Sony HCD-D90AV Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. Stereo System
  5. HCD-D90AV
  6. Service manual

Sony HCD-D90AV Service Manual

Compact disc deck receiver
Hide thumbs
Table of Contents

Advertisement

Quick Links

SERVICE MANUAL
HCD-D90AV/GR10AV/RX100AV is the
tuner, deck, CD and amplifier section in
MHC-D90AV/GR10AV/RX100AV.
MICROFILM
HCD-D90AV/GR10AV/
Photo : HCD-RX100AV : US model
Model Name Using Similar Mechanism
CD
CD Mechanism Type
SECTION
Base Unit Type
Optical Pick-up Type
TAPE
Model Name Using Similar Mechanism
DECK
Tape Transport Mechanism Type
SECTION
SPECIFICATIONS
COMPACT DISC DECK RECEIVER
— 1 —
RX100AV
US Model
HCD-D90AV/RX100AV
Canadian Model
AEP Model
UK Model
HCD-RX100AV
E Model
Australian Model
Tourist Model
HCD-GR10AV
HCD-H991AV
CDM38L-5BD29AL
BU-5BD29AL
KSS-213D/Q-NP
HCD-H991AV
TCM-220WR2
— Continued on next page —

Advertisement

Table of Contents
loading

Related Manuals for Sony HCD-D90AV

Summary of Contents for Sony HCD-D90AV

  • Page 1 Canadian Model AEP Model UK Model HCD-RX100AV E Model Australian Model Tourist Model HCD-GR10AV HCD-D90AV/GR10AV/RX100AV is the tuner, deck, CD and amplifier section in Photo : HCD-RX100AV : US model MHC-D90AV/GR10AV/RX100AV. Model Name Using Similar Mechanism HCD-H991AV CD Mechanism Type CDM38L-5BD29AL...
  • Page 2 REPLACE THESE COMPONENTS WITH SONY PARTS FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
  • Page 3 SAFETY CHECK-OUT CAUTION Use of controls or adjustments or performance of procedures After correcting the original service problem, perform the follow- other than those specified herein may result in hazardous ra- ing safety checks before releasing the set to the customer: diation exposure.

  • Page 4: Table Of Contents

    TABLE OF CONTENTS NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT 1. SERVICING NOTE ............5 The laser diode in the optical pick-up block may suffer electrostatic 2. GENERAL ................6 break-down because of the potential difference generated by the charged electrostatic load, etc.

  • Page 5: Servicing Note

    SECTION 1 SERVICING NOTE HOW TO OPEN THE DISC TRAY WHEN POWER SWITCH TURNS OFF 1 Remove the Case. 3 Pull-out the disc tray. 2 Turn the cam to the direction of arrow. — 5 —...

  • Page 6: General

    SECTION 2 GENERAL Front Panel !ª @º @¡ @™@£ @¢ @∞ @§ @¶ @• @ª #º #¡ #™ #£ !º !¡ !™ #¢ !£ #∞ !¢ !∞ !§ !¶ !• #• #ª $º $¡ $™ $£ $∞ $§ $¶ #¶ #§...
  • Page 7 LOCATION OF PARTS AND CONTROLS 1 POWER button 2 DISC SKIP EX-CHANGE button 3 CD 0, ) button 4 DISC1-DISC3 buttons 5 CD p button 6 § OPEN/CLOSE button 7 CD ·∏ button 8 TIMER SELECT button 9 CLOCK/TIMER SET button 0 SLEEP button !¡...

  • Page 8: Disassembly

    SECTION 3 DISASSEMBLY Note: Follow the disassembly procedure in the numerical order given. 3-1. LOADING PANEL 3 Loading panel Claws 1 Turn the cam to the direction of arrow. 2 Pull-out the disc tray. 3-2. FRONT PANEL 1 Remove the connectors. (Main board : CN401, CN402, CN701) CN402 CN401...

  • Page 9: Tc Mechanism Deck And Deco Board (Except Us, Cnd)

    3-3. TC MECHANISM DECK AND DECO BOARD (Except US, CND) 1 Push the buttons (EJECT) 4 and 5 . 9 Flat type wire (5 core) 8 DECO board 3 TC mechanism deck 2 Three screws (+BVTP2.6x8) Except US, CND 5 Button (EJECT) Claws 6 Cassette lid (A) assembly...

  • Page 10: Disc Tray

    3-5. DISC TRAY (Perform after removing the front panel.) 3 Flat type wire (8 core) 4 Two claws 2 Pull-out the disc tray. 5 Remove the disc tray. 1 Turn the cam to the direction of arrow. Note: When installing the Disc tray, pull around the flat type wire to pass through the claw A and claw B , as shown in the figure.

  • Page 11: Service Mode

    SECTION 4 SERVICE MODE MC Cold Reset • The cold reset clears all data including preset data stored in the RAM to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. Press three buttons SPECTRUM ANALYZER , ENTER/NEXT , and DISC 1 simultaneously. 2.
  • Page 12 Aging Mode This mode can be used for operation check of CD section and tape deck section. • If an error occurred: The aging operation stops. • If no error occurs: The aging operation continues repeatedly. 1. Aging Mode in CD Section 1-1.

  • Page 13: Mechanical Adjustments

    SECTION 5 SECTION 6 MECHANICAL ADJUSTMENTS ELECTRICAL ADJUSTMENTS Precaution DECK SECTION 0 dB=0.775V 1. Clean the following parts with a denatured alcohol-moistened swab: 1. Demagnetize the record/playback head with a head damagnetizer. record/playback heads pinch rollers 2. Do not use a magnetized screwdriver for the adjustments. erase head rubber belts 3.
  • Page 14 2. Turn the adjustment screw and check output peaks. If the peaks Tape Speed Adjustment (Deck A) do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1 dB of peak. Note: Set the test mode using the following method and begin tape speed adjustment.
  • Page 15 Record Bias Adjustment (Deck B) Record Level Adjustment (Deck B) Procedure: Procedure: INTRODUCTION INTRODUCTION When set to the test mode performed in Tape Speed Adjust- When set to the test mode performed in Tape Speed Adjust- ment, when the tape is rewound after recording, the “REC memory ment, when the tape is rewound after recording, the “REC memory mode”...
  • Page 16 TUNER SECTION 0dB=1µV Note 1: As a front-end (FE1) is difficult to repair if faulty, replace it with new one. Note 2: No adjustment is needed due to a tuner pack for except AEP, UK, German, East European, CIS models. AM Tuned Level Adjustment Note: FM Tuned Level adjustment should be performed after this AM Tuned Level Adjustment.
  • Page 17 FM Polar Adjustment (East European, CIS model only) Procedure : 1. Set the modulation of FM RF SSG to AUDIO 1 kHz, 10 kHz Connection 1 : deviation according to “Connection 1”. 2. Tune the set to 69 MHz. FM RF SSG coaxial 3.
  • Page 18 CD SECTION E-F Balance (1 Track Jump) check oscilloscope Note: BD board 1. CD Block is basically constructed to operate without adjustment. Therefore, check each item in order given. TP (TEO) 2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. TP (VC) 3.

  • Page 19: Diagrams

    DIAGRAMS 7-1. CIRCUIT BOARDS LOCATION ENCAPSULATED COMPONENT MOTOR (TURN) board (Except AEP, UK, G, EE, CIS) CD SW board CONNECTOR board TCB board (AEP, UK, G, EE, CIS) PANEL board BD board (including p B) SENSOR board HP/MIC board MOTOR (SLIDE) board TC SW board MAIN board Note: pA is including in AUDIO board.
  • Page 20 HCD-D90AV/GR10AV/RX100AV 7-2. BLOCK DIAGRAMS — TUNER SECTION — (AEP, UK, German model) ST +10V FM FRONT END ANTENNA 10.7MHz 10.7MHz IF AMP 10.7MHz IF AMP FM 75 MPX IN OUT L 18 AMP IN L ANT IN IF OUT 1 FM IN...

  • Page 21: Tuner Section (Aep, Uk, German Model)

    HCD-D90AV/GR10AV/RX100AV — TUNER SECTION — (East European, CIS model) ST +10V FM FRONT END ANTENNA 10.7MHz IF AMP 10.7MHz FM 75 ANT IN IF OUT 1 FM IN AM/FM 22 MPX IN Q1-4 COAXIAL OUT L POLAR/PILOT SWITCH IC1702 FM/AM MPX...
  • Page 22 HCD-D90AV/GR10AV/RX100AV — CD SECTION — IC841 CD DIGITAL D.OUT X101 16.9344MHz OPTICAL OPTICAL PICK-UP BLOCK FOCUS/TRACKING SERVO. RF AMP 89 • 90 IC101 (1/2) DETECTOR RF O LOUT1 L-CH DIGITAL SIGNAL PROCESSOR LOCK 29 LOCK LOUT2 R-CH IC103 C.OUT CNIN...

  • Page 23: Tuner Section (East European, Cis Model)

    HCD-D90AV/GR10AV/RX100AV — DECK SECTION — PB A/B S1008 S1004 B CrO A CrO CN403 R CH RV311 PLAYBACK IC611 PB-A/B A 120/70 LEVEL B 120/70 DECK A A IN PB OUT PB L B IN HP101 PB HEAD LM ON/...
  • Page 24 HCD-D90AV/GR10AV/RX100AV — MAIN SECTION — RV750 VOLUME DOLBY PRO LOGIC IC604 DELAY IC601 CENTER LEVEL REAR J751 IC602 IC603 MUTE REAR MIX MIC C-OUT REAR REAR Q602 S-OUT S-OUT S-IN L-IN MIC AMP L-OUT FRONT IC750 FRONT L-MIX CENTER DATA...

  • Page 25: Ea :Saudi Arabia Model

    HCD-D90AV/GR10AV/RX100AV TM402 — POWER SECTION — SURROUND POWER AMP SPEAKER IC601 REAR RY401 REAR –1 REAR REAR CENTER –2 CENTER CENTER CENTER RELAY DRIVE Q404 D90AV/GR10AV/RX100AV: US,CND FAN MOTOR M901 POWER AMP DRIVER IC201 Q961, 962 UNREG MOTOR –12V OVER LOAD...

  • Page 39: Tuner (Aep, Uk, German Model) Section

    7-19. IC BLOCK DIAGRAMS • Tuner section IC21 LC72130 PHASE DETECTOR CHARGE PUMP UNLOCK POWER DETECTOR RESET REFERENCE SWALLOW COUNTER DIVIDER 1/16, 1/17 4BITS 12BITS PROGRAMMABLE DRIVER UNIVERSAL DATA SHIFT REGISTER LATCH COUNTER 3 4 5 6 IC41 LA1835 17 16 DECODER RF.
  • Page 40 IC1701 IR3R42 19 18 14 13 PHASE COMPARATOR PHASE PHASE COMPARATOR 2 TRIGGER WAVEFORM SEP. REGULATOR SAMPLE GATE & HOLD MUTE BUFFER IC1752 BU1922 TEST LOGIC AND OUTPUT SELECTOR SWITCH 57kHz OSCILLATOR ANTI- QUALITY BIT RECONSTRUCTION BANDPASS ALIASING GENERATOR FILTER (8th ORDER) DIVIDER FILTER...

  • Page 41: Tuner (East European, Cis Model) Section

    • CD section IC101 CXA1992AR – RF SUMMING PD2 IV PD1 IV – FE_BIAS SENS2 – SENS1 – LASER POWER CONTROL F IV AMP FE AMP C. OUT – E IV AMP – DFCT XRST – LEVEL S DATA FO. BIAS WINDOW MIRR COMP.
  • Page 42 IC102 BA5941FP – – + – – + – – LEVEL SHIFT – LEVEL SHIFT LEVEL SHIFT – LEVEL SHIFT – – + – – + – MUTE IC103 CXD2519Q 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 LRCK AVSS WDCK...

  • Page 43: Tuner (East European, Cis Model) Section

    • Main section IC102 MC14052BCP IC103, 1702 MC14053BCP B.COM OPEN A.COM C.COM OPEN OPEN IC402 LB1641 T.S.D O.C.P MOTOR MOTOR DRIVE DRIVE FWD/REV/STOP CONTROL LOGIC IC602 LV1016 INV-PHASE ADM-CONT SRAM L+DELAY R+DELAY VOL/MUTE OUT-FILTER – DC-OUT IN-FILTER (7k/5k) (40kHz) L–R S-TRIM (–6dB) B-NR...

  • Page 44: Printed Wiring Board - Main Section

    IC601 LA2786 BPF1 NOISE NOISE FILTER BPF2 NOISE GENERATOR DATA BALANCE ENABLE VREF CONTROL V REF OSC1 DIVIDER CONTROL S-CH DC OUT C-CH DC OUT L-CH DC OUT R-CH DC OUT VREF L-IN L-OUT R-IN R-OUT S-OUT C-OUT CMODE-CAP. C-TRIM DC CUT R-BPF1 L-BPF1 R-BPF2...
  • Page 45 • Power section IC301 uPC1237HA OVER LOAD DET MUTE OFFSET DET LATCH/ AUTORESET AC OFF • Deck section IC602 uPC1330HA INVERTER COMPARATER SW R1 GND SW P1 CONT GND SW P2 GND SW R2 • CD motor section IC701 M54641L REFERENCE POWER OUT2...
  • Page 46 7-20. IC PIN FUNCTIONS • IC101 FOCUS/TRACKING/SLED SERVO RF AMP (CXA1992AR) Pin Name Function Pin No. Focus error amplifier output Connected internally to the window comparator input for bias adjustment Focus error input Capacitor connection pin for defect time constant FDFCT Ground this pin through a capacitor for cutting the focus servo high-frequency gain External time constant setting pin for boosting the focus servo low-frequency...

  • Page 47: E3 :With Sw Tuner E Model 7-10. Schematic Diagram - Main Section

    Pin No. Pin Name Function RF summing amplifier inverted input The RF amplifier gain is determined by the resistance connected between this pin and RF M RFO pin External time constant setting pin during RF level control RFTC APC amplifier output APC amplifier input RF I-V amplifier inverted input Connect these pins to the photo diode A+C and B+D pins...
  • Page 48 • IC103 DIGITAL SIGNAL PROCESSOR (CXD2519Q) Pin Name Function Pin No. – +5V power supply – Ground Lch “L” detection flog (Not used) LMUT Rch “L” detection flog (Not used) RMUT Test output (Not used) ACDT Master clock divider output (Not used) CKOUT Clock input for SQSO read out SQCK...
  • Page 49 Pin Name Function Pin No. AVSS – Analog ground Control voltage input for VCO CLTV AVDD Analog power supply – EFM signal input Asymmetry circuit constant current input BIAS ASYI Asymmetry comparate voltage input ASYO EFM full swing output (“L” =V , “H”...
  • Page 50 Pin Name Function Pin No. — Not used – AVSS Analog ground – AVDD Analog power supply – AOUT1 Lch analog output AIN1 Lch opamp input LOUT1 Lch line output AVSS Analog ground – XVDD Master clock power supply – XTAI X’tal oscillator circuit input XTAO...

  • Page 51: Schematic Diagram - Deck Section

    • IC601 DISPLAY CONTROL ( TMP87CH75F-6543) Pin Name Function Pin No. SEG35 FL segment signal output VLOAD – Power supply (–25V) for FL segment signal output 3 to 10 LED1 to LED8 LED driver output – Ground X-OUT X’tall (8MHz) X-IN RESET Reset signal input from main controller...
  • Page 52 • IC701 MASTER CONTROL (uPD780018YGF-013-3BA) Pin Name Function Pin No. TA-MUTE Line mute signal output DBFB-H/L DBFB H/L select signal output 427-LT Latch signal output for IC201 (62427) KCON-LT Not used KCON-ON F-RELAY Front speaker relay control output (Not used) R-RELAY Rear speaker relay control output PL-RELAY...
  • Page 53 Pin Name Function Pin No. COM-CLK Common serial clock output CD-POWER CD power on signal output CD-DATA CD data output CD-CLK CD clock output MSM-CMD Not used MSM-BUSY Connected to ground MSM-LT MSM-NAR Not used MSM-CH INPUT-CHANGE Input sensitivity switching output IIC-DATA Data output for IC601 IIC-CLK...
  • Page 54 Pin No. Pin Name Function EQ-H/N Equalizer H/N select output BIAS Bias ON/OFF signal output REC-MUTE REC mute ON/OFF selection output NR-ON/OFF NR ON/OFF signal output R/P-PASS REC/PB/PASS selection output TC-MUTE TC mute ON/OFF selection output A-PLAY-SW Deck A play detect B-PLAY-SW Deck B play detect TC-RELAY...

  • Page 55: Tourist Model

    SECTION 8 EXPLODED VIEWS NOTE: The components identified by • Items marked “*” are not stocked since they are • Abbreviation mark ! or dotted line with mark seldom required for routine service. Some delay CND : Canadian model ! are critical for safety. should be anticipated when ordering these items.
  • Page 56 8-2. MAIN BOARD SECTION AEP, G, EE, CIS, EA, AUS model UK model E, IA, TH model HK, SP, JE, MY model not supplied EA, SP, JE HK model E3, IA model model not supplied T501 US, CND model M901 US, CND only not supplied...
  • Page 57 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark * 51 A-4392-655-A POWER BOARD, COMPLETE (GR10AV) * 55 4-988-023-31 PANEL, BACK (JE) * 51 A-4392-656-A POWER BOARD, COMPLETE (AEP,UK,G,EE,CIS) * 55 4-988-023-51 PANEL, BACK (AUS) * 51 A-4392-657-A POWER BOARD, COMPLETE (US,CND) * 55 4-988-023-71 PANEL, BACK (TH)

  • Page 58: Schematic Diagram - Panel Section

    8-3. PANEL BOARD SECTION EXCEPT US, CND model not supplied FL601 S602 Supplied with S602 TCM-220WR2 — 94 —...
  • Page 59 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-986-877-11 KNOB (VOL) (BLACK) X-4948-113-1 KNOB (JOG) ASSY (SILVER) 4-986-877-31 KNOB (VOL) (SILVER) 4-986-881-11 JOG (PLATE) 4-986-843-11 BUTTON (EJECT) (BLACK) 4-986-843-31 BUTTON (EJECT) (SILVER) * 113 4-986-880-11 HOLDER (JOG) 4-986-893-11 KNOB (MICROPHONE) (BLACK) X-4947-919-1 BUTTON (E/N) ASSY (BLACK) X-4948-120-1 BUTTON (E/N) ASSY (SILVER)

  • Page 60: Front Panel Section

    4-986-860-11 BUTTON (POWER) (BLACK) X-4947-922-1 LID (A) ASSY, CASSETTE (BLACK) 4-986-860-31 BUTTON (POWER) (SILVER) X-4948-118-1 LID (A) ASSY, CASSETTE (SILVER) 4-962-708-21 EMBLEM (4-A), SONY X-4947-923-1 LID (B) ASSY, CASSETTE (BLACK) X-4948-119-1 LID (B) ASSY, CASSETTE (SILVER) X-4947-926-1 BUTTON (T/B) ASSY (BLACK)(AEP,UK,G)

  • Page 61: Printed Wiring Board - Panel Section

    8-5. TC MECHANISM SECTION 1 (TCM-220WR2) (including p A) supplied HRPE101 (including r A) not supplied not supplied HRPE101 (including r B) not supplied not supplied not supplied not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-908-560-01 SPRING, AZIMUTH ADJUSTMENT...
  • Page 62 8-6. TC MECHANISM SECTION 2 (TCM-220WR2) pA: MOTOR board (Suppplied with AUDIO board) not supplied Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 3-908-600-01 LEVER (REV-B) 3-908-597-01 CAM (A) 3-908-608-11 SCREW, STEP * 316 1-650-669-11 LEAF SWITCH BOARD X-3372-930-1 ARM (A) ASSY, FR 3-908-598-01 CAM (B) X-3370-169-1 FLYWHEEL (AR) ASSY...
  • Page 63 8-7. CD MECHANISM SECTION 1 (CDM38L-5BD29AL) M701 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-917-583-21 BRACKET, YOKE 4-977-941-01 BEARING (WORM) 4-977-945-01 TRAY (TURN) * 359 1-658-576-11 SENSOR BOARD X-4946-665-1 SHAFT ASSY, WORM 4-934-376-01 SHAFT (ROLLER) 4-977-943-01 BELT (TURN) (1.2) 4-977-956-01 WHEEL, WORM 4-981-187-01 COLLAR (WORM)

  • Page 64: Cd Mechanism Section 2 (Cdm38L-5Bd29Al)

    8-8. CD MECHANISM SECTION 2 (CDM38L-5BD29AL) not supplied not supplied M801 BU-5BD29AL S811 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 4-917-583-71 BRACKET, YOKE 4-985-672-01 SCREW (+PTPWH M2.6X6), FLOATING 4-977-954-01 PULLEY (SL) * 412 1-658-578-11 MOTOR (SLIDE) BOARD 4-977-953-01 GEAR (SL-A) 4-958-593-01 SPRING (BU), COMPRESSION 4-977-955-01 GEAR (SL-B)

  • Page 65: Schematic Diagram - Power Section

    8-9. BASE UNIT SECTION (BU-5BD29AL) M101 M102 Les composants identifiés par The components identified by mark ! or dotted line with mark une marque ! sont critiques pour ! are critical for safety. la sécurité. Replace only with part number Ne les remplacer que par une specified.

  • Page 66: Electrical Parts List

    SECTION 9 AUDIO ELECTRICAL PARTS LIST Note: • Due to standardization, replacements in the parts list • CAPACITORS The components identified by uF : µ F may be different from the parts specified in the mark ! or dotted line with mark •...
  • Page 67 AUDIO Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R414 1-247-882-11 CARBON 130K 1/4W C123 1-163-038-91 CERAMIC CHIP 0.1uF R415 1-247-850-11 CARBON 6.2K 1/4W C124 1-126-607-11 ELECT CHIP 47uF R431 1-249-430-11 CARBON 1/4W C125 1-164-232-11 CERAMIC CHIP 0.01uF C126 1-163-038-91 CERAMIC CHIP...
  • Page 68 CD SW Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R178 1-216-025-91 METAL GLAZE 1/10W < TRANSISTOR > R179 1-216-025-91 METAL GLAZE 1/10W Q101 8-729-010-08 TRANSISTOR MSB710-R R180 1-216-025-91 METAL GLAZE 1/10W < RESISTOR > R181 1-216-025-91 METAL GLAZE 1/10W R188...

  • Page 69: Printed Wiring Board - Power Section

    CD SW CONNECTOR DECO HP/MIC Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R721 1-247-804-11 CARBON 1/4W < TRANSISTOR > R722 1-247-804-11 CARBON 1/4W R723 1-247-804-11 CARBON 1/4W Q610 8-729-119-76 TRANSISTOR 2SA1175-HFE Q611 8-729-119-76 TRANSISTOR 2SA1175-HFE R724 1-247-807-31 CARBON 1/4W...
  • Page 70 LEAF SWITCH MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-650-669-11 LEAF SWITCH BOARD < CAPACITOR > ***************** C110 1-162-306-11 CERAMIC 0.01uF < CONNECTOR > C121 1-162-286-21 CERAMIC 220PF C122 1-162-286-21 CERAMIC 220PF * CN1001 1-568-854-11 SOCKET, CONNECTOR 11P C125 1-124-499-11 ELECT C127...
  • Page 71 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C275 1-162-294-31 CERAMIC 0.001uF C635 1-130-467-00 MYLAR 470PF C301 1-137-368-11 FILM 0.0047uF 5% C636 1-130-467-00 MYLAR 470PF C302 1-162-290-31 CERAMIC 470PF C637 1-162-306-11 CERAMIC 0.01uF C638 1-162-306-11 CERAMIC 0.01uF C303 1-136-165-00 FILM...

  • Page 72: Schematic Diagram - Cd Motor Section

    MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C901 1-126-937-11 ELECT 4700uF < GROUND TERMINAL > C902 1-126-768-11 ELECT 2200uF C903 1-164-159-21 CERAMIC 0.1uF * EPT901 1-537-738-21 TERMINAL, EARTH C904 1-164-159-21 CERAMIC 0.1uF < FERRITE BEAD > C908 1-126-933-11 ELECT 100uF...

  • Page 73: Indonesia 7-18. Printed Wiring Board - Cd Motor Section

    MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark Q407 8-729-900-80 TRANSISTOR DTC114ES R211 1-249-421-11 CARBON 2.2K 1/4W F Q408 8-729-119-76 TRANSISTOR 2SA1175-HFE R212 1-249-441-11 CARBON 100K 1/4W Q409 8-729-900-80 TRANSISTOR DTC114ES R213 1-249-429-11 CARBON 1/4W Q601 8-729-141-26 TRANSISTOR 2SC3622A-LK R214...
  • Page 74 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R414 1-249-429-11 CARBON 1/4W R730 1-249-431-11 CARBON 1/4W R415 1-249-432-11 CARBON 1/4W (GR10AV:TH) R416 1-249-429-11 CARBON 1/4W R730 1-249-425-11 CARBON 4.7K 1/4W F (GR10AV:AUS) R417 1-249-441-11 CARBON 100K 1/4W R731...

  • Page 75: Indonesia 7-19. Ic Block Diagrams

    MAIN MOTOR (SLIDE) MOTOR (TURN) PANEL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R880 1-249-437-11 CARBON 1/4W < RESISTOR > R881 1-249-437-11 CARBON 1/4W R901 1-247-895-91 CARBON 470K 1/4W R801 1-249-401-11 CARBON 1/4W F R902 1-249-417-11 CARBON 1/4W F <...
  • Page 76 PANEL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C607 1-126-160-11 ELECT D610 8-719-057-30 DIODE HLMF-K205-2UL (ENTER/NEXT) D611 8-719-057-97 DIODE SEL5923A-TP15 (PROLOGIC) C608 1-162-294-31 CERAMIC 0.001uF C609 1-162-282-31 CERAMIC 100PF D612 8-719-057-97 DIODE SEL5923A-TP15 (PROLOGIC) C610 1-162-282-31 CERAMIC 100PF D614...
  • Page 77 PANEL Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R621 1-249-419-11 CARBON 1.5K 1/4W F R689 1-249-419-11 CARBON 1.5K 1/4W F R622 1-249-401-11 CARBON 1/4W F R690 1-247-897-11 CARBON 560K 1/4W R623 1-249-403-11 CARBON 1/4W F R624 1-247-807-31 CARBON 1/4W...
  • Page 78 POWER Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4392-657-A POWER BOARD, COMPLETE (US,CND) C253 1-162-286-21 CERAMIC 220PF C254 1-126-967-11 ELECT 47uF ********************** C255 1-126-967-11 ELECT 47uF C256 1-128-560-11 ELECT 22uF 100V A-4392-656-A POWER BOARD, COMPLETE (AEP,UK,G,EE,CIS) (D90AV/GR10AV/RX100AV:US,CND) ********************** A-4392-655-A POWER BOARD, COMPLETE (GR10AV)
  • Page 79 POWER Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark D301 8-719-987-63 DIODE 1N4148M L404 1-420-872-00 COIL, AIR-CORE (RX100AV:AEP,UK,G,EE,CIS) D302 8-719-987-63 DIODE 1N4148M D303 8-719-987-63 DIODE 1N4148M < TRANSISTOR > D321 8-719-815-85 DIODE 1S1585 (D90AV/GR10AV/RX100AV:US,CND) Q111 8-729-900-80 TRANSISTOR DTC114ES (RX100AV:AEP,UK,G,EE,CIS) D321 8-719-987-63 DIODE 1N4148M (RX100AV:AEP,UK,G,EE,CIS)
  • Page 80 POWER SENSOR Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R331 1-247-890-11 CARBON 300K 1/4W R216 1-260-099-11 CARBON 1/2W (RX100AV:AEP,UK,G,EE,CIS) (GR10AV) R218 1-260-076-11 CARBON 1/2W R331 1-247-883-00 CARBON 150K 1/4W (RX100AV:AEP,UK,G,EE,CIS) R227 1-249-425-11 CARBON 4.7K 1/4W F R332 1-249-429-11 CARBON 1/4W...
  • Page 81 SENSOR SURROUND Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < RESISTOR > < TRANSISTOR > R701 1-249-416-11 CARBON 1/4W F Q601 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA R702 1-249-407-11 CARBON 1/4W F Q651 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA Q670 8-729-119-78 TRANSISTOR 2SC2785-HFE Q671 8-729-900-36 TRANSISTOR DTC124ES **************************************************************...

  • Page 82: Indonesia 7-20. Ic Pin Functions

    Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C1705 1-163-035-00 CERAMIC CHIP 0.047uF 1-101-004-00 CERAMIC 0.01uF 1-163-031-11 CERAMIC CHIP 0.01uF C1706 1-126-960-11 ELECT 1.0uF 1-163-031-11 CERAMIC CHIP 0.01uF C1707 1-163-129-00 CERAMIC CHIP 330PF 1-163-031-11 CERAMIC CHIP 0.01uF 1-163-038-91 CERAMIC CHIP 0.1uF...
  • Page 83 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1-216-295-91 METAL CHIP 1/10W 1-249-417-11 CARBON 1.0K 1/4W 1-216-295-91 METAL CHIP 1/10W 1-249-417-11 CARBON 1.0K 1/4W 1-216-295-91 METAL CHIP 1/10W 1-249-417-11 CARBON 1.0K 1/4W JR46 1-216-296-91 METAL CHIP 1/8W 1-247-807-31 CARBON 1/4W...
  • Page 84 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark RV42 1-238-600-11 RES, ADJ, CARBON 10K 1-104-396-11 ELECT 10uF RV1701 1-238-600-11 RES, ADJ, CARBON 10K 1-104-396-11 ELECT 10uF RV1702 1-238-599-11 RES, ADJ, CARBON 4.7K 1-104-396-11 ELECT 10uF 1-163-017-00 CERAMIC CHIP 0.0047uF 5% <...
  • Page 85 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < JUMPER RESISTOR > 1-249-417-11 CARBON 1/4W F 1-249-437-11 CARBON 1/4W 1-216-295-11 METAL CHIP 1/10W 1-249-429-11 CARBON 1/4W 1-216-295-11 METAL CHIP 1/10W 1-249-417-11 CARBON 1/4W F 1-216-295-11 METAL CHIP 1/10W 1-216-295-11 METAL CHIP 1/10W...
  • Page 86 TC SW TRANS Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4392-652-A TC SW BOARD, COMPLETE 1-663-994-11 TRANS BOARD ********************** *********** < CONNECTOR > < CONNECTOR > CN607 1-506-486-11 PIN, CONNECTOR 7P * CN501 1-564-527-11 PLUG, CONNECTOR 12P CN502 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P <...
  • Page 87 Ref. No. Part No. Description Remark ! 59 1-696-845-11 CORD, POWER (AUS) ! 59 1-751-326-21 CORD, POWER (TH) ! 59 1-751-529-11 CORD, POWER (UK) 1-769-909-11 WIRE (FLAT TYPE) (9 CORE) 1-777-869-11 WIRE (FLAT TYPE) (10 CORE) (Except US,CND) 1-777-871-11 WIRE (FLAT TYPE) (8 CORE) (US,CND) 1-777-936-11 WIRE (FLAT TYPE) (5 CORE) (Except US,CND) 1-452-538-11 MAGNET 1-776-042-11 WIRE (FLAT TYPE) (8 CORE)
  • Page 88 HCD-D90AV/GR10AV/RX100AV Sony Corporation 97C0994-1 Printed in Japan © 1997. 3 9-960-909-11 Home A&V Products Company Published by Service and Safety Engineering Dept. (Shibaura) — 124 —...

This manual is also suitable for:

Hcd-rx100avHcd-gr10av

Table of Contents