Table of Contents
Advertisement
f i r e f e a t u r e
C-View-PRC Custom Fireplace
BF-Series SS Gas Fireplace
C820-PV Shown
Warning:
Improper installation, adjustment, alteration, service or maintenance can cause
injury or property damage. Refer to this manual. For assistance or additional
information consult a qualified installer, service agency or the gas supplier.
Safety Notice:
Glass doors on gas fireplaces are extremely hot while the fireplace is on and remain
hot even after the fireplace has been turned off. Safety screens are available and
can reduce the risks of severe burns.
For Your Safety:
Do not store or use gasoline or other flammable vapors and liquids in the
vicinity of this or any other appliance.
Canadian Heating Products Inc. Langley, BC V4W 4A
XG0704
Installation Operation & Maintenance Manual
Check local codes and read all instructions prior to installation.
®
C
US
www.montigo.com
What to do if you smell gas
•
Do not try to light any appliance.
•
Do not touch any electrical
switch; do not use any phone in
your building.
•
Immediately call your gas
supplier from a neighbor's
phone. Follow the gas supplier's
instructions.
•
If you cannot reach your gas
supplier, call the fire department.
•
Installer: Leave this manual with the
appliance.
•
Consumer: Leave this manual for
future reference.
Montigo Del Ray Corp. Ferndale, WA 98248
C520
C1520
C620
C1620
C720
C1720
C820
C1820
C920
C1920
C1020 C2020
C1120 C2120
C1220 C2220
C1320 C2320
C1420 C2420
Warning:
department.
022509
Advertisement
Table of Contents
Related Manuals for Fire feature C520
Summary of Contents for Fire feature C520
-
Page 1: Safety Notice
• Installer: Leave this manual with the appliance. ® • Consumer: Leave this manual for future reference. department. Canadian Heating Products Inc. Langley, BC V4W 4A Montigo Del Ray Corp. Ferndale, WA 98248 XG0704 022509... -
Page 2: Table Of Contents
CVIEW-PRC Custom Gas Fireplace f i r e f e a t u r e Warning: Read this manual before installing, operating or troubleshooting this appliance. Please retain this owner's manual for future reference. Congratulations Congratulations on selecting a FireFeature Custom gas fireplace, This owner's manual should be retained for future reference. - Page 3 & away from furniture and which are beyond the capability of a B-vent model. draperies. The C520 is rated for Natural Gas and Propane at 60,000 BTU/H ■ Children and adults should be alerted to the hazards ...
-
Page 4: Warranty And Installation
This will power up both relays supplying 24 Volts to the Honeywell plied to Montigo). The vent run may also be lower than the fireplace control valves located in the bottom of the fireplace. The glow pug flue gas outlet, or have a portion that is lower than the main vent run, on the pilot system will ignite the pilots, and the sensor will identify as long as Montigo has reviewed and engineered the entire system. - Page 5 Installation C-View fireplace: C-View-PRC Fireplace Dimensions The fireplace may be installed in any location that maintains proper C520 C620 clearances to air conditioning ducts, electrical wiring and plumbing. C720 Safety, as well as efficiency of operation, must be considered when C820 selecting the fireplace location.
-
Page 6: Finishing Around The Fireplace
Combustible Construction allowed in shaded area. Figure 3. Framing dimensions Combustible Facing Non-Combustible Framing Framing Dimensions C520 C620 C720 C820 C920 C1020 Non-Combustible Drywall J-Track C1120 C1220 Figure 4. -
Page 7: Installing The Gas Line
CVIEW-PRC Custom Gas Fireplace f i r e f e a t u r e Installation Installations in Canada must be electrically grounded in accordance with CSA C22.1 Canadian Electrical Code Part 1 and/or Local Codes. Installations in the USA must be electrically grounded in accordance with local codes or, in the absence of local codes, with the National Electrical Code, ANSI/NFPA 70-1987. -
Page 8: Vent Terminations
110 1/3 EXPVDWH 10/12 UL certified B-Vent venting components. (Use of other non-certified parts will void the Montigo warranty, and may impede the operation of the fireplace). The clearance for B-Vents is listed by the manufacturer of the B-Vent. In- ... -
Page 9: Combustion Air Supply
The flexible portion of insulated pipe must have 1" clearance to all combus- to burn if the pressure is negative, past 0.3WC. tibles. For air supply runs over 25 feet consult with Montigo to have the vent supply re-sized. Figure 9. Installing the rear vent terminations. Page 9... - Page 10 CVIEW-PRC Custom Gas Fireplace f i r e f e a t u r e Installation WARNING! If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. 110V Power Supply 6 Amp 110V Fuse Post Purge Control...
-
Page 11: Startup Sequence
The glass temperature should not exceed 300 deg F. and the flue gas temperature should not exceed 380 deg F. Please consulted with your contact person at Montigo should you have any problems with your start up. Operation:... -
Page 12: Maintenance
10-24 screws. Follow the process below to remove, or install the items described. General Figure 14. The Fireplace as it is received from Montigo. Have the fireplace installation inspected yearly, including a visual Figure 15. (Step 2) Remove the Door-window trim by grasping the metal check of the vent system, the burner and the pilot flame. -
Page 13: Installing The Glass Beads And Optional River Rock
These may be spaced at random, or in a visual pattern of your preference. See the Montigo web site for photographs and ideas. www.montigo.com Note: Ensure the rocks or beads do not cover the Burners. -
Page 14: Troubleshooting
If you still do not have a closed circuit after the removal of the Terminals (24VAC To Wall Nominal, see INSET) glass front you need to consult with a technician at Montigo. Switch Igniter warms up and glows red. -
Page 15: Warranty
The duration of any implied warranty with respect to this Montigo Gas Appliance is limited to the duration of the foregoing warranty. Some states do not allow limitation on how long an implied warranty lasts, so the above may not apply to you. - Page 16 CVIEW-PRC Custom Gas Fireplace f i r e f e a t u r e Appendix A - State of Massachusetts Amendment (Gas Fireplace / Equipment sold in the State of Massachusetts) 5.08: Modifications to NFPA-54, Chapter 10 (1) Revise NFPA-54 section 10.5.4.2 by adding a second exception as follows: Existing chimneys shall be permitted to have their use continued when a gas conversion burner is installed, and shall be equipped with a manually reset device that will automatically shut off the gas to the burner in the event of a sustained back-draft (2) Revise 10.8.3 by...
-
Page 17: Notes
CVIEW-PRC Custom Gas Fireplace f i r e f e a t u r e Notes Page 17 Part No. XG0704... - Page 18 CVIEW-PRC Custom Gas Fireplace f i r e f e a t u r e Notes Page 18 Part No. XG0704...
- Page 19 CVIEW-PRC Custom Gas Fireplace f i r e f e a t u r e Notes Page 19 Part No. XG0704...
- Page 20 XG0704 - 022509 Montigo Del Ray Corp. Canadian Heating Products Inc. Langley, BC V4W 4A1 Ferndale, WA 98248...
Need help?
Do you have a question about the C520 and is the answer not in the manual?
Questions and answers