7.1-channel a/v receiver featuring airplay, dlna certified (1.5), internet radio with vtuner, made for ipad certification and 2-zone audio and video (2 pages)
PIONEER Service Manual. A subscription to, or additional copies Also test with plug reversed of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. VSX-515-K...
1 Continuous average power output of 110 watts* per channel, min., at 8ohms, from 20 Hz to 20,000 Hz with no more than 0.7%** total harmonic distortion (front). * Measured pursuant to the Federal Trade Commission’s Trade Regulation rule on Power Output Claims for Amplifiers. ** Measured by Audio Spectrum Analyzer. VSX-515-K...
Page 6
VOLUME CH SELECT MUTE LEVEL EFFECT TEST TONE CLASS TUNER AUDIO TUNING STATION DISPLAY SUB TITLE DVD CONTROL AA size IEC R6 AM loop antenna FM wire antenna Dry cell batteries (x2) RECEIVER (ATB7013) (ADH7030) Remote control unit (XXD3090) VSX-515-K...
Remote Control Unit XXD3090 Battery Cover XZN3139 NSP 8 Literature Bag AHG1180 Packing Sheet AHG7069 (2) CONTRAST TABLE VSX-515-K/KUCXJ and VSX-515-S/KUXCJ are constructed the same except for the following: VSX-515-K VSX-515-S Mark Description /KUCXJ /KUCXJ Packing Case XHD3474 XHD3475 VSX-515-K...
2.2 EXTERIOR SECTION VSX-515-S ONLY 47(2/2) Refer to "2.3 FRONT PANEL SECTION". 47(1/2) VSX-515-K...
Page 9
Rubber Sheet AEB1111 J37 10P F.F.C/30V XDD3178 J38 5P F.F.C/60V XDD3166 J43 15P F.F.C/60V XDD3162 (2) CONTRAST TABLE VSX-515-K/KUCXJ and VSX-515-S/KUCXJ are constructed the same except for the following: VSX-515-K VSX-515-S Mark Description /KUCXJ /KUCXJ Bonnet K V1 XZN3148 Not used...
Page 11
• • • • • • TUNER BTN See Contrast table(2) Sub BTN See Contrast table(2) JOG BUTTON See Contrast table(2) (2) CONTRAST TABLE VSX-515-K/KUCXJ and VSX-515-S/KUCXJ are constructed the same except for the following: VSX-515-K VSX-515-S Mark Description /KUCXJ /KUCXJ JOG Knob V1K...
VIDEO CN51 2.0mm WIRE TRAP KP200TA**L 2.0mm BOARD to BOARD KM200TA** 2.0mm BOARD to BOARD AKP7070, AKP7073 COMPONENT 1.25mm BOARD to BOARD ASSY AKP7059, AKP7062 1.25mm BOARD to BOARD (XWZ3934) AC CODE SOCKET AC CODE CONNECTOR AC CORD ADG7024 VSX-515-K...
Page 27
Ratings:Capacity(µF)/Voltage(V) unless otherwise noted. DC OUTPUT DETECTOR Rated Voltage:50V except for electrolytic capacitors. • NOTE FOR FUSE REPLACEMENT 3.DIODES : AUDIO SIGNAL ROUTE Indicated in 1SS133-T FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. CAUTION - REPLACE WITH SAME TYPE AND RATINGS ONLY. VSX-515-K...
AC WUP CN803 +12V AC RY KM200TA7 Stby5V SWOUT Q801 SBOUT GNDU DTA124ES Q804 GNDA DTC114ES GNDA SP-B RY SBOUT R/C RY CN802 SWOUT SP-A RY KM200TA20 Q803 GNDU HP.SW DTA124ES +12V +12V CN801 CN53 52045-2345 52045-2345 -12V CN302 VSX-515-K...
Page 29
REK1087 (10A) IC51: ATT7043 NEUTRAL U+5V REG.IC AC POWER CORD ADG7024 0.01 YF KN51 RCN1080 VNF1084 AMP&PRIMARY ASSY (XWZ3941) • NOTE FOR FUSE REPLACEMENT FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. CAUTION - REPLACE WITH SAME TYPE AND RATINGS ONLY. VSX-515-K...
SIDE B POWER TRANSFORMER TRANS1 XWZ3958 TRANS2 ASSY REMPLACER LE IC LINKS COMME INDIQUE. DE CHEZ LITTELFUSE INC. (XNP3091-B) TRANS2 ATTENTION XWZ3959 SIDE A XWZ3960 IC852 BROWN BLUE IC851 IC853 PRIMARY (XNP3091-B) TRANS1 ASSY SIDE A D E H Q VSX-515-K...
SYSTEM SETUP RETURN BAND (CLASS) XWZ3965 CN702 POWER SW & KEY ASSY H.P ASSY 1551 PWR & KEY S505 S502 S503 S504 SIGNAL SELECT STANDARD ADV.SUR STEREO/ DIRECT HCI40HI XWZ3918 XWZ3919 D501 S501 POWER (XNP3090-B) (XNP3090-B) M O P R VSX-515-K...
Page 47
FRONT KEY (XNP3090-B) HCI40HI FRONT KEY ASSY 7 VOL LED 6 ENTER 5 FENC A 4 FENC B S512 XWZ3913 3 GNDU 2 VENC B XWZ3965 1 VENC A HCI40HI S511 ENTER W289 XWZ3921 XWZ3922 D512 S513 R.ENCODER ASSY (XNP3090-B) VSX-515-K...
Page 48
TUNER (FM) CDR/TAPE R465 7 VOL LED (XNP3090-B) 6 ENTER R.ENCODER 5 FENC A 4 FENC B FRONT KEY ASSY 3 GNDU 2 VENC B 1 VENC A XWZ3921 XWZ3922 ENTER HCI40HI R.ENCODER ASSY KNIFE SPACE (XNP3090-B) M N P VSX-515-K...
Page 49
TONE TUNER EDIT TUNING/STATION BAND (CLASS) QUICK SETUP RETURN H.P ASSY POWER SW & KEY ASSY 1551 XWZ3918 PWR & KEY R505 R504 R503 XWZ3919 SIGNAL STEREO/ SELECT DIRECT STANDARD ADV.SUR Q1551 HCI40HI R501 Q1552 POWER R502 (XNP3090-B) (XNP3090-B) VSX-515-K...
REGULATOR Assy AMP&PRIMARY Assy Heat Sink ×3 Note : The unit does not operate when the screws of Speaker Terminal are taken off from Rear Panel. Heat-sink caution in the disassembling : Because Heat-sink becomes hot, please pay attention. VSX-515-K...
Page 59
TRANS 2 Assy MAIN Assy AMP INPUT Assy TRANS 1 Assy TRANS 3 Assy TRANS 4 Assy R. ENCODER Assy FRONT DISPLAY Assy H.P. Assy FRONT KEY Assy POWER. SW & KEY Assy NOTE : This photograph is VSX-915-K. VSX-515-K...
LOW_CONSUMPTION NECK_SEL P80/TA4OUT/U P33/A11 MVRATT DC PROT P77/TA3IN P34/A12 RY-AC Boad DET P76/TA3OUT P35/A13 HP DET P36/A14 MIC DET P75/TA2IN/W RY_A DSPOL P74/TA2OUT/W P37/A15 RY_C/R P73/CTS2/RTS2/TA1IN/V P40/A16 RY_B P72/CLK2/TA1OUT/V P41/A17 AMUTE P71/RxD2/SCL P42/A18 GAIN_SEL /TA0IN/TB5IN P70/TXD2/SDA P43/A19 INPUT_ATT /TA0OUT VSX-515-K...
Page 61
Data input signal for communication with DIR/DAC P50/WRL/WR DIR CS Chip select signal for communication with DIR/DAC P47/CS3 LSSN DSP ASSY P46/CS2 DIR CDC RST Reset signal for DIR CODEC P45/CS1 DIR ERR lock/unlock signal P44/CS0 XTL0 DIR X'tal change VSX-515-K...
Page 62
P02/D2 P01/D1 P00/D0 P107/AN7/KI3 P106/AN6/KI2 P105/AN5/KI1 P104/AN4/KI0 P103/AN3 P102/AN2 SIMUKE1 lnput 1 to switch region P101/AN1 SIMUKE2 lnput 2 to switch region AVSS AVSS Connect to VSS P100/AN0 VREF VREF Connect to VCC AVcc AVCC Connect to VCC P97/ADTRG/SIN4 VSX-515-K...
Page 63
P20/SCK3 C-MOS P-CH FIP31/P37 DISP EN P00/INTP0 C-MOS P-CH FIP32/P40 NC(PD)(MULTIROOM SRIN) P01/INTP1 C-MOS P-CH FIP33/P41 SR IN P02/T1 C-MOS P-CH FIP34/P42 AVSS P-CH FIP35/P43 KEY IN4 ANI3 COPM P-CH FIP36/P44 KEY IN3 ANI2 COMP P-CH FIP37/P45 Power LED VSX-515-K...
L : ON H : OFF Fan Stop DET. Q253 Fan Stop R265 Fan - Fan + -12V +12V 4. PCB Board Protection Circuit Diagram Main Assy Amp & Primary Assy Amp Input Assy Speaker u-con IC9001 Pin 24 VSX-515-K...
When an overload is detected, A.MUTE* is turned on, speaker relay is turned off, then "OVERLOAD" flashes on the display. ↓ The abnormality continues for 3 seconds. ↓ Continues. ↓ Recovery The power is shut off even if the The power is shut off. unit recovers. VSX-515-K...
Page 73
However, when the following keys are pushed so that the key input of a line and the service can be carried out, power can be on. 1 TESTMODE ON (A55F+A55F) 2 When power off, push FRONT ENTER key + ADVANCED SURROUND key continuously 2sec. (Effective, only when power-off is carried out by DC detection) VSX-515-K...
• After identify the failure channel, check that each part is not damaged (resistor, diode... etc. value / open / short) 7.4 CLEANING Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools: Position to be cleaned Cleaning tools Fans Cleaning paper : GED-008 VSX-515-K...
The MULTI JOG dial performs a number of STANDARD tasks. Use it to select options after pressing the Press for Standard decoding and to switch designated MULTI JOG buttons. between the various Pro Logic II and Neo:6 options. STANDBY/ON Switches the receiver between on and standby. VSX-515-K...
CENTER SURROUND BACK SURROUND (TV/SAT) AC OUTLET MONITOR FRONT ASSIGNABLE COAX DIGITAL IN D V D S I N G L E 5.1CH INPUT SEE INSTRUCTION WOOFER (CD) MANUAL CD-R PREOUT / TAPE COAX / MD (DVD PLAY /LD) VSX-515-K...
Page 77
Depending on your level settings for each reproduction of a source. channel, the maximum volume can range AUTO SURR. between –10 dB and –0 dB. Lights when the Auto Surround feature is switched on. VSX-515-K...
Pro Logic IIx Music and Neo:6 Music parameters. You can then use the LEVEL +/– buttons to make these adjustments. LEVEL +/– Use to adjust the effect and channel levels, as well as to change Dolby Pro Logic IIx and Neo:6 Music parameter settings. VSX-515-K...
Page 79
It also displays TV menus. 12 DVD CONTROL buttons RETURN You can use these buttons to control a Pioneer Confirm and exit the current menu screen. DVD player connected to your system. / ENTER Button What it does Use the arrow buttons when setting up your surround sound system.