Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Summary of Contents for SGB YOUNGMAN 10BY150ECB
- Page 1 PORTABLE FORCED AIR HEATER OWNER’S MANUAL Model BY150ECB 150,000 Btu/Hr 110v/50 Hz IMPORTANT Read and understand this manual before assembling, starting, or servicing heater. Improper use of heater can cause serious injury. Keep this manual for future reference.
-
Page 2: Safety Information
MODEL BY150ECB 150,000 Btu/Hr PORTABLE FORCED AIR HEATER SAFETY INFORMATION WARNINGS IMPORTANT: Read this Owner’s Manual carefully and completely before trying to assemble, oper- ate, or service this heater. Im- proper use of this heater can cause serious injury or death from burns, fire, explosion, electrical shock, and carbon monoxide poisoning. -
Page 3: Product Identification
PRODUCT IDENTIFICATION Lower Shell Fuel Cap Side Cover ASSEMBLY These models are furnished with wheels and a front handle. Some models are furnished with a rear handle also. Wheels, handle(s), and the mounting hardware are found in the shipping carton. Tools Needed •... -
Page 4: Theory Of Operation
MODEL BY150ECB 150,000 Btu/Hr PORTABLE FORCED AIR HEATER THEORY OF OPERATION The Fuel System: The air pump forces air through the air line. The air is then pushed through the burner head nozzle. This air causes fuel to lift from the tank. A fine mist of fuel is sprayed into the combus- tion chamber. -
Page 5: Preventative Maintenance Schedule
OPERATION CONTINUED Extension Cord Wire Size Requirements Up to 30.5 meters (100 feet) long, use 1.0 mm (16 AWG) conductor 30.6 to 61 meters (101 to 200 feet) long, use 1.5 mm (14 AWG) conductor Push ON/OFF switch to ON and heater should start. -
Page 6: Troubleshooting
MODEL BY150ECB 150,000 Btu/Hr PORTABLE FORCED AIR HEATER TROUBLESHOOTING OBSERVED FAULT Heater ignites, but flame-out control shuts off heater after a short period of time. Heater will not ignite, but motor runs for a short period of time. Motor does not start when heater is plugged in, fan rotates slowly or does not turn. -
Page 7: Service Procedures
SERVICE PROCEDURES WARNING: Never service heater while it is plugged in, op- erating, or hot. Severe burns and electrical shock can occur. UPPER SHELL REMOVAL 1. Remove screws along each side of heater using 5/16" nut-driver. These screws attach upper and lower shells together. -
Page 8: Fuel Filter
MODEL BY150ECB 150,000 Btu/Hr PORTABLE FORCED AIR HEATER FUEL FILTER 1. Remove side cover screws using 5/16" nut-driver. 2. Remove side cover. 3. Pull upper fuel line off fuel filter neck. 4. Carefully pry bushing, fuel filter, and lower fuel line out of fuel tank. 5. -
Page 9: Specifications
PUMP ROTOR (Procedure if rotor is binding) 1. Remove upper shell (see page 7). 2. Remove filter end cover screws using 5/16" nut-driver. 3. Remove filter end cover and air filters. 4. Remove pump plate screws using 5/16" nut-driver. 5. Remove pump plate. 6. -
Page 10: Wiring Diagram
MODEL BY150ECB 150,000 Btu/Hr PORTABLE FORCED AIR HEATER WIRING DIAGRAM Reset Button Flame-Out Control Blue On/Off Switch Black Black Terminal Board White White Blue White White Photocell White Ignitor Spark Plug Green/ Yellow Solid Black State Motor Green/ Relay Yellow Black Brown Blue... -
Page 11: Wheels And Handle Parts List
WHEELS AND HANDLE PARTS LIST 104001 KEY PART PART NO. NUMBER DESCRIPTION HA2204 Handles M12345-33 Screw, #10-24 x 1 3/4" M12831-3 Wheel Support Frame NTC-3C Hex Nut, #10-24 097896-03 Wheel M28526 Cap Nut M16801-2 Axle OWNER’S MANUAL QTY. -
Page 12: Illustrated Parts Breakdown
MODEL BY150ECB 150,000 Btu/Hr PORTABLE FORCED AIR HEATER ILLUSTRATED PARTS BREAKDOWN Burner Head Assembly 10-1 10-3 10-2 10-4 10-5 10-18 10-17 10-16 10-15 10-14 Motor and Pump Assembly 10-6 10-7 10-8 10-9 10-10 10-11 10-13 10-12 104001... -
Page 13: Parts List
PARTS LIST This list contains replaceable parts used in your heater. When ordering parts, be sure to provide the correct model and serial numbers (from the model plate), then the part number and description of the desired part. PART NUMBER DESCRIPTION 098511-138 Upper Shell... -
Page 14: Ec Conformity Declaration
EC CONFORMITY DECLARATION SGB YOUNGMAN Stanestreet, Slingfold, Horsham West Sussex Rh13 7RD United Kingdom (UK) Manufacturer: DESA International, Inc. 2701 Industrial Drive Bowling Green, KY 42101 U.S.A. Kerosene Portable Forced Air Heaters Model Number: BY150ECB DESA International, Inc. Vice President, Specialty Products Engineering Douglas D. - Page 15 OWNER’S MANUAL NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ 104001...
-
Page 16: Warranty And Repair Service
WARRANTY AND REPAIR SERVICE SGB YOUNGMAN warrants new Products sold by it to be free from defects in material or workmanship for a period of 360 days after date of delivery to the first user and subject to the following conditions: SGB YOUNGMAN’s obligation and liability under this War- ranty is expressly limited to repairing or replacing at SGB YOUNGMAN’s option, any parts which appear to SGB...
Need help?
Do you have a question about the 10BY150ECB and is the answer not in the manual?
Questions and answers