Table of Contents
Advertisement
Assembly, Safety and Operation Manual
Ransomes Gang Mower
Sportcutter Mk11, Magna Mk13
Product codes: LBMA171 Sportcutter Gang unit on pneumatic wheels
LBMA172 Sportcutter Gang unit on steel wheels
LJBA003 Sportcutter 3-unit on pneumatic wheels
LJBA004 Sportcutter 3-unit on steel wheels
LJBA011 Sportcutter Mounted 3-unit on pneumatic wheels
LJBA005 Sportcutter 5-unit on pneumatic wheels
LJBA006 Sportcutter 5-unit on steel wheels
LBMA174 Magna Gang unit on pneumatic wheels
LBMA173 Magna Gang unit on steel wheels.
LJBA015 Magna 3-unit on pneumatic wheels
LJBA016 Magna 3-unit on steel wheels
LJBA023 Magna Mounted 3-unit on pneumatic wheels
LJBA017 Magna 5-unit on pneumatic wheels
LJBA018 Magna 5-unit on steel wheels
WARNING: If incorrectly used this machine can cause severe
injury. Those who use and maintain this machine should be
trained in its proper use, warned of its dangers and should
read the entire manual before attempting to set up, operate,
adjust or service the machine.
GB
RJL 1C April 2013
United
Kingdom
22114H-GB (rev.2)
®
Advertisement
Chapters
Table of Contents
Related Manuals for Ransomes Magna Mk13 LJBA015
Summary of Contents for Ransomes Magna Mk13 LJBA015
- Page 1 22114H-GB (rev.2) ® Assembly, Safety and Operation Manual Ransomes Gang Mower Sportcutter Mk11, Magna Mk13 Product codes: LBMA171 Sportcutter Gang unit on pneumatic wheels LBMA172 Sportcutter Gang unit on steel wheels LJBA003 Sportcutter 3-unit on pneumatic wheels LJBA004 Sportcutter 3-unit on steel wheels...
- Page 2 © 2009, Ransomes Jacobsen Limited. All Rights Reserved...
-
Page 3: Table Of Contents
CONTENTS RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL CONTENTS PAGE INTRODUCTION IMPORTANT ......................2 PRODUCT IDENTIFICATION ...................2 SAFETY INSTRUCTIONS OPERATING INSTRUCTIONS .................3 SAFETY SIGNS ......................3 STARTING THE ENGINE ..................3 DRIVING THE MACHINE ..................3 TRANSPORTING ......................3 LEAVING THE DRIVING POSITION ................4 SLOPES ........................4... -
Page 4: Introduction
Any arbitrary modifi cations carried out on this machine may relieve the manufacturer of liability for any resulting damage or injury. 2006/42/EC These are the Original instructions verifi ed by Ransomes Jacobsen Limited. PRODUCT IDENTIFICATION Maximum front axle load in Kg (for machines... -
Page 5: Safety Instructions
SAFETY INSTRUCTIONS RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL • Remember that some people are deaf This safety symbol indicates important safety or blind and that children and animals messages in this manual. When you see this can be unpredictable. -
Page 6: Leaving The Driving Position
SAFETY INSTRUCTIONS RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 3.6 LEAVING THE DRIVING POSITION • To reduce the fi re hazard, keep the engine, silencer and battery compartments free of • Park the machine on level ground. - Page 7 SAFETY INSTRUCTIONS RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL DANGER - Indicates an imminently hazardous IMPORTANT: Transport speed is for highway situation which, if not avoided, WILL result in death use only. Never select transport speed on or serious injury.
-
Page 8: Conformity Certificates
A gyártó üzleti neve és teljes címe Ragione sociale e indirizzo completo del fabbricante Uz muma nosaukums un pilna West Road, Ransomes Europark, ražot ja adrese Verslo pavadinimas ir pilnas gamintojo adresas Isem kummer jali u indirizz s i tal-fabbrikant Nazwa firmy i pełny adres producenta Nome da Ipswich, England, IP3 9TT empresa e endereço completo do fabricante Denumirea comercial... - Page 9 A nyilatkozat kelte (hely és id ) Luogo e data della dichiarazione Deklar cijas vieta un datums Deklaracijos vieta ir data Il-post u d-data tad-dikjarazzjoni West Road, Ransomes Europark, Miejsce i data wystawienia deklaracji Local e data da declaração Locul i data declara iei Miesto a dátum vyhlásenia Kraj in datum izjave Lugar y fecha de la Ipswich, England, IP3 9TT declaración Plats och datum för deklarationen Tæknistaðlar og tæknilýsingar sem notaðar eru Benyttede tekniske standarder og spesifikasjoner Staður og dagsetning...
-
Page 10: Decals And Unit Specification
DECALS AND UNIT SPECIFICATIONS RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 5.1 SAFETY DECALS AND INSTRUCTION DECALS A903489 Keep a Safe Distance from the Machine. A903494 Caution Rotating Blades. 5.2 COMPONENTS FOR TRAILED UNITS Single unit Gang Mower... -
Page 11: Dimensions And Cutting Peformance
DECALS AND UNIT SPECIFICATIONS RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 5.3 DIMENSIONS AND CUTTING PERFORMANCE Mounted Model Gang Gang Mowers Mower Number of Cutting Units Width of 76 cm 2.1 m 3.5 m 3.27 m 6.25 m... -
Page 12: Single Unit Gang Mower
ASSEMBLY RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL ASSEMBLY—SINGLE UNIT GANG MOWER (Fig. 1). Unscrew the pivot bolt (A) from the centre of the unit frame. Insert the lifting lever (B), spring fi rst, into the rear of the unit frame. -
Page 13: 3-Unit Gang Mower
ASSEMBLY RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL Fig 3 6.2 ASSEMBLY—3-UNIT GANG MOWER Assemble each cutting unit as single unit mower instruction. Refer to page 10. (Fig. 3). To one of the cutting units bolt on the extension wings (A) one each side of the unit frame. -
Page 14: 3-Unit Mounted Gang Mower
ASSEMBLY RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL Fig 5 Fig 6 Fig 7 en-14... -
Page 15: Assembly Ransomes Gang Mowers
ASSEMBLY RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 6.3 ASSEMBLY—3-UNIT MOUNTED GANG MOWER (Fig. 5). Arrange the cutting units so that the front two are in line alongside each other, and the rear unit central. Attach the... - Page 16 CONTROLS RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL Swing up the lifting frame and couple the top link (B). The top hole and distance piece is used with Ford and British Leyland tractors. The top link on Massey Ferguson and David Brown trac tors is fi...
-
Page 17: 5-Unit Gang Mower
ASSEMBLY RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL Fig 10 6.4 ASSEMBLY—5-UNIT GANG MOWER (Fig. 10). From the three short drawbars Assemble three cutting units with unit remove the universal couplings (F). Bolt frames and short drawbars, and two two couplings into the towing points on cutting units with unit frames only. -
Page 18: 7-Unit Gang Mower
ASSEMBLY RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL Fig 12 6.5 ASSEMBLY—7-UNIT GANG MOWER coupling frames. Couple the four rear units to the towing point on the extension wings Assemble four cutting units with unit and centre of the twin coupling frames,... -
Page 19: 9-Unit Gang Mower
ASSEMBLY RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL en-19... - Page 20 ASSEMBLY RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 6.6 ASSEMBLY—9-UNIT GANG MOWER Assemble fi ve cutting units with unit frames and and short drawbars, two cutting units with unit frames and long drawbars, two cutting units with unit frames only. Refer to page 10.
-
Page 21: Coupling Gang Mowers To Power Units
ASSEMBLY RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 6.7 COUPLING THE GANG MOWERS TO A TRACTOR (Fig. 17). The tractor drawbar must be fi xed. If it is a swivelling type, a bracket (A) must be fi tted to prevent it from tipping up or down. -
Page 22: Lubrication
LUBRICATION RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 7.1 LUBRICATION GEAR CASE Machines are despatched without oil in the gearcases which must be fi lled to the correct level before use. (Fig. 21). Correct lubrication of the gear box is essential for long life and good performance. -
Page 23: Operation
OPERATION RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 8.1 OPERATING PROCEDURE CAUTION To help prevent injury, always wear safety glasses, leather work shoes or boots, a hard hat and ear protection. Under no circumstances should the engine be started without the operator seated on the tractor. -
Page 24: Daily Inspection
OPERATION RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 8.2 DAILY INSPECTION CAUTION The daily inspection should be performed only when the engine is off and all f uids are cold. Lower implements to the ground, engage parking brake, stop engine and remove ignition key. -
Page 25: Maintenance
MAINTENANCE RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 9.1 MAINTENANCE CUTTING CYLINDER ADJUSTMENT (Fig. 24). Before use, check the cutting cylinder adjustment, which must be set correctly and locked. To do this, check the adjustment by revolving the cutting cylinder manually and testing with thin paper, newspaper will do. -
Page 26: Transporting
TRANSPORTING RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL 10.1 TRANSPORTING TRAILED GANG UNITS When moving from site to site the cutting cylin ders must be out of gear, but this must not be done while the machine is in motion. -
Page 27: Guarantee/Sales & Service
GUARANTEE / SALES & SERVICE RANSOMES GANG MOWERS SPORTCUTTER Mk11, MAGNA Mk13 SAFETY AND OPERATORS MANUAL GUARANTEE We GUARANTEE that should any defect in workmanship or material occur in the goods within TWO YEARS or two thousand hours (on models equipped with hour meters), or whichever occurs f rst. - Page 30 Europe & Rest of The World Except North & South America Ransomes Jacobsen Limited West Road, Ransomes Europark, Ipswich, IP3 9TT English Company Registration No. 1070731 www.ransomesjacobsen.com North & South America Jacobsen, A Textron Company 11108 Quality Drive, Charlotte, NC 28273, USA...
Need help?
Do you have a question about the Magna Mk13 LJBA015 and is the answer not in the manual?
Questions and answers