1. Manuals
  2. Brands
  3. Treker Manuals
  4. Utility Vehicle
  5. 4420ST
  6. Operator's manual

Treker 4420ST Operator's Manual

Light utility vehicles
Hide thumbs
Table of Contents

Advertisement

Quick Links

Treker
4220ST & 4420ST Light Utility Vehicles
24700
Table of Contents
700-504M
Operator's Manual
!
Read the Operator's manual entirely. When
you see this symbol, the subsequent
instructions and warnings are serious - follow
without exception. Your life and the lives of
others depend on it!
© Copyright 2007 Printed
Cover photo may show optional equipment not supplied
with standard unit.
8/05/08

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 4420ST and is the answer not in the manual?

Questions and answers

Related Manuals for Treker 4420ST

Summary of Contents for Treker 4420ST

  • Page 1 Table of Contents Treker 4220ST & 4420ST Light Utility Vehicles 24700 700-504M Operator’s Manual Read the Operator’s manual entirely. When you see this symbol, the subsequent instructions and warnings are serious - follow without exception. Your life and the lives of others depend on it! ©...

  • Page 2: Table Of Contents

    Safety First ......1 Treker Options ......23 Using This Manual .

  • Page 3: Section 1: Introduction

    This places additional responsibility on the driver to The Treker line of light utility vehicles is designed by Land operate this vehicle well within safe operational limits and Pride exclusively for off-road use. They are not designed capabilities of the unit.

  • Page 4: Owner Assistance

    Table of Contents Section 1: Introduction Driving a Treker is as easy as driving a pickup with an Serial Number Plate automatic transmission. A simple forward and reverse Refer to Figure 1: shifter provides direction control. A neutral start feature...

  • Page 5: Section 2: Important Safety Information

    List" on page 15. etc., when conditions warrant. read and comprehended this No driver under age of 16. manual and who has not been properly trained in the safe operation of the equipment. 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...
  • Page 6 Because operating equipment involved. safely requires your full attention, avoid wearing radio headphones while operating machinery. It is the discretion of the operator and passenger to wear Seat Belts when available. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 7: Safe Operating Procedures

    The safe operation of any machinery is a big concern to avoid tree limbs and brush that have a potential of hitting all consumers. Your Treker has been designed with many and/or poking individuals riding the vehicle. Serious body built-in safety features. However, no one should operate harm could result.

  • Page 8: Transporting Safety

    The heavier the cargo load, the slower the hazards or traffic. turn should be. The 4-post accessory bar is not a certified ROPS (Roll Over Protection System). Always avoid roll-overs. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 9: Towing Safety

    25 MPH vehicle speed. Towing Safety Follow all towing instructions in this manual when towing the Treker behind another vehicle. Do not tow the vehicle faster than 25 MPH. See "Towing" on page 20. Beware, tow ropes, cables and chains can break when...

  • Page 10: Safety Decals

    Land Pride. When ordering new parts or components, also request corresponding safety decals. Your Treker comes equipped with all safety labels in place. 4. Refer to this section for proper label placement. Install new They were designed to help you safely operate your implement.
  • Page 11 Table of Contents Section 2: Important Safety Information 838-532C Warning: Cab Rollover Protection 24697 838-492C Caution: Maximum Power Source 24697 838-490C Caution: Stop Engine 24697 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...
  • Page 12 Table of Contents Section 2: Important Safety Information 838-486C Warning: General Utility Vehicle 24694 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...
  • Page 13 Table of Contents Section 2: Important Safety Information 838-570C Vehicle Loading Capacities, 4220ST Series 24694 838-663C Vehicle Loading Capacities, 4420ST Series 838-579C Trailer Towing Information 21147 838-508C 24735 Warning: Before Filling Tank with Gasoline 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...
  • Page 14 Table of Contents Section 2: Important Safety Information 21110 838-491C Warning: Improper Use 21110 838-489C Warning: Rollover Hazard 838-444C Danger: Muffler hot 24695 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 15: Section 3: Pre-Delivery And Check List

    39 if oil is low. ___Check tail lights and brake lights to make sure they are ___Check overall appearance for cleanliness and for body working and are properly mounted. and molding damage. 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 16: Dealer Test Ride List

    ___Fuel transportation and storage procedures have been explained. ___Fluid fill and lubrication points have been located and explained to customer. ___Customer has completed the driving course. ___Information on safety decals have been reviewed with customer. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 17: Section 4: Operating Instructions

    5. Turn ignition key counterclockwise to stop engine. • Turn on headlights to make sure battery has a charge Operating a Treker is as easy as operating a car with an and electrical lighting circuit is working. automatic transmission. A simple forward and reverse •...

  • Page 18: Indicating Lights And Gauges

    Dump Switch: An electric cylinder raises and 21460 lowers the cargo box. Press top of switch and hold to Figure 4-3 raise cargo box. Press bottom of switch and hold to 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 19: Choke

    22482 should not move when engine is idling. Adjust Shift Selector Shown in Park engine idle speed if vehicle moves while accelerator Figure 4-6 pedal is not being depressed. 24694 Figure 4-5 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 20: Fuel Gauge

    Two seat belts are factory supplied with the bench seat. A third accessory seat belt may be added. See “Treker Accessories” on page 24. It is the responsibility of the operator and passenger to decide if their situation warrants using seat belts.

  • Page 21: Glove Box Enclosure

    3. Pull gate release lever (#7) back on both sides and remove gate (#3) from cargo box. 4. Replace flat washers (#5) and cotter pins (#6) in 234699 tailgate cable pins (#8) for storage. Figure 4-12 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 22: Towing

    Treker. extremely important to change oil and oil filter often • Do not allow anyone to ride in the Treker while it is being whenever there is a high frequency of gas getting into the towed. oil reservoir. Not changing oil and oil filter often can result •...

  • Page 23: Traveling Tips From The Trail Masters

    2. Plan your gear and gear up for the best and worst of with the bottom of floorboards, but you must keep environmental conditions. these considerations in mind; you must know how 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...
  • Page 24 Remember, the only one who can prevent and avoid an accident is the operator in control and that’s you! 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 25: Section 5: Options And Accessories

    There are two types of tires available for your Land Pride Refer to Figure 5-1: Treker. See Figure 5-3. The All Terrain Tire is a good tire The front bumper is the most economical bumper option. to choose when traction is your first priority. This tire is a It can be unbolted from the Treker to add the optional tough tire for going over rough terrain.

  • Page 26: Treker Accessories

    Land Pride versatile full component package designed to plant or Treker a very functional and useful vehicle. See your spread seeds. It can then be used to spread prilled or nearest Land Pride Dealer for all available accessories.

  • Page 27: Section 6: Maintenance

    Correcting the problem as quickly as possible is It is important for your safety and the safety of others that the best insurance. the tires have correct air pressure. Check air pressure in 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 28: Jacking The Vehicle

    Then carefully lower jack until vehicle up before repositioning the rear shocks. vehicle is on the ground. 2. Refer to Figure 6-3. Locate shock absorber’s top three 8. Remove wheel chocks. mounting holes. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 29: Electrical System

    Always follow manufacturer’s maintenance, for troubleshooting and repair. safety, storing and charging specifications. Major overhaul or repair of starting motor and alternator should be performed by trained technicians only. 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 30: Adding Water To The Battery

    Prepare Vehicle to Jump-Start each cell should be up to the level indicator. If not, add 1. Use only a 12-volt battery to jump-start the Treker. water. Distilled water should be used to fill each cell in the Higher voltages can damage starter motor and other battery.

  • Page 31: Fuel System

    2. Cleans engine during operation. Allow engine to cool before filling. Spilling fuel over 3. Eliminates gum-like varnish build-up in the fuel system. engine, muffler, or a hot object may result in a fire or explosion. 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 32: Engine Maintenance

    6. Reattach fuel filter to fuel line with arrow on filter Treker vehicles shipped from the factory are stocked with pointing in the same direction fuel flows in the line. carburetors designed to operate efficiently between 0 Fuel flows towards the engine.

  • Page 33: Drive Belt Replacement

    Part No. Part Description remove cover. 6030-3001 DRIVEN PULLEY CAM SHOE 3. Hand squeeze the belt together between drive pulley (3 required) and driven pulley to force belt into the driven pulley. 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 34: Engine Air Filter Maintenance

    Also A specially designed dry filter is standard equipment on check gaskets for cuts or tears. Do not attempt to use the Treker and supplies clean combustion air to the a damaged element. A damaged element will allow engine.

  • Page 35: Cvt Snorkel Filter Maintenance

    Land Pride and the engine manufacturers have carefully selected a reliable filter designed to fit the needs of the Treker engines. Always specify a Land Pride filter part number 839-323C. Always use genuine Land Pride filters. Not using original equipment replacement parts is an alteration and will not be considered for warranty in the event of a dust ingested engine problem.

  • Page 36: Exhaust System

    Be careful not to damage spark arrester screen. 3. Inspect spark arrester for holes or breaks in the screen and replace if damaged. 4. Reattach spark arrester to muffler with mounting screw. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 37: Park Brake Adjustment

    2. Set shift selector in park. 15. Set shift selector in park, lower cargo box and remove wheel chocks. Ball Detents 23546 Park Brake Calipers Figure 6-13 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 38: Maintenance Schedule

    (10) Replace fuel filter immediately if excessive water accumulation or sediment is found. (11) Maker certain engine and exhaust are cool before cleaning. Check and clean engine fan cooling screen often when traveling in dirty trashy terrain. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 39: Section 7: Lubrication

    Make all subsequent oil changes every 6 months or every 100 hours of operation (whichever comes first). 6. Replace filler cap and dipstick. 21135 Engine Oil Fill, Drain and Check Locations Figure 7-1 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...
  • Page 40 See "Level Check" on page 37. 10. Replace filler cap, start engine and check oil filter for leaks. 11. Stop engine and check oil level as outlined in section titled “Engine Oil Level Check” on page 37. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 41: Case Oil

    Trans-axle case oil capacity: 20 oz. Quantity: Fill to center line of output shaft. (Approximately 4 1/2” from top of fill opening to top of oil level.) Drain Plug 24707b Rear Trans-axle Drain Plug Figure 7-5 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 42: Center Transfer Case

    Drain plug location: Bottom center (see large arrow) Type of lubrication: Mobil 424 Front differential Case oil capacity: 5 oz. (Approximately 1/4” from bottom of fill opening to top of fill opening.) 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 43: Brake Fluid

    See also "Section 10: Specifications and Capacities" on page 45 Fill cap location: Located on driver’s side of vehicle under front hood. (see Figure 7-8) Type of fluid: DOT 3 Quantity: Fill to line on reservoir. 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 44: Section 8: Seasonal Storage

    12. Check and inflate tires to correct air pressure. valve mechanism. 7. Clean exterior surface of engine. Spread a light film of oil over any exposed metal surfaces of engine that are subject to corrosion. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 45: Section 9: Body Repair

    Table of Contents Section 9: Body Repair Section 9: Body Repair Introduction Scratch Land Pride Treker bodies are constructed of ABS with Required Tools and Materials (See note to left) WeatherPro G Color Cap. Scuffs, light scratches and • 1,000 rpm buffing tool, DeWalt #849 deep gouges are in most situations repairable.
  • Page 46 7. Apply color-matched paint system with HVLP paint • DuPont Chroma Base/ Clear Coat Paint System sprayer according to supplier’s recommendations to • HVLP Paint Sprayer meet WeatherPro G’s surface finish, i.e. DuPont’s two part Base/ Clear coat system. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 47: Section 10: Specifications And Capacities

    3rd seat belt available as an accessory. Base unit does not include optional cargo racks. ** Tire pressure may be increased to accommodate additional cargo load. Max.tire pressure is noted on tire side wall. 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 48: Section 11: Features And Benefits

    For added security and convenience. Dash Mounted Shifter For added convenience. with Integral Park Brake Removable Cargo Box Sides For added versatility. Warranty One year against manufacturing defects. Two years manufactured engine warranty. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 49: Section 12: Troubleshooting

    Engine oil level is low. Add specified engine oil. Carburetor air intake tube is plugged. Clean air intake tube. Air cleaning element is plugged or Replace or clean air cleaner with air. missing. 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...
  • Page 50 Adjust neutral switch to be engaged with shift selector in neutral. Shifter link is out of adjustment. With shift selector in neutral, adjust shifter link at engine to be in neutral position. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...
  • Page 51 Harness pin connections are bent. Straighten harness pins. Harness is defective. Replace harness. Ignition switch is defective. Replace ignition switch. Starter is defective. Replace starter. Engine oil is too heavy. Replace with SAE 10W30 oil. 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...
  • Page 52 Drive belt is wet and slips. Rev engine in neutral for one minute. Drive belt is worn. Replace drive belt. 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 53: Section 13: Appendix

    Tire Inflation Chart Tire Inflation PSI Front Tires 7 psi Rear Tires 7 psi Tire pressure may be increased to accommodate additional cargo load. Maximum tire pressure is noted on tire side wall. 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...

  • Page 54: Notes

    Table of Contents Section 13: Appendix Notes 8/05/08 4220ST & 4420ST Light Utility Vehicles 700-504M...

  • Page 55: Land Pride Limited Warranty

    Any breach of warranty claim must be brought forth within 15 months of original sale. Legal Rights This warranty gives you specific legal rights and you may also have other rights which vary from state, province or country. Effective January 2, 2003 4220ST & 4420ST Light Utility Vehicles 700-504M 8/05/08...
  • Page 56 Corporate Office: P.O. Box 5060 Salina, Kansas 67402-5060 USA www.landpride.com...

Table of Contents