Table of Contents
Advertisement
Quick Links
Download this manual
See also:
Owner's Manual
Wood/coal RangE
ModEl SR57E oWnERS Manual
Save this manual for future reference!
READ ALL INSTRUCTIONS CARE-
FULLY BEFORE STARTING THE
INSTALLATION OR OPERATING
THE STOVE. FAILURE TO FOLLOw
INSTRUCTIONS mAY RESULT IN
P R O P E R T Y DA m AG E , B O D I LY
INjURY, OR EVEN DEATH.
SAFETY INSTRUCTIONS
SAFETY NOTICE: IF THIS STOVE IS NOT PROPERLY INSTALLED, A HOUSE/BUILDING FIRE mAY
RESULT. FOR YOUR SAFETY, CONTACT LOCAL BUILDING OR FIRE OFFICIALS ABOUT PERmITS,
RESTRICTIONS, AND INSTALLATION REqUIREmENTS FOR YOUR AREA.
READ ALL INSTRUCTIONS CAREFULLY.
1. The installation of this stove must comply
with your local building code rulings. Please
observe the clearances to combustibles (see
reference figures 1 & 2).
2. Do not install this stove in a mobile home
or trailer (NO EXCEPTIONS).
3. Always connect this stove to a chimney and
vent to the outside. Never vent to another
room or inside a building.
4. Do NoT coNNecT a wood burning stove
to an aluminum Type B gas vent. This is not
safe. Use approved masonry or a UL 103 HT
Listed Residential Type and Building Heat-
ing Appliance Chimney. Use a 6" diameter
chimney or larger, that is high enough to
give a good draft (see specifics in installation
instructions.)
5. Be sure that your chimney is safely
constructed and in good repair. Have the
chimney inspected by the fire department
VGZ-004 / 20110524.0
THE RancHER™
NOT
DO
USE THIS STOVE IN A
mOBILE HOmE, mANUFACTURED HOmE,
TENT OR TRAILER. (NO EXCEPTIONS)
NOTE: THIS STOVE IS
NOT
A UL LISTED STOVE.
or a qualified inspector. Your insurance
company may be able to recommend a
qualified inspector.
6. Creosote or soot may build up in the chimney
connector and chimney and cause a house/
building fire. Inspect the chimney connector
and chimney twice monthly during the heating
season and clean if necessary (see Mainte-
nance & Service Hints, page 9.)
7. To prevent injury, do not allow anyone to use
this stove who is unfamiliar with the correct
operation of the stove.
8. Do not operate stove while under the
influence of drugs or alcohol.
9. For further information on using your stove
safely, obtain a copy of the National Fire
Protection Association (NFPA) publication,
"Using Coal and Wood Stoves Safely" NFPA
No. HS-10-1978. The address of the NFPA is
Battery March Park, Quincy, MA 02269.
Vogelzang International Corporation
400 West 17th Street
Holland, Michigan 49423
www.vogelzang.com
Phone: 1-616-396-1911
Fax: 1-616-396-1971
continued on page 2
Page 1
SR57E /
Advertisement
Table of Contents
Related Manuals for Vogelzang International THE RANCHER SR57E
Summary of Contents for Vogelzang International THE RANCHER SR57E
-
Page 1: Safety Instructions
No. HS-10-1978. The address of the NFPA is constructed and in good repair. Have the Battery March Park, Quincy, MA 02269. chimney inspected by the fire department continued on page 2 Vogelzang International Corporation 400 West 17th Street Holland, Michigan 49423 www.vogelzang.com Phone: 1-616-396-1911... -
Page 2: Assembly Instructions
SAFETY INSTRUCTIONS continued… 10. The paint used on your stove may give off 14. Ashes should not be allowed to accumulate smoke and/or odor during the first fires. This higher than the side of the ash pan. Dispose of may occur during the first 12 to 15 fires until ashes in a metal container with a tight fitting the paint has cured. -
Page 3: Draft Damper
D-6 DRAFT DAmpER A Draft Damper included with the stove must be Draft Damper installed in the first straight section of pipe exit- (must be installed ing the stove before the stove pipe is connected before use — NO EXCEpTIONS!) and the cook stove is used. -
Page 4: Minimum Clearances To Combustible Surfaces
lOCATINg STOvE continued… mINImUm CLEARANCES CORNER CLEARANCES TO COmBUSTIBLE SURFACES 36" Unit to Sidewall ....... 36 inches Unit to Backwall ...... 36 inches Unit Corner to wall ....36 inches Pipe Connector to Ceiling ..18 inches 36" CAUTION: kEEP FURNISHINGS AND OTHER COmBUSTIBLE mATERIALS AwAY FROm THE Fig. -
Page 5: Chimney Connections
ChImNEY CONNECTIONS Chimneys perform two functions. CHIMNEY THIMBLE FLUE 1). As a means of exhausting smoke and flue COLLAR 6˝ ROUND 24 ga. BLACK gases which are the result of fuel combustion. 5/8" TILE CONNECTOR 2). The chimney provides “draft” which allows CHIMNEY STOVEPIPE LINER... - Page 6 ChImNEY CONNECTIONS continued … VENTING TO EXISTING FIREPLACE In some instances, people desire to convert an existing fireplace for stove use. Usually, safe connection to an existing masonry chimney requires more work than using a prefabricated chimney. The existing fireplace must be closed and sealed at the damper with high-temperature caulk, ceramic wool, or furnace cement.
-
Page 7: Fireplace Installation
ChImNEY CONNECTIONS continued … should be checked carefully before connecting a 2. Install a metal or fire clay (5/8” minimum thick- ness) thimble. Make sure the thimble is flush stove to them. with the inner surface of the chimney liner and Venting a stove directly into a fireplace does does not protrude into the flue (see figure 5 on not meet code and should not be attempted. -
Page 8: Operating Instructions
OpERATINg INSTRUCTIONS This stove is designed to burn CAUTION: HOUSE FIRE HAZARDS wOOD OR COAL. • H ot w H i l e i n o p e r at i o n . K e e p Hardwood, 10” to 14” should be split and air dried CHILDREN, CLOTHING AND FURNITURE (seasoned), for 6 months to obtain maximum burning AwAY. - Page 9 OpERATINg INSTRUCTIONS continued … 4. Make sure lid(s) is(are) replaced and fully seated. CAUTION: DO NOT OVER FIRE APPLIANCE. TOO mUCH wOOD OR BURNING NON-REC- 5. Adjust the damper and slide draft control. OmmENDED mATERIALS SUCH AS TRASH 6. Empty ashes regularly. Do not allow ashes to pile OR FLAmmABLE LIqUIDS mAY CAUSE OVER up higher than the top of the hearth (see Safety FIRING.
-
Page 10: Ordering Parts
mAINTENANCE & SERvICE continued … STOVE jOINTS – Required Tune-up. A fire in the stove may be smothered by pouring a large quantity of coarse salt, baking soda, or This stove is manufactured with cast iron cool ashes on top of the fire. components. - Page 11 ChImNEY CONNECTOR SYSTEmS & ClEARANCES A. Brick Masonry Minimum 3.5˝/ 89mm thick brick masonry all framed into combustible wall with a minimum of 12˝/305mm brick separation from clay liner to combustibles. The fireclay liner shall run from outer surface of brick wall to, but not beyond, the inner surface of chimney flue liner and shall be firmly cemented in place.
- Page 12 “FOR GOD SO LOVED THE wORLD THAT HE GAVE HIS ONLY BEGOTTEN SON, THAT wHOEVER BELIEVES IN HIm SHALL NOT PERISH BUT HAVE ETERNAL LIFE” jOHN 3:16 mADE IN CHINA Vogelzang International Corporation 400 West 17th Street Holland, Michigan 49423 www.vogelzang.com...
Need help?
Do you have a question about the THE RANCHER SR57E and is the answer not in the manual?
Questions and answers