1. Manuals
  2. Brands
  3. Sony Manuals
  4. Projection TV
  5. KF-50SX300
  6. Service manual

Sony KF-50SX300 Service Manual

Lcd projection tv
Hide thumbs
Table of Contents

Advertisement

Quick Links

SERVICE MANUAL
MODEL
KF-50SX300
KF-50SX300K
KF-50SX300U
COMMANDER
DEST
CHASSIS NO.
RM-906
AEP
SCC-R01A-A
RM-906
OIRT
SCC-R03A-A
RM-906
UK
SCC-R02B-A
MODEL
KF-60SX300
KF-60SX300K
KF-60SX300U
KF-50/60SX300

LCD PROJECTION TV

- 1 -
KF-50/60SX300
RM-906
LE-4A
CHASSIS
COMMANDER
DEST
CHASSIS NO.
RM-906
AEP
SCC-R01B-A
RM-906
OIRT
SCC-R03B-A
RM-906
UK
SCC-R02A-A
RM-906

Advertisement

Table of Contents
loading

Related Manuals for Sony KF-50SX300

Summary of Contents for Sony KF-50SX300

  • Page 1: Lcd Projection Tv

    KF-50/60SX300 RM-906 SERVICE MANUAL LE-4A CHASSIS MODEL MODEL COMMANDER DEST CHASSIS NO. COMMANDER DEST CHASSIS NO. KF-50SX300 KF-60SX300 RM-906 SCC-R01A-A RM-906 SCC-R01B-A KF-50SX300K KF-60SX300K RM-906 OIRT SCC-R03A-A RM-906 OIRT SCC-R03B-A KF-50SX300U KF-60SX300U RM-906 SCC-R02B-A RM-906 SCC-R02A-A KF-50/60SX300 RM-906 LCD PROJECTION TV...

  • Page 2: Table Of Contents

    THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE 4-3. Test Test Mode ........... PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN WARNING !! SUPPLEMENTS PUBLISHED BY SONY.

  • Page 3: Caution

    Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -...

  • Page 4: Specifications

    KF-50/60SX300 RM-906 l l a l l a . s l < / < / . s l . s l . s l . s l n i l e i l . s l a j i . o i n i l i n i WARNING (UK Models only)

  • Page 5: Connectors

    KF-50/60SX300 RM-906 21 pin connector Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A Standard level : 0.5V rms (left)
  • Page 6 KF-50/60SX300 RM-906 SECTION 1 SELF DIAGNOSIS FUNCTION LE-4A Self Diagnostic Software The identification of errors within the LE-4A chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty.

  • Page 7: General

    KF-50/60SX300 RM-906 SECTION 2 GENERAL – 7 –...
  • Page 8 KF-50/60SX300 RM-906 – 8 –...
  • Page 9 KF-50/60SX300 RM-906 – 9 –...
  • Page 10 KF-50/60SX300 RM-906 – 10 –...
  • Page 11 KF-50/60SX300 RM-906 – 11 –...
  • Page 12 KF-50/60SX300 RM-906 – 12 –...
  • Page 13 KF-50/60SX300 RM-906 – 13 –...
  • Page 14 KF-50/60SX300 RM-906 – 14 –...
  • Page 15 KF-50/60SX300 RM-906 – 15 –...
  • Page 16 KF-50/60SX300 RM-906 – 16 –...
  • Page 17 KF-50/60SX300 RM-906 – 17 –...
  • Page 18 KF-50/60SX300 RM-906 – 18 –...
  • Page 19 KF-50/60SX300 RM-906 – 19 –...
  • Page 20 KF-50/60SX300 RM-906 – 20 –...

  • Page 21: Disassembly

    KF-50/60SX300 RM-906 SECTION 3 DISASSEMBLY 3-1. REAR COVER REMOVAL 3-2. CENTER PILLAR REMOVAL Rear cover Three screws (+BVTP 4x16) Three Center fasten tags pillar Two screws (+PSW 3x8) Two screws Eleven screws (+BVTP 4x16) (+BVTP 4x16) 3-3. SERVICE POSITION 3-4. CHASSIS, OPTICAL UNIT, DC FAN REMOVAL Four screws (+PWH 4x35) Connector...

  • Page 22: Power Block Removal

    KF-50/60SX300 RM-906 3-5. POWER BLOCK REMOVAL 3-6. H1 BOARD REMOVAL Power supply block Screen mirror block assembly Screw Two screws (+BVTP 3x12) (+PWH 4x16) H1 button Two screws (+BVTP 4x16) H1 bracket cap Screw Connector H1 board H1 bracket (+BVTP 3x12) Two connectors 3-7.

  • Page 23: A Board Removal

    KF-50/60SX300 RM-906 3-9. A BOARD REMOVAL 3-10. G BOARD REMOVAL Nine connectors G bracket Two fasten tags Fasten tag 1 Two screws (+BVTP 4 X 16) Connector Two claws A board 3 G board 1 Screw (+BVTP 4 X 16) 3-11.

  • Page 24: Front Cover Removal

    KF-50/60SX300 RM-906 3-13. FRONT COVER REMOVAL 3-14. CONTROL PANEL REMOVAL 1 Two screws (+BVTP 4 X 16) 1 Four strikes 2 Control panel block assembly 2 Front cover L 1 Two screws (+BVTP 4 X 16) 2 Front cover R 1 Four strikes 3-15.

  • Page 25: Mirror Cover Block Assembly Removal

    KF-50/60SX300 RM-906 3-16. MIRROR COVER BLOCK ASSEMBLY REMOVAL Mirror cover block assembly 1 Six screws 1 Three screws (+BVTP 4 X 16) (+BVTP 4 X 16) 1 Seven screws (+BVTP 4 X 16) 3-17. CONTRAST SCREEN, DIFFUSION PLATE REMOVAL 2 Screen holder 1 Four screws (+BVTP 4 X 16) 1 Six screws...

  • Page 26: Woofer Block Assembly Removal

    KF-50/60SX300 RM-906 3-18. WOOFER BLOCK ASSEMBLY REMOVAL 1 Two screws (+BVTP 4 X 16) 2 Woofer block assembly 3-19. SPEAKER REMOVAL 3-20. MIRROR REMOVAL 1 Two screws (+BVTP 4 X 16) 1 Two screws (+BVTP 4 X 16) 3 Speaker (13 X 7cm) 5 Two screws (+BVTP 4 X 16) 1 Two screws...

  • Page 27: Electrical Adjustments

    KF-50/60SX300 RM-906 SECTION 4 ELECTRICAL ADJUSTMENTS 4-1. Adjustments with Commander 4-1-2. Programming the Remote Commander for Operation in Service Mode Service adjustments to this model can be performed using the Press the VCR/TV/DVD button until the supplied remote Commander RM-906. TV LED lights.
  • Page 28 KF-50/60SX300 RM-906 c t i t l i – 28 –...

  • Page 29: Operation Method For Adjustments

    KF-50/60SX300 RM-906 4-1-5. Operation Method for Adjustments 4-3. TEST-TEST MODE Is available by programming the Remote Commander for operation in Service Mode [ As shown on Page 27 ] then pressing the VIDEO TV STANDBY VIDEO STANDBY button twice, OSD 'TT' appears. The functions describe below are available by selecting the two numbers.
  • Page 30 KF-50/60SX300 RM-906 MEMO – 30 –...

  • Page 31: Block Diagram (1)

    5-1. BLOCK DIAGRAMS (1) TUNER TU1100 IC2000 IC4401 SOUND IC2300 IR/RECEIVER CN4404 PROCESSOR AUDIO AMP J2200 SIRCS REAR-R STBY 5V SPEAKERS CN4302 REAR-L HEADPHONE R OUT TO A BOARD IC2400 FM/AM AUDIO AMP WOOFER CN0001 CN2004 KEY 2 HEADPHONE L OUT J4302 WOOFER SP TO A BOARD...

  • Page 32: Block Diagram (2)

    5-1. BLOCK DIAGRAMS (2) CN3400 R3404 MICRO, 3D COMB R3407 TO C BOARD R3411 CN3004 R3414 CN3401 TO C BOARD IC0001 CN3004 & CN3007 H SYNC OCP-OVP P2.15 V SYNC OCP-FLAG BLANK/ FB-M2 FB-M2 P2.14 RS OUT EPG-MODE P2.11 XTAL 1 IR DATA P2.9 X0001...

  • Page 33: Block Diagram (3)

    5-1. BLOCK DIAGRAMS (3) IC2501 CLOCK/CALENDAR SCANRATE, BACKEND, CN2551 DIGITLA GAMMA, LCD DRIVERS D-A 0 SID OUT P SIG-OB P SIG-OB Q2502 SID OUT Q2504 D-A 1 B-SIG 01 B-SIG 01 SIG-B6 SH OUT 1 D-A 2 B-SIG 02 B-SIG 02 SIG-B5 SH OUT 2 3D GAMMA...

  • Page 34: Block Diagram (4)

    5-1. BLOCK DIAGRAMS (4) 5-2. CIRCUIT BOARD LOCATION Reference Information RESISTOR : METAL FILM : SOLID FPRD : NON FLAMMABLE CARBON FUSE : NON FLAMMABLE FUSIBLE : NON FLAMMABLE METAL OXIDE : NON FLAMMABLE CEMENT : NON FLAMMABLE WIREWOUND CVM Board IC3800 S1 Board CN3801...

  • Page 35: A Board Schematic Diagram

    HP OUT 1/3 TUNER, AUDIO, REGULATORS COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ~ A Board Schematic Diagram [ Tuner, Audio, Regulators ] Page 1/3 ~ - 35 -...
  • Page 36 TO H1 BOARD CN4404 TO H2 BOARD CN4404 ~ A Board Schematic Diagram [ Tuner, Audio, Regulators ] Page 2/3 ~ - 36 -...
  • Page 37 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ~ A Board Schematic Diagram [ Tuner, Audio, Regulators ] Page 3/3 ~ - 37 -...

  • Page 38: A Printed Wiring Board

    ~ A Printed Wiring Board Conductor Side ~ ~ A Board Semiconductor Location Table ~ ~ A Board Semiconductor Voltage Table ~ ~ A Board IC Voltage Table ~ - 38 -...

  • Page 39: B Board Schematic Diagram

    B-#SSLE4A<...>-B..-KF-50/60SX300 COMB FILTER MEMORY 3D COMB FILTER CHROMA DECODER 1/3 MICRO, 3D COMB COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ~ B Board Schematic Diagram [ Micro, 3D Comb ] Page 1/3 ~ - 39 -...
  • Page 40 TO C BOARD CN3004 CN3004 & CN3007 B-#SSLE4A<...>-B..-KF-50/60SX300 2.7K 8.2K 100K ~ B Board Schematic Diagram [ Micro, 3D Comb ] Page 2/3 ~ CN5201 - 40 -...
  • Page 41 B-#SSLE4A<...>-B..-KF50/60SX300 RESET M24C32-WMN6T(A) DEF 5V RESET CMOS SDRAM MICRO CONTROLLER M27V160-100K1-LE4001 ~ B Board Schematic Diagram [ Micro, 3D Comb ] Page 3/3 ~ - 41 -...

  • Page 42: B Printed Wiring Board

    ~ B Printed Wiring Board Conductor Side A ~ ~ B Board Semiconductor Location Table (A Side) ~ ~ B Printed Wiring Board Conductor Side B ~ ~ B Board Semiconductor Location Table (B Side) ~ - 42 -...

  • Page 43: C Board Schematic Diagram

    1/4 SCANRATE, BACKEND, DIGITAL GAMMA, LCD DRIVERS 12-STAGE BINARY COUNTER VOLTAGE DETECTOR COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ~ C Board Schematic Diagram [ Scanrate, Backend, Digital Gamma, LCD Drivers ] Page 1/4 ~ - 43 -...
  • Page 44 RESET IC OCTAL BUS BUFFER 12C BUS EEPROM 12C DIGITAL TEMP SENSOR ~ C Board Schematic Diagram [ Scanrate, Backend, Digital Gamma, LCD Drivers ] Page 2/4 ~ - 44 -...
  • Page 45 +5V REGULATOR COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL ~ C Board Schematic Diagram [ Scanrate, Backend, Digital Gamma, LCD Drivers ] Page 3/4 ~ - 45 -...
  • Page 46 ANALOG MUX/DEMUX COLOUR DECODER & SCANRATE CONVERTER ~ C Board Schematic Diagram [ Scanrate, Backend, Digital Gamma, LCD Drivers ] Page 4/4 ~ - 46 -...

  • Page 47: C Printed Wiring Board

    ~ C Printed Wiring Board Conductor Side A ~ ~ C Board Location Table (A Side) ~ - 47 -...
  • Page 48 ~ C Board Location Table (B Side) ~ ~ C Printed Wiring Board Conductor Side B ~ - 48 -...

  • Page 49: J Board Schematic Diagram

    J..-KF-50/60SX300 R2808 470k SC1-OUT-R R3862 C3842 C3845 L3814 C2804 R2877 R2800 R2804 1/10W C2810 0.022 CN3808 D2830 R_PC CHIP R2801 R2851 UDZS-TE17-9.1B D2800 Q3856 D3822 UDZS-TE17-9.1B SC1-IN-R C3846 MSD601-RST1 UDZS-5.6B C2805 R2809 C2808 R3852 D2801 R3865 2.2k 1000p 470k G_PC R2802 C2801 UDZS-TE17-9.1B...

  • Page 50: J Printed Wiring Board

    ~ J Printed Wiring Board Conductor Side A ~ ~ J Board Location Table (A Side) ~ ~ J Board IC Voltage Table ~ ~ J Board Location Table (B Side) ~ ~ J Printed Wiring Board Conductor Side B ~ - 50 -...

  • Page 51: G Board Schematic Diagram

    ~ G Board Schematic Diagram [ Power Supply ] ~ - 51 -...

  • Page 52: G Printed Wiring Board

    ~ G Printed Wiring Board Conductor Side ~ ~ G Board IC Voltage Table ~ ~ G Board Semiconductor Voltage Table ~ ~ H1 Printed Wiring Board Conductor Side ~ ~ H2 Printed Wiring Board Conductor Side ~ ~ H3 Printed Wiring Board Conductor Side ~ ~ T Printed Wiring Board Conductor Side ~ Note : Portions of the circuit contained within...

  • Page 53: H1 Schematic Diagram

    ~ H1 Board Schematic Diagram [ User Key, Sircs ] ~ ~ H2 Board Schematic Diagram [ LED Indicators ] ~ H2.-KF-50/60SX300 COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL R4404 R4405 1/10W 1/10W C4404 R4411 Q4403 2SC1623-L5L6 1/10W Q4405 Q4402...

  • Page 54: Semiconductors

    5-4. SEMICONDUCTORS 1E3-TB CXD3804R-T6 PQ1CG2032FZ CATHODE D1N20R D1NS4 ERA11-08 UF4005PKG23 ANODE 1SS355TE-17 MA113-(TX) UDZ-TE-1713B UDZSTE-173.6B ANODE UDZSTE-179.1B CATHODE PST9143NL 2SA1023AK-T146-R 2SA1162-G D10SC4M 1 2 3 4 5 2SC1623-L5L6 D10SC6M 2SD2114K D10SC6MR DTA114EKA-T146 DTC114EK RD5.6M-B2 RD5.6M-B3 2SK2663 L7805CV/LSY STP5NK40Z(033Y) S-80743AL-47-S ST2310DHI S80727-SN-DQ-T1 BA033T LM75C1MX-5...
  • Page 55 MC74LVX8053 P-MQFP-128 MQFP144 PQ20VZ-U LM75 M27V160 L7800 SI8050S SI8033S - 55 -...

  • Page 56: Ic Block Diagrams

    5-5 IC BLOCK DIAGRAMS A BOARD IC2500 TDA7269 A BOARD IC6201 BA033T REFERENCE VOLTAGE A BOARD IC6208 PQ1CG2032FZ Vout ON/OFF PWM COMP ON/OFF ERROR AMP Oadj Vref - 56 -...
  • Page 57 A BOARD IC2000 MSP3411G SBUS Interface I2C Interface DEMODULATOR IDENT SCART Switching Facilities G BOARD IC1601 MCZ3001D Remote DVLD Internal Driver Sel=34v ref 5v Reg. 10v 15v/8v Level Shift Vsense Control Logic Latch Centre Timer - 57 -...

  • Page 58: Exploded Views

    X-4041-958-1 COVER ASSY, FRONT (KF-60SX300) 4-094-695-41 COVER, REAR (KF-60SX300) 4-094-706-01 BUTTON, POWER 1-825-580-11 LOUDSPEAKER (10CM) 4-036-405-01 SPRING, COMPRESSION X-4041-944-1 COVER (50) ASSY, MIRROR (KF-50SX300) 7-685-648-79 SCREW +BVTP 3X12 TYPE2 IT-3 X-4041-954-1 COVER (60) ASSY, MIRROR (KF-60SX300) 4-094-707-01 GUIDE (LED), LIGHT 4-077-752-02 HOLDER (L), MIRROR...

  • Page 59: Cabinet Block

    4-097-548-01 CUSHION, FOOT 4-098-512-01 DOOR, H3 *A-1405-811-A MOUNTED PC BOARD, T 4-094-757-01 SPRING, PLATE A-1606-075-A LAMP BLOCK ASSY *A-1405-806-A MOUNTED PC BOARD, H3 *3-650-537-00 WASHER X-4041-946-1 CABINET (50) ASSY (KF-50SX300) 4-094-747-11 DOOR, LAMP X-4041-956-1 CABINET (60) ASSY (KF-60SX300) - 59 -...

  • Page 60: Main Bracket Block

    KF-50/60SX300 RM-906 6-3. MAIN BRACKET BLOCK The components identified by shading £ and mark are critical for safety. Replace only with part number specified. REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK 4-096-934-11 BRACKET, MAIN *A-1302-408-A COMPLETE PC BOARD, G *A-1405-803-A MOUNTED PC BOARD, A 4-065-070-01 HOLDER, AC CORD 8-598-535-20 FRONT END BTF-EF411...

  • Page 61: Picture Tube Block

    KF-50/60SX300 RM-906 6-4. PICTURE TUBE BLOCK The components identified by shading £ and mark are critical for safety. Replace only with part number specified. REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK - 61 -...

  • Page 62: Electrical Parts List

    SECTION 7 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page B BOARD COMPLETE Parts List : ...................... A BOARD COMPLETE Parts List : ...................... J BOARD COMPLETE Parts List : ...................... T BOARD COMPLETE Parts List : ...................... G BOARD COMPLETE Parts List : ......................
  • Page 63 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK * H-8001-379-A B Board Complete C3106 1-127-715-91 CERAMIC CHIP 0.22UF C3107 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V < CAPACITOR > C3108 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C3109 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V C0005 1-162-921-11...
  • Page 64 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C3402 1-126-947-11 ELECT 47UF 20.00% 35V C3836 1-164-156-11 CERAMIC CHIP 0.1UF C3403 1-164-156-11 CERAMIC CHIP 0.1UF C3837 1-164-156-11 CERAMIC CHIP 0.1UF C3405 1-164-156-11 CERAMIC CHIP 0.1UF C3838 1-164-156-11 CERAMIC CHIP 0.1UF C3406 1-126-947-11 ELECT 47UF...
  • Page 65 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < CONNECTOR > L3403 1-414-928-21 INDUCTOR L3404 1-414-928-21 INDUCTOR CN0004 * 1-564-507-11 PLUG, CONNECTOR 4P L3800 1-414-928-21 INDUCTOR CN3100 1-794-244-11 CONNECTOR, DIN (PLUG) 96P L3801 1-414-928-21 INDUCTOR CN3400 * 1-564-524-11 PLUG, CONNECTOR 9P L3802 1-414-928-21 INDUCTOR...
  • Page 66 F4 A REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK JR0011 1-216-864-11 SHORT CHIP R0052 1-216-809-11 METAL CHIP 1/10W JR3400 1-216-864-11 SHORT CHIP R0053 1-216-829-11 METAL CHIP 4.7K 5% 1/10W JR3404 1-216-864-11 SHORT CHIP R0056 1-216-809-11 METAL CHIP 1/10W JR3406 1-216-864-11 SHORT CHIP R0057...
  • Page 67 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3212 1-216-864-11 SHORT CHIP R3820 1-216-864-11 SHORT CHIP R3240 1-216-864-11 SHORT CHIP R3821 1-216-864-11 SHORT CHIP R3241 1-216-864-11 SHORT CHIP R3822 1-216-818-11 METAL CHIP 1/10W R3242 1-216-864-11 SHORT CHIP R3823 1-216-864-11 SHORT CHIP R3270 1-216-864-11 SHORT CHIP...
  • Page 68 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3888 1-216-829-11 METAL CHIP 4.7K 5% 1/10W RB0031 1-233-576-11 RES, CHIP NETWORK 100 R3890 1-216-864-11 SHORT CHIP RB0032 1-233-576-11 RES, CHIP NETWORK 100 R3892 1-216-864-11 SHORT CHIP RB0033 1-233-576-11 RES, CHIP NETWORK 100 R3893 1-216-835-11 METAL CHIP...
  • Page 69 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C1304 1-216-864-11 SHORT CHIP C2414 1-164-156-11 CERAMIC CHIP 0.1UF C1307 1-125-891-11 CERAMIC CHIP 0.47UF 10.00% 10V C2500 1-126-952-11 ELECT 1000UF 20.00% 35V C1904 1-163-009-91 CERAMIC CHIP 0.001UF 10.00% 50V C2501 1-126-952-11 ELECT 1000UF 20.00% 35V C2000...
  • Page 70 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C6243 1-104-665-11 ELECT 100UF 20.00% 25V CN6204 1-695-915-11 TAB (CONTACT) C6244 1-126-947-11 ELECT 47UF 20.00% 35V CN6205 1-695-915-11 TAB (CONTACT) C6245 1-126-947-11 ELECT 47UF 20.00% 35V CN6206 * 1-816-977-51 PLUG, CONNECTOR 6P C6247 1-126-964-11 ELECT...
  • Page 71 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < SOCKET > < TRANSISTOR > J2200 1-784-632-11 JACK, PIN 2P Q0200 8-729-028-28 TRANSISTOR 2SK2036(TE85L) Q0201 8-729-028-28 TRANSISTOR 2SK2036(TE85L) < COIL > Q1300 8-729-010-29 TRANSISTOR MSD601-RST1 Q1301 8-729-010-05 TRANSISTOR MSB709-RT1 L0001 1-412-987-31 INDUCTOR 4.7UH Q1912...
  • Page 72 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R1300 1-216-821-11 METAL CHIP 1/10W R2504 1-216-841-11 METAL CHIP 1/10W R1303 1-216-805-11 METAL CHIP 1/10W R2505 1-216-821-11 METAL CHIP 1/10W R1304 1-216-821-11 METAL CHIP 1/10W R2506 1-216-836-11 METAL CHIP 1/10W R1956 1-216-833-11 METAL CHIP 1/10W R2507...
  • Page 73 H5 A REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6244 1-216-841-11 METAL CHIP 1/10W R8436 1-216-793-11 METAL CHIP 1/10W R6245 1-216-864-11 SHORT CHIP R8437 1-216-793-11 METAL CHIP 1/10W R6246 1-216-864-11 SHORT CHIP R8438 1-216-813-11 METAL CHIP 1/10W R6247 1-216-864-11 SHORT CHIP R8439 1-216-813-11...
  • Page 74 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C2859 1-126-964-11 ELECT 10UF 20.00% 50V < DIODE > C2860 1-126-947-11 ELECT 47UF 20.00% 35V C3808 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V D800 8-719-069-55 DIODE UDZSTE-175.6B C3809 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V D2800 1-803-974-21 VARISTOR CHIP...
  • Page 75 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D3827 8-719-069-55 DIODE UDZSTE-175.6B R2806 1-216-813-11 METAL CHIP 1/10W D3828 8-719-069-55 DIODE UDZSTE-175.6B R2808 1-216-853-11 METAL CHIP 470K 5% 1/10W D3829 8-719-069-55 DIODE UDZSTE-175.6B R2809 1-216-853-11 METAL CHIP 470K 5% 1/10W R2810 1-216-853-11 METAL CHIP 470K 5%...
  • Page 76 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3803 1-216-022-00 RES-CHIP 1/10W R3872 1-216-813-11 METAL CHIP 1/10W R3804 1-216-022-00 RES-CHIP 1/10W R3873 1-216-821-11 METAL CHIP 1/10W R3805 1-216-809-11 METAL CHIP 1/10W R3874 1-216-864-11 SHORT CHIP R3807 1-216-809-11 METAL CHIP 1/10W R3875 1-216-805-11 METAL CHIP...
  • Page 77 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C1615 1-126-948-11 ELECT 100UF 20.00% 35V C1668 1-109-843-11 CERAMIC 33PF 5.00% 2KV C1616 1-137-605-11 MYLAR 0.01UF 10.00% 250V C1669 1-109-843-11 CERAMIC 33PF 5.00% 2KV C1617 1-126-965-91 ELECT 22UF 20.00% 50V C1670 1-125-497-11 ELECT(BLOCK) 100UF 400V C1618...
  • Page 78 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D1630 8-719-988-61 DIODE 1SS355TE-17 < TRANSISTOR > D1631 8-719-988-61 DIODE 1SS355TE-17 D1632 1-216-295-91 SHORT CHIP Q1601 8-729-046-40 TRANSISTOR 2SK2663 D1635 8-719-060-90 DIODE S2L60F Q1602 8-729-023-22 TRANSISTOR 2SD2114K D1636 8-719-060-90 DIODE S2L60F Q1603 8-729-023-22 TRANSISTOR 2SD2114K Q1604...
  • Page 79 G H1 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R1645 1-216-017-91 RES-CHIP 1/10W < DIODE > R1646 1-216-057-00 RES-CHIP 2.2K 5% 1/10W R1647 1-216-041-00 RES-CHIP 1/10W D4401 8-719-069-55 DIODE UDZSTE-175.6B R1648 1-216-089-91 RES-CHIP 1/10W D4402 8-719-069-55 DIODE UDZSTE-175.6B R1649 1-216-049-11 RES-CHIP 1/10W...
  • Page 80 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < RESISTOR > R4303 1-216-813-11 METAL CHIP 1/10W R4305 1-216-821-11 METAL CHIP 1/10W R4402 1-216-809-11 METAL CHIP 1/10W R4307 1-216-849-11 METAL CHIP 220K 5% 1/10W R4403 1-216-809-11 METAL CHIP 1/10W R4308 1-216-849-11 METAL CHIP 220K 5% 1/10W...
  • Page 81 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C2529 1-164-156-11 CERAMIC CHIP 0.1UF C2663 1-164-156-11 CERAMIC CHIP 0.1UF C2530 1-164-156-11 CERAMIC CHIP 0.1UF C2664 1-164-156-11 CERAMIC CHIP 0.1UF C2531 1-164-156-11 CERAMIC CHIP 0.1UF C2665 1-164-156-11 CERAMIC CHIP 0.1UF C2551 1-164-156-11 CERAMIC CHIP 0.1UF C2666 1-128-992-21...
  • Page 82 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C3032 1-164-156-11 CERAMIC CHIP 0.1UF C3106 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C3033 1-164-156-11 CERAMIC CHIP 0.1UF C3107 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C3034 1-164-156-11 CERAMIC CHIP 0.1UF C3108 1-126-204-11 ELECT CHIP 47UF 20.00% 16V C3035...
  • Page 83 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C4012 1-127-715-91 CERAMIC CHIP 0.22UF CN3004 * 1-764-007-11 PIN, CONNECTOR (SMD) 12P C4013 1-164-156-11 CERAMIC CHIP 0.1UF CN3005 1-770-629-21 PIN, CONNECTOR 12P C4015 1-127-715-91 CERAMIC CHIP 0.22UF CN3006 1-770-629-21 PIN, CONNECTOR 12P C4018 1-127-715-91 CERAMIC CHIP 0.22UF...
  • Page 84 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK IC2701 8-752-106-13 IC CXA7001R-T6 L3105 1-412-029-11 INDUCTOR 10UH IC2801 8-759-388-31 IC PQ20VZ1U L3106 1-412-029-11 INDUCTOR 10UH IC3003 8-759-196-93 IC TC7SH00FU-TE85R L3107 1-412-029-11 INDUCTOR 10UH IC3004 6-803-215-01 IC DPS9450AA1T L3108 1-412-029-11 INDUCTOR 10UH IC3005 8-759-926-98 IC SN74HC4040ANS...
  • Page 85 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK JR4001 1-216-864-11 SHORT CHIP R2525 1-216-864-11 SHORT CHIP JR4004 1-216-864-11 SHORT CHIP R2526 1-216-864-11 SHORT CHIP JR4005 1-216-864-11 SHORT CHIP R2529 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10W JR4007 1-216-864-11 SHORT CHIP R2530 1-218-712-11 METAL CHIP 6.8K 0.5% 1/10W...
  • Page 86 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R2703 1-216-833-11 METAL CHIP 1/10W R3032 1-216-809-11 METAL CHIP 1/10W R2704 1-216-805-11 METAL CHIP 1/10W R3033 1-216-809-11 METAL CHIP 1/10W R2705 1-216-805-11 METAL CHIP 1/10W R3039 1-216-809-11 METAL CHIP 1/10W R2706 1-216-864-11 SHORT CHIP R3040 1-216-809-11...
  • Page 87 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3125 1-216-864-11 SHORT CHIP R4019 1-218-732-11 METAL CHIP 0.5% 1/10W R3126 1-216-833-11 METAL CHIP 1/10W R4020 1-218-732-11 METAL CHIP 0.5% 1/10W R3127 1-216-864-11 SHORT CHIP R4021 1-218-732-11 METAL CHIP 0.5% 1/10W R3128 1-216-833-11 METAL CHIP 1/10W...
  • Page 88 B1 C REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK RB2503 1-233-574-11 RES, CHIP NETWORK 10 MISCELLANEOUS RB2553 1-233-782-91 RES, NETWORK 10 (1608) RB2601 1-233-782-91 RES, NETWORK 10 (1608) 1-825-580-11 LOUDSPEAKER (10CM) RB2602 1-233-574-11 RES, CHIP NETWORK 10 1-544-857-11 SPEAKER (13X7CM) RB2603 1-233-574-11 RES, CHIP NETWORK 10...
  • Page 89 • User programmable Functional Check through Infrared • Fast and documented Test Mode setting of all Sony TV chassis Additional features such as Adjustments and Troubleshooting are available in chassis-dependent software modules. Please contact your local Sony Service organisation for the latest information.

This manual is also suitable for:

Kf-50sx300kKf-60sx300uKf-50sx300uKf-60sx300Kf-60sx300k

Table of Contents