Page 1 ThinkCentre Hardware Maintenance Manual Machine Types: 0267, 0268, 0385, 1730, 1981, 1943, 4166, 4167, 4169, 5025, 5030, 5032, 5048, 5049, 5069, 5070, 7517, and 7518...
Page 2 “Safety information” on page 3 and Appendix A “Notices” on page 369. Third Edition (Februray 2012) © Copyright Lenovo 2011, 2012. LIMITED AND RESTRICTED RIGHTS NOTICE: If data or software is delivered pursuant a General Services Administration “GSA” contract, use, reproduction, or disclosure is subject to restrictions set forth in Contract No. GS-35F-05925.
Page 3: Table Of Contents
Chapter 3. General information ..33 Chapter 7. Symptom-to-FRU index . . 49 Lenovo Welcome....Hard disk drive boot error ..
Page 4 Replacing the system board ..Windows 7 Home Premium 32 Recovery CD ....Replacing the primary hard disk drive ..Windows 7 Professional 32 Recovery CD .
Page 6 ThinkCentre Hardware Maintenance Manual...
Page 7: Chapter 1. About This Manual
® the front cover. This manual is intended only for trained Service Providers who are familiar with Lenovo computer products. Note: Be sure to read and understand the Chapter 2 “Safety information” on page 3 before using the information in this manual.
Page 8 Lenovo plans to transition to RoHS compliance well before the implementation date and expects its suppliers to be ready to support Lenovo's requirements and schedule in the EU. Products sold in 2005 will contain some RoHS compliant FRUs. The following statement pertains to these products and any product Lenovo produces containing RoHS compliant parts.
Page 10 Important: Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electrostatic discharges. Do not use this type of mat to protect yourself from an electric shock.
Page 11: Voltage-Selection Switch
Voltage-selection switch Some computers are equipped with a voltage-selection switch located near the power-cord connection point on the computer. If your computer has a voltage-selection switch, ensure that you set the switch to match the voltage available at your electrical outlet. Setting the voltage-selection switch incorrectly can cause permanent damage to the computer.
Page 12: Handling Electrostatic Discharge-Sensitive Devices
5. Check for any obvious alterations. Use good judgment as to the safety of any alterations. 6. Check inside the unit for any obvious unsafe conditions, such as metal filings, contamination, water or other liquids, or signs of fire or smoke damage. 7.
Page 13 • French • German • Hebrew • Italian • Korean • Spanish DANGER Electrical current from power, telephone and communication cables is hazardous. To avoid a shock hazard: • Do not connect or disconnect any cables or perform installation, maintenance, or reconfiguration of this product during an electrical storm.
Page 14 CAUTION: When laser products (such as CD-ROMs, DVD-ROM drives, fiber optic devices, or transmitters) are installed, note the following: • Do not remove the covers. Removing the covers of the laser product could result in exposure to hazardous laser radiation. There are no serviceable parts inside the device. •...
Page 15 Chapter 2 Safety information...
Page 16 ≥18 kg (37 lb) ≥32 kg (70.5 lb) ≥55 kg (121.2 lb) ThinkCentre Hardware Maintenance Manual...
Page 17 PERIGO A corrente elétrica proveniente de cabos de alimentação, de telefone e de comunicações é perigosa. Para evitar risco de choque elétrico: • Não conecte nem desconecte nenhum cabo ou execute instalação, manutenção ou reconfiguração deste produto durante uma tempestade com raios. •...
Page 18 CUIDADO: Ao substituir a bateria de lítio, utilize apenas uma bateria com Número de Peça 45C1566 ou um tipo de bateria equivalente recomendado pelo Se o seu sistema possui um módulo com uma bateria de lítio, substitua-o apenas por um módulo do mesmo tipo e do mesmo fabricante. A bateria contém lítio e pode explodir se não for utilizada, manuseada ou descartada de maneira correta.
Page 19 CUIDADO: O botão de controle de alimentação do dispositivo e o botão para ligar/desligar da fonte de alimentação não desligam a corrente elétrica fornecida ao dispositivo. O dispositivo também pode ter mais de um cabo de alimentação. Para remover toda a corrente elétrica do dispositivo, assegure que todos os cabos de alimentação estejam desconectados da fonte de alimentação.
Page 20 ThinkCentre Hardware Maintenance Manual...
Page 21 Chapter 2 Safety information...
Page 22 ThinkCentre Hardware Maintenance Manual...
Page 23 DANGER Le courant électrique provenant de l'alimentation, du téléphone et des câbles de transmission peut présenter un danger. Pour éviter tout risque de choc électrique : • Ne manipulez aucun câble et n'effectuez aucune opération d'installation, d'entretien ou de reconfiguration de ce produit au cours d'un orage.
Page 24 ATTENTION: Remplacer la pile au lithium usagée par une pile de référence identique exclusivement, (référence 45C1566), ou suivre les instructions du fabricant qui en définit les équivalences. Si votre système est doté d'un module contenant une pile au lithium, vous devez le remplacer uniquement par un module identique, produit par le même fabricant.
Page 25 ≥18 kg (37 lb) ≥32 kg (70.5 lb) ≥55 kg (121.2 lb) ATTENTION: Soulevez la machine avec précaution. ATTENTION: L'interrupteur de contrôle d'alimentation de l'unité et l'interrupteur dubloc d'alimentation ne coupent pas le courant électrique alimentantl'unité. En outre, le système peut être équipé de plusieurs cordonsd'alimentation.
Page 26 VORSICHT An Netz-, Telefon- und Datenleitungen können gefährliche Spannungen anliegen. Aus Sicherheitsgründen: • Bei Gewitter an diesem Gerät keine Kabel anschließen oder lösen. Ferner keine Installations-, Wartungs- oder Rekonfigurationsarbeiten durchführen. • Gerät nur an eine Schutzkontaktsteckdose mit ordnungsgemäß geerdetem Schutzkontakt anschließen.
Page 27 ACHTUNG: Bei der Installation von Lasergeräten (wie CD-ROM-Laufwerken, DVD- aufwerken, Einheiten mit Lichtwellenleitertechnik oder Sendern) Folgendes beachten: • Die Abdeckungen nicht entfernen. Durch Entfernen der Abdeckungen des Lasergeräts können gefährliche Laserstrahlungen freigesetzt werden. Das Gerät enthält keine zu wartenden Teile. •...
Page 28 ThinkCentre Hardware Maintenance Manual...
Page 29 Chapter 2 Safety information...
Page 30 PERICOLO La corrente elettrica proveniente dai cavi di alimentazione, del telefono e di comunicazione può essere pericolosa. Per evitare il rischio di scosse elettriche: • Non collegare o scollegare qualsiasi cavo oppure effettuare l'installazione, la manutenzione o la riconfigurazione del prodotto durante un temporale. •...
Page 31 ATTENZIONE: Quando si sostituisce la batteria al litio, utilizzare solo il Numero parte 45C1566 o un tipo di batteria equivalente consigliato dal produttore. Se sul sistema è presente un modulo che contiene una batteria al litio, sostituirlo solo con un tipo di modulo dello stesso tipo della stessa casa di produzione. La batteria contiene litio e può...
Page 32 ≥18 kg (37 lb) ≥32 kg (70.5 lb) ≥55 kg (121.2 lb) ATTENZIONE: Prestare attenzione nel sollevare l'apparecchiatura. ATTENZIONE: Il pulsante di controllo dell'alimentazione presente sull'unità e l'interruttore dell'alimentatore non disattivano l'alimentazione corrente fornita all'unità. E' possibile che l'unità disponga di più cavi di alimentazione.
Page 33 Chapter 2 Safety information...
Page 34 ThinkCentre Hardware Maintenance Manual...
Page 35 PELIGRO La corriente eléctrica procedente de cables de alimentación, teléfonos y cables de comunicación puede ser peligrosa. Para evitar el riesgo de descarga eléctrica: • No conecte ni desconecte los cables ni realice ninguna tarea de instalación, mantenimiento o reconfiguración de este producto durante una tormenta eléctrica. •...
Page 36 PRECAUCIÓN: Cuando haya productos láser (como unidades de CD-ROM, unidades de DVD, dispositivos de fibra óptica o transmisores) instalados, tenga en cuenta lo siguiente: • No quite las cubiertas. Si quita las cubiertas del producto láser, podría quedar expuesto a radiación láser peligrosa.
Page 37 PRECAUCIÓN: El botón de control de alimentación del dispositivo y el interruptor de alimentación de la fuente de alimentación no desconectan la corriente eléctrica suministrada al dispositivo. Además, el dispositivo podría tener más de un cable de alimentación. Para suprimir toda la corriente eléctrica del dispositivo, asegúrese de que todos los cables de alimentación estén desconectados de la toma de corriente.
Page 38 ThinkCentre Hardware Maintenance Manual...
Page 39: Chapter 3. General Information
To access the Lenovo ThinkVantage Tools program, click Start ➙ All Programs ➙ Lenovo ThinkVantage Tools. The following table lists the programs that you can access from the Lenovo ThinkVantage Tools program. To access a program, double-click the corresponding icon.
Page 40: Lenovo Solution Center
The Lenovo Solution Center program enables you to troubleshoot and resolve computer problems. It combines diagnostic tests, system information collection, security status, and support information, along with hints and tips for maximum system performance. See “Lenovo Solution Center” on page 39 for detailed information.
Page 41: For Machine Types: 0268, 1730, 1943, 4166, 4169, 5030, 5048, 5069, And 7517
For machine types: 0268, 1730, 1943, 4166, 4169, 5030, 5048, 5069, and 7517. Dimensions Width: 175 mm (6.89 inches) Height: 414 mm (16.30 inches) Depth: 442 mm (17.40 inches) Weight Maximum configuration as shipped: 11 kg (24.25 lb) Environment • Air temperature: Operating: 10°C to 35°C (50°F to 95°F) Non-operating: -40°C to 60°C (-40°F to 140°F) Non-operating: -10°C to 60°C (14°F to 140°F) (without package)
Page 42 Non-operating: -40°C to 60°C (-40°F to 140°F) Non-operating: -10°C to 60°C (14°F to 140°F) (without package) • Humidity: Operating: 20% to 80% (non-condensing) Non-operating: 20% to 90% (non-condensing) • Altitude: Operating: -50 to 10 000 ft (-15.2 to 3 048 m) Non-operating: -50 to 35 000 ft (-15.2 to 10 668 m) Electrical input •...
Page 43: Chapter 4. General Checkout
Service Support and Engineering functions. • Machine type and model • Processor or hard disk drive upgrades • Failure symptom – Do diagnostics indicate a failure? – What, when, where, single, or multiple systems? © Copyright Lenovo 2011, 2012...
Page 44 – Is the failure repeatable? – Has this configuration ever worked? – If it has been working, what changes were made prior to it failing? – Is this the original reported failure? • Diagnostics version – Type and version level •...
Page 45: Chapter 5. Diagnostic Programs
3. If you are unable to isolate and repair the problem yourself after running the programs, save and print the log files created by the programs. You will need the log files when you speak to a Lenovo technical support representative.
Page 46: Pc-Doctor For Dos
Note: If you are unable to isolate and repair the problem yourself after running the program, save and print the log files created by the program. You will need the log files when you speak to a Lenovo technical support representative.
Page 47: Test Results
• Using the cursor movement keys, highlight Run Normal Test or Run Quick Test from the Diagnostics menu and then press Enter. This automatically runs a pre-defined group of tests from each test category. Run Normal Test runs a more extensive set of tests than Run Quick Test does and takes longer to complete.
Page 48: Viewing The Test Log
• Full Erase Hard Drive Quick Erase Hard Drive provides a DOS utility that performs the following: • Destroys the Master Boot Record (MBR) on the hard disk drive. • Destroys all copies of the FAT Table on all partitions (both the master and backup). •...
Page 49: Chapter 6. Using The Setup Utility Program
• Administrator Password • Hard Disk Password You do not have to set any passwords to use your computer. However, using passwords improves computing security. If you decide to set any passwords, read the following sections. © Copyright Lenovo 2011, 2012...
Page 50: Password Considerations
Password considerations A password can be any combination of up to 64 alphabetic and numeric characters. For security reasons, it is recommended to use a strong password that cannot be easily compromised. To set a strong password, use the following guidelines: •...
Page 51: Erasing Lost Or Forgotten Passwords (Clearing Cmos)
Note: A password can be any combination of up to 64 alphabetic and numeric characters. For more information, see “Password considerations” on page 44. Erasing lost or forgotten passwords (clearing CMOS) This section provides instructions on how to erase lost or forgotten passwords, such as a user password. To erase a lost or forgotten password, do the following: 1.
Page 52: Selecting A Startup Device
• Select ATA Drive Setup to enable or disable an internal or external SATA device. 4. Select the desired settings and press Enter. 5. Press F10 to save and exit the Setup Utility program. See “Exiting the Setup Utility program” on page 47. Selecting a startup device If your computer does not start up from a device such as the disc or hard disk drive as expected, do one of the following to select the startup device you want.
Page 53: Smart Performance Choices
8. Press F10 to save changes and exit the Setup Utility program. Press Enter when prompted to confirm the exit. Note: When ErP compliance mode is enabled, you can wake up your computer by doing one of the following: • Pressing the power switch •...
Page 54 • If you do not want to save the settings, select Exit ➙ Discard Changes and Exit. • If you want to return to the default settings, press F9 to load the default settings. ThinkCentre Hardware Maintenance Manual...
Page 55: Chapter 7. Symptom-To-Fru Index
Check the power-on switch for continuity. Power-on switch Diagnostic error codes Refer to the following diagnostic error codes when using the diagnostic tests. See “Running tests” on page 40 for the specific type for information about the diagnostic programs. © Copyright Lenovo 2011, 2012...
Page 56 In the following index, X can represent any number. Diagnostic Error Code FRU/Action No action 000-000-XXX BIOS Test Passed 000-002-XXX BIOS Timeout 1. Flash the system. See “Updating (flashing) the BIOS from a disc” on page 365. 2. System board 000-024-XXX BIOS Addressing test failure 1.
Page 57 Diagnostic Error Code FRU/Action 1. Make sure the component that is called out is 000-197-XXX BIOS test warning connected and/or enabled. See Chapter 6 “Using the Setup Utility program” on page 43 2. Re-run test 3. Replace the component that is called out in warning statement 4.
Page 58 Diagnostic Error Code FRU/Action 1. Adapter card 001-038-XXX System Extension failure 2. System board 001-039-XXX System DMI data structure error 1. Flash the system. See “Updating (flashing) the BIOS from a disc” on page 365 2. System board 001-040-XXX System IRQ failure 1.
Page 59 Diagnostic Error Code FRU/Action 001-273-XXX System IRQ6 (diskette drive) failure 1. Diskette Cable 2. Diskette drive 3. System board 001-274-XXX System IRQ7 failure 1. Device on IRQ7 2. System board 001-275-XXX System IRQ8 failure 1. Device on IRQ8 2. System board 001-276-XXX System IRQ9 failure 1.
Page 60 Diagnostic Error Code FRU/Action 1. Video Ram 005-016-XXX Video Simple Pattern test failure 2. Video card, if installed 3. System board 005-024-XXX Video Addressing test failure 1. Video card, if installed 2. System board 005-025-XXX Video Checksum Value error 1. Video card, if installed 2.
Page 61 Diagnostic Error Code FRU/Action 005-2XX-XXX 005-3XX-XXX Video subsystem error 1. Video card, if installed 2. System board 006-000-XXX Diskette interface Test Passed No action 006-0XX-XXX Diskette interface error 1. Diskette drive Cable 2. Diskette drive 3. System board 006-195-XXX Diskette interface Test aborted by user Information only Re-start the test, if necessary 006-196-XXX Diskette interface test halt, error threshold 1.
Page 62 Diagnostic Error Code FRU/Action 011-196-XXX Serial port test halt, error threshold 1. Press F3 to review the log file exceeded 2. Re-start the test to reset the log file 011-197-XXX Serial port test warning 1. Make sure the component that is called out is connected and/or enabled.
Page 63 Diagnostic Error Code FRU/Action 014-197-XXX Parallel port test warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Using the Setup Utility program” on page 43 2. Re-run test 3. Replace the component that is called out in warning statement 4.
Page 64 Diagnostic Error Code FRU/Action 015-196-XXX USB port test halt, error threshold exceeded 1. Press F3 to review the log file 2. Re-start the test to reset the log file 015-197-XXX USB port test warning 1. Make sure the component that is called out is connected and/or enabled.
Page 65 Diagnostic Error Code FRU/Action 018-250-XXX PCI Card Services error 1. PCI card 2. Riser card, if installed 3. System board 020-000-XXX PCI Interface Test Passed No action 020-0XX-XXX PCI Interface error 1. PCI card 2. Riser card, if installed 3. System board 020-195-XXX PCI Test aborted by user Information only Re-start the test, if necessary 020-196-XXX PCI test halt, error threshold exceeded...
Page 66 Diagnostic Error Code FRU/Action 1. IDE signal cable 025-02X-XXX 025-03X-XXX 025-04X-XXX IDE Interface failure 2. Check power supply 3. Reseat IDE signal cable 4. IDE device 5. System board 025-195-XXX IDE interface Test aborted by user Information onlyRe-start the test, if necessary 025-196-XXX IDE interface test halt, error threshold 1.
Page 67 Diagnostic Error Code FRU/Action 030-196-XXX SCSI interface test halt, error threshold 1. Press F3 to review the log file exceeded 2. Re-start the test to reset the log file 030-197-XXX SCSI interface test warning 1. If a component is called out, make sure it is connected and/or enabled.
Page 68 Diagnostic Error Code FRU/Action 071-00X-XXX 071-01X-XXX 071-02X-XXXAudio port 1. Run Setup error 2. Flash the system. See “Updating (flashing) the BIOS from a disc” on page 365 3. System board 071-03X-XXX Audio port failure 1. Speakers 2. Microphone 3. Audio card, if installed 4.
Page 69 Diagnostic Error Code FRU/Action 1. Make sure the component that is called out is 080-197-XXX Game Port interface test warning connected and/or enabled. See Chapter 6 “Using the Setup Utility program” on page 43 2. Re-run test 3. Replace the component that is called out in warning statement 4.
Page 70 Diagnostic Error Code FRU/Action 086-199-XXX Mouse Port interface test failed, cause 1. See “Undetermined problems” on page 71 unknown 2. Flash the system and re-test. See “Updating (flashing) the BIOS from a disc” on page 365 3. Replace component under function test 089-000-XXX Microprocessor Test Passed No action 089-XXX-XXX Microprocessor failure...
Page 71 Diagnostic Error Code FRU/Action 170-199-XXX Voltage Sensor(s) test failed, cause 1. See “Undetermined problems” on page 71 unknown 2. Flash the system and re-test. See “Updating (flashing) the BIOS from a disc” on page 365 3. Replace component under function test 1.
Page 72 Diagnostic Error Code FRU/Action 1. Replace the memory module called out by the test 201-XXX-XXX System Memory error 2. System board No action 202-000-XXX System Cache Test Passed 202-XXX-XXX System Cache error 1. Cache, if removable 2. System board 3. Microprocessor 206-000-XXX Diskette Drive Test Passed No action 206-XXX-XXX Diskette Drive error...
Page 73: Beep Symptoms
Diagnostic Error Code FRU/Action No action 305-000-XXX Monitor DDC Test Passed 305-250-XXX Monitor DDC self test failure 1. Run Setup to enable DDC 2. Cable 3. Monitor 4. Video card 5. System board 415-000-XXXModem Test Passed No action 415-XXX-XXX Modem error Remove the Modem and re-test the system Beep symptoms Beep symptoms are tones or a series of tones separated by pauses (intervals without sound) during POST.
Page 74: Post Error Codes
POST error codes Each time you power-on the system, it performs a series of tests that check the operation of the system and some options. This series of tests is called the Power-On Self-Test, or POST. POST does the following operations.
Page 75: Miscellaneous Error Messages
POST Error Message Description/Action Pressing the TAB key permits the user to toggle between Press TAB to show POST screen the default POST display screen and a custom POST display screen. Error: Non-System disk or disk error Replace and press The BIOS was unable to find a suitable boot device.
Page 76 Message/Symptom FRU/Action "Insert a Diskette" icon appears with a known-good 1. System Board diagnostics diskette in the first 3.5-inch diskette drive. 2. Diskette Drive Cable 3. Network Adapter Intensity or color varies from left to right of characters 1. Display and color bars 2.
Page 77: Undetermined Problems
Undetermined problems If you encounter undetermined problems, do the following: 1. Turn off the computer and the power. 2. Remove or disconnect the following components (if installed) one at a time. a. External devices (modem, printer, or mouse) b. Any adapter cards c.
Page 78 ThinkCentre Hardware Maintenance Manual...
Page 79: Chapter 8. Replacing Frus (Machine Types: 0268, 1730, 1943, 4166, 4169, 5030, 5048, 5069, And 7517)
Locations This section provides information to help you locate your computer connectors, components, parts on the system board, and internal drives. Note: The components in your computer might look slightly different from the illustrations. © Copyright Lenovo 2011, 2012...
Page 80: Locating Connectors, Controls, And Indicators On The Front Of Your Computer
Locating connectors, controls, and indicators on the front of your computer Figure 1 “Front connector, control, and indicator locations” on page 74 shows the locations of the connectors, controls, and indicators on the front of your computer. Figure 1. Front connector, control, and indicator locations Hard disk drive activity indicator USB connector (USB port 1) Power indicator...
Page 81: Locating Connectors On The Rear Of Your Computer
Locating connectors on the rear of your computer Figure 2 “Rear connector locations” on page 75 shows the locations of the connectors on the rear of your computer. Some connectors on the rear of your computer are color-coded to help you determine where to connect the cables on your computer.
Page 82: Locating Components
Locating components Figure 3 “Component locations” on page 76 shows the locations of the various components in your computer. To remove the computer cover, see “Removing the computer cover” on page 79. Figure 3. Component locations Heat sink and fan assembly Hard disk drive Microprocessor PCI card (installed in some models)
Page 83: Locating Parts On The System Board
Locating parts on the system board Figure 4 “System board part locations” on page 77 shows the locations of the parts on the system board. Figure 4. System board part locations 4-pin power connector eSATA connector Microprocessor Power fan connector Microprocessor fan connector Front panel connector (for connecting LED indicators and power switch)
Page 84: Locating Internal Drives
Locating internal drives Internal drives are devices that your computer uses to read and store data. You can add drives to your computer to increase storage capacity and enable your computer to read other types of media. Internal drives are installed in bays. In this manual, the bays are referred to as bay 1, bay 2, and so on. When installing or replacing an internal drive, it is important to note the type and size of the drive that you can install or replace in each bay and correctly connect the cables to the drive installed.
Page 85: Installing Or Replacing Hardware
ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides Notes: 1. Use only computer parts provided by Lenovo. 2. When installing or replacing an option, use the appropriate instructions in this section along with the instructions that come with the option.
Page 86: Removing And Reinstalling The Front Bezel
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to remove and reinstall the front bezel.
Page 87: Installing Or Replacing A Pci Card
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to install or replace a PCI card. Your computer has two standard PCI card slots, one PCI Express x1 card slot, and one PCI Express x16 graphics card slot.
Page 88 3. At the rear of the computer, press the release button to open the card latch Figure 8. Opening the PCI card latch 4. Depending on whether you are installing or replacing a PCI card, do one of the following: •...
Page 89 Figure 9. Removing a PCI card Notes: a. The card fits tightly into the card slot. If necessary, alternate moving each side of the card a small amount until it is removed from the card slot. b. If the card is held in place by a retaining latch, press the card retaining latch as shown to disengage the latch.
Page 90: Installing Or Replacing A Memory Module
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to install or replace a memory module.
Page 91 • If you are replacing an old memory module, open the retaining clips and gently pull the memory module out of the memory slot. Figure 11. Removing a memory module • If you are installing a memory module, open the retaining clips of the memory slot into which you want to install the memory module.
Page 92: Installing Or Replacing The Optical Drive
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to install or replace the optical drive.
Page 93 • If you are replacing an optical drive, disconnect the signal cable and the power cable from the rear of the optical drive, press the blue release button, and then slide the optical drive out of the front of the computer. Figure 14.
Page 94: Installing Or Replacing The Card Reader
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to install or replace the card reader.
Page 95: Installing The Card Reader
Note: The card reader is only available in some models. For new installation, see “Installing the card reader” on page 89. For replacement, see “Replacing the card reader” on page 91. Installing the card reader To install the card reader, do the following: 1.
Page 96 7. Slide the card reader with retainer into the card reader drive bay until it snaps into position. Figure 20. Installing the card reader 8. Connect the card reader cable to Front USB connector 2 on the system board. See “Locating parts on the system board”...
Page 97: Replacing The Card Reader
Replacing the card reader To replace the card reader, do the following: 1. Remove all media from the drives and turn off all attached devices and the computer. Then, disconnect all power cords from electrical outlets and disconnect all cables that are connected to the computer. 2.
Page 98: Replacing The Battery
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides Your computer has a special type of memory that maintains the date, time, and configuration information for built-in features.
Page 99: Replacing The Power Supply Assembly
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the power supply assembly.
Page 100 DANGER Hazardous moving parts. Keep fingers and other body parts away. CAUTION: Never remove the cover on a power supply or any part that has the following label attached. Hazardous voltage, current, and energy levels are present inside any component that has this label attached.
Page 101: Replacing The Heat Sink And Fan Assembly
9. Install and tighten the four screws to secure the power supply assembly. Note: Use only screws provided by Lenovo. 10. Reconnect the power supply assembly cables to the system board and each of the drives.
Page 102 2. Remove the computer cover. See “Removing the computer cover” on page 79. 3. Lay the computer on its side for easier access to the system board. 4. Locate the heat sink and fan assembly. See “Locating parts on the system board” on page 77. 5.
Page 103: Replacing The Microprocessor
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the microprocessor.
Page 104 6. Lift the small handle and open the retainer to access the microprocessor Figure 29. Accessing the microprocessor 7. Lift the microprocessor straight up and out of the microprocessor socket. Figure 30. Removing the microprocessor Notes: a. Your microprocessor and socket might look different from the one illustrated. ThinkCentre Hardware Maintenance Manual...
Page 105 b. Note the orientation of the microprocessor in the socket. You can either look for the small triangle on one corner of the microprocessor or note the orientation of the notches on the microprocessor. This is important when installing the new microprocessor on the system board. c.
Page 106: Replacing The System Board
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the system board.
Page 107 8. Remove the eight screws that secure the system board. Figure 32. Removing the eight screws that secure the system board 9. Carefully slide the system board so that it can be released from the mounting studs that secure the system board in place.
Page 108 1. Release the lever securing the microprocessor retainer and open the retainer to access the microprocessor. 2. Grasp the microprocessor on the sides and lift it straight up and out of the socket. Do not touch the contacts on the microprocessor socket. 3.
Page 109: Replacing The Primary Hard Disk Drive
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the primary hard disk drive.
Page 110 9. To install a new hard disk drive into the blue bracket, flex the bracket and align pin , pin , pin and pin on the bracket with the corresponding holes in the hard disk drive. Do not touch the circuit board on the bottom of the hard disk drive.
Page 111: Replacing The Secondary Hard Disk Drive
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides Note: Depending on your model type, your computer might come with a secondary hard disk drive bay for installing or replacing a secondary hard disk drive.
Page 112 9. To install a new hard disk drive into the blue bracket, flex the bracket and align pin , pin , pin and pin on the bracket with the corresponding holes in the hard disk drive. Do not touch the circuit board on the bottom of the hard disk drive.
Page 113: Replacing The Front Fan Assembly
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the front fan assembly.
Page 114: Replacing The Rear Fan Assembly
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the rear fan assembly.
Page 115 5. The rear fan assembly is attached to the chassis by four rubber mounts. Remove the rear fan assembly by breaking or cutting the rubber mounts and gently pulling the rear fan assembly out of the chassis. Note: The new rear fan assembly will have four new rubber mounts attached. Figure 43.
Page 116: Replacing The Front Audio And Usb Assembly
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the front audio and USB assembly.
Page 117: Replacing The Internal Speaker
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the internal speaker.
Page 118 3. Locate the internal speaker connector on the system board. See “Locating parts on the system board” on page 77. 4. Disconnect the internal speaker cable from the system board. 5. Push the metal tab on the top of the internal speaker outward and slide the internal speaker upward to completely remove it from the chassis.
Page 119: Completing The Parts Replacement
6. Position the new internal speaker into the four metal clips and push downward on the internal speaker until it is secured in place. Figure 47. Installing a new internal speaker 7. Connect the internal speaker cable to the system board. See “Locating parts on the system board” on page 77.
Page 120 9. To update your configuration, refer to Chapter 6 “Using the Setup Utility program” on page 43. Note: In most areas of the world, Lenovo requires the return of the defective Field Replaceable Units (FRUs). Information about this will come with the new FRUs or will come a few days after you receive the new FRUs.
Page 121: Chapter 9. Replacing Frus (Machine Types: 0267, 0385, 1981, 4167, 5025, 5032, 5049, 5070, And 7518)
Locations This section provides information to help you locate your computer connectors, components, parts on the system board, and internal drives. Note: The components in your computer might look slightly different from the illustrations. © Copyright Lenovo 2011, 2012...
Page 122: Locating Connectors, Controls, And Indicators On The Front Of Your Computer
Locating connectors, controls, and indicators on the front of your computer Figure 49 “Front connector, control, and indicator locations” on page 116 shows the locations of the connectors, controls, and indicators on the front of your computer. Figure 49. Front connector, control, and indicator locations Optical drive eject/close button USB connector (USB port 2) Power switch...
Page 123: Locating Connectors On The Rear Of Your Computer
Locating connectors on the rear of your computer Figure 50 “Rear connector locations” on page 117 shows the locations of the connectors on the rear of your computer. Some connectors on the rear of your computer are color-coded to help you determine where to connect the cables on your computer.
Page 124: Locating Components
Locating components Figure 51 “Component locations” on page 118 shows the locations of the various components in your computer. To open the computer cover, see “Opening the computer cover” on page 121. Figure 51. Component locations Heat sink and fan assembly System fan assembly Microprocessor Internal speaker (installed in some models)
Page 125 Figure 52. System board part locations 4-pin power connector eSATA connector Microprocessor Power fan connector Microprocessor fan connector Front panel connector (for connecting LED indicators and power switch) Memory slot 1 (DIMM1) Front USB connector 1 (for connecting USB ports 1 and 2 on the front bezel) Memory slot 2 (DIMM2) Front USB connector 2 (for connecting additional USB...
Page 126: Locating Internal Drives
Locating internal drives Internal drives are devices that your computer uses to read and store data. You can add drives to your computer to increase storage capacity and enable your computer to read other types of media. Internal drives are installed in bays. In this manual, the bays are referred to as bay 1, bay 2, and so on. Your computer comes with the following factory-installed drives: •...
Page 127: Installing Or Replacing Hardware
ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides Notes: 1. Use only computer parts provided by Lenovo. 2. When installing or replacing an option, use the appropriate instructions in this section along with the instructions that come with the option.
Page 128: Removing And Reinstalling The Front Bezel
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to remove and reinstall the front bezel.
Page 129 3. Remove the front bezel by releasing the three plastic tabs on the top of the front bezel and pivoting the front bezel outward to remove it from the computer. Figure 55. Removing the front bezel Chapter 9 Replacing FRUs (Machine Types: 0267, 0385, 1981, 4167, 5025, 5032, 5049, 5070, and 7518)
Page 130: Accessing The System Board Components And Drives
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to access the system board components and drives.
Page 131: Installing Or Replacing A Memory Module
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to install or replace a memory module.
Page 132: Installing Or Replacing A Pci Card
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to install or replace a PCI card. Your computer has two standard PCI card slots, one PCI Express x1 card slot, and one PCI Express x16 graphics card slot.
Page 133 3. Rotate the PCI card retainer to the open position. 4. Depending on whether you are installing or replacing a PCI card, do one of the following: • If you are installing a PCI card, remove the appropriate metal slot cover. •...
Page 134: Installing Or Replacing The Card Reader
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to install or replace the card reader.
Page 135 5. Install the new card reader into the card reader bracket. Then install the two screws to secure the card reader to the bracket. 6. Install the card reader bracket to the chassis. Then push the bracket to the left to align the screw hole in the bracket with the corresponding hole in the chassis.
Page 136 7. Install the screw to secure the card reader bracket to the chassis. Figure 63. Installing the screw that secures the card reader 8. Pivot the optical drive bay upward and connect the card reader cable to one of the USB connectors on the system board.
Page 137 1. Remove all media from the drives and turn off all attached devices and the computer. Then, disconnect all power cords from electrical outlets and disconnect all cables that are connected to the computer. 2. Open the computer cover. See “Opening the computer cover” on page 121. 3.
Page 138 9. Install the card reader bracket to the chassis. Then push the bracket to the left to align the screw hole in the bracket with the corresponding hole in the chassis. Figure 66. Installing the card reader ThinkCentre Hardware Maintenance Manual...
Page 139: Replacing The Battery
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides Your computer has a special type of memory that maintains the date, time, and configuration information for built-in features.
Page 140: Replacing The Hard Disk Drive
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the hard disk drive.
Page 141 4. Pull on the handle of the hard disk drive bracket as shown and then lift the hard disk drive bracket up from the optical drive bay. Figure 70. Removing the hard disk drive 5. Disconnect the signal cable and the power cable from the hard disk drive to completely remove the hard disk drive from the chassis.
Page 142 7. To install a new hard disk drive into the bracket, flex the bracket and align pin , pin , pin , and pin on the bracket with the corresponding holes in the hard disk drive. Important: Do not touch the circuit board on the bottom of the hard disk drive.
Page 143: Replacing The Optical Drive
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the optical drive.
Page 144 7. Press the optical drive lock and slide the optical drive out of the rear of the drive bay assembly. Figure 74. Removing the old optical drive 8. Install the optical drive retainer on the side of the new optical drive. Figure 75.
Page 145: Replacing The Heat Sink And Fan Assembly
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the heat sink and fan assembly.
Page 146 4. Follow this sequence to remove the four screws that secure the heat sink and fan assembly to the system board: a. Partially remove screw , then fully remove screw , and then fully remove screw b. Partially remove screw , then fully remove screw , and then fully remove screw Note: Carefully remove the four screws from the system board to avoid any possible damage to the...
Page 147 6. Remove the two screws that secure the heat sink fan duct. Then remove the heat sink fan duct from the failing heat sink and fan assembly. Figure 78. Removing the heat sink fan duct 7. Place the new heat sink and fan assembly on the system board so that the four screws are aligned with the corresponding holes in the system board.
Page 148: Replacing The Power Supply Assembly
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the power supply assembly.
Page 149 DANGER Hazardous moving parts. Keep fingers and other body parts away. CAUTION: Never remove the cover on a power supply or any part that has the following label attached. Hazardous voltage, current, and energy levels are present inside any component that has this label attached.
Page 150 5. Remove the two screws that secure the heat sink fan duct, and then lift the heat sink fan duct out of the chassis. Figure 80. Removing the heat sink fan duct ThinkCentre Hardware Maintenance Manual...
Page 151 6. Pivot the optical drive upward and disconnect the power supply assembly cables from all drives and from power connectors on the system board. Figure 81. Power connectors on the system board Note: You might also need to release the power supply assembly cables from some cable clips or ties that secure the cables to the chassis.
Page 152 Then, install the three screws to secure the new power supply assembly in place. Note: Use only screws provided by Lenovo. Figure 83. Installing the power supply assembly 10.
Page 153: Replacing The Microprocessor
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the microprocessor.
Page 154 3. Locate the system board and disconnect all cables connected to the system board. See “Locating parts on the system board” on page 77. 4. Remove the heat sink and fan assembly with the fan duct. See “Replacing the heat sink and fan assembly”...
Page 155 b. Note the orientation of the microprocessor in the socket. You can either look for the small triangle on one corner of the microprocessor or note the orientation of the notches on the microprocessor. This is important when installing the new microprocessor on the system board. c.
Page 156: Replacing The System Board
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the system board.
Page 157 4. Remove the hard disk drive. See “Replacing the hard disk drive” on page 134. 5. Pivot the optical drive bay assembly upward to gain access to the system board. See “Accessing the system board components and drives” on page 124. 6.
Page 158 16. Lower the optical drive bay assembly. See “Accessing the system board components and drives” on page 124. 17. Install the hard disk drive. See “Replacing the hard disk drive” on page 134. 18. To complete the replacement, go to “Completing the parts replacement” on page 113. The failing system board must be returned with a microprocessor socket cover to protect the pins during shipping and handling.
Page 159: Replacing The System Fan Assembly
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the system fan assembly.
Page 160 6. The system fan assembly is attached to the chassis by four rubber mounts. Remove the system fan assembly by cutting the rubber mounts and lifting the system fan assembly out of the chassis. Note: The new system fan assembly will have four new rubber mounts attached. Figure 92.
Page 161: Replacing The Internal Speaker
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the internal speaker.
Page 162 6. Remove the screw that secures the cover presence switch (intrusion switch) and remove the cover presence switch from the chassis. Figure 95. Removing the cover presence switch ThinkCentre Hardware Maintenance Manual...
Page 163 7. Push the internal speaker outward through the hole to disengage it from the two metal tabs on the chassis. Then, slide the internal speaker to the right to remove it from the chassis. Figure 96. Removing the internal speaker 8.
Page 164 Figure 97. Installing the new internal speaker 9. Reconnect the internal speaker cable to the system board. See “Locating parts on the system board” on page 77. 10. Position the cover presence switch so that the screw hole in the cover presence switch is aligned with the corresponding hole in the chassis.
Page 165: Replacing The Front Audio And Usb Assembly
Do not open your computer or attempt any repair before reading and understanding the “Important safety information” in the ThinkCentre User Guide. To obtain a copy of the ThinkCentre User Guide, go to: http://www.lenovo.com/ThinkCentreUserGuides This section provides instructions on how to replace the front audio and USB assembly.
Page 166: Completing The Parts Replacement
4. Pivot the optical drive bay upward and disconnect the front audio and USB assembly cables from the system board and note the cables routing. See “Locating parts on the system board” on page 77. 5. Remove the screw that secures the front audio and USB assembly bracket. Then remove the front audio and USB assembly bracket from the chassis.
Page 167 8. To update your configuration, see Chapter 6 “Using the Setup Utility program” on page 43. Note: In most areas of the world, Lenovo requires the return of the defective Field Replaceable Units (FRUs). Information about this will come with the new FRUs or will come a few days after you receive the new FRUs.
Page 168 ThinkCentre Hardware Maintenance Manual...
Page 169: Chapter 10. Fru Lists
Optional-service CRU. Overall: MT 0267, 0385, 1981, 4167, 5025, 5032, 5049, 5070, and 7518 The following replaceable components are available for the 0267, 0385, 1981, 4167, 5025, 5032, 5049, 5070, and 7518 machine type models. © Copyright Lenovo 2011, 2012...
Page 170 Item # FRUs FRU # LX-323 Intel 95W thermal kit • MT 0385: all models • MT 1981: all models • MT 4167: all models • MT 5025: all models • MT 5032: all models • MT 5049: all models •...
Page 171 Item # FRUs FRU # Microprocessor, Ci7 2600 sandy bridge stepping D2 8MB 4c FCLGA 3.4GHZ 95W vPro • MT 0385: • MT 1981: CTO • MT 4167: A7G A8G A9G • MT 5025: A7G A8G • MT 5032: B6M C1A C1T C4U C4F C4S A7V D4M •...
Page 172 Item # FRUs FRU # Microprocessor, Ci5 2300 sandy bridge stepping D2 6MB 4c FCLGA 2.8GHZ • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T8035 Microprocessor, Ci7 2600S sandy bridge stepping D2 8MB 4c FCLGA 2.8GHZ 65W vPro...
Page 173 Item # FRUs FRU # Microprocessor, G620 sandy bridge stepping Q-0 3MB 2c FCLGA 2.6GHz • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: D7M E4M D8V D9V • MT 5049: E9U E9F E9S •...
Page 174 Item # FRUs FRU # • MT 5049: C7M C8M C9M C2H C3H C4H C5H C6A C6T A8S A8D A8Y A9S A9D A9Y B1S B1D B1Y D1A D1T D2A D2T D7G A1G D3U D3F D3S D3P D3L D3D D3Y D4U D4F D4S D5U D5F D5S D6U D6F D6S B4G B5G B6G B7G B8G B9G C1G B2Q B3Q E1S E1D E1Y E2S E2D E2Y E3P E4A E4T F1U F1F F1S E7U E7F E7S E8U E8F E8S E9U E9F E9S E5G E6G F2J F3J F4J F5J F6J F7J F8G D7P G3P G4P D3A D4A D3T D4T G1J G2J...
Page 175 Item # FRUs FRU # Memory module, 1GB PC3-10600 1333MHz DDR3 UDIMM • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 64Y6648 Memory module, 2GB PC3-10600 1333MHz DDR3 UDIMM •...
Page 176 Item # FRUs FRU # Optical drive, DVD-ROM Drive - 16x/48x - SATA • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: A3V A4V E1M D7M E5M D8V D9V F1M • MT 5049: C3H C4H F3J F5J F7J G1J H1J H6J H8J •...
Page 177 Item # FRUs FRU # F1S E7U E7F E7S E8U E8F E8S E9U E9F E9S E5G E6G F2J F4J F6J F8G D7P G3P G4P D3A D4A D3T D4T G2J G5A G5T • MT 5070: D8G • MT 7518: A1S A1D A1Y A2S A2D A2Y A3D A3S A3Y A8U A8F A8S A9U A9F A9S B1U B1F B1S B2U B2F B2S C1S C1D C1Y C2S C2D C2Y C3S C3D C3Y C4S C4D C4Y C5U C5F C5S D2U D2F D2S D3U D3F D3S D1U D1F D1S B7U B7F B7S B6U B6F B6S B3S B4S B5S...
Page 178 Item # FRUs FRU # Internal speaker, 400mm 40*28.5 internal speaker cable • MT 0385: all models • MT 1981: all models • MT 4167: all models • MT 5025: all models • MT 5032: all models • MT 5049: all models •...
Page 179 Item # FRUs FRU # SATA 250GB 7200RPM/3Gb/8M • MT 0385: • MT 1981: • MT 4167: • MT 5025: • MT 5032: B3M B1A B1T B2A B2T C6Q B7A B7T C2U C2F C2S A1Q A2Q E1M E4M D6A D6T E8M F1M F3A F3T F2A F2T G2M G3M G4M •...
Page 180 Item # FRUs FRU # SATA 320GB 7200 RPM/3Gb/8M • MT 0385: A1U A1F A1S A1P A1L A1D A1Y A1G A1M A1A A1Q A1T A1C A1B A1H A1V A1K A1R A1E A1J A2U A2F A2S A2L A2D A2Y A2G A2M A2A A2Q A2T A2B A2H A2V A2K A2R A2E A2J A2P A2C •...
Page 181 Item # FRUs FRU # SATA 1TB 7200RPM/3Gb/32M • MT 0385: • MT 1981: • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 45K0412 SATAIII 320GB 7200RPM/6Gb/16M • MT 0385: A1U A1F A1S A1P A1L A1D A1Y A1G A1M A1A A1Q A1T A1C A1B A1H A1V A1K A1R A1E A1J A2U A2F A2S A2L A2D A2Y A2G A2M A2A A2Q A2T A2B A2H A2V A2K A2R A2E A2J A2P A2C •...
Page 182 Item # FRUs FRU # SATAIII 1TB 7200RPM/6Gb/32M • MT 0385: • MT 1981: • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T7042 2.5 inch 160G SATA SSD • MT 0385: •...
Page 183 Item # FRUs FRU # SATAIII 250GB 7200RPM/6Gb/16M • MT 0385: • MT 1981: • MT 4167: B1A B1T • MT 5025: A9G A1G A2G • MT 5032: B3M B1A B1T B2A B2T C6Q B7A B7T C2U C2F C2S A1Q A2Q E1M E4M D6A D6T E8M F1M F3A F3T F2A F2T •...
Page 184: Mechanical Frus
Mechanical FRUs The FRUs listed in the following tables are not illustrated. Mechanical FRUs FRU # FRU, LX-323 fan duct • MT 0385: all models • MT 4167: all models • MT 5025: all models 03T9509 • MT 5032: all models •...
Page 185 Mechanical FRUs FRU # FRU, LED/switch cable (11L_420mm) • MT 0385: all models • MT 4167: all models • MT 5025: all models 54Y9916 • MT 5032: all models • MT 5049: all models • MT 5070: all models • MT 7518: all models FRU, optical bezel assembly •...
Page 186 Mechanical FRUs FRU # FRU, card reader bezel • MT 0385: all models • MT 4167: all models • MT 5025: all models 03T9600 • MT 5032: all models • MT 5049: all models • MT 5070: all models • MT 7518: all models FRU, second serial port cable 120mm with level shift IC •...
Page 187 Mechanical FRUs FRU # FRU, PS2 cable (170mm) • MT 0385: all models • MT 4167: all models • MT 5025: all models 43N9149 • MT 5032: all models • MT 5049: all models • MT 5070: all models • MT 7518: all models FRU, rear USB cable_R_200mm_LP •...
Page 188 Mechanical FRUs FRU # FRU, daughter card for slim ODD and 2HDD bracket • MT 0385: all models • MT 4167: all models • MT 5025: all models 71Y6841 • MT 5032: all models • MT 5049: all models • MT 5070: all models •...
Page 189 Mechanical FRUs FRU # FRU, universal 2nd HDD bezel • MT 0385: all models • MT 4167: all models • MT 5025: all models 03T9608 • MT 5032: all models • MT 5049: all models • MT 5070: all models •...
Page 190 Mechanical FRUs FRU # FRU, mechanical kit • MT 0385: all models • MT 4167: all models • MT 5025: all models 03T9585 • MT 5032: all models • MT 5049: all models • MT 5070: all models • MT 7518: all models FRU, mechanical chassis without front bezel •...
Page 191: Keyboard And Mouse
Mechanical FRUs FRU # FRU, top cover assembly • MT 0385: all models • MT 4167: all models • MT 5025: all models 03T9591 • MT 5032: all models • MT 5049: all models • MT 5070: all models • MT 7518: all models FRU, bottom assembly •...
Page 192 Keyboard - Preferred Pro PS/2 FRU # • MT 5032: • MT 5049: • MT 5070: • MT 7518: PS/2--Arabic/French • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: •...
Page 193 Keyboard - Preferred Pro PS/2 FRU # PS/2--Bulgarian • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41A5045 PS/2--Chinese/US • MT 0385: • MT 1981: CTO •...
Page 194 Keyboard - Preferred Pro PS/2 FRU # PS/2--Dutch • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41A5049 PS/2--French • MT 0385: • MT 1981: CTO •...
Page 195 Keyboard - Preferred Pro PS/2 FRU # PS/2--German • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41A5053 PS/2--Greek • MT 0385: • MT 1981: CTO •...
Page 196 Keyboard - Preferred Pro PS/2 FRU # PS/2--Hungarian • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41A5056 PS/2--Iceland • MT 0385: • MT 1981: CTO •...
Page 197 Keyboard - Preferred Pro PS/2 FRU # PS/2--Korean • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41A5060 PS/2--LA Spanish • MT 0385: • MT 1981: CTO •...
Page 198 Keyboard - Preferred Pro PS/2 FRU # PS/2--Portuguese • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41A5064 PS/2--Romanian • MT 0385: • MT 1981: CTO •...
Page 199 Keyboard - Preferred Pro PS/2 FRU # PS/2--Slovak • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41A5068 PS/2--Spanish • MT 0385: • MT 1981: CTO •...
Page 200 Keyboard - Preferred Pro PS/2 FRU # PS/2--Thailand • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41A5072 PS/2--Turkish • MT 0385: • MT 1981: CTO •...
Page 201 Keyboard - Preferred Pro PS/2 FRU # PS/2--US European • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41A5076 PS/2--Slovenian • MT 0385: • MT 1981: CTO •...
Page 202 Keyboard -Preferred Pro USB FRU # • MT 7518: A8U A9U B1U B2U C5U D2U D3U D1U B7U B6U D6U D4U D5U D7U D8U Arabic • MT 0385: A1G A2G • MT 1981: CTO • MT 4167: A1G A2G A3G A4G A5G A6G A7G A8G A9G B2G B3G B4G B5G •...
Page 203 Keyboard -Preferred Pro USB FRU # Brazilian Portuguese • MT 0385: A1P A2P • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: D3P E3P D7P G3P G4P G7P • MT 5070: • MT 7518: 41A5294 Bulgarian •...
Page 204 Keyboard -Preferred Pro USB FRU # Danish • MT 0385: A1G A2G • MT 1981: CTO • MT 4167: A1G A2G A3G A4G A5G A6G A7G A8G A9G B2G B3G B4G B5G • MT 5025: A9G A1G A2G A3G A4G A5G A6G A7G A8G B1G •...
Page 205 Keyboard -Preferred Pro USB FRU # French Canadian • MT 0385: A1F A2F • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: C2F C3F C4F • MT 5049: D3F H3F H4F • MT 5070: • MT 7518: A8F A9F B1F B2F C5F D2F D3F D1F B7F B6F D4F D5F D6F D7F D8F D9F 41A5302 German •...
Page 206 Keyboard -Preferred Pro USB FRU # Hebrew • MT 0385: A1G A2G • MT 1981: CTO • MT 4167: A1G A2G A3G A4G A5G A6G A7G A8G A9G B2G B3G B4G B5G • MT 5025: A9G A1G A2G A3G A4G A5G A6G A7G A8G B1G •...
Page 207 Keyboard -Preferred Pro USB FRU # Japanese • MT 0385: A1J A2J • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: F2J F3J F4J F5J F6J F7J G1J G2J H1J H2J H6J H7J H8J H9J •...
Page 208 Keyboard -Preferred Pro USB FRU # Polish • MT 0385: A1G A2G • MT 1981: CTO • MT 4167: A1G A2G A3G A4G A5G A6G A7G A8G A9G B2G B3G B4G B5G • MT 5025: A9G A1G A2G A3G A4G A5G A6G A7G A8G B1G •...
Page 209 Keyboard -Preferred Pro USB FRU # Russian/Cyrillic • MT 0385: A1G A2G • MT 1981: CTO • MT 4167: A1G A2G A3G A4G A5G A6G A7G A8G A9G B2G B3G B4G B5G • MT 5025: A9G A1G A2G A3G A4G A5G A6G A7G A8G B1G •...
Page 210 Keyboard -Preferred Pro USB FRU # Swedish/Finnish • MT 0385: A1G A2G • MT 1981: CTO • MT 4167: A1G A2G A3G A4G A5G A6G A7G A8G A9G B2G B3G B4G B5G • MT 5025: A9G A1G A2G A3G A4G A5G A6G A7G A8G B1G •...
Page 211 Keyboard -Preferred Pro USB FRU # Turkish • MT 0385: A1G A2G • MT 1981: CTO • MT 4167: A1G A2G A3G A4G A5G A6G A7G A8G A9G B2G B3G B4G B5G • MT 5025: A9G A1G A2G A3G A4G A5G A6G A7G A8G B1G •...
Page 212 Keyboard -Preferred Pro USB FRU # Arabic (New) • MT 0385: A1G A2G • MT 1981: CTO • MT 4167: A1G A2G A3G A4G A5G A6G A7G A8G A9G B2G B3G B4G B5G • MT 5025: A9G A1G A2G A3G A4G A5G A6G A7G A8G B1G •...
Page 213 Keyboard -Fingerprint FRU # US English/Chinese-Simplified • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03X8001 Arabic • MT 0385: • MT 1981: CTO •...
Page 214 Keyboard -Fingerprint FRU # Belgium English • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03X8005 Brazilian Portuguese • MT 0385: • MT 1981: CTO •...
Page 215 Keyboard -Fingerprint FRU # Czech (ABB) • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03X8009 Danish • MT 0385: • MT 1981: CTO •...
Page 216 Keyboard -Fingerprint FRU # French Canadian • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03X8013 French Canadian • MT 0385: • MT 1981: CTO •...
Page 217 Keyboard -Fingerprint FRU # Greek/US • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03X8017 Hebrew • MT 0385: • MT 1981: CTO • MT 4167: •...
Page 218 Keyboard -Fingerprint FRU # Italy • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03X8021 Japanese • MT 0385: • MT 1981: CTO • MT 4167: •...
Page 219 Keyboard -Fingerprint FRU # Norwegian • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03X8025 Polish • MT 0385: • MT 1981: CTO • MT 4167: •...
Page 220 Keyboard -Fingerprint FRU # Romanian • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03X8039 Russian/Cyrillic • MT 0385: • MT 1981: CTO • MT 4167: •...
Page 221 Keyboard -Fingerprint FRU # Spanish • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03X8030 Swedish/Finnish • MT 0385: • MT 1981: CTO • MT 4167: •...
Page 222 Keyboard -Fingerprint FRU # Turkish • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03X8041 Turkish • MT 0385: • MT 1981: CTO • MT 4167: •...
Page 223 Keyboard -Fingerprint FRU # • MT 5049: • MT 5070: • MT 7518: Keyboard -Slim USB FRU # Slim USB--US English/Chinese-Simplified • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: •...
Page 224 Keyboard -Slim USB FRU # Slim USB--Belgium English • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 54Y9254 Slim USB--Brazilian Portuguese • MT 0385: •...
Page 225 Keyboard -Slim USB FRU # Slim USB--Czech (ABB) • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 54Y9258 Slim USB--Danish • MT 0385: • MT 1981: CTO •...
Page 226 Keyboard -Slim USB FRU # Slim USB--French Canadian • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 54Y9262 Slim USB--French Canadian • MT 0385: •...
Page 227 Keyboard -Slim USB FRU # Slim USB--Greek/US • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 54Y9266 Slim USB--Hebrew • MT 0385: • MT 1981: CTO •...
Page 228 Keyboard -Slim USB FRU # Slim USB--Italy • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 54Y9270 Slim USB--Japanese • MT 0385: • MT 1981: CTO •...
Page 229 Keyboard -Slim USB FRU # Slim USB--Norwegian • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 54Y9274 Slim USB--Polish • MT 0385: • MT 1981: CTO •...
Page 230 Keyboard -Slim USB FRU # Slim USB--Russian/Cyrillic • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 54Y9278 Slim USB--Serbian/Cyrillic • MT 0385: • MT 1981: CTO •...
Page 231 Keyboard -Slim USB FRU # Slim USB--Swedish/Finnish • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 54Y9282 Slim USB--Swiss French/German • MT 0385: • MT 1981: CTO •...
Page 232 Keyboard -Slim USB FRU # Slim USB--Turkish • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 54Y9286 Slim USB--UK English • MT 0385: • MT 1981: CTO •...
Page 233 • MT 7518: 51J0061 Lenovo enhanced optical USB Mouse • MT 0385: A1U A1F A1S A1P A1L A1D A1Y A1G A1M A1A A1Q A1T A1C A1B A1H A1V A1K A1R A1E A1J A2U A2F A2S A2L A2D A2Y A2G A2M A2A A2Q A2T A2B A2H A2V A2K A2R A2E A2J A2P A2C •...
Page 234: Adapters And Miscellaneous Frus
Mice FRU # • MT 5070: D8G • MT 7518: A1S A1D A1Y A2S A2D A2Y A3D A3S A3Y A8U A8F A8S A9U A9F A9S B1U B1F B1S B2U B2F B2S C1S C1D C1Y C2S C2D C2Y C3S C3D C3Y C4S C4D C4Y C5U C5F C5S D2U D2F D2S D3U D3F D3S D1U D1F D1S B7U B7F B7S B6U B6F B6S B3S B4S B5S D6U D6S D6F D4U D4F D4S D5U D5S D5F D7U D7F D7S D8U D8F D8S D9U D9F D9S...
Page 235 Adapters and miscellaneous FRUs FRU # DVI_I(M)-VGA(F) adpater • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 54Y8255 PCI-E IEEE 1394 firewire adapter (ATX) •...
Page 236 Adapters and miscellaneous FRUs FRU # Lenovo branded speakers • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41A5334 Speaker power brick • MT 0385: •...
Page 237 Adapters and miscellaneous FRUs FRU # NVIDIA Quadro FX380 (DVI + DP) LP • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 64Y8206 HD6450 DVI+DP LP •...
Page 238: Power Cords
Adapters and miscellaneous FRUs FRU # NVIDIA GeForce310 512M DMS59 (LP) • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 89Y9227 DMS59 to Dual DVI Dongle •...
Page 239 Power Cords --primary FRU # • MT 5049: • MT 5070: • MT 7518: Line cord-Japan • MT 0385: A1J A2J • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: F2J F3J F4J F5J F6J F7J G1J G2J H1J H2J H6J H7J H8J H9J •...
Page 240 Power Cords --primary FRU # Line cord-Korea • MT 0385: A1K A1R A2K A2R • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 41R3260 Line cord-Taiwan • MT 0385: A1V A2V •...
Page 241 Power Cords --primary FRU # Line cord-Switzerland • MT 0385: A1G A2G • MT 1981: CTO • MT 4167: A1G A2G A3G A4G A5G A6G A7G A8G A9G B2G B3G B4G B5G • MT 5025: A9G A1G A2G A3G A4G A5G A6G A7G A8G B1G •...
Page 242 Power Cords --primary FRU # Line cord-Indonesia, Laos, Cambodia and Vietnam, Austria, Belgium, Croatia, Czechoslovakia, Finland, France, Germany, Hungary, Netherlands, Norway, Poland, Portugal, Romania, Spain, Sweden • MT 0385: A1A A2A • MT 1981: CTO • MT 4167: B1A • MT 5025: •...
Page 243 Power Cords --secondary FRU # • MT 5070: • MT 7518: A1S A1D A2S A2D A3D A3S A8U A8F A8S A9U A9F A9S BIU BIF BIS B2U B2F B2S C1S C1D C2S C2D C3S C3D C4S C4D C5U C5F C5S D2U D2F D2S D3U D3F D3S D1U D1F D1S B7U B7F B7S B6U B6F B6S B3S B4S B5S D6U D6S D6F D4U D4F D4S D5U D5S D5F D7U D7F D7S D8U D8F D8S D9U D9F D9S Line cord-China...
Page 244 Power Cords --secondary FRU # Line cord-ANZ • MT 0385: A1M A2M • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: B3M B4M B5M B6M A9M D1M D3M D4M D5M E1M D7M E4M E5M E6M E7M E8M E9M F1M F4M F5M F9M G1M G2M G3M G4M •...
Page 245 Power Cords --secondary FRU # Line cord-Denmark • MT 0385: A1G A2G • MT 1981: CTO • MT 4167: A1G A2G A3G A4G A5G A6G A7G A8G A9G B2G B3G B4G B5G • MT 5025: A9G A1G A2G A3G A4G A5G A6G A7G A8G B1G •...
Page 246 Power Cords --secondary FRU # Line cord-India • MT 0385: A1Q A2Q • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: C6Q A1Q A2Q • MT 5049: B2Q B3Q • MT 5070: • MT 7518: 41R3175 Line cord-Indonesia, Laos, Cambodia and Vietnam, Austria, Belgium, Croatia, Czechoslovakia, Finland, France, Germany, Hungary, Netherlands, Norway, Poland, Portugal, Romania, Spain, Sweden...
Page 247: Recovery Discs
Recovery discs Windows 7 Home Premium 32 Recovery CD Windows 7 Home Premium 32 FRU # Chinese Traditional • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: •...
Page 248 Windows 7 Home Premium 32 FRU # Hebrew • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0799 Hong Kong • MT 0385: • MT 1981: CTO •...
Page 249 Windows 7 Home Premium 32 FRU # Korean • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0803 Portuguese • MT 0385: • MT 1981: CTO •...
Page 250: Windows 7 Professional 32 Recovery Cd
Windows 7 Home Premium 32 FRU # US English • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0807 C&L Nordics (DK/FI/SV/NO/EN) • MT 0385: •...
Page 251 Windows 7 Professional 32 FRU # • MT 7518: D3U D6U Chinese-Traditional (Hong Kong) • MT 0385: A1B • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0778 Japanese •...
Page 252 Windows 7 Professional 32 FRU # Italian • MT 0385: A1G • MT 1981: CTO • MT 4167: B3G B5G • MT 5025: • MT 5032: • MT 5049: B5G B6G B8G B9G C1G E6G • MT 5070: • MT 7518: 03T0780 Brazilian Portuguese •...
Page 253 Windows 7 Professional 32 FRU # C&L Nordics (EN DK FI NO SV) • MT 0385: A1G • MT 1981: CTO • MT 4167: B3G B5G • MT 5025: • MT 5032: • MT 5049: B5G B6G B8G B9G C1G E6G •...
Page 254 Windows 7 Professional 32 FRU # Russian • MT 0385: A1G • MT 1981: CTO • MT 4167: B3G B5G • MT 5025: • MT 5032: • MT 5049: B5G B6G B8G B9G C1G E6G • MT 5070: • MT 7518: 03T0786 Polish •...
Page 255 Windows 7 Professional 32 FRU # Greek • MT 0385: A1G • MT 1981: CTO • MT 4167: B3G B5G • MT 5025: • MT 5032: • MT 5049: B5G B6G B8G B9G C1G E6G • MT 5070: • MT 7518: 03T0775 Turkish •...
Page 256 Windows 7 Professional 32 FRU # Hungarian • MT 0385: A1G • MT 1981: CTO • MT 4167: B3G B5G • MT 5025: • MT 5032: • MT 5049: B5G B6G B8G B9G C1G E6G • MT 5070: • MT 7518: 03T0779 Czech •...
Page 257: Windows 7 Professional 64 Recovery Cd
Windows 7 Professional 32 FRU # Portuguese • MT 0385: A1G • MT 1981: CTO • MT 4167: B3G B5G • MT 5025: • MT 5032: • MT 5049: B5G B6G B8G B9G C1G E6G • MT 5070: • MT 7518: 03T0784 C&L Croatian (EN/SL/CR) •...
Page 258 Windows 7 Professional 64 FRU # Czech • MT 0385: A2G • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: D7G A1G E5G F8G G6G G8G H5G • MT 5070: • MT 7518: 03T0829 India English •...
Page 259 Windows 7 Professional 64 FRU # German • MT 0385: A2G • MT 1981: CTO • MT 4167: A2G A3G A4G A5G A9G • MT 5025: A9G A2G A3G A5G A6G A7G A8G B1G • MT 5032: C5G • MT 5049: D7G A1G E5G F8G G6G G8G H5G •...
Page 260 Windows 7 Professional 64 FRU # Italian • MT 0385: A2G • MT 1981: CTO • MT 4167: A2G A3G A4G A5G A9G • MT 5025: A9G A2G A3G A5G A6G A7G A8G B1G • MT 5032: C5G • MT 5049: D7G A1G E5G F8G G6G G8G H5G •...
Page 261 Windows 7 Professional 64 FRU # Portuguese • MT 0385: A2G • MT 1981: CTO • MT 4167: A2G A3G A4G A5G A9G • MT 5025: A9G A2G A3G A5G A6G A7G A8G B1G • MT 5032: C5G • MT 5049: D7G A1G E5G F8G G6G G8G H5G •...
Page 262 Windows 7 Professional 64 FRU # Sebian-latin • MT 0385: A2G • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: D7G A1G E5G F8G G6G G8G H5G • MT 5070: • MT 7518: 03T0845 Turkish •...
Page 263: Windows 7 Home Basic 32 Recovery Cd
Windows 7 Professional 64 FRU # C&L EMEA (NL/FR/GR/IT/EN) • MT 0385: A2G • MT 1981: CTO • MT 4167: A2G A3G A4G A5G A9G • MT 5025: A9G A2G A3G A5G A6G A7G A8G B1G • MT 5032: C5G •...
Page 264 Windows 7 Home Basic 32 FRU # India English • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0812 Russian • MT 0385: • MT 1981: CTO •...
Page 265: Windows 7 Home Premium 64 Recovery Cd
Windows 7 Home Basic 32 FRU # Turkish • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0816 US English • MT 0385: • MT 1981: CTO •...
Page 266: Windows 7 Ultimate 32 Recovery Cd
Windows 7 Home Premium 64 FRU # • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: Windows 7 Ultimate 32 Recovery CD Windows 7 Ultimate 32 FRU # India English • MT 0385: •...
Page 267: Windows 7 Starter 32 Recovery Cd
Windows 7 Ultimate 64 FRU # • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: Windows 7 Starter 32 Recovery CD Windows 7 Starter 32 FRU # Arabic •...
Page 268: Windows Xp Professional 32 Recovery Cd
Windows 7 Starter 32 FRU # Russian • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0823 Spanish • MT 0385: • MT 1981: CTO •...
Page 269 Windows XP Professional 32 FRU # Japanese • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0590 English • MT 0385: • MT 1981: CTO •...
Page 270 Windows XP Professional 32 FRU # Czech • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0740 Denmark • MT 0385: • MT 1981: CTO •...
Page 271 Windows XP Professional 32 FRU # German • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0744 Hong Kong • MT 0385: • MT 1981: CTO •...
Page 272 Windows XP Professional 32 FRU # Polish • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T0748 Russian • MT 0385: • MT 1981: CTO •...
Page 273: Windows Xp Professional Generic Recovery Cd
Windows XP Professional 32 FRU # • MT 5049: • MT 5070: • MT 7518: Windows XP Professional Generic Recovery CD Note: The Windows XP Professional recovery DVDs are available only for models with a valid Microsoft Windows XP Professional certificate of authenticity (COA) affixed to the system. Due to a Microsoft licensing limitation, if a model came with Windows XP Professional preinstalled from the factory, but has either a Windows 7 or Windows Vista COA affixed to the system, that model is eligible only for recovery DVDs that match the operating system specified on the COA.
Page 274: Windows Vista Business 32 Recovery Cd
Windows XP Professional Generic FRU # Korean • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03W7489 Dutch • MT 0385: • MT 1981: CTO •...
Page 275: Windows Vista Home Basic 32 Recovery Cd
Windows Vista Business 32 FRU # India English • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T1320 English • MT 0385: • MT 1981: CTO •...
Page 276 Windows Vista Home Basic 32 FRU # • MT 5070: • MT 7518: German • MT 0385: • MT 1981: CTO • MT 4167: • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: 03T1324 Italian •...
Page 277: Overall: 0268, 1730, 1943, 4166, 4169, 5030, 5048, 5069, And 7517
Windows Vista Home Basic 32 FRU # • MT 5025: • MT 5032: • MT 5049: • MT 5070: • MT 7518: Overall: 0268, 1730, 1943, 4166, 4169, 5030, 5048, 5069, and 7517 The following replaceable components are available for the 0268, 1730, 1943, 4166, 4169, 5030, 5048, 5069, and 7517 machine type models.
Page 278 Item # FRUs FRU # • MT 4169: all models • MT 5030: all models • MT 5048: all models • MT 7517: all models Microprocessor, Ci3 2100 sandy bridge stepping Q0 3MB 2c FCLGA 3.1GHZ • MT 1730: • MT 1943: CTO •...
Page 279 Item # FRUs FRU # Microprocessor, Ci5 2400 sandy bridge stepping D2 6MB 4c FCLGA 3.1GHZ 95W vPro • MT 1730: A2U A2F A2S A2L A2D A2Y A2G A2M A2A A2Q A2T A2B A2H A2V A2K A2R A2E A2J A2P A2C •...
Page 280 Item # FRUs FRU # Microprocessor, Ci5 2400S sandy bridge stepping D2 6MB 4c FCLGA 2.5GHZ 65W vPro • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T8017 Microprocessor, G620 sandy bridge stepping Q-0 3MB 2c FCLGA 2.6GHz 65W •...
Page 281 Item # FRUs FRU # Memory module, 2GB PC3-10600 1333MHz DDR3 UDIMM • MT 1730: A2U A2F A2S A2L A2D A2Y A2G A2M A2A A2Q A2T A2B A2H A2V A2K A2R A2E A2J A2P A2C • MT 1943: CTO • MT 4166: B1Q B2A B2T B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G •...
Page 282 Item # FRUs FRU # Optical drive, DVD Recorder Rambo 8 - SATA 12XRAM write • MT 1730: A1U A1F A1S A1P A1L A1D A1Y A1G A1M A1A A1Q A1T A1C A1B A1H A1V A1K A1R A1E A1J A2U A2F A2S A2L A2D A2Y A2G A2M A2A A2Q A2T A2B A2H A2V A2K A2R A2E A2J A2P A2C •...
Page 283 Item # FRUs FRU # Hard disk drive, SATA 160GB 7200RPM/3Gb/8M • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 53Y6837 Hard disk drive, SATA 250GB 7200RPM/3Gb/8M •...
Page 284 Item # FRUs FRU # Hard disk drive, SATA 320GB 7200 RPM/3Gb/8M • MT 1730: A1U A1F A1S A1P A1L A1D A1Y A1G A1M A1A A1Q A1T A1C A1B A1H A1V A1K A1R A1E A1J A2U A2F A2S A2L A2D A2Y A2G A2M A2A A2Q A2T A2B A2H A2V A2K A2R A2E A2J A2P A2C •...
Page 285 Item # FRUs FRU # Hard disk drive, SATAIII 320GB 7200RPM/6Gb/16M • MT 1730: A1U A1F A1S A1P A1L A1D A1Y A1G A1M A1A A1Q A1T A1C A1B A1H A1V A1K A1R A1E A1J A2U A2F A2S A2L A2D A2Y A2G A2M A2A A2Q A2T A2B A2H A2V A2K A2R A2E A2J A2P A2C •...
Page 286 Item # FRUs FRU # Hard disk drive, 2.5 inch 300G 10K RPM HDD • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 91Y1657 Hard disk drive, SATAII and III 160GB 7200RPM/6Gb and 3Gb •...
Page 287 Item # FRUs FRU # • MT 7517: A1S A1D A1Y A2U A2F A2S A3U A3F A3S A4U A4F A4S A5U A5F A5S A6U A6F A6S A8U A8F A8S A9U A9F A9S B1S B1U B1F B2S B2U B2F B3U B3S B3F B4U B4F B4S B5U B5F B5S B6U B6F B6S System board, planar- Intel Q65 planar - ATX (USI)(SPI) •...
Page 288 Item # FRUs FRU # D6S B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G A9Q B1V B2V E1P E7U E7F E7S E8U E8F E8S E6U E6F E6S E9U E9F E9S F1U F1F F1S E2G E3G E4V E5V F2J F3J F4J F5J F6J F7J F8G G3P G4P G5P G6A G6T G8P G9G G7G H3S H3F H3U H1J H2J H4G H5J H6J H7J H8J •...
Page 289: Mechanical Frus
Mechanical FRUs The FRUs listed in the following tables are not illustrated. FRUs FRU # Tamdhu IV 9225 front fan (with fan bracket) • MT 1730: all models • MT 1943: all models • MT 4166: all models • MT 4169: all models •...
Page 290 FRUs FRU # Cabel-SATA 420mm with 2 latch • MT 1730: all models • MT 1943: all models • MT 4166: all models • MT 4169: all models • MT 5030: all models • MT 5048: all models • MT 7517: all models 54Y9948 Speaker cable_R_9*5_400mm •...
Page 291 FRUs FRU # FDD/cardreader cover • MT 1730: all models • MT 1943: all models • MT 4166: all models • MT 4169: all models • MT 5030: all models • MT 5048: all models • MT 7517: all models 45K6262 ODD blank cover assembly •...
Page 292 FRUs FRU # eSATA cable FH • MT 1730: all models • MT 1943: all models • MT 4166: all models • MT 4169: all models • MT 5030: all models • MT 5048: all models • MT 7517: all models 41R3308 PS2 cable_R_170mm_knockout (with screw) •...
Page 293 FRUs FRU # Shield, 5.25 EMC • MT 1730: all models • MT 1943: all models • MT 4166: all models • MT 4169: all models • MT 5030: all models • MT 5048: all models • MT 7517: all models 41N8080 Side cover •...
Page 294 FRUs FRU # USB cover • MT 1730: all models • MT 1943: all models • MT 4166: all models • MT 4169: all models • MT 5030: all models • MT 5048: all models • MT 7517: all models 45K6260 1st ODD cover assembly •...
Page 295 FRUs FRU # front bezel with 1st ODD bezel assembly • MT 1730: all models • MT 1943: all models • MT 4166: all models • MT 4169: all models • MT 5030: all models • MT 5048: all models •...
Page 296: Keyboard And Mouse
Keyboard and Mouse Keyboard - Preferred Pro PS/2 FRU # PS/2--US English/Chinese-Simplified • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41A5039 PS/2--Arabic • MT 1730: • MT 1943: CTO •...
Page 297 Keyboard - Preferred Pro PS/2 FRU # PS/2--Belgium English • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41A5043 PS/2--Brazilian Portuguese • MT 1730: • MT 1943: CTO •...
Page 298 Keyboard - Preferred Pro PS/2 FRU # PS/2--Danish • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41A5048 PS/2--Dutch • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 299 Keyboard - Preferred Pro PS/2 FRU # PS/2--German • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41A5053 PS/2--Greek • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 300 Keyboard - Preferred Pro PS/2 FRU # PS/2--Iceland • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41A5057 PS/2--Italy • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 301 Keyboard - Preferred Pro PS/2 FRU # PS/2--Norwegian • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41A5062 PS/2--Polish • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 302 Keyboard - Preferred Pro PS/2 FRU # PS/2--Serbian/Cyrillic • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41A5067 PS/2--Slovak • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 303 Keyboard - Preferred Pro PS/2 FRU # PS/2--Thailand • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41A5072 PS/2--Turkish • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 304 Keyboard - Preferred Pro PS/2 FRU # PS/2--Slovenian • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41A5077 PS/2--India • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 305 Keyboard -Preferred Pro USB FRU # Arabic/French • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41A5291 Belgium French • MT 1730: A1G A2G • MT 1943: CTO •...
Page 306 Keyboard -Preferred Pro USB FRU # Bulgarian • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G • MT 4169: A1G A2G • MT 5030: B1G B2G B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G E4G C5G F6G •...
Page 307 Keyboard -Preferred Pro USB FRU # Dutch • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G • MT 4169: A1G A2G • MT 5030: B1G B2G B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G E4G C5G F6G •...
Page 308 Keyboard -Preferred Pro USB FRU # German • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G • MT 4169: A1G A2G • MT 5030: B1G B2G B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G E4G C5G F6G •...
Page 309 Keyboard -Preferred Pro USB FRU # Hungarian • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G • MT 4169: A1G A2G • MT 5030: B1G B2G B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G E4G C5G F6G •...
Page 310 Keyboard -Preferred Pro USB FRU # LA Spanish • MT 1730: A1S A1D A1Y A2S A2D A2Y • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: D5S D6S D7S E9S F1S E8S F5S G1S G2S G3S G2Y G3Y •...
Page 311 Keyboard -Preferred Pro USB FRU # Romanian • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G • MT 4169: A1G A2G • MT 5030: B1G B2G B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G E4G C5G F6G •...
Page 312 Keyboard -Preferred Pro USB FRU # Slovak • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G • MT 4169: A1G A2G • MT 5030: B1G B2G B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G E4G C5G F6G •...
Page 313 Keyboard -Preferred Pro USB FRU # Thailand • MT 1730: A1T A2T • MT 1943: CTO • MT 4166: B2T • MT 4169: • MT 5030: C4T C5T C6T D2T D3T D4T E3T F7T F8T • MT 5048: C8T C9T D2T G6T •...
Page 314 Keyboard -Preferred Pro USB FRU # US European • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G • MT 4169: A1G A2G • MT 5030: B1G B2G B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G E4G C5G F6G •...
Page 315 Keyboard -Preferred Pro USB FRU # Estonia • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G • MT 4169: A1G A2G • MT 5030: B1G B2G B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G E4G C5G F6G •...
Page 316 Keyboard -Fingerprint FRU # Arabic/French • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03X8003 Belgium French • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 317 Keyboard -Fingerprint FRU # Chinese/US • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03X8008 Czech (ABB) • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 318 Keyboard -Fingerprint FRU # French Canadian • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03X8013 French Canadian • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 319 Keyboard -Fingerprint FRU # Hebrew • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03X8018 Hungarian • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: •...
Page 320 Keyboard -Fingerprint FRU # Korean • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03X8023 LA Spanish • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 321 Keyboard -Fingerprint FRU # Romanian • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03X8038 Romanian • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: •...
Page 322 Keyboard -Fingerprint FRU # Spanish • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03X8030 Swedish/Finnish • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: •...
Page 323 Keyboard -Fingerprint FRU # Turkish • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03X8034 UK English • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 324 Keyboard -Slim USB FRU # • MT 7517: Slim USB--Arabic • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 54Y9251 Slim USB--Arabic/French • MT 1730: • MT 1943: CTO •...
Page 325 Keyboard -Slim USB FRU # Slim USB--Bulgarian • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 54Y9256 Slim USB--Chinese/US • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 326 Keyboard -Slim USB FRU # Slim USB--French • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 54Y9261 Slim USB--French Canadian • MT 1730: • MT 1943: CTO •...
Page 327 Keyboard -Slim USB FRU # Slim USB--Greek/US • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 54Y9266 Slim USB--Hebrew • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 328 Keyboard -Slim USB FRU # Slim USB--Japanese • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 54Y9271 Slim USB--Korean • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 329 Keyboard -Slim USB FRU # Slim USB--Portuguese • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 54Y9276 Slim USB--Romanian • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 330 Keyboard -Slim USB FRU # Slim USB--Spanish • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 54Y9281 Slim USB--Swedish/Finnish • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 331 Keyboard -Slim USB FRU # Slim USB--Turkish • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 54Y9286 Slim USB--UK English • MT 1730: • MT 1943: CTO •...
Page 332 • MT 7517: 41R0018 Lenovo enhanced optical USB mouse • MT 1730: A1U A1F A1S A1P A1L A1D A1Y A1G A1M A1A A1Q A1T A1C A1B A1H A1V A1K A1R A1E A1J A2U A2F A2S A2L A2D A2Y A2G A2M A2A A2Q A2T A2B A2H A2V A2K A2R A2E A2J A2P A2C •...
Page 333: Adapters And Miscellaneous Frus
Adapters and miscellaneous FRUs Adapters and miscellaneous FRUs FRU # USB2.0 media card reader 25 in 1 ROHS • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 45R8139 ATI HD5450 (DP+DVI) HP 512M 64 bit •...
Page 334 • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T7030 Lenovo branded speakers • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: •...
Page 335 Adapters and miscellaneous FRUs FRU # Speaker power brick • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 89P8571 NVIDIA Quadro FX380 (DVI + DP) ATX • MT 1730: •...
Page 336: Power Cords
Adapters and miscellaneous FRUs FRU # DMS59 to Dual DVI Dongle • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 41X6398 Geforce 310 512M 64BIT VGA +DP ATX •...
Page 337 Power Cords --primary FRU # Line cord-Japan • MT 1730: A1J A2J • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: F2J F3J F4J F5J F6J F7J G1J G2J H1J H2J H5J H6J H7J H8J •...
Page 338 Power Cords --primary FRU # Line cord-Taiwan • MT 1730: A1V A2V • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: A3V A4V A5V A6V A7V A8V A9V E5V E6V • MT 5048: B1V B2V E4V E5V •...
Page 339 Power Cords --primary FRU # Line cord-Israel • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G • MT 4169: A1G A2G • MT 5030: B1G B2G B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G E4G C5G F6G •...
Page 340 Power Cords --primary FRU # Line cord-Hong Kong, Singapore, Malaysia, Brunei,UK, Ireland • MT 1730: A1G A1A A1B A1H A2G A2A A2B A2H • MT 1943: CTO • MT 4166: B2A B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G •...
Page 341 Power Cords --secondary FRU # Line cord-Japan • MT 1730: A1J A2J • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: F2J F3J F4J F5J F6J F7J G1J G2J H1J H2J H5J H6J H7J H8J •...
Page 342 Power Cords --secondary FRU # Line cord-Taiwan • MT 1730: A1V A2V • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: A3V A4V A5V A6V A7V A8V A9V E5V E6V • MT 5048: B1V B2V E4V E5V •...
Page 343 Power Cords --secondary FRU # Line cord-Israel • MT 1730: A1G A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G • MT 4169: A1G A2G • MT 5030: B1G B2G B3G B4G B5G B6G B7G B8G B9G C1G C2G C3G E4G C5G F6G •...
Page 344: Recovery Discs
Power Cords --secondary FRU # Line cord-Hong Kong, Singapore, Malaysia, Brunei, UK, Ireland • MT 1730: A1G A1A A1B A1H A2G A2A A2B A2H • MT 1943: CTO • MT 4166: B2A B3G A1G A2G A3G A4G A5G A6G A7G A8G A9G B4G B5G B6G B7G •...
Page 345 Windows 7 Home Premium 32 FRU # French • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T0797 German • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 346 Windows 7 Home Premium 32 FRU # Japanese • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T0802 Korean • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 347: Windows 7 Professional 32 Recovery Cd
Windows 7 Home Premium 32 FRU # US English • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T0807 C&L Nordics (DK/FI/SV/NO/EN) • MT 1730: • MT 1943: CTO •...
Page 348 Windows 7 Professional 32 FRU # • MT 5048: • MT 7517: Japanese • MT 1730: A1J • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: F4J F5J F6J F7J G1J G2J H1J H2J •...
Page 349 Windows 7 Professional 32 FRU # Brazilian Portuguese • MT 1730: A1P • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: E1P • MT 7517: 03T0769 German • MT 1730: A1G • MT 1943: CTO •...
Page 350 Windows 7 Professional 32 FRU # Chinese-Simplified • MT 1730: A1C • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T0770 Chinese-Traditional (Taiwan) • MT 1730: A1V • MT 1943: CTO •...
Page 351 Windows 7 Professional 32 FRU # Hebrew • MT 1730: A1G • MT 1943: CTO • MT 4166: E5G E7G • MT 4169: • MT 5030: B1G B2G B3G B4G B5G B9G C1G C5G • MT 5048: E3G • MT 7517: 03T0777 Greek •...
Page 352 Windows 7 Professional 32 FRU # Hungarian • MT 1730: A1G • MT 1943: CTO • MT 4166: E5G E7G • MT 4169: • MT 5030: B1G B2G B3G B4G B5G B9G C1G C5G • MT 5048: E3G • MT 7517: 03T0779 Czech •...
Page 353: Windows 7 Professional 64 Recovery Cd
Windows 7 Professional 32 FRU # • MT 1943: CTO • MT 4166: E5G E7G • MT 4169: • MT 5030: B1G B2G B3G B4G B5G B9G C1G C5G • MT 5048: E3G • MT 7517: Windows 7 Professional 64 Recovery CD Windows 7 Professional 64 FRU # Arabic...
Page 354 Windows 7 Professional 64 FRU # French • MT 1730: A2F A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A9G • MT 4169: A1G A2G • MT 5030: D5F D6F D7F E9F F1F E8F F5F G1F • MT 5048: D7G D8G A1G B3G B4G B5G B6G B7G B8G B9G E2G F8G G9G G7G H4G •...
Page 355 Windows 7 Professional 64 FRU # Hungry • MT 1730: A2G • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: F6G • MT 5048: D7G D8G A1G B3G B4G B5G B6G B7G B8G B9G E2G F8G G9G G7G H4G •...
Page 356 Windows 7 Professional 64 FRU # Porguese • MT 1730: A2G • MT 1943: CTO • MT 4166: B3G A1G A2G A9G • MT 4169: A1G A2G • MT 5030: F6G • MT 5048: D7G D8G A1G B3G B4G B5G B6G B7G B8G B9G E2G F8G G9G G7G H4G •...
Page 357 Windows 7 Professional 64 FRU # Turkish • MT 1730: A2G • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: F6G • MT 5048: D7G D8G A1G B3G B4G B5G B6G B7G B8G B9G E2G F8G G9G G7G H4G •...
Page 358: Windows 7 Home Basic 32 Recovery Cd
Windows 7 Home Basic 32 Recovery CD Windows 7 Home Basic 32 FRU # Arabic • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: E4G • MT 5048: • MT 7517: 03T0810 Brazilian Portuguese •...
Page 359: Windows 7 Home Premium 64 Recovery Cd
Windows 7 Home Basic 32 FRU # Serbian-Latin • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: E4G • MT 5048: • MT 7517: 03T0815 Turkish • MT 1730: • MT 1943: CTO •...
Page 360: Windows 7 Ultimate 32 Recovery Cd
Windows 7 Home Premium 64 FRU # • MT 7517: US English • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T0855 Windows 7 Ultimate 32 Recovery CD Windows 7 Ultimate 32 FRU # India English...
Page 361: Windows 7 Starter 32 Recovery Cd
Windows 7 Ultimate 64 FRU # • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: Windows 7 Starter 32 Recovery CD Windows 7 Starter 32 FRU # Arabic • MT 1730: •...
Page 362: Windows Xp Professional 32 Recovery Cd
Windows 7 Starter 32 FRU # Spanish • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T0824 Turkish • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 363 Windows XP Professional 32 FRU # • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: Brazil Portuguese • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: •...
Page 364 Windows XP Professional 32 FRU # Finnish • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T0742 French • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 365 Windows XP Professional 32 FRU # Norwegian • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T0747 Polish • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 366: Windows Xp Professional Generic Recovery Cd
Windows XP Professional 32 FRU # • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: Windows XP Professional Generic Recovery CD Note: The Windows XP Professional recovery DVDs are available only for models with a valid Microsoft Windows XP Professional certificate of authenticity (COA) affixed to the system.
Page 367: Windows Vista Business 32 Recovery Cd
Windows XP Professional Generic FRU # Korean • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03W7489 Dutch • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 368: Windows Vista Home Basic 32 Recovery Cd
Windows Vista Business 32 FRU # • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: Windows Vista Home Basic 32 Recovery CD Note: The Windows Vista recovery DVDs are available only for models with a valid Microsoft Windows Vista certificate of authenticity (COA) affixed to the system.
Page 369 Windows Vista Home Basic 32 FRU # Italian • MT 1730: • MT 1943: CTO • MT 4166: • MT 4169: • MT 5030: • MT 5048: • MT 7517: 03T1325 English • MT 1730: • MT 1943: CTO • MT 4166: •...
Page 370 ThinkCentre Hardware Maintenance Manual...
Page 371: Chapter 11. Additional Service Information
“Using passwords” on page 43. Operating system password Note: This section applies only to computer models that have an operating system preinstalled from Lenovo. An operating system password is very similar to a power-on password and denies access to the computer by an unauthorized user when the password is activated.
Page 372: Updating (Flashing) The Bios From Your Operating System
Updating (flashing) the BIOS from your operating system Note: Because Lenovo makes constant improvements to its Web sites, the Web page contents are subject to change without notice, including the contents referenced in the following procedure.
Page 373: Power Management
2. Remove or open the computer cover. For machine types 0268, 1730, 1943, 4166, 4169, 5030, 5048, 5069, and 7517, see “Removing the computer cover” on page 79. For machine types 0267, 0385, 1981, 4167, 5025, 5032, 5049, 5070, and 7518, see “Opening the computer cover” on page 121. 3.
Page 374 ThinkCentre Hardware Maintenance Manual...
Page 375: Appendix A. Notices
Lenovo representative for information on the products and services currently available in your area. Any reference to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo product, program, or service may be used. Any functionally equivalent product, program, or service that does not infringe any Lenovo intellectual property right may be used instead.
Page 376: Trademarks
Macrovision Corporation. Reverse engineering or disassembly is prohibited. European conformance CE mark Trademarks The following terms are trademarks of Lenovo in the United States, other countries, or both: Lenovo The Lenovo logo Rescue and Recovery...
Page 377: Index
81, 126 connectors, controls, indicators 74, 116 power supply assembly front audio and USB assembly, replacing 110, 159 replacing 93, 142 front bezel power-on password removing, reinstalling 80, 122 productivity center, ThinkVantage © Copyright Lenovo 2011, 2012...
Page 378 (flashing) the BIOS updating (flashing) the BIOS rear connectors 75, 117 using rear fan assembly, replacing passwords recovering Setup Utility from a POST and BIOS update failure Setup Utility program recovery Boot-block Recovery removing computer cover removing, reinstalling viewing and changing settings front bezel 80, 122 replacing...
Page 380 Part Number: 0A74545 Printed in USA (1P) P/N: 0A74545 *0A74545*...

This manual is also suitable for:

Thinkcentre 0267 Thinkcentre 0268 Thinkcentre 0385 Thinkcentre 1730 Thinkcentre 1981 Thinkcentre 1943 ... Show all

Lenovo ThinkCentre M81 Hardware Maintenance Manual

Chapter 1. About this Manual

Chapter 2. Safety Information

Chapter 3. General Information

Chapter 4. General Checkout

Chapter 5. Diagnostic Programs

Chapter 6. Using the Setup Utility Program

Chapter 7. Symptom-To-FRU Index

Chapter 8. Replacing Frus (Machine Types: 0268, 1730, 1943, 4166, 4169, 5030, 5048, 5069, and 7517)

Chapter 9. Replacing Frus (Machine Types: 0267, 0385, 1981, 4167, 5025, 5032, 5049, 5070, and 7518)

Chapter 10. FRU Lists

Chapter 11. Additional Service Information

Appendix A. Notices

Index

Quick Links

Related Manuals for Lenovo ThinkCentre M81

Summary of Contents for Lenovo ThinkCentre M81

This manual is also suitable for:

Table of Contents