Flame King YSN320K Operating Instructions And Parts Manual

HEAVY DUTY ROOFING TORCH
Operating Instructions and Parts Manual For Models:
Model
YSN320K
Conforms to UL 147- 201 6
Certified to CGA 2.29-1997 (R2014)
Safety Hand-Held Torches for Fuel Gasses
• Gloves should be used at all times. Long sleeves, long pants & boots are recommended.
• Use only vapor torches on cylinders equipped with vapor withdrawal valves.
• Secure cylinders in a level, upright position. Do not invert or lay cylinders on their sides.
• Do not apply flame to cylinders to check for leaks or to increase gas pressure.
• Keep torches, open flame and sow· c es of ignition away from cylinders, regulators and
hose.
• Do not operate torches or any equipment if the odor of L P-Gas is evident. Immediately
shut off all valves and, using soapy water, check all equipment for leaks.
• Cylinder valves must be protected. Do not hoist a cylinder by the valve.
• Do not leave the torch unattended while in operation.
• Do not stand or prop the torch on the burner end while in operation.
• This equipment is for outdoor use only with adequate ventilation.
• Have a type ABC fire extinguisher on the job site, easily accessible to the person operat­
ing the torch.
Flame King
Riverside, CA 92507
Tel (310)715-1122
info@flameking.com www.flameking.com
Please Read All
Instructions and Save
These Instructions For
Future Reference.
• This device is intended
for outdoor use only.
• This torch is designed for a
vapor-withdrawal LP-Gas cylinder only.
Maximum rating value BTU/HR
319960
I·
C US
Safety Check List:
DO NOT OPERATE THIS EQUIPMENT IF:
• You are subject to seizures, loss of
consciousness, or fainting.
• You have been drinking alcohol, using
illicit drugs, or prescription drugs that
might effect your judgment or balance.
• You have not read or do not
understand the operator's manual.
• You are not capable of safely
operating ti1is type of equipment.
DO NOT A L LOW CHILDREN TO
OPERATE THIS EQUIPMENT.
FOR YOUR SAFETY!
lfYou Smell Gas:
I. Shut off gas to the device.
2. Extinguish any open flame.
3. Check the device for leaks using
soapy water.
4. DO NOT attempt to relight the
device until leaks are repaired and
there is no gas smell
DO NOT use this device in areas
where gasoline or other liquids having
flammable vapor are stored or used.
WARNING:
Use extreme caution at all times. You
are using an intense open flame. This
torch produces an extremely hot and
nearly invisible flame. Read and follow
the Safety Check List and Daily Equip­
ment Check List before attempting to
operate this torch.
CAUTION
• Propane is heavier than air which can
cause it to accumulate in low areas. Be
certain all areas are well ventilated.
• Propane has a distinct ODOR. If you
smell i� IMMEDIATELY discontinue
work, extinguish all fl a mes, locate the
leak and correct it, ventilate area
before lighting torch.
• Use extreme caution at all times.
This device has an intense open flame.
Disregard of safe practices can result in
severe fire damage, personal injury, or
possible death.
• Never direct torch flame toward any
person or animal.
NOTE:This torch is designed to
combust vapor-fuel output from an
approved propane cylinder, do
allow liquid-fuel to feed the bur
head.