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 12...
- Page 14 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 13...
- Page 15 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 14...
- Page 16 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 15...
- Page 17 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 16...
- Page 18 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 17...
- Page 19 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 18...
- Page 20 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 19...
- Page 21 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 20...
- Page 22 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 21...
- Page 23 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 22...
- Page 24 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 23...
- Page 25 Operation and Care Manual # 8 4 5 2 / 5 3 / 5 5 • 24...
- Page 26 Fryer • Original Equipment Limited D a m a g e a n d C l a i m s Alto-Shaam, Inc. warrants to the original purchaser that any original part that All Alto-Shaam equipment is is found to be defective in material or workmanship will, at our option, subject sold F.O.B.