Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Imperial TG5000PS-SS
Summary of Contents for Imperial TG5000PS-SS
- Page 1 Imperial Cal. Products, Inc. Installation Guide And Users Manual MODELS: TG5000PS-SS – Island Hood & TW5000PS-SS – Wall Hood 425 Apollo St. Brea, CA 92821 www.imperialhoods.com 800-851-4192 DO NOT THROW AWAY PROPERTY OFTHE HOME OWNER...
-
Page 2: Table Of Contents
Table of Contents Important Safety Instructions …………………………….. P.01 - Installation ………………………………………………... P.01 - Operations …………………………………………….….. P.01 - Cleaning …………………………………………………... P.01 Before You Start ……………………………………………. P.02 Electrical requirements ……………………………………. P.03 List of Materials …………………………………………….. P.04 Planning for the instruction ………………………………... P.05 - Important ………………………………………………... -
Page 3: Important Safety Instructions
A. IMPORTANT SAFETY INSTRUCTIONS Read all Instructions before installing and operating this appliance. Installation Do not install if the outside/appearance of this appliance is already damaged. 1. The installation in this manual is intended for qualified installers, service technicians or someone with similar qualified background NEVER attempt to install this appliance yourself. - Page 4 It is very important for your safety and safety of others. Always read and obey all safety messages. All safety messages will inform you on what the potential hazards are, how to reduce the chance of injury, and what can happen if the instructions are not followed. These alerts are here to help you avoid potential hazards that can kill or hurt you.
-
Page 5: Electrical Requirements
C. ELECTRICAL REQUIREMENTS OBSERVE ALL GOVERNING CODES AND ORDINANCES WARNIN G * Electrical ground is required on this range hood. * Check with a qualified electrician if you are not sure whether the range hood is properly grounded. * Failure to follow electrical requirements may result in a fire. * a fuse in the neutral or grounding circuit could result in electrical shock. - Page 6 Description Quality Main body (Body of Hood) include aluminum filter (s) 1 Set Duct Cover Sets (Upper Duct & Lower Duct) 1 Set Supporting frames (with 8 sets of 5mm x 16mm screw with washers) 1 Set Duct Set (include O-ring) 1 Set Installation Guide 1 Set...
-
Page 7: Important
A. Important: Must measure following steps before installation. The Duct Covers are adjustable and designed to meet various ceiling or wall height. The duct covers can be adjusted for ceiling between 8ft and 9ft depending on the distance between the bottom of the hood and the cook top) For shorter ceiling, have the duct cover cut at a sheet metal shop. -
Page 8: Installation Instructions
The vent system must have a damper. If roof or wall cap has a damper, Do Not use damper supplied with the range hood. - Use duct tape to seal all joints in the vent system. - Fasten all connections with sheet metal screws and tape all joints with certified Silver Tape or Duct Tape. Calculate the duct run length: If ducted with the required minimum of 7"... -
Page 9: For Island Type Of Models
- Due to the size and weight of this range hood, the support must be firmly attached to the ceiling or wall. For plaster or sheet rock ceilings, the support must be attached to the joists. If this is not possible, a support structure must be built behind the plaster or sheet rock. -
Page 10: For Wall-Mount Type Of Models
and washers. Pay extra attention to sharp edges on the duct covers and minimize duct cover movements to avoid scratches on the duct covers. You may use a screw driver to prevent them from sliding down as illustrated in figure 6. CAUTION: 1. - Page 11 2. Use four sets of 5mm x 16mm screws with flat washer to install the body hooks onto the hood (see figure 2) 3. Install the duct set by using six 4mm x 16mm screw (See figure 3). 4. Find an optimal location for the duct cover's fix panel. The fix panel must be placed directly above and align with the two body hooks.
-
Page 12: Range Hood Operation
G. RANGE HOOD OPERATIONS Po we r Switc h L ow Spe ed Lig ht Sw itch Me dium Spee d High Spe ed TURN ON: - Press the speed control (Low Speed, Medium Speed, High Speed) switch to select the desired level of power. -
Page 13: Trouble Shooting
I. TROUBLE SHOOTING WARNING HAZARD OF ELECTRICAL SHOCK! Do not perform service on an electrically live systems. Disconnect the main electrical supply before servicing this device. Touching electrical connectors or other exposed electrical circuitry inside this range hood when they are energized could result in death, serious bodily injury, or property damage. -
Page 14: Maintenance
J. MAINTENANCE Prior to any maintenance operation ensure that the range hood is disconnected from the power supply. WARNING : FAILURE TO CARRY OUT THE BASIC STANDARDS OF CLEANING THE RANGE HOOD AND REPLACEMENT OF THE FILTERS MAY CAUSE FIRE RISKS. THEREFORE WE RECOMMEND OBSERVING THESE INSTRUCTIONS. -
Page 15: Wiring Diagram
Replacing the light bulb: LED Light Design: - For LED Light replacement, please contact with distributor(s)/ dealer(s) - Should the light bulb burned out due to age or prolonged use, replace with LED bulb. - If new lights do not operate, make sure the light bulb is inserted correctly. Before replacing LED light ensure the unit is switched off, when you want to change the LED light please always wear WARNING: Disconnect the hood from electricity and be sure the lights are cool. - Page 16 In-home service for parts and labor. Parts ONLY for one additional year. Call for service at: 800-851-4192. Items Imperial Will NOT Pay For Service calls to correct the installation of your appliance, to instruct you how to use your appliance, to replace or repair house fuses or the correct housing wiring or plumbing.
Need help?
Do you have a question about the TG5000PS-SS and is the answer not in the manual?
Questions and answers