Summary of Contents for Holland Fifth Wheel FW35 (XA-351)
Page 1
FW35 (XA-351) FIFTH WHEEL Trouble-Shooting Guide Before proceeding, verify that your fifth wheel top plate is a XA-351 model by following the 3 steps below: ➊ ➋ XA-3501 SERIES Open loop release handle Bracket pin retained internally IF YOU HAVE THIS FIFTH WHEEL, REFER TO THE FW3500 (XA-3501) TROUBLESHOOTING GUIDE SECTION.
Page 2
FW35 (XA-351) FIFTH WHEEL Trouble-Shooting Guide TABLE OF CONTENTS Difficult to uncouple from trailer......3 – 4 Difficult to couple to trailer .
Refer to Holland Service Bulletin XL-SB004-01 for lube plate warnings. 6. Check the kingpin with a Holland TF-0110 kingin gage and bolster plate with a 48˝ straight edge – repair or replace as required (See Figure 2 below, and Service Bulletin XL-SB-020.)
Lock Adjustment section of the maintenance instructions included with your fifth wheel (Holland publication XL-FW-308). 8. Fifth wheel must be rebuilt. Obtain the proper rebuild kit for your model top plate. 9. Rebuild fifth wheel with the proper Holland rebuild kit.
Page 5
Service Bulletin XL-SB036-01. 5. Replace release handle using rebuild kit RK-08415-1. 6. Inspect for kingpin damage (impact) (see Figure 5). If damaged, rebuild fifth wheel with the proper Holland rebuild kit. Figure 5 Trailer Improper coupling attempt. Severely misaligned trailer...
7. Check the kingpin and upper plate coupler as detailed in Holland Service Bulletin XL-SB020-01. Remove any improperly installed or improperly specified lube plates. Refer to Holland Service Bulletin XL-SB004-01 for lube plate warnings. Check the kingpin with a Holland TF-0110 kingin gage and bolster plate with a 48˝...
2. Warped trailer upper coupler plate. Remedy 1. Check the kingpin and upper plate coupler as detailed in Holland Service Bulletin XL-SB020-01. Remove any improperly installed or improperly specified lube plates. Refer to Holland Service Bulletin XL-SB004-01 for lube plate warnings.
Hex head cap screw (5/8"-18 x 1-3/4") XB-07431 Washer (2-5/8" x 21/32") XA-1507 Roller (5/8” I.D.) * Parts not included in rebuild kit (available from your local Holland distributor.) ** Parts included in rebuild kits RK-351-A-L-02 and RK-351-A-02. NOTE: FOR RIGHT HAND RELEASE. ITEM NO.