Related Manuals for KZ SPREE ESCAPE
Summary of Contents for KZ SPREE ESCAPE
- Page 1 GUIDEBOOK TO ENJOYMENT OF YOUR KZRV RECREATIONAL VEHICLE SPORTSMEN CLASSIC SPREE ESCAPE PDF created with pdfFactory trial version www.pdffactory.com...
- Page 2 THE PURPOSE OF THIS OWNER’S MANUAL IS TO PROVIDE MOST CURRENT INFORMATION AVAILABLE FOR YOUR RECREATIONAL VEHICLE ABOUT USAGE AND OPERATION. ALSO MINOR MAINTENANCE AND CRITICAL SAFETY WARNINGS INCLUDED ,MUST READ, UNDERSTOOD AND OBEYED. ADDITIONAL MAINTENANCE INFORMATION IS FOUND IN THE ‘’MAINTENANCE MANUAL’’ SUPPLIED WITH YOUR RECREATIONAL VEHICLE.
- Page 3 KZRV “BUILDING QUALITY AND FUN FOR OVER 40 YEARS” We congratulate you on your purchase of a KZRV, recreational vehicle. You have chosen a quality built RV which should provide you with many years of camping memories and fun. The recreational vehicle you have purchased has been inspected by our trained inspectors and fully meets our high quality standards.
-
Page 4: Table Of Contents
TABLE OF CONTENTS Chapter 1 – Introduction to RV Ownership ........1 Safety Considerations ..............2 Reporting Safety Defects ............2 Safety When Emergency Stopping ........3 Additional Safety Considerations .......... 3 Condensation ................ 4 Chapter 2 – Service Procedures............. 5 Basic Service Procedures ............ - Page 5 Combo Propane and Carbon Monoxide……..……………..24 Operation…………………………………………………..24 Gas Alarm……………………………………………………...25 Simultaneous CO and Gas Alarms…………………………25 Brown Out Protection…………………………………………25 Low Power Operation………………………………………...25 Visual and Audible Alarm Signals…………………………...25 CO Alarm………………………………………………………25 Propane Gas Alarm…………………………………………..26 End of Life Signal……………………………………………..26 What is Carbon Monoxide……………………...…………… 27 Smoke Alarm… ..............27 Steps…………………………………………………………...28 Windows…………………………………………………….….28 Doors…………………………………………………………...29...
- Page 6 Operation………….............. 50 If You Smell Gas ............51 Propane Gas Consumption ..........51 Electrical System……… ............53 General Information ............53 Changes and Modifications ..........53 Power Cord……….............. 53 Circuit Breakers ............53 GFCI Protection ............55 12 Volt DC System……………………………………………56 Converter………………………………………………….56 Auxiliary Battery…………………………………………..57 Circuit Breakers and Fuses……………………………..57...
-
Page 7: Chapter 1 - Introduction To Rv Ownership
KZRV product allows you to enter this type of camping and leisure travel. Your coach has been designed and engineered to offer many comforts of home. KZ recreational vehicles are designed and constructed to be used as temporary living quarters for camping and travel uses. -
Page 8: Safety Considerations
operation. Camping is a great way to relax and enjoy the outdoors with your friends and family. Please remember to tread lightly on our beautiful land and leave only your footprints so that others may enjoy nature as much as you did. SAFETY CONSIDERATIONS The terms NOTE, CAUTION, WARNING, and DANGER have specific meanings in this manual as well as component and vender... -
Page 9: Safety When Emergency Stopping
Washington, DC 20590 You can also obtain other information about motor vehicle safety from the Hotline. Safety When Emergency Stopping It is wise to carry road flags and/or triangular warning devices to be used when necessary. When pulling off a highway, use your four way hazard lights as warning flashers, even if only to change drivers. -
Page 10: Condensation
CONDENSATION Where it comes from, what causes it, and various solutions. Causes: A. It occurs when warm moist air contacts a cold surface, such as rain touching a tent, awning fabric with people breathing warm moist air against it from inside due to normal breathing. B. -
Page 11: Chapter 2 - Service Procedures
0985 N 900 W Shipshewana, IN 46565 Phone: (866)472-5460 Hours: (8am-5pm E.S.T.) E-mail: kz@kz-rv.com Website: http://www.kz-rv.com Give all the above information as requested along with the serial number of the coach in question. We will make every attempt to resolve your problem. -
Page 12: Dealer
Dealer Your authorized KZRV dealer has performed a PDI (pre-delivery inspection) on your recreational vehicle. Since your dealer is authorized to sell KZRV products, he is also there to supply parts, optional equipment, and provide service repairs, warranty or otherwise as needed. First choice for warranty repairs is your selling dealer. -
Page 13: Seasonal Site
As an owner and operator, it is your responsibility and obligation to inspect and return your coach to an authorized dealer for repairs as required. Your authorized selling dealer is always your first choice and he certainly has continued interest in your satisfaction. As your manufacturer, we recommend that inspection and service be performed by your selling dealership. - Page 14 PDF created with pdfFactory trial version www.pdffactory.com...
-
Page 15: Towable Limited Warranty
CLASSIC - ESCAPE TOWABLE LIMITED WARRANTY PDF created with pdfFactory trial version www.pdffactory.com... -
Page 16: Chapter 3 Using Your Rv
CHAPTER 3 USING YOUR RV In this chapter you will find three areas of useful information to assist you with correct equipment, traveling, and finally, actually using your recreational vehicle. EQUIPMENT Tow Vehicle Begin your camping experiences by obtaining a tow vehicle which will adequately transport your recreational vehicle to and from your chosen destinations. -
Page 17: Hitch Height Specifications - Travel Trailer
Optional sway controls are also helpful with travel towing, especially long and heavy tongue weight coaches. CAUTION Trailers with tandem axles need to travel as level as possible, avoiding different weights on each axle plus handling conditions. CAUTION Using an oversized or undersized hitch can cause damage to the frame of your travel trailer and/or tow vehicle. -
Page 18: The Safety Chain (Travel Trailer)
8. Attach the cable for the breakaway switch to the tow vehicle. 9. Attach safety chains as per your state laws. 10. Plug in your 12-volt, seven way electrical cord and connector from the trailer to the tow vehicle connector. 11. - Page 19 tire-ground interfaces. One of five components will determine this rating, tires, axle, springs, brakes, or wheels. One of these five is generally rated slightly less than the others which the rating is based Gross Vehicle Weight Rating (GVWR): is the maximum permissible weight of this trailer when fully loaded.
-
Page 20: Cargo Capacities And Load Limits
Cargo Capacities and Load Limits Cargo may be loaded into coach, up to the maximum weight allowed as specified on the placard. As the combined weight of the cargo is provided as a single number. In any case, remember, the total weight of a fully loaded coach CAN NOT exceed the stated GVWR. -
Page 21: Towing
side loading affects spring condition. Excess weight behind the axle lightens the hitch weight and will tend to magnify any sway that may occur when passing trucks or when gusty winds are present. Uncalculated weight can and will effect road performance. WARNING The rear bumper on the frame of your recreational vehicle is NOT designed to carry over 100 pounds of weight. -
Page 22: Tires
TIRES All KZRV towable coaches are equipped with appropriate tires for recreational vehicles. Tire are radial in design, using components to offer excellent strength and mileage in all kinds of weather conditions. ST refers to “service trailer” as marked on tires, NOT for automobiles. -
Page 23: Understanding Tire Pressure & Load Limits
wish to record this information and keep it with your owner’s manual inside of your coach. Under Standing Tire Pressure and Load Limits Tire inflation pressure is the level of air in the tire that provides it with load carrying capacity and affects the overall performance of the vehicle. -
Page 24: Tire Balance & Wheel Alignment
0816 say’s it was built 8th week of 2016. Other information is size, ply rating, load capacity required air pressure, plus much more. Each original tire installed on a KZ RV has a speed rating of 75 mph. or greater. Please note maximum load rating, tire pressure, and speed rating as imprinted on sidewall of tire. -
Page 25: How To Change Tire
When towing a overloaded vehicle, it’s harder to drive and steer plus harder to stop. In cases of serious overloading, brakes can fail completely, particularly on steep hills. The load a tire will carry safely is a combination of the size of tire, it’s load range, and corresponding inflation pressure. -
Page 26: Wheel Lugs
Wheel Lugs When the wheels are newly installed on your recreational vehicle, the lug nuts must be tightened numerous times because the powder coat paint on the wheel is thick. You must re-torque lugs at 50 and 200 miles. A decal on wheel may require torque- sooner. -
Page 27: Breakaway Switch
front end to brakes. Brake assemblies are wired in parallel, never in series. Being parallel, there will be equal voltage and amperage at each brake assembly. Use the foot pedal control for general operation on combined use of both brake systems. Manual control is to be used only in special situations, such as slow movement or icy road conditions. -
Page 28: Setting Up And Using Your Recreational Vehicle
SAFETY BREAK-AWAY SWITCH WILL NOT OPERATE Unless connected to a power source equivalent to or greater than an auto -motive type 12 volt, 12 amp hour wet-cell battery. SETTING UP AND USING YOUR RECREATIONAL VEHICLE We recommend that you select a level or nearly level place for camping. - Page 29 To operate the stabilizer jack, place crank onto the jack shaft and turn clockwise to lower until the frame begins to raise slightly. Equalize all four jacks for best support. You may need to adjust each jack two or three times. To raise jack to upper travel position, turn counterclockwise until jack is seated in UP travel position.
-
Page 30: General Detector Information
GENERAL DETECTOR INFORMATION As you are confined in a RV which is much smaller than a standard house, you must realize safety detectors will be activated much sooner than in a residential house, due to there being much less air volume. -
Page 31: Gas Alarm
section, Trouble-Shooting Guide, in manual provided by manufacture for further information. Do not attempt to fix it yourself. Gas Alarm: When you power the alarm, it has a warm-up period of approximately 1 minute. This unit cannot go into a gas alarm during the warm-up period. -
Page 32: Propane Gas Alarm
PROPANE GAS ALARM The RED LED will flash and the alarm will sound a steady tone whenever a dangerous level of propane or butane gas is detected. IMMEDIATE ACTION IS REQUIRED. See Procedures To Take During A Gas Alarm. The detector will continue to alarm until the Test/Mute switch on the front of the alarm is pressed. -
Page 33: What Is Carbon Monoxide
days the signal cannot be reset and the alarm MUST be replaced. DO NOT DISCONNECT THE ALARM UNTIL YOU HAVE A REPLACEMENT ALARM AVAILABLE TO INSTALL. This alarm is designed to detect CO and Propane. It is NOT designed to detect smoke WHAT IS CARBON MONOXIDE? Carbon Monoxide (CO) is a highly poisonous gas which is released when fuels are burnt. -
Page 34: Steps
alarm horn is loud to alert you to an emergency. The alarm horn may be harmful to your hearing. • The test button accurately tests all functions. Never use an open flame from a match or lighter to test this smoke alarm. You may ignite and set fire to the smoke alarm and your home. -
Page 35: Doors
(Escape) windows, screens are attached to swing out panel of window. Doors Locks on entrance doors have two lock mechanisms, a deadbolt in the frame section of lock and a standard lock in the handle. Both locks use the same key. All doors, entrance and baggage/trunk doors are keyed a like. -
Page 36: Slide-Outs
SLIDE OUTS Slide outs come in many sizes and different systems. In this model you have what is called “above floor slide-out”, all components are located inside and above floor, under sofa or under dinette. A single ram is attached to slide and is access-able inside on floor and lag bolts from ram mount into outer wall. - Page 37 OPERATION NOTE; 1. Before operating the slide room, level trailer front to rear and side to side. 2. Extend ALL stabilizer jacks to make contact with ground and/or solid blocks. Placing stabilizer jacks onto a hard surface allows the coach to remain square and assures a good weather tight seal between the room and trailer sidewall.
-
Page 38: Toy Hauler Group
DANGER *Always make sure that the trailer is level before operating slide-out room. *Always make sure that there are no obstructions blocking the path of the room when it is moving. *Always make sure that the path is clear of people and objects before operating. -
Page 39: Fuel In Cargo Area
Excess weight behind the axle lightens hitch weight, which may cause sway when passing vehicles and when gusty winds are present. Since these coaches are designed and built to carry such cargo in the rear portion of the unit, special care must be exercised in loading to prevent potential handling concerns. -
Page 40: Rear Cargo Door
4. DO NOT store or transport supplementary fuel within the vehicle. 5. Ventilate the interior of the vehicle to reduce the risk of fire, explosion or asphyxiation. 6. DO NOT operate gas appliances, pilot lights or electrical equipment when motorized vehicle or motorized equipment are inside the RV vehicle. REAR CARGO DOOR Rear door on Classic and Escape coaches have“... -
Page 41: Chapter 4 - Systems
CHAPTER 4 SYSTEMS WATER AND DRAINAGE PLUMBING Your KZ recreational vehicle has a complete water system, to carry fresh water, as well as holding tanks for used water. Each group has its own explanation along with its own operation. Tanks Water containers are installed inside of the coach are under the bed, dinette or sofa. -
Page 42: 12-Volt Demand Pump
CAUTION DO NOT leave tank unattended while filling. CAUTION Excessive pressure from water supply systems may be encountered in some parks, especially in mountain regions. Water pressure regulators are available to protect your system against such high pressure. A regulator at 45 pound rating is recommended to prevent damage to the plumbing sys- tem or components. -
Page 43: Bath And Shower
Bath and Shower Your bathtub and shower are built with ABS, Fiberglass & Waterproof Vinyl material, similar to those in your home. Shower curtains are provided with the coach and must be used to prevent water from spilling onto the floor, causing potential damage. The shower head used in the bathroom has a non- positive shutoff valve and will drip slightly in shut-off position. -
Page 44: Drainage (Fresh Water)
8. Drain solution and flush as desired with fresh water. Drainage (Fresh water) All permanent fresh water tanks can be drained. Two types of drains are used, (1) a push/pull, or, (2) a turn valve with open/close position. Valve is normally close to tank. To drain the supply lines and the entire system, you need to follow the steps listed below. -
Page 45: Using Toilet And Tank System
When hooked up to a sewer drain at a camp ground, ALWAYS keep the termination valve CLOSED until the tank is at least 3/4 full. This will provide To add To flush sufficient water to assist in complete draining of tank. Manufacturer toilet, Thetford... -
Page 46: Draining The Tanks
2. Place the recommended quantity of chemicals for waste holding tank as per instructions on the bottle into the toilet bowl. 3. Flush liquids into the tank and allow up to two gallons of water to flow into the tank. Each time you drain the tank, you should follow the above instructions before using. -
Page 47: Maintenance For Holding Tanks
Sam Camp Guide, KOA Kampgrounds Camp Guide, or various other publications. Some fuel stations also have dump stations. CAUTION It is important to use adequate water to flush and have several gallons of water with chemicals in the tank. This helps the flow of wastes and reduces solid waste build-up. -
Page 48: Black Flush System
Method 2 Using RV antifreeze in lines. To winterize the plumbing system. 1. Turn off the pump. 2. Drain the water heater and the entire water system. 3. Change the flow direction on By-Pass Kit by turning both valves 90 degrees to prevent anti freeze from entering water heater. - Page 49 Rinse for several minutes to remove any foreign matter from tank. Remember the moisture content may give you a false reading on your monitor panel indicating it is full. Allow time to dry out tank or recharge for next use. DANGER DO NOT use Ethylene Glycol (automotive antifreeze) or Methanol (windshield washer antifreeze) in your fresh water system because they are...
-
Page 50: Propane Fuel System
PROPANE FUEL SYSTEM The fuel system in your recreational vehicle has numerous compo- nents such as, piping, copper tubing, brass connectors, hoses, reg- ulators and appliances. Each of these components will be explained in its appropriate area. Propane is the only fuel permitted to be used in a recreational vehi- cle and its appliances. -
Page 51: Servicing And Filling Propane Containers
1. Main pass thru portion to fill container and draw propane from, is controlled by upper three sided knob. 2. 10% valve, a small screw on the side of main body allows any air to be released and indicates when container is filled to ca- pacity at 80%. - Page 52 When refilling propane containers, they are generally removed from propane compartment or tie downs. BE SURE to reinstall correctly, as shown in installation instructions, and test for leaks. When propane containers are filled to 80% level there is available space for safe expansion of the vaporized liquid. Should your con- tainer become slightly overfilled, pressure may rise due to hot sun.
- Page 53 When disconnecting propane containers, you must turn the ACME fitting in a clockwise direction because left-hand threads are utilized. When reconnecting, turn connections counterclockwise. Connec- tions must be tight, however DO NOT over-tighten. 1. Knob to open and close main valve. 2.
-
Page 54: Installing Propane Containers
Installing Propane Containers Classic and Escape recreational vehicles are equipped with 1 -20 pound propane container for each coach. Mounting and attaching instructions are listed below: 1. Locate the pre-installed screws (2) in the top of A-frame near tongue jack at front end. 2. -
Page 55: High Pressure Hoses With Acme Connectors
If pressure is too high, it affects performance and safety. Should pressure be too low, appliances will not operate correctly. An au- thorized technician with proper equipment should perform such tests and adjustments, as may be required. Your propane regulator that is used on Classic and Escape prod- ucts is the standard two stage regulator. -
Page 56: Operation
Should you experience a gas “freeze-up”, close the main valve and wait 15 minutes before trying again. Keep the container valve (s) closed when traveling. Some states prohibit traveling with the pro- pane container valves open, especially in underground tunnels on expressways. -
Page 57: If You Smell Gas
your own protection, the preceding warning label has been placed near the cooking area to remind you of the need of oxygen for combustion and breathing. Due to smaller area in your recrea- tional vehicle, there is less oxygen than in your home. Proper venti- lation is required when cooking. - Page 58 DANGER IT IS NOT SAFE TO USE COOKING APPLIANCES FOR COMFORT HEATING. Cooking appliances need fresh air for safe operation. Before operation: 1. Open overhead vent or turn on exhaust fan 2. Open window FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY. Unlike homes, the amount of oxygen supply is limited due to the size of the recreational vehicle, and proper ventilation when using the cooking appliance (s) avoid dangers of asphyxiation.
-
Page 59: Electrical System
ELECTRICAL SYSTEM General Information electrical system your recreational vehicle is designed for using both 120 volt AC (alternating current) and 12 volt DC (direct current) 30-A, 125-V, 2-pole, 3-wire, capabilities. installations grounding type designs are built to comply with safety requirements of ANSI standard 1192, National Electric Code and Canadian Standards Association. - Page 60 The following generic drawing shows the circuit breaker alignment with number one being the main breaker on all floor plans. Depending on the size, floor plan and options of your coach, circuit three through six will vary and possibly not all circuits will be used. Number two is generally the 20 amp air conditioner circuit.
-
Page 61: Gfci Protection
GFCI Protection Each coach has a GFCI, Ground Fault Circuit Interrupter, protection receptacle installed into the circuitry. This GFCI device is designed to protect people from hazards of line to ground electric shock. The purpose is to reduce possible injury caused by electrical shock, resulting from faulty installation improper polarity and related to moisture and/or earth ground. -
Page 62: Volt Dc System
12— Volt DC System Most interior lights and appliances receive 12-volt DC power through converter output and/or the auxiliary battery. Exterior lights and brakes also use 12-volt DC power from the tow vehicle battery and/or auxiliary battery through the seven way connecter and wire attached to the tow vehicle. -
Page 63: Auxiliary Battery
Auxiliary Battery All coaches are pre-built to accept an Auxiliary Battery, which is not provided by manufacture of your coach. Recommended batteries are of deep-cycle type as you need longer, slow consuming power rather than cold-cranking power. A battery is always required for a break-away switch to function. A battery requires routine maintenance for long life. - Page 64 DANGER DO NOT replace circuit breakers or fuses with a higher current rating than those supplied with your coach. Over-fusing can cause a fire hazard by overheating the electrical wiring. #1 – Black/Ground (8 Gauge) #2 – Blue/Brakes #3 – Green/Running #4 –...
-
Page 65: Exterior Lights And Connector (12V)
FURRION is a hook-up for a portable solar panel to be located on ground or table aimed into sun light. Hook-up is installed from rear wall to convertor area. Solar panel is available through after market and not from KZ RV. Main function is keep any auxiliary battery charged while camping. CAUTION Any electrical installation that does not meet the criteria of the manufacturer’s specification will VOID THE WARRANTY on the electrical... -
Page 66: Chapter 5 - Appliances
CHAPTER 5 APPLIANCES KZRV places quality-built equipment, as guided by current codes and standards, in all recreational vehicles. Some appliances are built and equipped to operate on propane gas ONLY. DO NOT attempt to operate on natural, or butane gas. Each appliance has its own specific manual, written and published by its manufacturer. -
Page 67: Operating Instructions
and/or the convertor in the coach. This power MUST be present before propane can enter through the control to the burner tube. The combustion chamber is completely sealed to prevent any carbon monoxide from entering into the coach. Oxygen is drawn into the chamber through the upper vent and exhaust fumes expelled through the lower vent. - Page 68 DANGER Be sure to follow all directions to operate furnace and to prevent any damages or malfunctions. Errors could cause personal injury. WARNING Do not install screens over the vents for any reason. Screens will become restrictions causing unsafe or inefficient operation. WARNING DO NOT operate furnace while vehicle is in motion or being towed.
-
Page 69: Cooking System
Any mechanical adjustments, such as electrode adjustments, should be performed by a qualified service technician. DANGER Do not use gas cooking appliances for comfort heating. Can lead to carbon monoxide poisoning, which can lead to death or serious inju- Gas cooking appliances need fresh air for safe operation. Before operating, open vents or windows slightly or turn on exhaust fan prior to using cooking appliance. - Page 70 3. If any burner should extinguish after initial lighting or due to accidental blow out, turn gas off by turning control knob clockwise to “OFF”. Wait five minutes before attempting to relight the burner. Failure to follow these instructions could result in an injury.
-
Page 71: Water Heater
CAUTION Before attempting to operate any water heater, you must be sure the heater is full of water. Failure to fill with water will result in the tank warping and the element burning up. WATER HEATER Several energy sources are available to heat water: ( 1) Propane gas and 12 volt DC combination. -
Page 72: Winterizing Your Water Heater
(storing it for the winter) and replace it with a 3/4 inch drain plug. REFRIGERATOR KZ recreational vehicle installs many different sizes and models of refrigerators operating on 120 volt AC , propane, and optional 12 volt DC energy sources. -
Page 73: Leveling
Leveling For correct operation, the refrigerator must be within three degrees of level in any direction. Continued operation outside of these limits will result in irreparable damage to the cooling unit in the refrigerator. Stay within 1 degree for best results. Venting For an absorption unit to operate fully it must have two vents. -
Page 74: Operation During Travel
Operation during Travel During travel over the road, camper will not be level, how ever the chemicals in cooling unit will also be moving preventing any problems. Keep the door shut to retain cold temperature during travel. AIR CONDITIONER —OPTIONAL Normal air conditioner is built into sidewall, near roof line and will be installed only by factory trained production personnel. -
Page 75: Important Information On Your Tent
of coach, more so at night than day. Such condensation can be reduced or possibly eliminated by opening the upper corner of bunk end panel, 1/2" to 1". Fold over to allow small quantity of air to move across roof panel at the end which has head of sleeping person. Each tent has bed bow mounted onto the bunk door which will swing into upright position. -
Page 76: Cleaning Your Tent
• Do not spray insect repellant or hair spray on fabric as these items may destroy water repellency of this fabric • Do not put tent away in wet conditions. This might be difficult when leaving campsite in raining conditions. If this does occur, within 24 hours be sure to open tents, set up completely for the tents to dry out to prevent any possibility of mildew to start. - Page 77 Important Phone Numbers _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ _________________________________ PDF created with pdfFactory trial version www.pdffactory.com...
Need help?
Do you have a question about the SPREE ESCAPE and is the answer not in the manual?
Questions and answers