Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Summary of Contents for Voltmaster TSP2
- Page 1 Voltmaster Trash Pumps Model TSP2, TSP3 and TSP4 Owner’s Manual July 2010...
-
Page 3: Table Of Contents
Voltmaster Trash Pumps Table of Contents Introduction ............ - Page 4 List of Tables Table 4.1 Parts list for Model TSP2, 2-inch trash pump ..... 11 Table 4.2 Parts list for Model TSP3, 3-inch trash pump ..... 11 Table 4.3...
-
Page 5: Introduction
Voltmaster Trash Pumps Introduction Read before using This is a gas engine powered, industrial strength trash pump. The gas engine and the pump are both potentially hazardous and could cause physical injury or even death if improperly used. Before attempting to operate this unit: ■... - Page 6 Voltmaster Trash Pumps Owner’s Manual...
-
Page 7: Safety Information
Voltmaster Trash Pumps Safety Information Operating safety DANGER Explosion hazard. ■ NEVER use for pumping flammable, corrosive, or combustible fluids. ■ NEVER operate the pump in an explosive atmosphere or near combustible materials. WARNING Improper use of equipment could cause serious injury or death. -
Page 8: Engine Safety
Voltmaster Trash Pumps Engine safety 2.2.1 Operator safety DANGER Explosion hazard. ■ Keep engine, fuel, and other combustibles away from sparks, open flame, and burning objects. ■ Do not smoke near engine. ■ Stop engine before filling or draining fuel tank. -
Page 9: California Proposition 65
Voltmaster Trash Pumps 2.2.2 California Proposition 65 WARNING Health hazard. Engine exhaust and some of its constituents are known to the State of California to cause cancer, birth defects, and other reproductive harm. 2.2.3 Spark arresters IMPORTANT! State and local safety codes specify that, in certain locations, internal combustion engines that use hydrocarbon fuels must be used with spark arresters. - Page 10 Voltmaster Trash Pumps Owner’s Manual...
-
Page 11: Operation
Voltmaster Trash Pumps Operation Before starting 3.1.1 Safety Before operating the Voltmaster Trash Pump: ■ Read and be familiar with this instruction manual. ■ Read and follow all safety instructions (see Section 2.1, page 3). ■ Read and follow instructions in the engine manufacturer’s documentation. -
Page 12: Installation
Voltmaster Trash Pumps 3.1.3 Installation Install a suction strainer at the suction hose or pipe: ■ A strainer is provided with holes or slots small enough to prevent larger particulate matter from entering and damaging the pump. The strainer should be installed into the suction end of the line, before piping enters the pump. -
Page 13: Troubleshooting
Voltmaster Trash Pumps Troubleshooting Common problems For troubleshooting, check and resolve the following issues as needed. Contact the factory for assistance if necessary (see Section 1.2, Where to obtain service, page 1). If the pump fails to prime: ■ The priming chamber might be empty or not sufficiently full ■... -
Page 14: Parts Lists
Voltmaster Trash Pumps Parts lists Figure 4.1 Trash pump exploded view Owner’s Manual... -
Page 15: Table 4.1 Parts List For Model Tsp2, 2-Inch Trash Pump
Voltmaster Trash Pumps Table 4.1 Parts list for Model TSP2, 2-inch trash pump Table 4.2 Parts list for Model TSP3, 3-inch trash pump Item Description Qty. Item Description Qty. Honda engine 5.5HP Honda engine 8HP or Honda engine 9HP Pump adapter... -
Page 16: Table 4.3 Parts List For Model Tsp4, 4-Inch Trash Pump
Voltmaster Trash Pumps Table 4.3 Parts list for Model TSP4, 4-inch trash pump Item Description Qty. Honda engine 13HP Pump adapter Washer Serrated bolt 5/16"-24 x 3/4" SS Knob 3/8"-16 Engine adapter Seal & seal seat 3"/4" T Washer Bolt Seal sleeve 3"/4"... - Page 18 WANCO INC. 5870 Tennyson Street Arvada, Colorado 80003 800-972-0755 303-427-5700 303-427-5725 fax www.voltmaster.com ©2010 Wanco Inc. All rights reserved. Printed in the USA. | [part no., rev.]...
Need help?
Do you have a question about the TSP2 and is the answer not in the manual?
Questions and answers