Table of Contents
Advertisement
Quick Links
CO Guardian LLC
Document No. 01-2510-02
1951 E. AIRPORT DRIVE
Date: 11/23/02
TUCSON, AZ. 85706
REV A
CO Guardian LLC
1951 E. Airport Dr.
Tucson, AZ 85706
CARBON MONOXIDE DETECTOR MODEL 452 INSTALLATION AND
OPERATIONAL MANUAL
Document No. 01-2510-02
MODEL 452 INSTALLATION AND OPERATIONAL MANUAL
Page 1 of 17
Advertisement
Table of Contents
Summary of Contents for CO Guardian 452
- Page 1 1951 E. AIRPORT DRIVE Date: 11/23/02 TUCSON, AZ. 85706 REV A CO Guardian LLC 1951 E. Airport Dr. Tucson, AZ 85706 CARBON MONOXIDE DETECTOR MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Document No. 01-2510-02 MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 1 of 17...
- Page 2 CO Guardian LLC Document No. 01-2510-02 1951 E. AIRPORT DRIVE Date: 11/23/02 TUCSON, AZ. 85706 REV A INTENIONALLY LEFT BLANK MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 2 of 17...
-
Page 3: Log Of Revisions
LOG OF REVISIONS PAGE DATE DESCRIPTION APPROVED 1 thru 17 9/15/02 Initial Release ASH VIJ 1 thru 17 11/23/02 Editorial Changes and ASH VIJ Revised Figure 2 and 5. Revised Self Test MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 3 of 17... -
Page 4: Intenionally Left Blank
CO Guardian LLC Document No. 01-2510-02 1951 E. AIRPORT DRIVE Date: 11/23/02 TUCSON, AZ. 85706 REV A INTENIONALLY LEFT BLANK MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 4 of 17... -
Page 5: Table Of Contents
CARBON MONOXIDE DETECTOR SCHEDULED MAINTENANCE .........14 SELF TEST SEQUENCE ......................15 10.0 PILOT RESPONSE TO IN-FLIGHT CO ALARM..............15 11.0 ALERT CYCLE ........................16 12.0 UNIT FAILURE INDICATION: ....................16 13.0 RS-232 DATA BUSS OPTION ....................16 14.0 Warranty ..........................16 MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 5 of 17... -
Page 6: Rev A
When reporting a specific problem, please describe it briefly and include the document number, the paragraph/figure/table number, and the page number. Send your comments to the address above. MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 6 of 17... -
Page 7: Description
REV A DESCRIPTION GENERAL This section gives a physical and functional description of the CO Guardian CO Detector indicator as installed in Cessna 172 aircraft. PHYSICAL DESCRIPTION CO Detector indicator flange type front panel unit part numbers are listed in Table 1. -
Page 8: Table 2 - Leading Particulars
Dissipation (nominal) 14 and 28 vdc models <1 watt Dissipation (maximum) 14 vdc models (heater ON) 9 watts 10 watts 28 vdc models (heater ON) TABLE 2 - Leading Particulars MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 8 of 17... -
Page 9: Scope
CO. SERVICE FACILITIES The operator can service all components other than the model 452 units itself at an FAA certified Repair Station. NOTE: The sensor requires special gases for testing and calibration. If any... - Page 10 • Insure that the CO Detector installation area meets the temperature and humidity ranges listed in the List of Particulars specifications. Temperature and humidity conditions outside the specification may affect the sensitivity of the alarm. MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 10 of 17...
-
Page 11: Figure 1 - Recommended Installation Locations
Gain access to the area, front and back, where the CO Detector is to be installed. Verify that the unit will not interfere with any other instruments. Cut to the dimensions shown in Figure 2. FIGURE 2 - Indicator Cutout MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 11 of 17... -
Page 12: Figure 3 - Circuit Breaker Cutout
4. All wire to be MIL-W-22759/16 or equivalent. FIGURE 4 - Installation Schematic Mount CO Detector per Figure 2. With the CO Detector disconnected from the aircraft harness, conduct a continuity check of the added aircraft wiring. MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 12 of 17... - Page 13 Verify the unit can be shut off with the circuit breaker. Unit weights 3.5 oz. Record in Aircraft weight and balance manual. MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 13 of 17...
-
Page 14: Maintenance Instructions
WARNING: If the model 452 unit shows a blinking Amber light approximately each second and a flashing Amber external remote light every 4 seconds, return the unit to CO Guardian for repair or replacement. No Field repair or service is allowable other than to the aircraft wiring harness and circuit breaker. -
Page 15: Self Test Sequence
REV A SELF TEST SEQUENCE When power is applied to the Model 452 CO Detector, a self-test routine begins. The test checks for functionality of the critical components such as the CO sensor, temperature sensor, and the integrity of the total CO Detector system. -
Page 16: Alert Cycle
The RS-232 Data Buss option is not currently available. When available, the RS- 232 data buss output will couple CO Detector status information to electronic display systems with RS-232 input capability. 14.0 Warranty MODEL 452 INSTALLATION AND OPERATIONAL MANUAL Page 16 of 17... - Page 17 Warranty Performance: During the above warranty period, your product will be replaced with a comparable product if the defective product is returned, postage prepaid, to CO Guardian, Customer Service Department, 1951 East Airport Drive, Tucson, AZ 85706, together with proof of purchase date.
Need help?
Do you have a question about the 452 and is the answer not in the manual?
Questions and answers