Page 1
Mini Bike OWNERS MANUAL MINIMUM AGE 16 Younger riders require adult supervision. Important Information. Read thoroughly before riding the first time. MOTOVOX.COM VISIT US ON THE WEB FOR MORE INFORMATION...
Page 2
Due to improvements or production changes, there could be discrepancies in this manual. Motovox reserves the right to make product changes at any time, without notice and without obligation to make the same or similar changes to any vehicle previously built or sold.
CONTENTS Motovox warrants to the first buyer of the Product (“Buyer”) that on the date of purchase of the Product, as shown on Buyer’ s sales receipt (“Purchase Date”), the Product shall be free from defects in material or workmanship subject to and in accordance PRODUCT WARRANTY with the terms and conditions set forth herein.
• Instructions, such as Riding Techniques or Braking Techniques Please be sure to register your Motovox product and notify us of This manual is filled with important safety information, please any address changes so we may contact you in the future with any read it carefully and be sure that you understand it.
Page 5
Any modifications or improper accessories added to the react to hazards. mini bike with parts that are not manufactured by Motovox can make it Never drink alcohol and ride. Even one drink can impair your unsafe. Motovox strongly recommends that you do not remove any of the ability to ride safely and each additional drink worsens your ability to do so.
TROUBLE DO NOT RETURN TO STORE 888-488-MOTO (6686) contact us! or email info@motovox.com OPERATING CONTROLS OPERATING CONTROLS BEFORE STARTING When you operate a mini bike you need to be able to operate the Before starting your MB 10, you must be sure that the kill switch is in the ON throttle, brake and other controls without stopping to look at them.
Page 7
Brake Your MBx10 mini bike is equipped with a rear disc make the width of the mini bike narrower when it is brake. The brake provides the stopping power to bring being stored.
3. Riding pants with knee and hip pads. 4. Riding jersey with elbow pads and chest/shoulder protection. out of your Motovox mini bike. As a reminder: Never ride without a helmet. Helmets significantly reduce the number and severity of head injuries.
TROUBLE DO NOT RETURN TO STORE 888-488-MOTO (6686) contact us! or email info@motovox.com BASIC OPERATION BASIC OPERATION The following section of the manual provides some basic information on 7. Once the engine starts to run, let it warm up by operating the throttle up how to begin riding your mini bike.
TROUBLE DO NOT RETURN TO STORE 888-488-MOTO (6686) contact us! or email info@motovox.com BRAKING TECHNIQUE MAINTAINING YOUR MB This section will cover basic braking technique for your mini bike. To slow Keeping your mini bike in perfect operating condition is absolutely essential or stop the bike, squeeze the brake lever firmly and smoothly.
SEE MOTOVOX.COM FOR SIMPLE HOW-TO VIDEOS FOR ALL MAINTENANCE PROCEDURES ABOVE. See the Maintenance Videos section of the MBx10 page on motovox.com for an easy to follow, step-by-step instructional video called “Initial Setup”. * Can be performed by owner with proper tools and knowledge, otherwise consult with a service center.
The air filter keep impurities like dust and dirt out of the engine, and a clogged filter can seriously affect the performance and extend IMPORTANT! The motor oil that comes in your MBx10 is break-in oil and the life of your mini bike engine.
Never ride the mini bike when the brake is not working properly. If you can not get the brake adjusted and repaired properly, you may need to replace the brake pads. Refer to your local Motovox Service Center for assistance.
Page 14
If you notice that a rim is bent or dented, please you may have picked up. refer to your local Motovox Service Center for assistance in replacing the rim. • Inspect the tread depth of your tires and replace them if the depth drops Front Wheel below a tenth of an inch, or if you notice a serious reduction in traction.
Proper drive chain maintenence will also extend the life of other parts on which requires periodic maintenance to operate your MBx10, like the drive sprockets and the clutch. properly. If you experience a noisy or “grabby” clutch, especially if it kills the engine at idle or IT IS CRITICAL THAT YOU CHECK THE DRIVE CHAIN low speeds, it is time to service your clutch.
Is it dirty or caked with residue? Clean or replace. 7. Spark Test: If none of the above steps work, please contact Motovox by calling us at: a. Put the spark plug back into the boot without installing in 888-488-MOTO (6686) the engine.
Sometimes crash damage is not immediately apparent so be sure to inspect the mini bike very carefully after you get it home. And always have a Motovox Service Center inspect your mini bike after a crash to determine if it is safe to ride your mini bike.
Page 18
If the chain breaks when it comes off, chances are that you will not have a spare master link with you for the repair. But your chain may be able to be salvaged with a new master link. Consult your Motovox Service Center. BRAKE If you experience a problem with one of the brake system components and you lose your brake, do not ride this mini bike.
OWNER’S WARRANTY RESPONSIBILITIES incidental, consequential or exemplary arising in connection with the sale or use of or inability to use the Motovox brand As the vehicle owner, you are responsible for the performance of the required maintenance listed in your owner’ s vehicle for any purpose.
Page 20
Register your Motovox MBx10 Mini Bike so that we can Motovox MBx10 Product Registration provide you fast solutions to any problems you may have with Please complete and mail this card within 10 days of purchase. your product and so that we can keep in touch with you Name regarding any product updates.
Page 21
For step-by-step maintenance videos and much more information about Motovox would sincerely like to thank you for choosing one of your Motovox MBx10, visit motovox.com our fine products and we hope you will have many years of...
Page 23
IF YOU HAVE TROUBLE DO NOT RETURN TO STORE CALL MOTOVOX AND WE WILL MAKE IT RIGHT. Motovox Motorsports 8844 Hillcrest Road, Kansas City, MO 64138-3759 Toll Free: 1-888-488-MOTO (6686) Motovox.com email info@motovox.com...
Need help?
Do you have a question about the MBx10 and is the answer not in the manual?
Questions and answers