Page 1
Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 368023 Cleveland, Ohio 44136-9722. CUB CADET LLC P.O. BOX 361131 CLEVELAND, OHIO 44136-0019 769-00078C.fm PRINTED IN U.S.A.
A sample model plate is explained below. For future reference, please copy the model number and the serial number of the equipment in the space below. Copy the model number here: Copy the serial number here: CUB CADET LLC P. O. BOX 361131 www.cubcadet.com CLEVELAND, OH 44136...
SECTION 1: IMPORTANT SAFE OPERATION PRACTICES WARNING: This symbol points out important safety instructions which, if not followed, could endanger the personal safety and/or property of yourself and others. Read and follow all instructions in this manual before attempting to operate or service this vehicle. When you see this symbol - heed its warning.
contains carbon monoxide fumes, which are very alert to the presence of children. Children are often poisonous and can be deadly. attracted to the vehicle. They do not understand the 26. Do not change engine governor setting or over dangers. Never assume that children will remain speed the engine.
Page 5
4. Do not operate vehicle with cargo box in raised c. When practical, remove gas-powered position. equipment from the truck or trailer and refuel 5. Do not operate vehicle with cargo box latch it on the ground. If this is not possible, then unlatched.
SECTION 2: KNOW YOUR UTILITY VEHICLE NOTE: Reference to right or left hand side of the utility vehicle is observed from the operating position. Figure 1 Brake Pedal Read this operator’s manual, safety labels, and operating instructions on the vehicle before operating. The brake pedal is located on the left side of the floor Compare the illustrations in this manual with your unit beneath the dash panel.
12V Power Outlet • To engage the parking brake, push brake pedal down firmly, pull out on the parking brake knob, The 12V power outlet is located on the right side of the and release foot from brake pedal. Brake pedal will dash panel.
Low Fuel Engine Oil Light Pressure Light Engaged Parking Alternator Brake Discharge Light Figure 6 Choke The choke lever is located on the left side of the dash Differential Lock panel. The choke is used when starting a cold engine. It Lever Gearshift Lever Disengaged...
WARNING: Make sure seat is in locked to dump cargo. If the cargo box has a manual lift, there position prior to operation and do not try to is a support rod to lock the box in place. See Figure 11. adjust the seat position while operating the WARNING: Do not exceed the vehicle’s vehicle.
Page 11
Driving Utility Vehicle • Raise cargo box manually to upright position using the handle on the drivers side of box. • Make sure front wheels are turned to the desired See Figure 12. direction. • Place support rod into the slot when cargo box is •...
• If using an electric lift, raise cargo box to dump load • Reduce load and ground speed when operating and lower box when empty. over rough or hilly terrain. DO NOT overload vehicle. Limit loads to those that can be safely WARNING: The center of gravity changes as controlled.
Page 13
• Lubricate three grease fittings on each u-joint with 2 could change the polarity and cause damage to your or 3 shots of grease 100 hours. engine’s alternating system. Rear & Center Arms Clean Battery and Terminals • Lubricate the eight grease fittings on the rear and •...
Wheel Replacement If the vehicle has not been put into use for an extended period of time, charge the battery with an automotive type 12-volt charger for a minimum of one hour at six WARNING: Using an unstable lifting device amps.
Page 15
Add approximately 189 oz (5.5 liters) of Shell TTF- • Raise and secure cargo box, if manual lift. SB Oil (Cub Cadet Part No. 737-3120 or 737-3121). • Check oil level by screwing dipstick fully into Dirt and debris in oil may cause damage to IMPORTANT: transaxle and then remove to check level.
Drive Belt Adjusting Brake The wet brake system is an internal part of the WARNING: Fingers or loose clothing can get transmission and it is adjusted externally without caught in rotating parts. Stop engine and wait opening the transmission. There are two sets of brakes for all moving parts to stop before servicing.
WARNING: Damage may occur if direct hose • Prepare fuel system for storage. spray comes in contact with any other electri- If planning to store vehicle with fuel tank empty: cal components, i.e. at instrument cluster or • Add a small quantity of fresh stabilized fuel to tank. under dash.
NOTE: Some of these accessories may come already Electric Bed Lift 39A-100-100 equipped on your vehicle. If they are not equipped, they Horn 39A-101-100 may be ordered through your local Cub Cadet service Rear Electric Outlet 39A-102-100 dealer. Rear Receiver Hitch 39A-103-100...
Engine oil low. charge Loose or corroded connections. Engine operated too long at slow Sulfated or worn out battery. engine speed. Fluid level low. NOTE: For repairs beyond minor adjustments or corrections, contact your nearest Cub Cadet service dealer or call 1-877-282-8684.
Page 20
MANUFACTURER’S LIMITED WARRANTY FOR: The limited warranty set forth below is given by Cub Cadet its possessions and territories, except those sold LLC with respect to new merchandise purchased and used in through Cub Cadet LLC’s authorized channels of the United States, its possessions and territories.