StraubelStone  STEELMAN & EXECUTIVE GAS BARBECUE CARTS, PEDESTALS & BUILT-INS Installation And Operation Instructions Manual

StraubelStone STEELMAN & EXECUTIVE GAS BARBECUE CARTS, PEDESTALS & BUILT-INS Installation And Operation Instructions Manual

Straubelstone steelman & executive gas barbecue carts, pedestals & built-ins

Advertisement

INSTALLATION
AND OPERATION
INSTRUCTIONS
STRAUBELSTONE STEELMAN &
EXECUTIVE GAS BARBECUE CARTS,
PEDESTALS & BUILT-INS
CONGRATULATIONS, on the purchase of your new
STRAUBELSTONE GAS BARBECUE. These units are
designed and intended for outdoor use only.

GENERAL INFORMATION

These instructions are intended as a general guide and
do not supersede national or local codes in any way.
Authorities having jurisdiction should be consulted
before installation.
Installation and provision for combustion and ventilation
air must conform to the National Fuel Gas Code, ANSI
Z223.1, or CAN/CGA-B149.1, Natural Gas Installation
Code, or CAN/CGA-B149.2, Propane Installation Code.
This barbecue has been tested to, and complies with,
ANSI Z21.58 and CAN/CGA 1.6 ( 1995 ), STANDARDS
FOR OUTDOOR COOKING GAS APPLIANCES.
!!! IMPORTANT !!!
Read these instructions carefully before installing or
operating this gas barbecue. These instructions should
be left with the homeowner for future reference.
!!! WARNING !!!
If the information in this manual is not followed exactly, a
fire or explosion may result causing property damage,
personal injury or loss of life.
Do not store combustible materials or use
gasoline or other flammable vapors and
liquids in the vicinity of this or any other
appliance.
A liquid propane tank, not connected for
use with this gas barbecue, shall not be
stored in the vicinity of this or any other
appliance.
Installation and service must be performed
by a: Qualified technician, service agency,
or the gas supplier.

TABLE OF CONTENTS

!!! WARNING !!!
Gas supply system must be installed in accordance with
the U.S. National Fuel Gas Code.
This appliance and its individual shut off valve must be
disconnected from the gas supply piping system during
any system pressure test in excess of ½ PSI ( 3.5 KPA ).
Use a system manual shut off valve to shut off the gas
supply to this gas appliance before continuing with
installation procedures.
GAS-FIRED OUTDOOR COOKING APPLIANCE IN
ACCORDANCE WITH THE AMERICAN NATIONAL
STANDARDS INSTITUTE (ANSI) STANDARD FOR
OUTDOOR COOKING GAS APPLIANCES Z21.58-
1995 83EK
WHAT TO DO IF YOU SMELL GAS:
< Shut off gas supply to the appliance.
< Extinguish any open flames.
< Open barbecue lid.
< If odor continues, Immediately call your
gas supplier. Follow the gas supplier's
instructions.
< If you can not reach your gas supplier,
call the fire department.
1
1
2
5
5
6
6
7
10
12
14
16
18
20
27
28

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the STRAUBELSTONE STEELMAN & EXECUTIVE GAS BARBECUE CARTS, PEDESTALS & BUILT-INS and is the answer not in the manual?

Questions and answers

Summary of Contents for StraubelStone STRAUBELSTONE STEELMAN & EXECUTIVE GAS BARBECUE CARTS, PEDESTALS & BUILT-INS

  • Page 1: Table Of Contents

    INSTALLATION - Carts & Pedestals SET-UP & ASSEMBLY - Carts & Pedestals CONGRATULATIONS, on the purchase of your new INSTALLATION - Built-ins STRAUBELSTONE GAS BARBECUE. These units are LIQUID PROPANE INFORMATION designed and intended for outdoor use only. NATURAL GAS INFORMATION...
  • Page 2 STRAUBELSTONE STEELMAN STRAUBELSTONE EXECUTIVE GAS BARBECUE MODELS GAS BARBECUE MODELS...
  • Page 3: Models

    STRAUBELSTONE STEELMAN STRAUBELSTONE STEELMAN PEDESTAL GAS BARBECUE BUILT-IN GAS BARBECUE MODELS MODELS...
  • Page 4 STRAUBELSTONE GAS BARBECUE ACCESSORIES UNDER SHELF & CONDIMENT HOLDER SIDE SHELF COVER COOKING & SEARING GRATES ROTISSERIE DOOR PANELS SIDE PANELS SIDE GRILL DEEP FRYER & BASKET GRIDDLE MESH SHELF CONDIMENT TRAY...
  • Page 5: Shipping And Packing List

    PROPER CLEARANCES FROM COMBUSTIBLE CONSTRUCTION AND MATERIALS MUST BE MAINTAINED FROM ALL SIDES, TOP, AND BOTTOM Your STRAUBELSTONE GAS BARBECUE comes assembled, OF THIS APPLIANCE ( 24" IN ANY DIRECTION ). ready for the gas connection, with the exception of hood and/or shelf assembly, wheel and axle assembly, condiment holder, and handle on some models.
  • Page 6: Specifications - Carts & Pedestals

    10.5” W.C. 30,000 LOCATION With optional Side Grill 45,000 LIQUID PROPANE - RATED PRESSURE – 11.0” W.C. Your StraubelStone Gas Barbecue can be installed on any flat, stable surface away from any combustible MINIMUM GAS MAXIMUM GAS ORIFICE BTU/HR materials or construction. See " CLEARANCES FOR...
  • Page 7: Set-Up & Assembly - Carts & Pedestals

    Do not over tighten. available. Call the StraubelStone Service Center. Gas ( SEE FIGURE 4 ) conversions must be performed by a qualified installer.
  • Page 8 FOR UNITS REQUIRING WHEEL ASSEMBLY Remove wheels from carton. Using an adjustable wrench, or a 3/4" open-end wrench, remove wheel nuts from each end of axle. Leave wheel spacers in place on axle. Place one ( 1 ) wheel ( spoke side in ) over each end of the axle.
  • Page 9 LEVELING Once you have selected the location for your barbecue, adjust the adjuster nuts, located on the casters, at each of the two ( 2 ) bottom right side corners of the cart chassis base frame, for level adjustment. For triangular pedestal units, all four casters are adjustable.
  • Page 10: Installation - Built-Ins

    !!! WARNING !!! ( SEE FIGURE 1, PAGE 6 ) For Liquid Propane models, with Side Grill applications, As StraubelStone can not anticipate any one particular both Barbecue and Side Grill must be converted to Built-in installation method, adjustable installation Liquid Propane.
  • Page 11: Specifications

    45,000 barbecue rim; venting holes in the basin rim must be left unobstructed, so as to permit the flow of combustion and ventilation air. STRAUBELSTONE EXECUTIVE BUILT IN SERIES GAS BARBECUE SPECIFICATIONS !!! IMPORTANT !!! Be sure to allow for access to the grease cup. The NATURAL GAS - RATED PRESSURE - 7.0”...
  • Page 12: Liquid Propane Information

    If the tank manufacturer does not resolve any issue to your satisfaction, please call the StraubelStone FIGURE 11 Customer Service Center.
  • Page 13 Align the TYPE 1 - LP TANK CONNECTOR with the hose and regulator furnished with this appliance or a the valve threads. StraubelStone approved replacement. Turn the fitting clock-wise until snug. DO NOT ( SEE FIGURE 12 ). OVER TIGHTEN! ( SEE FIGURE 13 ) Figure 2 Hose &...
  • Page 14: Natural Gas Information

    A regulated Natural Gas kit may be purchased by calling Remove the existing cap or gas jet assembly the StraubelStone Customer Service Center. from the gas stub. Install a manual valve. Install a 3/8" male flare...
  • Page 15 ROTISSERIE KIT FINAL SET UP For installation of the rotisserie kit, see the instructions Final set up on your StraubelStone Gas Barbecue may that come with the kit. vary depending on the model purchased. WIRE MESH SHELF...
  • Page 16: Operation

    OPERATION FLAME PRESS TO IGNITE VIEWER FOR YOUR SAFETY – READ BEFORE LIGHTING !!! WARNING !!! IGNITE Do not use this appliance if any part has been under water. Immediately call a qualified service technician to inspect the barbecue and replace any part of the control BURNER system and any gas control that has been under water.
  • Page 17 FLAME VIEW, or between the grill grates to achieve ignition. If, after repeated attempts the Medium settings should be used for cooking steaks, pork burner does not light, call the StraubelStone Customer chops, grilled fowl parts, and burgers. Service Center or your installer.
  • Page 18: Maintenance

    BURNER ASSEMBLY continued MAINTENANCE FOR STEELMAN SERIES: Your StraubelStone Gas Barbecue should be thoroughly cleaned on a regular basis. Remove the cooking grates For left side burner: Lift outside of burner in a and burner plate to collect or vacuum ashes and food clockwise direction until it is perpendicular to its debris.
  • Page 19 GAS VALVE MANIFOLD ASSEMBLY continued Remove burner control knobs by gripping firmly and pulling away from control plate. Using a #2 Phillips screw driver, remove the four ( 4 ) control plate mounting screws. Remove burner assembly. ( See Burner Assembly ) Remove the igniter wires from the back of the push button igniter ( mark the locations of the...
  • Page 20: Parts Listing

    STRAUBELSTONE STEELMAN GAS BARBECUE PARTS LIST ITEM DESCRIPTION QUANTITY MSS-HB1420/12 MACHINE SCREW STAINLESS - 5/32 HEX BUTTON HEAD 1/4 20 X 1/2 Q24-BS BBQ 24 BASIN - STAINLESS STEEL Q24-BB BBQ 24 BASIN - BLACK Q24-GC BBQ 24 GREASE CUP QPR-316/600 BBQ 24 POP RIVET - 3/16"...
  • Page 21 BBQ 24 SEARING GRATE - PORCELAIN - 15" X 12" Q24-WR BBQ 24 WARMING RACK Q24P-REG/A BBQ 24 LIQUID PROPANE REGULATOR AND HOSE ASSEMBLY IM-SEPB INSTRUCTION MANUAL - STRAUBELSTONE STEELMAN, EXECUTIVE, PEDESTAL, BUILT-IN ST-WC STRAUBELSTONE WARRANTY CARD Q24-NGC BBQ 24 NATURAL GAS CONVERSION KIT Q24N-REG/A...
  • Page 22 STRAUBELSTONE STEELMAN CART SECTION PARTS LIST ITEM DESCRIPTION QUANTITY Q24C-TOP/S BBQ 24 CART - TOP - STAINLESS Q24C-HAN/S BBQ 24 CART - HANDLE - STAINLESS Q24C-LFL/S BBQ 24 CART - LEG FRONT LEFT - SILVER Q24C-LFR/S BBQ 24 CART - LEG FRONT RIGHT - SILVER...
  • Page 23 STRAUBELSTONE EXECUTIVE GAS BARBECUE PARTS LIST ITEM DESCRIPTION QUANTITY MSS-1420HB/12 MACHINE SCREW STAINLESS - 5/32 HEX BUTTON HEAD - 1/4 20 X 1/2 Q36-BS BBQ 36 BASIN - STAINLESS STEEL Q36-BB BBQ 36 BASIN - BLACK Q36-GC BBQ 36 GREASE CUP QPR-316/600 BBQ 24 POP RIVET - 3/16"...
  • Page 24 BBQ 24 GRATE - PORCELAIN - 16" X 12" Q24-SG/1512 BBQ 24 SEARING GRATE - PORCELAIN - 15" X 12" Q24-WR BBQ 24 WARMING RACK IM-SBQCS36 INSTRUCTION MANUAL - STRAUBELSTONE STEELMAN GAS BBQ ST-WC STRAUBELSTONE WARRANTY CARD Q36-NGC BBQ 36 NATURAL GAS CONVERSION KIT Q36N-REG/A...
  • Page 25 STRAUBELSTONE EXECUTIVE CART SECTION PARTS LIST ITEM DESCRIPTION QUANTITY Q36C-TOP/S BBQ 24 CART - TOP - STAINLESS Q24C-HAN/S BBQ 24 CART - HANDLE - STAINLESS Q24C-LFL/S BBQ 24 CART - LEG FRONT LEFT - SILVER Q24C-LFR/S BBQ 24 CART - LEG FRONT RIGHT - SILVER...
  • Page 26 STRAUBELSTONE STEELMAN PEDESTAL SECTION PARTS LIST ITEM DESCRIPTION QUANTITY Q24PT-TOP/S BBQ 24 TRIPOD PEDESTAL - TOP - STAINLESS Q24PT-LFL/S BBQ 24 TRIPOD PEDESTAL - LEG FRONT LEFT - SILVER Q24PT-LFR/S BBQ 24 TRIPOD PEDESTAL - LEG FRONT RIGHT - SILVER...
  • Page 27: Trouble Shooting

    STRAUBELSTONE GAS BARBECUE TROUBLE SHOOTING PROBLEM OBSERVED POSSIBLE CAUSE CORRECTIVE MEASURE Gas odor during set up Gas leak See " What to do if you smell gas " page 1 Check all gas connections Gas odor before first ignition Gas leak See "...
  • Page 28: Warranty

    StraubelStone™ hereby warrants to the ORIGINAL PURCHASER of this StraubelStone™ Gas Barbecue, StraubelStone is not liable for any special, indirect or that it will be free from defects in material and consequential damages. StraubelStone’s liability is workmanship from the date of purchase as follows: limited to the purchase price of this StraubelStone Gas Barbecue.

This manual is also suitable for:

Steelman seriesExecutive series

Table of Contents

Save PDF