Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Hussmann Q3-DV-8
Summary of Contents for Hussmann Q3-DV-8
- Page 1 0619 /SPECIALTY DELI VERTICAL MERCHANDISER U S E R M A N U A L - Q3-DV-4 Vertical Case - Q3-DV-5 Vertical Case - Q3-DV-6 Vertical Case - Q3-DV-8 Vertical Case - Q3-DV-10 Vertical Case - Q3-DV-12 Vertical Case - Q3-DV-22.5IS/OS Vertical Case Remote - Q3-DV-45IS/OS Vertical Case...
-
Page 2: Table Of Contents
Refrigerant piping Line Sizing Oil Traps Refrigeration Spec Sheets DOE 2012 Hussmann refrigerated merchandisers con gured for sale for use in the United States Energy E ciency meet or surpass the requirements of the DOE 2012 energy e ciency standards. Compliant... -
Page 3: Notice
Notice WARNING 1. DO NOT overload or stand over top of case. Glass breakage may occur if precautions are disregarded. *Broken glass can cause lacerations, cuts, and puncture wounds which may result in severed arteries or tendons, amputations, eye injuries, or exposure to disease. -
Page 4: General Information
Shortages: Check your shipment for any possible shortages of material. If a shortage should exist and is found to be the responsibility of Hussmann Chino, notify Hussmann Chino. If such a shortage involves the carrier, notify the carrier immediately, and request an inspection. Hussmann Chino will acknowledge shortages within ten days from receipt of equipment. -
Page 5: Case Sections
Case Sections Q3-DV Multi-Deck Service Deli Case (673) (305) (587) (356) (629) (1327) (391) (581) (654) (264) (638) (149) (1051) Q3-DV, BV (149) (562) (638) (714) (203) (127) (156) (1064) Elec Drain Refrig (264) End Panels customer side (1219) (1829) (2438) (3658) (29) -
Page 6: Installation
Case is to arrive at store as was shipped form factory. See reference above for proper shipment referencing. (not actual case) Receiving Case Upon receiving your new Hussmann Case all equipment should be thoroughly examined for shipping damage before and during unloading. This equipment has been carefully inspected at our factory. -
Page 7: Placement
Installation (cont’d) Placement panels. Check for damage before discarding packaging. Important: See lifting instructions to properly lift In the case a fork lift truck is not available follow case when being placed on dollies or permanent the demonstration below to properly lift case us- location. -
Page 8: Q3Dv Lifting And Transport Instructions
Installation (cont’d) Q3DV Lifting and Transport 5. The Q3-DV merchandiser can be raised at Instructions one end underneath the deck with a forklift to allow the placement of rollers or dollies. 1. The Q3-DV can be lifted by a forklift at typical 6. -
Page 9: Front Body Panel Install
Installation (cont’d) Front Body Panel Install Fasten Rear Body Panel Install (1) Align pre drilled holes to base of case A Phillips Screw Driver/Bit will be needed to (2) Secure top and bottom of rear panel using install body panels. fasteners as shown below. -
Page 10: Leveler Adjustment
Installation (cont’d) Leveler Adjustment Note: To avoid removing concrete flooring, begin line up levelling from the Highest point of the Position the case at the highest point. Set a long store floor. magnetized level (4ft [1220 mm] or more) on either underneath the deck or on top of the case. Ensure to level case from front to back and side to side. -
Page 11: Parts List
Parts List 1H97637 1 PER JOINT Joining part 3 3/8"-16 NUT/BOLT 3 PER JOINT LOOSE 3/8"-0. 5 625" OD WASHER 4 PER JOINT LOOSE 1H97784 1 PER JOINT Joininh part 4 1/4"-0.5625" OD WASHER 1 PER JOINT LOOSE / TOP CANOPY ONLY 1H63905 1 PER JOINT Joining part 1... -
Page 12: Q3-Dv Canopy Adjustment
Installation (cont’d) - Page 13 Installation (cont’d)
- Page 14 Installation (cont’d)
-
Page 15: Joining Preparation
Installation (cont’d) - Page 16 Installation (cont’d)
- Page 17 Installation (cont’d)
-
Page 18: Refrigeration
In the case pressure was not maintained sealed at factory already. Seal both the inside contact your Hussmann Service Tech for further and outside. We recommend using an expanding assistance. -
Page 19: Refrigeration Spec Sheets
Refrigeration Spec Sheets DELI / BAKERY, SERVICE CASE, VERTICAL GLASS REVISION DATE 04/27/18 HUSSMANN - Q3-DV/BV (CHINO) REFRIGERATION DATA: CAPACITY *** EST. GLYCOL (20°F TEMPERATURE (ºF) (BTU/HR/FT) (TOTAL REFG. VELOCITY INLET, 6° RISE) CASE CASE FOR WEDGES) CHRG. (FT/MIN) LENGTHS... -
Page 20: Electrical
Electrical Field Wiring Merchandiser Electrical Data Field wiring must be sized for component am- Technical data sheets are shipped with this peres stamped on the serial plate (refer to pg 16 manual. The data sheets provide merchandiser for location). Actual ampere draw may be less electrical data. -
Page 21: Remove Rear Raceway
Electrical Cont’d Remove Rear Raceway Electrical Conduit (Electrical Box) The Merchandisers Electrical access is located The Merchandisers Electrical conduit can be at the rear of the case. Fasteners must be re- found inside the compartmentat the rear. Remov- moved in order to gain access. See illustration ing the raceway will gain access to the electrical below. -
Page 22: Electrical Wiring Diagram
Electrical Wiring Diagram... - Page 23 Electrical Wiring Diagram (Cont’d)
- Page 24 Electrical Wiring Diagram (Cont’d)
- Page 25 Electrical Wiring Diagram (Cont’d)
-
Page 33: User Information
User Information Start Up Load Limit See the merchandisers Data Sheet Set for refrig- Each Merchandiser has a Load Limit. Shelf life of erant settings and defrost requirements. Bring perishables will shorten if Load Limit is violated. merchandisers down to the operating tempera- AT NO TIME SHOULD THE MERCHANDISER tures listed on the Data Sheet. -
Page 34: Case Cleaning
User Information Cont’d Case Cleaning Clean frequently to avoid build-up of hard, stub- Long life and satisfactory performance of any born stains. A stainless steel cleaning solution equipment are dependent upon the care it re- may be used periodically to minimize scratching ceives. - Page 35 User Information Cont’d • Remove the product and all loose debris to avoid clogging the waste outlet. • Store product in a refrigerated area such as a cooler during the cleaning process. Remove only as much product as can be taken to the cooler in a timely manner.
-
Page 36: Troubleshooting
Troubleshooting Problem Possible Cause Possible Solution Case temperature is Ambient conditions may Check case position in store. Is the case located near an too warm. be affecting the case open door, window, electric fan or air conditioning vent that operation. may cause air currents? Case must be located minimum 15 Ft away from doors or windows. - Page 37 Troubleshooting Cont’d Problem Possible Cause Possible Solution Water has pooled Case drain is clogged. Clear drain. under case. PVC drains under case Repair as needed. may have a leak. Case tub has unsealed Seal as needed. opening. If the case is in a line- Install case to case joint and seal as needed.
- Page 38 To obtain warranty information or other support, contact your Hussmann representative. Please include the model and serial number of the product. Hussmann Warranty / Technical Assistance (800) 592-2060 Hussmann Corporation, Corporate Headquarters: Bridgeton, Missouri 63044 2014...
Need help?
Do you have a question about the Q3-DV-8 and is the answer not in the manual?
Questions and answers