Table Of Contents - Land Pride RC35120 Operator's Manual

Table of Contents

Table of Contents
Important Safety Information . . . . . . . . . . .1
Safety Notations . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Safety Rules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Prior To Operation . . . . . . . . . . . . . . . . . . . . . . 1
During Operation . . . . . . . . . . . . . . . . . . . . . . . . 1
During Maintenance . . . . . . . . . . . . . . . . . . . . . 1
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Introduction . . . . . . . . . . . . . . . . . . . . . . . .6
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . 6
Terminology: . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Definitions: . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . 6
Section 1 Assembly and Setup . . . . . . . . .7
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 7
Lift-Type Cutter . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Hitch & Axle Assembly . . . . . . . . . . . . . . . . . . . 7
Tailwheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Pull-Type Cutter . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Tongue . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Rear Axle . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Tailwheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Leveling Rod . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Driveline Installation . . . . . . . . . . . . . . . . . . . . . . . 11
Lift-Type Cutter . . . . . . . . . . . . . . . . . . . . . . . . 11
Pull-Type Cutter . . . . . . . . . . . . . . . . . . . . . . . 11
Safety Guards . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Tractor Hook-Up . . . . . . . . . . . . . . . . . . . . . . . . . 11
Lift-Type Cutter . . . . . . . . . . . . . . . . . . . . . . . . 11
Pull-Type Cutter . . . . . . . . . . . . . . . . . . . . . . . 13
Section 2 Operating Instructions . . . . . .14
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Operating Check List . . . . . . . . . . . . . . . . . . . . . . 14
Cutting Instructions . . . . . . . . . . . . . . . . . . . . . . . 14
©
Copyright 2008 All rights Reserved
Land Pride provides this publication "as is" without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual,
Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land
Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect
the product in the future. The illustrations in this manual are not intended for safe and proper assembly or disassembly of equipment. The illustrations are intended for or-
dering parts only.
All other brands and product names are trademarks or registered trademarks of their respective holders.
RC35120 RCM35120 Rotary Cutter 312-301M
Section 3 Adjustments . . . . . . . . . . . . . . .16
Lift-Type Cutting Height . . . . . . . . . . . . . . . . . . . . 16
Pull-Type Cutting Height . . . . . . . . . . . . . . . . . . . 16
Deck Attitude Adjustment . . . . . . . . . . . . . . . . . . . 16
Section 4 Troubleshooting . . . . . . . . . . .17
Section 5 Maintenance and Lubrication .19
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Service Cutting Blades . . . . . . . . . . . . . . . . . . . . . 19
Skid Shoe Service & Replacement . . . . . . . . . . . . 19
Flex Couplers . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Clutch Run-In . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Pivoting Upper Hitch . . . . . . . . . . . . . . . . . . . . 20
Lift-Type Tailwheel Spindle Hub . . . . . . . . . . . 20
Lift-Type Tailwheel Hub . . . . . . . . . . . . . . . . . . 21
Pull-Type Tailwheel Hub . . . . . . . . . . . . . . . . . 21
Ratchet Jack . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Driveline U-Joints . . . . . . . . . . . . . . . . . . . . . . 21
Driveline . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
T-Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
4-Plate Slip Clutch . . . . . . . . . . . . . . . . . . . . . . . . 23
Disassembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Section 6 Specifications and Capacities 24
Section 7 Appendix . . . . . . . . . . . . . . . . .25
Torque Values Chart for Common Bolt Sizes . . . . 25
Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Land Pride is registered trademark.
Printed in the United States of America.
Land Pride
7/14/08