(636)-240-2400 • FAX (636)272-2408 • INT’L FAX (636)272-7546 • (800)325-6152 Parts Department (800)424-TRUE • Parts Department FAX# (636)272-9471 I NST AL L AT I O N M A N U AL F O R T - 23 D T F R E E Z E R /...
Page 2
True Food Service Equipment, Inc..... www.truemfg.com ....
Efficient and Successful Operation You have selected one of the finest commercial refrigeration units made. It is manufactured under strict quality controls with only the best quality materials available. Your TRUE cooler when properly maintained will give you many years of trouble-free service.
• Leave the shelves in place so that children may not easily climb inside. USE OF EXTENSION CORDS NEVER USE AN EXTENSION CORD! TRUE will not warranty any refrigerator that has been connected to an extension cord..... www.truemfg.com ....
(North America Use Only!) NEMA plugs TRUE uses these types of plugs. If you do not have the right outlet have a certified electrician install the correct power source..... www.truemfg.com ....
INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS OWNERSHIP Before you start to install your TRUE unit, carefully To ensure that your unit works properly from the first day, it must be installed properly. We highly recommend inspect it for freight damage. If damage is discovered, a trained refrigeration mechanic and electrician install immediately file a claim with the delivery freight carrier.
WARNING ventilation in your room. Under extreme heat Cabinet warranties are void if OEM power cord is tampered with. TRUE will not warranty any units that are connected to conditions, (100°F+, 38°C+), you may want to install an extension cord.
True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION OF CASTORS OR OPTIONAL LEGS Important Safeguard for installation of leg/castor (Images 1-5 demonstrate procedure) Securing Castors and Legs B. Install the desired number of shims, making sure the slot of the shim is in contact with the threaded stem To obtain maximum strength and stability of the unit, of the castor.
True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS CONDUCTORS AND CIRCUITS Wire Gauge for 2% Voltage Drop in Supply Circuits 115 Volt Distance In Feet To Center of Load Amps Wire Gauge for 2% Voltage Drop in Supply Circuits...
To reference wiring diagram - Remove front louvered grill, wiring diagram is positioned on the inside cabinet wall. TRUE requires that a sole use circuit be dedicated for the unit. Failure to do so voids warranty. SEALING CABINET TO FLOOR...
REPLACEMENT PARTS D. Good air flow in your TRUE unit is critical. Be TRUE maintains a record of the cabinet serial number careful to load product so that it neither presses for your cooler. If at any time during the life of your...
Page 12
True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS SHELVING INSTALLATION / OPERATION & LIGHT SWITCH LOCATION WARNING Do not use pliers or any crimping tools when installing shelf clips. Altering shelf clips in any way can lead to shelving instability.
The evaporator fans will remain off for an additional 3 minutes. e. The display will continue to show “deF” for an additional 30 minutes. TRUE Manufacturing recommends that only the Set-Point may be adjusted due to certain conditions..... www.truemfg.com ....
Page 14
After the 2 minute delay the compressor will restart, and evaporator fan(s) will delay 60 seconds. d. The display will continue to show “deF” for an additional 30 minutes. TRUE Manufacturing recommends that only the Set-Point may be adjusted due to certain conditions..... www.truemfg.com ....
Page 15
True Food Service Equipment, Inc. Danfoss Electronic Control (Power On) Press both buttons to power on temp control TURNING ON POWER A. Press both buttons to power on the temperature control. Danfoss Electronic Control (Power Off) Press both buttons and hold for 6 seconds...
Page 16
True Food Service Equipment, Inc. Danfoss Electronic Control (Defrost) Press bottom button and hold for 6 seconds to start defrost DEFROST A. Press bottom button and hold for 6 seconds to defrost. Danfoss Electronic Control (Cut out Temperature) Press and release top...
True Food Service Equipment, Inc. MAINTENANCE, CARE & CLEANING MAINTENANCE, CARE & CLEANING CLEANING THE CONDENSER COIL When using electrical appliances, basic safety precautions should be followed, including the following: REQUIRED TOOLS: Step 8 Reinstall louver assembly onto unit with appropriate fastener • Phillips Screwdriver...
6. Reconnect the electrical power to the unit. If you have any questions, please call TRUE Manufacturing at 636-240-2400 or 800-325-6152 and ask for the Service Department. Service Department Availability Monday-Friday 7:30 a.m. to 5:30p.m. and Saturday 8:00 a.m. to 12:00 a.m. CST.
True Food Service Equipment, Inc. MAINTENANCE, CARE & CLEANING Stainless Steel Equipment Care and Cleaning CAUTION: Do not use any steel wool, abrasive or chlorine based products to clean stainless steel surfaces. • Stainless Steel Opponents There are three basic things which can break down your stainless steel’s passivity layer and allow corrosion to rear its ugly head.
True Food Service Equipment, Inc. MAINTENANCE, CARE & CLEANING Stainless Steel Equipment Care and Cleaning Recommended cleaners for certain situations / environments of stainless steel A) Soap, ammonia and detergent medallion applied with a cloth or sponge can be used for routine cleaning.
TRUE and upon proper installation and start-up in accordance with the instruction packet supplied with each TRUE unit. TRUE’s obligation under this warranty is limited to a period of one (1) year from the date of original installation or 15 months after shipment date from TRUE, whichever occurs first.