Page 1
KD-S7R SERVICE MANUAL CD RECEIVER KD-S7R COMPACT DIGITAL AUDIO Area Suffix E ---- Continental Europe EX---------Central Europe Contents Safety precaution Adjustment method 1-11 Preventing static electricity Flow of functional Important for laser products operation unit TOC read 1-12 Location of main parts...
KD-S7R Safety precaution Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system. Please use enough caution not to see the beam directly or touch it in case of an...
KD-S7R Preventing static electricity Electrostatic discharge (ESD), which occurs when static electricity stored in the body, fabric, etc. is discharged, can destroy the laser diode in the traverse unit (optical pickup). Take care to prevent this when performing repairs. 1.1. Grounding to prevent damage by static electricity Static electricity in the work area can destroy the optical pickup (laser diode) in devices such as DVD players.
KD-S7R Important for laser products 5.CAUTION : If safety switches malfunction, the laser is able 1.CLASS 1 LASER PRODUCT to function. 2.DANGER : Invisible laser radiation when open and inter 6.CAUTION : Use of controls, adjustments or performance of lock failed or defeated. Avoid direct exposure to beam.
KD-S7R Location of main parts Control unit LED & key control board Display Main unit Main board ISO connector Antenna jack Tuner pack Power IC Main board Connector to controller CD mechanism Mechanism relay board Loading motor Damper Spindle motor...
KD-S7R Disassembly method Removing the front panel unit (See Fig.1) 1. Press the release button and remove the front panel unit in the direction of the arrow. Fig.1 Removing the front chassis (See Fig.2) 1. Insert a screwdriver to the joints a on the side of the front chassis and two joints b on the right side, then detach the front chassis toward the front side.
Page 7
KD-S7R CN501 Main amplifier board Removing the main amplifier board (See Fig.5 and 6) Remove the front chassis. Remove the bottom cover. Remove the two screws B attaching the main amplifier board assembly on the bottom of the body. Remove the three screws C attaching the main amplifier board assembly on the back of the body.
KD-S7R Damper bracket <CD mechanism section> CD mechanism assembly Prior to disassembling the CD mechanism, remove the following parts. The front panel unit and the front chassis (Refer to Fig.1 and 2) The heat sink (Refer to Fig.3) The bottom cover (Refer to Fig.4) The main amplifier board (Refer to Fig.5 and 6)
Page 9
KD-S7R Removing the loading motor Loading motor (See Fig.12 to 14) Prior to performing the following procedure, remove the CD mechanism control board. Belt Remove the two springs k attaching the CD mechanism ass’y and the front bracket. Fig.14 Remove the two screws G and the front bracket while pulling the flame outward.
KD-S7R Removing the feed motor assembly Part n Feed motor FD screw assembly (See Fig.19) Prior to performing the following procedure, remove the CD mechanism control board, the front bracket Part O (loading motor) and the CD mechanism ass’y. Remove the two screws K and the feed motor ass’y.
6. Digital tester MW 522kHz ~ 1620 kHz 7. Tracking offset meter LW 144kHz ~ 279kHz 8. Test Disc JVC :CTS-1000 9. Extension cable for check EXTGS004-26P 1 Dummy load Exclusive dummy load should be used for AM,and FM. For FM dummy load,there is a loss of 6dB between SSG output and antenna input.The loss of 6dB need not be considered...
KD-S7R Flow of functional operation until TOC read Power ON • When the laser diode correctly Set Function to CD • When the pickup correctly moves emits to the inner area of the disc Microprocessor Microprocessor Disc inserted commands commands TC9462 "53"...
KD-S7R Feed Section Check CD 9V Is the voltage output at Is the wiring for IC521 Is 5V present at IC581 and 5V. IC521 pin "53" 5V or 0V? (90) ~ (100) correct? pin "11"? Check the vicinity of IC521.
KD-S7R Maintenance of laser pickup (1) Cleaning the pick up lens Before you replace the pick up, please try to clean the lens with a alcohol soaked cotton swab. (2) Life of the laser diode When the life of the laser diode has expired, the following symptoms will appear.
KD-S7R UPD178076GF-525 (IC701): System CPU 1.Terminal layout 100 ~ 81 31 ~ 50 2.Block diagram TO0/VTR-CONT NC,JBUS-INT,SW1, 16-bit TIMER/ PORT 0 TI00/POWER REMOCON,PS1,PS2, EVENT COUNTER DETACH,NC TI01/CD-ON TI50/MUTE PORT 1 KEY0,KEY1,KEY2,LEVEL, 8-bit TIMER/ EVENT COUNTER 0 SM,NC, TO50/NC JBUS-SI,JBUS-SO, TI51/STAGE...
Page 17
KD-S7R 3.Pin function UPD178076GF-525(1/2) FUNCTION Symbol Non connection BUSINT JVC BUS COMMUNICATION LINE BUSSI JVC BUS COMMUNICATION LINE BUSSO JVC BUS COMMUNICATION LINE JBUS-SCK JVC BUS COMMUNICATION LINE Non connection Non connection I2CDAI SERIAL DATA INPUT I2CDAO SERIAL DATA OUTPUT...
Page 18
KD-S7R UPD178076GF-525(2/2) FUNCTION Symbol CD MECHA SW REMOCON REMOCON INPUT Non connection TEL_MUTE TEL MUTE OUTPUT POWER POWER CONT. CDON CD POWER CONT. MUTE MUTE CONT STAGE 1 BUZZER Non connection STAGE 2 Non connection Non connection Non connection Non connection...
Page 19
KD-S7R BA4905-V3 (IC961) : Regulator 1.Terminal layout 2.Block daigram REGULATOR RESET RESET COMP VDD 5.7V CD 8V AUDIO 9V CTRL ILM 10V 3.Pin function Pin no. Symbol Function RESET If VDD voltage becomes 4V or less.RESET output becomes low level.
Page 24
KD-S7R TC9462F (IC541) : DSP & DAC 1.Pin Layout 2.Pin Function (1/2) Symbol Pin No. Function Test mode terminal. Normally, keep at open TEST0 Playback speed mode flag output terminal Playback speed mode flag output terminal UHSO Sub code Q data emphasis flag output terminal. "H"=ON "L"=OFF EMPH Channel clock output terminal.(44.1kHz) "H"=Rch "L"=Lch...
Page 25
KD-S7R 2.Pin Function (2/2) TC9462F Symbol Function Pin No. RFRP signal center level input terminal RFCT RFRP zero cross input terminal RFZI RF ripple signal input terminal RFRP Focus error signal input terminal Sub-beam adder signal input terminal SBAD Test input terminal Normally, keep at "vref" level TSIN Tracking error signal input terminal.
Page 26
KD-S7R SAA6579T-X (IC71) : RDS demodulator 1. Pin layout 2. Pin function Symbol Function QUAL Quality indication output RDDA RDS data output Vref Reference voltage output (0.5VDDA) Multiplex signal input VDDA +5V supply voltage for anarog part VSSA Ground for analog part (0V)
Page 28
KD-S7R RPM6938-SV4(IC652) : Remote sensor 1.Block diagram Comp Rout Detector conversion trimming circuit magnetic shield NJM4565M-WE (IC581) : Ope. amp A OUTPUT B OUTPUT A INPUT A INPUT B INPUT B INPUT 1-28...
Page 29
KD-S7R VICTOR COMPANY OF JAPAN, LIMITED MOBILE ELECTRONICS DIVISION PERSONAL & MOBILE NETWORK BUSINESS UNIT. 10-1,1Chome,Ohwatari-machi,Maebashi-city,Japan Printed in Japan (No.49611) 200102(V)
KD-S7R Standard schematic diagrams Main amp. section TUNER SIGNAL CD SIGNAL FRONT SIGNAL REAR SIGNAL Parts are safety assurance parts. When replacing those parts make sure to use the specified one.
Page 33
KD-S7R KD-S7R CD servo section DIGITAL SIGNAL ANALOG SIGNAL...
KD-S7R PARTS LIST [ KD-S7R ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix E ----------- Continental Europe EX --------------- Central Europe - Contents - Exploded view of general assembly and parts list...
KD-S7R Parts list (General assembly) Block No. M1MM Item Description Parts number Parts name Q'ty Area --------------- CD MECHA FSJC1029-404 TOP CHASSIS SIDE PANEL FSMH3001-202 FSKM3011-002 BOTTOM COVER FSMA3004-003 INSULATOR QYSDST2604Z SCREW 3 CHASSIS+MECHA B FSKZ4005-001 SCREW 2 CHASSIS+SIDE PA...
KD-S7R CD mechanism assembly and parts list Block No. Grease TN-CCD1001Z-136J G-31SA G-31SA(Bottom side) RX-405 106 29...
Page 40
KD-S7R Parts list (CD mechanism) Block No. M2MM Item Description Parts number Parts name Q'ty Area 30310101T FRAME 30310103T DANPER PIN UPPER PLATE 30310107T 30310108T SEL STOP PLATE 30310142T SEL ARM (L)L 30310143T SEL ARM (R)L 30310145T S ARM SPRING(L)
Page 41
KD-S7R Parts list (CD mechanism) Block No. M2MM Item Description Parts number Parts name Q'ty Area 64180403T DET SWITCH 2 ESE22MH3 68150232T CONNECTOR 1 TKC-W26X-C1 SOPPORT PLATE 30311105T 30311138T GR MT BLK(N) 30311109T LDG GEAR (2) 30311110T LDG GEAR (3)
Page 42
KD-S7R Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area NDC21HJ-5R0X C CAPACITOR C 521 NCB21HK-103X C CAPACITOR NDC21HJ-100X C CAPACITOR C 522 NCB21HK-103X C CAPACITOR QERF1HM-104Z E CAPACITOR .10MF 20% 50V...
Page 43
KD-S7R Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area C 712 NDC21HJ-680X C CAPACITOR Q 31 2SD601A/R/-X TRANSISTOR C 713 NCB21HK-103X C CAPACITOR Q 32 2SD601A/R/-X...
Page 44
KD-S7R Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area R 184 NRSA02J-332X MG RESISTOR R 592 NRSA02J-223X MG RESISTOR R 185 NRSA02J-473X MG RESISTOR R 593...
Page 45
KD-S7R Electrical parts list (Main board) Block No. 01 Item Remarks Parts number Parts name Area R 911 NRSA02J-100X MG RESISTOR R 976 NRSA02J-473X MG RESISTOR R 977 NRSA02J-273X MG RESISTOR R 978 NRSA02J-123X MG RESISTOR TU 1 QAU0156-002 TUNER...
Page 46
KD-S7R Electrical parts list (Front board) Block No. 02 Item Parts number Parts name Remarks Area Item Remarks Parts number Parts name Area C 601 NCB21HK-223X C CAPACITOR R 655 NRSA02J-103X MG RESISTOR C 602 NCS21HJ-681X C CAPACITOR R 656...
KD-S7R Packing materials and accessories parts list Block No. Block No. E version only A2~A4 KIT : A6~A10 3-12...
Page 48
KD-S7R Parts list (Packing ) Block No. M3MM Item Description Parts number Parts name Q'ty Area GE30123-040A PACKING CASE GE10008-001A CUSHION POLY BAG 1 SET QPC03004315P FSPG4002-001 POLY BAG 1 INST.BOOK FSPG4002-001 POLY BAG 2 INST.BOOK QPA00801205 POLY BAG 1 SCREW...
Need help?
Do you have a question about the KD-S7R and is the answer not in the manual?
Questions and answers