Table of Contents
Advertisement
ii
illll
ill i,i,
LJLI
STORAGE
Immediately
prepare your tractor for storage at the end of
the season or if the unit will not be used for 30 days or more.
CAUTION:
Never store the tractor with
gasoline in the tank inside a building
where fumes may reach an open flame
or spark.
Allow the engine to cool
before storing in any enclosure.
TRACTOR
Remove mower from tractor for winter storage.
When
mower is to be stored for a period of time, clean it thor-
oughly, remove all dirt, grease, leaves, etc,, Give blades
and underside
of housing a good coat of grease or rust
preventative.
Store in a clean, dry area.
•
Clean entire tractor (See "CLEANING"
in the Mainte-
nance section of this manual).
•
Inspect and replace belts, if necessary
(See belt re-
placement instructions in the Service and Adjustments
section of this manual),
.
Lubricate as shown in the Maintenance
section of this
manual.
•
Be sure that all nuts, bolts and screws are securely
fastened.
Inspect moving parts for damage, breakage
and wear.
Replace if necessary.
•
Touch up all rusted or chipped paint surfaces;
sand
lightly before painting.
BATTERY
.
Fully charge the battery for storage.
*
After a period of time in storage, battery may require
recharging,
•
To help prevent corrosion and power leakage during
long periods of storage,
battery cables should
be
disconnected and battery cleaned thoroughly (see "TO
CLEAN BATTERY AND TERMINALS
in the Mainte-
nance sectioin of this manual)_
•
After cleaning, leave cables disconnected
and place
cables where they cannot come in contact with battery
terminals.
•
Be sure battery drain tube is securely attached to drain
in battery tray,
ENGINE
FUEL SYSTEM
IMPORTANT:
1T IS IMPORTANT
TO PREVENT GUM
DEPOSITS FROM FORMING IN ESSEN-
TIAL FUEL SYSTEM PARTS SUCH AS
CARBURETOR,
FUEL FILTER,
FUEL
HOSE, OR TANK DURING STORAGE,
ALSO, EXPERIENCE
INDICATES THAT
ALCOHOL
BLENDED
FUELS (CALLED
GASOHOL
OR USING
ETHANOL
OR
METHANOL) CAN ATTRACT MOISTU RE
WHICH LEADS TO SEPARATION
AND
FORMATION
OF
ACIDS
DURING
STORAGE° ACIDIC GAS CAN DAMAGE
THE FUEL SYSTEM
OF AN ENGINE
WHILE IN STORAGE,,
•
Drain the fuel tank_
Start the engine and let it run until the fuel lines and
carburetor are empty°
•
Never use engine or carburetor cteaner products in the
fuel tank or permanent damage may occur,
•
Use fresh fuel next season,.
NOTE:
Fuel stabilizer
is an acceptable
alternative
in
minimizing the formation of fuel gum deposits during stor-
age,
Add stabilizer to gasoline
in fuel tank or storage
container.
Always follow the mix ratio found on stabilizer
container.
Run engine at least 10 minutes after adding
stabilizer to allow the stabilizer to reach the carburetor.
Do
not drain the gas tank and carburetor if using fuel stabilizer.
ENGINE
OIL
Drain oil (with engine warm) and replace with clean engine
oil.
(See "ENGINE"
in the Maintenance
section of this
manual).
CYLINDERS
•
Remove spark plug(s).
•
Pour one ounce of oil through spark plug hole(s) into
cylinder(s).
•
Turn ignition key to START position for a few seconds
to distribute oilo
•
Replace with new spark plug(s),
OTHER
•
Do not store gasoline from one season to another.
•
Replace your gasoline can if your can starts to rust,
Rust and/or dirt in your gasoline will cause problems.
•
If possible, store your unit indoors and cover it to give
protection from dust and dirL
•
Cover your unit with a suitable protective cover that
does not retain moisture°
Do not use plastic. Plastic
cannot breath which allows condensation
to form and
will cause your unit to rust,
IMPORTANT:
NEVER COVER TRACTOR WHILE EN-
GINE AND EXHAUSTAREAS
ARE STILL
WARM.
25
Hide quick links:
Advertisement
Table of Contents
