Advertisement
Table of Contents
Advertisement
Table of Contents
Summary of Contents for Afrigreen YASBP-38HL
- Page 1 AIR SOURCE HEAT PUMP WATER HEATER UNIT Installation & Instruction Manual A p p l i c a b l e M o d e l : YA S B P - 3 8 H L YA S B P - 5 6 H L YA S B P - 7 8 H L YA S B P - 9 5 H L YA S A - 1 3 5 H S...
-
Page 2: Table Of Contents
AIR SOURCE HEAT PUMP WATER HEATER Contents To our customers Product Introduction Technical data LCD Controller Display Pipe connection Fitting instruction Debugging and preoperation Maintenance Operation data setting table Trouble shooting guide Wiring Diagram... -
Page 3: To Our Customers
AIR SOURCE HEAT PUMP WATER HEATER To valued customers 1. Dear customer, please read the instruction carefully before you install this product,otherwise it may lead to damage to the instrument or may injure operators as well as cause financial loss 2. -
Page 4: Product Introduction
AIR SOURCE HEAT PUMP WATER HEATER Product Introduction: Safe and Reliable Heat pump water heater is a equipment which use electricity but doesn't be used for heating water directly. Water and electricity is separated to ensure use safe, to avoid electric shock, burning, explosion and intoxication etc, these problem is apt to happen when use electric or gas water heater. -
Page 5: Technical Data
AIR SOURCE HEAT PUMP WATER HEATER Technical Data 1. Performance data of air source heat pump water heater Model YASBP-25HL YASBP-38HL YASBP-56HL YASBP-78HL YASBP-95HL 3300 4200 6100 7800 9500 Heating Capacity 11260 14330 20813 26000 32000 Power Supply V/PH/HZ 220V/1/50HZ Input Power 0.82... -
Page 6: Lcd Controller Display
AIR SOURCE HEAT PUMP WATER HEATER 2. LCD Controller Display Heating mode Cooling mode Temp Display TEMP TheCurrent Water Temp Temp Setting Locked Display Timing-on Time Display Timing- off ON OFF Timing ON/OFF Setting Mode Down 2.1Key function ON OFF: To turn on and turn off the unit. MODE To change modes To check the setting parameters of system.Usually state press and... - Page 7 AIR SOURCE HEAT PUMP WATER HEATER 2 2How to set operation paramrer Status Inquiry When shutdown remote control displays the current temperature When ture on the unit Remote control displays the current temperature and set “ ” “ ▼ ”, temperature On the the main interface press...
- Page 8 AIR SOURCE HEAT PUMP WATER HEATER Lock and unlock the keys “ ” “▼ ” On the main interface press and hold for 3 second after “ ” “ ▼ ” ring press it and will lock During locking press and hold 3 seconds after ring it will lift lock “...
-
Page 9: Pipe Connection
AIR SOURCE HEAT PUMP WATER HEATER 3 Pipe connection Water piper system diagram for Water-cycle heater Water outlet Water inlet Drain Water outlet water Water switch valve Re-water inlet valve Water inlet Cycle water return valve Drain... - Page 10 AIR SOURCE HEAT PUMP WATER HEATER Fitting notice Drain pipe, overflow pipe of water tank should fit near by drainage channel to facilitate drain, drain pipe should install drain valve. Service valve should be installed before installing electropneumatic valve on the system pipe to facilitate troubleshooting later.
-
Page 11: Fitting Instruction
AIR SOURCE HEAT PUMP WATER HEATER 4. Fitting instruction 4.1 Unit installing Hot water outlet Pressure water tank Water pipe insulation unit Check Valves Running water Sewage discharge Water inlet 4.1.1 Fitting place choice 4.1.1.1 Mainframe Should fitted in bigger space and well-ventilated place. Fitting place ensure inlet opening and air outlet well-ventilated.(please see belowed diagram). - Page 12 AIR SOURCE HEAT PUMP WATER HEATER T H E T O P IS F A R F R O M A B O V E A IR IN L E T A IR IN L E T A IR IN L E T A B O V E A B O V E A B O V E...
-
Page 13: Debugging And Preoperation
AIR SOURCE HEAT PUMP WATER HEATER 5. Debugging and preoperation 5.1 Preparation before debugging. a) Heat pump water heater unit inspection Check overview and inside pipe system of unit, whether it is damaged during transportation. Check whether there is air in pipe of unit, if there is , should use manual vent valve on the water pipe inside the unit and vent valve of water pump to drain out of the air. - Page 14 AIR SOURCE HEAT PUMP WATER HEATER O FF water temp. Set water temp. (Set water temp. -5)
-
Page 15: Maintenance
AIR SOURCE HEAT PUMP WATER HEATER Maintenance Heat pump water heater is a high automation equipment, regular check unit situation during uses, long term and effective maintenance for unit could improve running reliability and using life obviously. The water filter installed outside of unit should clean regularly, to guarantee water clean in side of system, to avoid dirty water filter damage unit. -
Page 16: Operation Data Setting Table
AIR SOURCE HEAT PUMP WATER HEATER 6.Operation data setting table Digit Range Default Adjust(yes/no) Meaning Tank set temperature hysteresis 0-30 Water tank temperature setting 8-55 Defrost Cycle 30-90Min 40Min The time point to enter defrosting in 0-30 heating Exit defrost temperature 2-30 Exit condition of defrost time 1-12Min... -
Page 17: Trouble Shooting Guide
AIR SOURCE HEAT PUMP WATER HEATER 7.Trouble shooting guide Malfunction Reason Resolution 1. Disconnect the power switch, check the power supply, power supply for the three- 1.Power Failure phase, check the correct phase sequence Unit not 2.Unit power cable loose 2.To connect the loose power cord running 3.Unit control power fuse is fusing... -
Page 18: Wiring Diagram
AIR SOURCE HEAT PUMP WATER HEATER Wiring Diagram (YASBP-25HL) AC-L AC-N Flow switch should installation at this... - Page 19 AIR SOURCE HEAT PUMP WATER HEATER (YASBP-38HL YASBP-56HL) AC-L AC-N...
- Page 20 Thanks for Your Choice...
Need help?
Do you have a question about the YASBP-38HL and is the answer not in the manual?
Questions and answers