Table of Contents
Advertisement
Quick Links
Operating instructiOns and Owner's Manual
Mr. Heater
1000ID,
2000ID
3000ID
indirect Fired
pOrtaBle Heater
if the information in this manual is not followed exactly, a fire or explosion
warning:
may result causing property damage, personal injury or loss of life.
— Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any
other appliance.
— Service must be performed by a qualified service agency.
This is a vented portable heater. It uses air (oxygen) from the area in which it is used. Adequate
combustion air and ventilation must be provided. Refer to page 5.
read instructiOns careFullY: Read
and follow all instructions. Place instructions in
a safe place for future reference. Do not allow
anyone who has not read these instructions to
assemble, light, adjust or operate the heater.
ENERCO GROUP, INC., 4560 W. 160TH ST., CLEVELAND, OHIO 44135 • 800-251-0001
Heatstar
BY enercO
1000ID,
2000ID
3000ID,
4000ID
08/08 #50120
Advertisement
Table of Contents
Related Manuals for Mr. Heater 1000ID
Summary of Contents for Mr. Heater 1000ID
-
Page 1: Parts List
Operating instructiOns and Owner’s Manual Heatstar read instructiOns careFullY: Read Mr. Heater and follow all instructions. Place instructions in BY enercO a safe place for future reference. Do not allow 1000ID, 2000ID 1000ID, 2000ID anyone who has not read these instructions to 3000ID 3000ID, 4000ID assemble, light, adjust or operate the heater. -
Page 2: Table Of Contents
warning: warning: YoUR SAFeTY IS IMPoRTANT To YoU AND To oTHeRS, NoT FoR HoMe oR ReCReATIoNAl VeHICle USe So PleASe ReAD THeSe INSTRUCTIoNS BeFoRe YoU oPeRATe THIS HeATeR. warning: general HaZard warning: FIRe, BURN, INHAlATIoN, AND eXPloSIoN HAZARD. KeeP SolID CoMBUSTIBleS, SUCH AS BUIlDING MA- FAIlURe To CoMPlY WITH THe PReCAUTIoNS AND TeRIAlS, PAPeR oR CARDBoARD, A SAFe DISTANCe INSTRUCTIoNS PRoVIDeD WITH THIS HeATeR, CAN... -
Page 3: Specifications
(see “TeCHNICAl SPeCIFICATIoN” sheet). • Make sure fire fighting equipment is readily available. • Unplug heater when not in use. • Make sure sufficient fresh outside air is provided according MH 1000id MH 2000id MH 3000id tecHnical speciFicatiOns Hs 1000id... -
Page 4: Warnings
OperatiOn • The air inlet and outlet must never be blocked for any reason. Before any attempt of starting the heater is made, check that • Install the heater on a flat, level floor in a steady postion. your electrical supply conforms to the data on the model plate. •... -
Page 5: Maintenance
The hot air heaters with wheels must be wheeled. The suspended description version which has no wheels must be transported with adequate a) Minimal 39” machinery. B) Minimal 39” Maintenance c) The shortest Preventive and regular maintenance will ensure a long trouble free d) The same or bigger than the smokes outlet diameter of life to your heater. -
Page 6: Troubleshooting
trOuBlesHOOting trOuBle cause sOlutiOn Motor does not start, no ignition No electrical current Check mains (should be 120 V – 1~ – 60 Hz) Check proper positioning and functioning of switch Check fuse Wrong setting of room ther- Check correct setting of heater control. If thermostat, make mostat or other control sure selected temperature is higher than room temperature Thermostat or other control... -
Page 7: Wiring Diagrams
1000id series MOdels drawing legend Fuse Control Transformer H.V. Room Thermostat overheat Thermostat Relays Solenoid Valve 1° Control Box Photocell Air pressure control Condenser Heater filter Fan Motor Fan thermostat electric pilot Ground eNeRCo GRoUP, INC. |Indirect Fired Portable Heater... -
Page 8: Wiring Diagram
wiring diagraM 2000id and 3000id series MOdels drawing legend Fuse 20A Control Transformer H.V. Room Thermostat plug overheat Thermostat Relay Solenoid Valve 1° Control Box Solenoid Valve 2° Fan thermostat Photocell Air pressure control Condenser Heated filter Fan Motor Air pressure switch electric pilot lamp Ground eNeRCo GRoUP, INC. - Page 9 wiring diagraM 4000id series MOdels drawing legend Fuse 20A Room Thermostat plug Transformer H.V. Relay overheat Thermostat Control Box Solenoid Valve 1° Fan thermostat Solenoid Valve 2° Heated filter Photocell Connector Condenser overheat safety thermostat Fan Motor Ground electric pilot lamp Control eNeRCo GRoUP, INC.
- Page 10 1000id series indirect-Fired portable Heater eNeRCo GRoUP, INC. |Indirect Fired Portable Heater operating Instructions and owner’s Manual...
-
Page 11: Parts List 1
1000id series indirect-Fired portable Heater parts list stOck nO. descriptiOn stOck nO. descriptiOn G06102 SWITCH SUPPoRT G06075-9010 oUTleT CoNe e50437 PReSSURe SWITCHeS HoNeYWell G06077 CHIMNeY Ø 150 e20319 TeRMINAl BoARD G06079 CoMBUSTIoN CHAMBeR SUPPoRT e20305 TeRMINAl BoARD G06081 CoMBUSTIoN CHAMBeR e1 1 125 RelAY FINDeR 65.31 AC... - Page 12 2000id/3000id series indirect-Fired portable Heaters eNeRCo GRoUP, INC. |Indirect Fired Portable Heater operating Instructions and owner’s Manual...
- Page 13 2000id/3000id series indirect-Fired portable Heater parts list stOck nO. 2000 3000 descriptiOn stOck nO. 2000 3000 descriptiOn G061 13-9010 • oUTleT CoNe I31130 • • CoNN. STRAIGHT Ø6 1/8” G061 14-9010 • e20953 • • CABle HolDeR PG11 G06077 • •...
- Page 14 4000id series indirect-Fired portable Heaters eNeRCo GRoUP, INC. |Indirect Fired Portable Heater operating Instructions and owner’s Manual...
- Page 15 4000id series indirect-Fired portable Heaters eNeRCo GRoUP, INC. |Indirect Fired Portable Heater operating Instructions and owner’s Manual...
- Page 16 4000id series indirect-Fired portable Heater parts list nO. stOck nO. descriptiOn nO. stOck nO. descriptiOn G06156-9010 outlet cone G06165-9005 Fuel tank 135 I G06157 Centrifuge air fan C30367 Drain plug e50767 Thermostat TY95A 105°C Campini G06068-9005 Power lead hook G06171 Combustion chamber support G06166-9010 Base...
- Page 17 4000id series indirect-Fired portable Heater parts list nO. stOck nO. descriptiOn e30443 eI. wire with plug and cable fastener e11030 lamp 230V T20353 Nozzle 1,50 GPH 45° W P10137 Burner’s head with electrodes e10254 electrodes P10134 electrodes stirrup 133002 Nozzle support P20529 Burner flange 0 102mm G02076...
-
Page 18: Parts Ordering Information
Operating instructiOns and Owner’s Manual Heatstar read instructiOns careFullY: Read Mr. Heater and follow all instructions. Place instructions in BY enercO a safe place for future reference. Do not allow 1000ID, 2000ID 1000ID, 2000ID anyone who has not read these instructions to 3000ID 3000ID, 4000ID assemble, light, adjust or operate the heater. - Page 19 PIèCeS PRoCUReR PoSSIBLe FABRICANT. ReMPLACeMeNT PIèCeS N’UTILISeZ AVERTISSEMENT: chauffage. appareil fonctionner faire 4000Id 3000Id, 3000Id régler d’allumer, d’assembler, instructions 2000Id 1000Id, 2000Id 1000Id, présentes n’ayant quiconque à Interdisez ultérieurement. référer vous pour instructions ENERCO Conservez instructions. toutes observez Lisez HEATER...
- Page 20 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO BLANC QUITTÉ INTENTIONNELLEMENT COLONNE 04,5 droit Raccord Support G06170-9005 filtre Cartouche T20242 gasoil filtre T20241 1/4" pre-chauffage Filtre T20239 Condensateur 1233 condensateur avec 200W Moteur E10677-110 ventilateur moteur Support G06169-9005 F12,7...
- Page 21 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO Bouchon e20665 2,62 C30350 3P+T thermostat Fiche e20640 vidange Bouchon 125019 Interrupteur E10102-P elastique Rondelle M20202 support Plaqu G06073 Roue C10546 21-24 LANDIS Coffret e40113 roues essieu Support G06151-9005 21-24 LANDIS...
- Page 22 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO Indirect-tiré Portatif Chauffage Série 4000ID...
- Page 23 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO Indirect-tiré Portatif Chauffage Série 4000ID...
- Page 24 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO 1/8” CoUde • • I20325 • • • • FILTRe CARToUCHe T20242 1/8” CoUde I20325 • • • GASoIL FILTRe T20241 1/8” CoUde I30325-1 ACCoUPLeMeNT • e10514 Ø5X9 SILICoNe TUYAU •...
- Page 25 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO Indirect-tiré Portatif Chauffage Série 2000ID/3000ID...
- Page 26 CARRoSSeRIe G06083-9010 GICLeUR SUPPoRT I33001 CoMBUSIoN CHAMBRe G06081 80° 0,60 GICLEUR T20339 CoMBUSTIoN CHAMBRe PRoTeCTIoN G06079 230V LAMPe e11030 Ø CHeMINÉe G06077 CÂBLE PRESSE FICHE AVEC CÂBLE e30443 CoNIQUe eMBoUT G06075-9010 LEGENDE STOCk LEGENDE STOCk Indirect-tiré Portatif Chauffage Série 1000ID...
- Page 27 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO Indirect-tiré Portatif Chauffage Série 1000ID...
- Page 28 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO Terre d’alimentation temoin Lampe surchauffe securite Thermostat ventilator Moteur rechauff gasoil Filtre Condensateur Connecteur Photoresistance ventilateur Thermostat 2° Electrovanne securite Coffret 1° Electrovanne Relais surchauffe Thermostat d’ambiace thermostat Prise H.T.
- Page 29 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO d’alimentation temoin Lampe Terre ventilator Moteur optional Pressostats Condensateur rechauff gasoil Filtre Photoresistance ventilateur Thermostat 2° Electrovanne securite Coffret 1° Electrovanne Relais surchauffe Thermostat d’ambiace thermostat Prise H.T. Transformateur Commutateur Fusible...
- Page 30 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO Terre d’alimentation temoin Lampe ventilateur Thermostat ventilator Moteur rechauff gasoil Filtre Condensateur optional Pressostats Photoresistance securite Coffret 1° Electrovanne Relais surchauffe Thermostat d’ambiace thermostat Prise H.T. Transformateur Fusible Commutateur LÉGENDE DESSIN...
- Page 31 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO autorisé assistance – vente centre proche plus notre contacter veuillez générateur, fonctionnement mauvais cause sont solutions contrôles l’électrovanne corps Remplacer ferme L’électrovanne s’arrête générateur gicleur Subtituer pompe pression valeur Vérifier brûleur...
- Page 32 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO CHEMINÉE FIXATION SCHÉMA eLeCTRodeS”. “TRoU schéma données respectant distance leur régler électrodes nettoyer parties, différentes nettoyer brûleur •Démonter électrodes; tension haute connexions câbles l’état •Contrôler ventilateur; pales interne partie nettoyer cylindrique...
- Page 33 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO MARCHe”. “MISe paragraphe spécifiques NUe. FLAMMe d’UNe LoIN instructions répéter réarmement bouton pousser L’EXTÉRIEUR, À RÉSERVOIR TOUJOURS REMPLISSEZ • faut générateur redémarrer faire Pour ventilateur). arrêt CoMBUSTIBLe. AJoUTeR l’air, sortie l’entrée...
- Page 34 Puisance Fuel gazole/Pétrole Combustible Type 2.760 2.500 1.530 [cfm] d’air débit [kBTU/h] entrée termique Puisance 4000ID 3000ID 2000ID 1000ID SPECIFICATIONS TECHNICAL 3000ID 2000ID 1000ID combustion. produits fabrication. plaque écrites chaud l’air bien aussi pièce dans envoie générateur celles à...
- Page 35 Propriétaire Manuel Instructions marcher Faire fait indirect-tiré portatif |Chauffage INC. GROUP, ENERCO BRÛLe! dANGeR D’ÉCHAPPEMENT. L’ISSUE TOUCHEZ • IMPeRMÉABLe. COURANT PRISE AVEC ORIGINAL H07RN-F l’appareil. impropre utilisation à sonnes per-rès, et/ou D’ALIMENTATION CÂBLE SEULEMENT UTILISEZ • choses dommages pour responsable n’est constructeur QUALIFIÉ.
- Page 36 PORTATIF CHAUFFAGE TIRÉ INDIRECT chauffage. appareil fonctionner faire 4000Id 3000Id, 3000Id régler d’allumer, d’assembler, instructions 2000Id 1000Id, 2000Id 1000Id, présentes n’ayant quiconque à Interdisez ultérieurement. référer vous pour instructions ENERCO Conservez instructions. toutes observez Lisez HEATER...