Sun Dolphin Sundolphin ASL Owner's Manual

Water wheeler electric pedal boat

Advertisement

O w n e r ' s M a n u a l
Water Wheeler ASL
Electric Pedal Boat
1790 Sun Dolphin Drive
Muskegon, Michigan 49444
phone 231-733-2725
fax
231-739-4502
email
klsales@klindustries.com
website www.sundolphin.com

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Sundolphin ASL and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Sun Dolphin Sundolphin ASL

  • Page 1 O w n e r ’ s M a n u a l Water Wheeler ASL Electric Pedal Boat 1790 Sun Dolphin Drive Muskegon, Michigan 49444 phone 231-733-2725 231-739-4502 email klsales@klindustries.com website www.sundolphin.com...
  • Page 2 Congratulations on the recent purchase of your new pedal boat! You have purchased a boat from one of the nations leading manufacturers of small boats. Your boat represents years of commitment to product design, excellence in engineering and quality in manufacturing. With proper care and maintenance your pedal boat should last for many years to come. Please call our helpful and knowledgeable Customer Support Department if you have any questions.
  • Page 3 Paperwork warranty registration To properly register your boat with KL Industries for warranty validation please fill out the warranty registration form online at www.sundolphin.com. Please review our full warranty statement. If you are unable to register your boat online please contact our Customer Support Department at 231-733-2725. The serial number can be found on the outside of the hull in the back right corner just under the rubrail.
  • Page 4 Owner’s Manual Keep your owner’s manual for future reference. It is a good idea to write down the following information: Serial Number ________________________________ Date of Purchase ________________________________ Purchased from ________________________________ applying Decals Before applying boat registration decals (if required), clean the area with alcohol or any solvent that does not leave a residue. Make sure solvent is put aside and is dry.
  • Page 5 Once the prop is clear lower the motor and push in the circuit breaker to reset it. If it trips again, don’t use the motor. Refer to the trouble-shooting guide in this manual or call KL Industries.
  • Page 6: Care And Maintenance

    Your pedal boat has a covered compartment in the rear. Always face the stern (rear) of the boat towards the direction of travel to prevent the wind from tearing the compartment lid off. If this happens you can contact KL Industries for replacement.
  • Page 7: Frequently Asked Questions

    • If possible, it is best to store your pedal boat inside for the winter. If stored outside custom mooring covers that prevent water and debris from accumulating are available from KL Industries. Order online at www.sundolphin.com. • When storing your boat, open the drain plug and stand it on its front bow to ensure proper drainage. Either store it on its bow or turn it upside down.
  • Page 8: Security Measures

    seCurITY Measures Warning Read the following information before using your pedal boat. Failure to follow the warning precautions below may lead to serious injury including the possibility of death. never exceed the maximum weight capacity. never exceed your ability: Assess your physical capability as to how far and how long you can pedal and swim. Make sure your drain plugs are secure.
  • Page 9: Troubleshooting

    Industries for replacement. Prop jammed against obstruction Check prop for obstruction due to weeds, fishing line, rope, etc. Reset and try again. If no obstruction is found, call KL Industries for replacement. Defective control switch Call KL Industries for replacement.
  • Page 10 Reverse battery. Problem: Motor only operates on one or two speeds Defective control switch Call KL Industries for replacement. Loose connections at control switch Disconnect battery. Remove control panel. Disconnect, clean and/or recrimp connectors one at a time. Reconnect leads to switch terminals.
  • Page 11 water wheeler asl electric Adjustable sun lounger electric powered pedal boat aVaIlaBle aCCessOrIes: • Mooring Cover • Salt Water Drive System OPTIOnal aCCessOrIes: Order online at www.sundolphin.com Adjustable seats so Integrated Minn Kota® electric motor for effortless cruising people of all heights Battery Seating for (battery not included)
  • Page 12: Warranty

    KL Industries, Inc. warrants to the original owner of any KL Industries boat. Any part of the boat that is defective in material or workmanship will be repaired, without charge, at the purchasers’ local dealer or at KL Industries.

This manual is also suitable for:

Water wheeler asl

Table of Contents