GSM Mobile Cellular Phone SGH-600 SERVICE Manual GSM Mobile Cellular Phone CONTENTS 1. General Description 2. Circuit Description 3. Specification 4. Manual Adjustment Test Procedure 5. Troubleshooting 6. PCB Views 7. Electrical Parts List PQRS WXYZ 8. Exploded Views and Parts List 9.
Page 4
MS, transferring cell information to MS on downlink, transferring the information about RX level, Quality, and RX level of adjacent cell on uplink. FACCH (Fast Associated Control Channel) steals and changes the TCH when needing a Handover. SDCCH (Stand-alone Dedicated Control Channel) and RACH (Random Access Channel) operate during the call setup procedure. Samsung Electronics...
In particular, the rise and fall profiles can be controlled to meet the stringent power/time templates and switching transient requirements of GSM 05.05. The RF output passes to the antenna connector via an integrated TX/RX switch and lowpass filter to attenuate the harmonics generated by the power amplifier. Samsung Electronics...
Page 9
The interface is controlled through TX Data, RX Data, control, and status registers. Transmit and receive data may use a 256 byte buffer or be exchanged through single byte registers. SIMVCC may be used to control the power supply to the SIM card. Samsung Electronics...
Page 10
The simplified built-in charger circuit diagram is as below ; 3.3V 3.6V 3.6V 3.3V 3.0V BATT DC/DC 3.0V Buzzer Backlight LED Vibrator V DECTECTOR BAT_VOLT CHARGER T DECTECTOR Temperature DC IN DECTECTOR DC In Charger On < Fig. 4 Built-in Charger Circuitry > Samsung Electronics...
To control the spectral splatter and thus the intersymbol interference (ISI), filtering is applied to the baseband pulses. The required filtering achieved very simply using a small, low cost discrete LC structure, which has the great advantage of not consuming current. Samsung Electronics...
¥ Programmable power template for Tx burst control ¥ AGC in Receive mode ¥ I,Q inputs or single intermediate frequency (IF) input ¥ Detection of FCCH, SCH, Normal and Dummy Bursts ¥ Flash ROM programming abilities ¥ Auxiliary ADC for battery voltage and temperature monitoring Samsung Electronics...
Page 13
¥ Voice Activity Detection (VAD) output ¥ Fully asynchronous coding and decoding ¥ A-law PCM conversion ¥ DTMF generation ¥ Sidetone level control ¥ Programmable microphone amplifier with two differential input ports ¥ Two programmable audio output amplifiers ¥ 13 MHz master clock Samsung Electronics...
55 degrees C, charging stops. AUTONOMOUS TIMER If MPU has stopped charging and the timer goes to the ÔonÕ state by an external shock, overcharging may occur. A timer (U7-4) prevents the battery from being overcharged by any unexpected external influence. Samsung Electronics...
Page 15
In addition, the temperature limit is -20 upto +85 ¼C for storage, and 0 to +40 ¼C for operating. The CLA size of SGH-600 is 89.3 x 43 x 27 mm, and the weight is 110 g. 2-12 Travel Adaptor (TA) 2-12-1 General Description This adaptor is designed for use with a portable hand held phone (HHP).
Page 16
- Speaker S/N: -45 dB ± 3 dB (1W Output) - Speaker Distortion: 20% below (3W Output) - Speaker Feature: Impedance 4½, Max 5W Output - Echo Cancellation: 50 dB (Min) - Noise Suppression: 15 dB (Min) 2-10 Samsung Electronics...
Extreme: -20 ¼C ~ +55 ¼C 3-1-9 MS Max Power: 2 W (33 dBm) 3-1-17 Operating Voltage 3-1-10 MS Min Power: 0.3 W (5 dBm) - High Voltage: 4.1 V - Nominal Voltage: 3.7 V - Low Voltage: 3.4 V Samsung Electronics...
Page 18
- Spurious signal atenuating : ²-70 dBc - Wide Bandwidth to make plane Group delay (147 bits) characteristic [ s] < Fig. 6 Power-Time Template > 3-2-5 Power Amplifier - Total Efficiency: 40~45 % at Pin=1mW, =3.6 V, Pout=3.2 W Samsung Electronics...
Page 23
Check the path from D401 to U402 3.3V (when pusging (DC/DC convert circuit) pwr Key) Check the clock generation circuit Check for the clock siganl (related to U201 and U200) at U408 pin 83 Check J301 Check the initial operation Samsung Electronics...
Page 24
Pin 54 (REFTXP) 3.0V Check R471, R472, R473 Pin 53 (REFTXN) Pin 56 Check the circuit around U452 (REFADCP) 2.6V? PROM) and data stored in it Check R470, R435, R469 Pin 58 (REFADCN) 0.3V? Resolder all pins of U408 Samsung Electronics...
Select backlight ‘ON’ mode U408 pin 76 Check the U450 and R426 and R426 = ‘H’ ? Is Q400 drived? Check R425, R426 and Q400 Check the solder status of the LEDS LED on? and the related resistors Samsung Electronics...
Page 26
Troubleshooting RING INDICATOR LED Ring Indicator LED does not work U408 pin 106 = ‘H’? Check the U408 Is U403 Drived? Check the U403 Check the LED Samsung Electronics...
Page 27
U400 pin 1 Check the continuity from After SIM card insert, U400 pin 2 (RST) = ‘H’? U408 pin 9 to U400 pin 2 Check the circuit around U412 (Serial E PROM) and data stored in it Samsung Electronics...
Page 28
144 of U408 (kernel) 143, and 144 of U408? Resolder U408 pin 1, 2, 3, 4 and 5 Check the bad contact on any key and Is the key data input OK? clean the keypad area on the B’D Samsung Electronics...
Resolder U405 pin 36 form on the U405 pin 36 during alert tone test? Is it present Check the circuit around U308 the alert wave form on the U308 pin 5? Check the circuit around U452 (E PROM) Samsung Electronics...
Page 30
Resolder the R413, R417, R419, from U405 pin 26, 27 to R420, C430, C407 and C922 MIC+ and MIC-? Check connection Resolder the C406, C429, from U405 pin 21, 22 to C426 and C425 MIC+ and MIC-? 5-10 Samsung Electronics...
U408 (kernel) pin 85 to the U405 pin 64? U405 (vocoder) pin 64 Check the connection from U405 pin 30, 32 Resolder the U405 pin 30, 32 to SPK+ and SPK- Check the speaker volume level is appropriate Samsung Electronics 5-11...
Resolder or replace U304 Is the LCD Display normal? the voltage of U304 pin 14, 15 pin14, 15 Check the U303 Resolder or replace pin 3 4.1V? U303, U304 Check U408 Resolder or replace U408 pin 7 Repair 5-12 Samsung Electronics...
Exploded View and its Parts List 8-5 Travel Adaptor 8-6 Travel Adaptor Parts List Type SEC Code Remark GH44-30548A CHINA GH44-30549A EUROPE GH44-30547A UNITED KINGDOM Samsung Electronics...
Exploded View and its Parts List 8-7 Ciger Light Adaptor 8-8 Ciger Light Adaptor Part List Description SEC Code Remark Ciger Light Adaptor Code GH44-30546A BLACK Samsung Electronics...
Exploded View and its Parts List 8-11 Hands Free Car Kit Option 8-11-1 Hands Free Car Kit Ass’y Hands-free box Micro Phone Orange (lgnition) Brown (Stereo Mute) Red (Vehicle Battery) Black (GND) Bracket Phone Cradle Antenna Clam Shell Mount Option Code: GH96-01150A 8-10 Samsung Electronics...
Page 51
Exploded View and its Parts List 8-11-2 Hands Free Cradle Exploded View Samsung Electronics 8-11...
Page 52
GH72-41522A SCREW M2.6 x 6, +, BH 6003-000107 GH41-10639A SCREW M2 x 6, +, BH 6003-000158 CABLE CAP GH72-41252A CRADLE LOWER GH72-41520A SCREW M3 x 8, +, BH 6001-000158 CRADLE LABEL GH68-31163A EJECTOR GH72-41523A CRADLE DATA CABLE 8-12 Samsung Electronics...