Advertisement
Table of Contents
INFRA-RED
Patio II
T T M M
OWNER'S MANUAL
Thermal Engineering Corporation
P.O. Box 868, Columbia, South Carolina 29202-0868
2741 The Boulevard, Columbia, South Carolina 29209
Telephone: (803) 783-0750 Toll-free (800) 331-0097
Fax : (803) 783-0756 Toll-free fax: (888) 581-0286
Website: www.tecinfrared.com
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for TEC Patio II
Summary of Contents for TEC Patio II
- Page 1 INFRA-RED Patio II T T M M OWNER’S MANUAL Thermal Engineering Corporation P.O. Box 868, Columbia, South Carolina 29202-0868 2741 The Boulevard, Columbia, South Carolina 29209 Telephone: (803) 783-0750 Toll-free (800) 331-0097 Fax : (803) 783-0756 Toll-free fax: (888) 581-0286...
- Page 2 Revised 08/04 -- Z21.58b/CGA1.6b-2002...
-
Page 3: For Your Safety
Warnings Notices Notice to Consumer For Your Safety PRIOR TO INSTALLING AND USING THIS APPLIANCE, If you smell gas: READ THIS MANUAL FULLY AND CAREFULLY. RETAIN THIS MANUAL FOR FUTURE REFERENCE AND HAVE 1. Shut off gas to the appliance. AVAILABLE AT ALL TIMES. - Page 4 UNDER THIS WARRANTY We will, at our option, repair or replace any component part deemed by TEC to be defective when returned to the TEC factory, freight prepaid, within the warranty period. Prior to authorization of repair or replacement, you must supply the date of original purchase and serial number of your grill.
- Page 5 We would be grateful if you would take a few minutes to complete it and send it to us -- after you’ve used your new TEC a few times. We’ll send you a free TEC apron as a token of our...
-
Page 6: Table Of Contents
Contents Installation Installation ......General Overview Assembly ......WARNING: THIS GRILL IS DESIGNED CERTIFIED Gas Connection ...... FOR USE OUTDOORS ONLY. Operation ......10 THIS GRILL SHOULD NOT BE USED IN A BUILDING, GARAGE OR OTHER ENCLOSED AREA AND IS NOT Infra-Red Cooking .... -
Page 7: Installation
Installation Assembly continued General Overview COMBUSTIBLE CONSTRUCTION The Patio II™ gas grill is designed for easy assembly. The Patio II™ grill is available with three base mounting Sides 12” options. Assembly procedures for each of these options Back 12” follow. - Page 8 Assembly continued Pedestal Base In-Ground Post Base & Bolt-Down Base Assemble the Pedestal Base and mount the Grill Housing 1. Install the In-ground or Bolt-down Post Base in as follows. The required hardware is tied to the top accordance with the instructions accompanying the Post Base.
-
Page 9: Gas Connection
1/4”-20 Follow the procedures outlined in this section closely to CARRIAGE BOLT W/ FLAT ensure safe and proper grill operation. The Patio II™ grill WASHER AND NUT (TYP. 4 is offered in one of two gas configurations: LP or Natural PLACES) gas. - Page 10 Gas Connection continued DESIGN TO PROTECT THE CYLINDER VALVE FROM Be sure to set the gas cylinder upright so the Cylinder Valve DAMAGE. DO NOT USE OR TRY TO REPAIR A is at the top. This will ensure proper vapor withdrawal. DAMAGED LP GAS CYLINDER AT ANY TIME.
-
Page 11: Gas Leak Test
Gas Connection continued 5. Inspect Regulator and hose assembly. Look for any Permanent Installation damage such as abrasions or holes, dirt or debris. CAUTION: Remove dirt or debris. Replace damaged parts prior GAS PIPING TO YOUR GRILL MUST BE IN to use. -
Page 12: Operation
BURNER, CAUSING IT TO FUNCTION IMPROPERLY. 8. For LP gas, close the Gas Cylinder Valve by turning The Patio II™ grill is equipped with a pilot burner. This the Handwheel clockwise. For Natural gas, close the safety feature will re-ignite the burner if it goes out while gas valve in the main line. - Page 13 Operation continued Procedure: Low Heat Adjustment 1. Open the Hood, ensure all valves are closed and that WARNING: NEVER ADJUST THE BURNER SO LOW the cooking surface of the grill is not covered. THAT IT MAY GO OUT DURING USE. DO NOT OPERATE 2.
- Page 14 Operation continued Pilot Flame Adjustment WARNING: EACH GAS ORIFICE MUST BE PROPERLY LOCATED ON THE ORIFICE BRACKET, ATTACHED TO The pilot flame length is preset at the factory, but can be THE VENTURI ON THE BURNER ASSEMBLY. AN adjusted. The flame length should be approximately one IMPROPERLY LOCATED ORIFICE CAN LEAD TO BODILY INJURY AND PROPERTY DAMAGE.
-
Page 15: Infra-Red Cooking
Infra-Red Cooking Sample Cooking Methods Unless otherwise noted, these cooking guidelines require cooking with hood open. Use this chart as a cooking guide. Cooking times may vary, depending on thickness of food. FOOD CONTROL SETTING TOTAL COOKING TIME Steak 1" Thick High fire 2 min. - Page 16 When turning or moving foods, use tongs or a TEC Infra-Red gas grills make it possible for you to enjoy spatula, instead of a fork. Piercing the food with a cooking outdoors quickly and effortlessly.
-
Page 17: Care, Cleaning And Maintenance
Your dealer them to backfire, especially if the burner output is set at should have TEC covers designed specifically for your HIGH. If this occurs repeatedly, the burners may crack. -
Page 18: Appendix B - Replacement Parts
Gas Leak Test on page 9, you should be able to If you need replacement parts or accessories, contact your resume normal use of your grill. TEC authorized dealer. See Appendix C of this manual for a listing of replacement parts and accessories. Cleaning... -
Page 19: Installing The Rotisserie
Spit rod Motor For best results, refer to the Infra-Red Cooking section of motor this manual. The TEC Rotisserie has not been tested by the American Gas Association or the Canadian Gas Association. Figure 16. Rotisserie Rotisserie Cooking versatility is a trademark of TEC grills. With the Rotisserie, you can add a new and exciting dimension to cooking. - Page 20 Bar-B-Que tray. Figure 17. Bar-B-Que Tray The TEC Bar-B-Que Tray has not been tested by the American Gas Association or the Canadian Gas Association. Bar-B-Que Tray The primary purpose of the Bar-B-Que Tray is to deflect the Infra-Red heat so that it does not contact the food directly.
- Page 21 Smoker to remove Smoker. Figure 18. Wood Chip Smoker The TEC Wood Chip Smoker has not been tested by the American Gas Association or the Canadian Gas Association. Wood Chip Smoker With the Wood Chip Smoker, delicious smoked flavor can enhance the taste of foods.
- Page 22 Appendix A: Accessories continued Deep Fryer Use Refer to Figure 19. CAUTION: DO NOT CLOSE HOOD WHILE USING THIS ATTACHMENT FOR FRYING. HOT COOKING OIL Fryer / Steamer Fryer/Steamer CAN CAUSE BURNS. ALWAYS WEAR OVEN MITTS WHEN USING THE DEEP FRYER AND USE EXTREME CAUTION WHEN HANDLING HOT COOKING OIL OR WATER.
- Page 23 Figure 20. Steamer Attachment 1. Remove the Cooking Grid over the burner that will The TEC Steamer has not been tested by the American Gas Association or the be used to operate the Deep Fryer/Steamer. It does Canadian Gas Association.
- Page 24 Griddle. Figure 21. Griddle The TEC Griddle has not been tested by the American Gas Association or the Canadian Gas Association. Griddle This Griddle provides a surface for you to use your grill for pan frying foods such as bacon, eggs, sausage, french toast and pancakes, and for blackening fish and meats.
- Page 25 P2DT ......Drip Tray The TEC Wok has not been tested by the American Gas Association or the Canadian Gas Association.
-
Page 26: Appendix C: Troubleshooting
Appendix C: Troubleshooting PROBLEM PROBABLE CAUSE REMEDY Pilot will not light. a. Lack of gas. a. After turning Pilot Output Knob to ON b. Obstruction in pilot orifice. position, wait approximately 20-30 seconds c. Defective piezo ignitor. for air to purge gas supply line before d. - Page 27 Notes...
Need help?
Do you have a question about the Patio II and is the answer not in the manual?
Questions and answers