Lincoln Electric CAN-M460-C Datasheet

M A T E R I A L S A F E T Y D A T A S H E E T
Conforms to Workplace Hazardous Materials Information System (WHMIS) Rev. November, 1988
Section I & II - Preparation and Product Information
The Lincoln Electric Company of Canada LP
179 Wicksteed Avenue
Toronto, Ontario M4G 2B9 CANADA
Phone: (416) 421-2600
I M P O R T A N T !
This section covers the materials from which this product is manufactured. The fumes and gases produced during welding with the normal use of this
product are covered by Section VII; see it for industrial hygiene information.
CAS Number shown is representative for the ingredients listed. All ingredients listed may not be present in all sizes.
(1) The term "hazardous" in "Hazardous Ingredients" should be interpreted as a term required and defined in the Hazardous Products Act and
does not necessarily imply the existence of any hazard.
Ingredients:
Titanium dioxides
Mineral silicates
Chromium and chromium alloys or compounds (as Cr)
Limestone and/or calcium carbonate
Silicates and other binders
Iron
Iron oxides
Manganese and/or manganese alloys and compounds (as Mn)
Quartz
Fluorides (as F)
Niobium alloys (as Nb) (347 type only)
Cobalt
Nickel (metal) (2100 type only)
Molybdenum alloys (as Mo) (316 type only)
Lithium compounds (as Li)
Stainless steel core wire
Nominal core wire composition:
Chromium
Nickel
Molybdenum (316 type only)
Manganese
Iron
Notes:
(*) Not listed. Nuisance value maximum is 10 milligrams per cubic meter.
TLV value for iron oxide is 5 milligrams per cubic meter.
(**) As respirable dust.
Physical data such as odor, vapor pressure, density, evaporation rate and freezing or boiling points are not listed as they are not applicable
to this product and its use.
Non Flammable; Welding arc and sparks can ignite combustibles and flammable products. See CSA W117.2 Section 9.7 as referenced in
Section VIII. Product is inert, no special handling or spill procedures required.
Rev 9/07
Date:
Trade Name:
Sizes:
Supersedes:
For Welding Consumables and Related Products
Product Type:
Products:
Section III - Hazardous Ingredients (1)
CAS No. Wt. %
13463-67-7
1332-58-7
7440-47-3
1317-65-3
1344-09-8
7439-89-6
65996-74-9
7439-96-5
14808-60-7
7789-75-5
7440-03-1
7440-48-4
7440-02-0
7439-98-7
554-13-2
7440-47-3
7440-02-0
7439-98-7
7439-96-5
7439-89-6
Section IV - Physical Data
Section V - Hazard Data
MSDS No.:
11/12/2008
Blue Max Manual Electrodes
All
11/15/06
Covered Electrode
Blue Max
Prepared by The Lincoln Electric Company, Cleveland, Ohio, USA
(216) 481-8100, on the date shown above.
TLV
3
mg/m (Route/Species)
10-30 10
5-10 5**
1-5 0.5(b)
(intravenous/rat)tumorigenic
1-5 10
1-5 10*
1-5 10*
1-5 5
0.1-1 0.2
0.1-1 #0.05**
0.1-1 2.5
0.1-1 10*
0.1-1 .02
0.1-1 1.5
0.1-1 10
0.1-1 10*
60-100
20-30 0.5(b)
(intravenous/rat)tumorigenic
10-13 1.5
2.5 10
2.0 0.2
bal. 10*
(LDLo, LCLo) Lowest published toxic concentration.
(b) The OSHA PEL for chromium (VI) is 5 micrograms (0.005
milligrams) per cubic meter. The TLV for water soluble
chromium (VI) is 0.05 milligrams per cubic meter and the
TLV for insoluble chromium (VI) is 0.01 milligrams per
cubic meter.
(#) Crystalline silica (quartz) is on the IARC (International
Agency for Research on Cancer) and NTP (National
Toxicology Program) lists as posing a carcinogenic risk to
humans.
(CONTINUED ON SIDE TWO)
CAN-M460-C
308/308L AC-DC 309/309L AC-DC
316/316L AC-DC 347 AC-DC
2100
LD LC
50 50
(Route/Species)
Not Available Not Available
590 g/kg LDLo Not Available
(oral/rat) reproductive
2.16 mg/kg LDLo Not Available
Not Available Not Available
1153 mg/kg Not Available
(oral/rat)
Not Available Not Available
Not Available Not Available
9 g/kg 2.3 LCLo
(oral/rat) (inhalation/human)
200 mg/kg LDLo 300 LCLo
(intratracheal/rat) (inhalation/human)
4250 mg/kg Not Available
(oral/rat)
Not Available Not Available
6170 mg/kg Not Available
(oral/rat)
50 mg/kg LDLo Not Available
(intravenous/mouse)
114 mg/kg LDLo Not Available
(intraperitoneal/rat)
4111 mg/kg LDLo Not Available
(oral/human)
2.16 mg/kg LDLo
Not Available
50 mg/kg LDLo
Not Available
(intravenous/mouse)
114 mg/kg LDLo
Not available
(intraperitoneal/rat)
9 g/kg 2.3 LCLo
(oral/rat) (inhalation/human)
Not Available Not Available
3
mg/m