Page 1 BY GRAND DESIGN RV OWNER’S MANUAL...
Page 2 This page is intentionally blank.
Page 3 THANK YOU for purchasing a Grand Design recreational vehicle to enjoy the adventure, leisure, and fun of the RV lifestyle. Your new RV has been designed and built to Grand Design’s highest quality and safety standards. To keep you and your family safe, our products meet or exceed all applicable state and federal regulations, standards and requirements as well as those of the Recreational Vehicle Industry Association.
Page 4 This page is intentionally blank.
Page 5: Table Of Contents
Travel Trailer Owner's Manual Table of Contents Introduction ......Reporting Safety Defects .
Page 6 This page is intentionally blank.
Page 7: Introduction
RV. Grand Design RV Customer Service Contact Information If you have any questions, concerns, or require assistance regarding any aspect of your RV, please contact your dealer or Grand Design RV Customer Service. Contact Information: www.gdrv.com Website customerservice@gdrv.com...
Page 8 Owner Information Package. Some component manuals are ONLY available on the manufacturer’s website. Manufacturing Certification All Grand Design RV fifth wheels and travel trailers are built to meet or exceed the thorough safety and manufacturing codes, standards, and regulations of the Recreational Vehicle Industry Association (RVIA).
Page 9: Vehicle Identification Number
A-frame. It is also listed on the Federal Certification label. are also the RV's serial number. A breakdown of a typical Grand Design RV VIN is shown in the For the example shown, the serial number is S3300001. example below:...
Page 10: Safety Precautions
Introduction Safety Precautions Nothing is more important than the personal safety of you, your Various safety and family and others. Safety encompasses several areas related information labels to the RV experience. This includes driving/towing safety, are attached to surfaces both inside occupant safety, operational safety, environmental safety, and and outside your RV.
Page 11 Additional Terminology Used [Customer Supplied] This denotes aftermarket items not installed or included by Grand Design RV. Items noted as “customer supplied” are not covered by the Limited Towable Base, Limited Towable Structural, and Limited Towable Frame Warranties.
Page 12: Reporting Safety Defects
If they determine that a safety defect exists in other vehicles, a recall and remedy campaign may be ordered. The NHTSA does not become involved in individual cases between you, your dealer, or Grand Design RV. To contact the NHTSA, www.nhtsa.gov...
Page 13: Service & Warranty
Limited Towable Frame Warranties. The Limited 4. SEND your completed Warranty Registration and Towable Base, New Vehicle PDI Check List to Grand Design RV. Limited Towable Structural and Limited • Your registration form is required within 30 days of Towable Frame Warranties the delivery date to activate your warranty coverage.
Page 14: Owner's Responsibilities
◦ We recommend warranty and maintenance services or loss of warranty. be performed by your Grand Design RV dealer. • It is important to protect yourself and others with insurance coverage for your RV. Your insurance agent can assist you in obtaining the appropriate insurance coverage for personal liability, theft, collision, property damage, etc.
Page 15: Obtaining Warranty Service
• If a problem re-occurs after leaving the dealership, Please familiarize yourself with the RV dealer or repair contact the dealer’s service manager and Grand Design center’s policies. RV Customer Support, to quickly resolve the issue.
Page 16: Obtaining Emergency Warranty Repair
FOR REIMBURSEMENT: You or the RV repair facility must send a copy of your Itemized Repair Bill, and ◦ RETURN all requested parts to Grand Design RV by UPS (regular ground, freight pre-paid) within 60-days of the completed repair date.
Page 17: Replacement Parts
(or any effect of the alterations) to any of the parts, components, systems, or assemblies installed by Grand Design RV. Grand Design RV is not responsible for the safety or quality of design features, materials, or workmanship of any alterations...
Page 18 (used) Grand Design RV. Federal law requires that we keep the contact information current for all Grand Design RV owners (mailing address, phone number, and email) in order to promptly contact you in the event of a customer notification letter or recall.
Page 19 • Three-Year Limited Towable Structural Warranty • Five-Year Limited Towable Frame Warranty The three Grand Design RV Warranties are printed in the Grand Design RV Fifth Wheel / Travel Trailer Warranty Grand Design RV Fifth Wheel / Travel Trailer Warranty &...
Page 20: Component Supplier Contact Information
Service & Warranty Component Supplier Contact Information All component suppliers listed are correct at the time of printing. Grand Design RV may change components at their discretion. Please contact GDRV Customer Support with any questions. Phone Component Brand Supplier Website...
Page 21: Component Manufacturer Warranty Information
Service & Warranty Component Manufacturer Warranty Information Each OEM component equipped on your Reflection TT carries their own manufacturer warranty. Details can be found on the individual company websites or by contacting them by phone. Warranty information is accurate at time of printing but is subject to change at any time per the manufacturer.
Page 22 This page is intentionally blank.
Page 23: Occupant Safety
Occupant Safety Occupant Safety Your Reflection Travel Trailer is designed with safety as the top WARNING priority. This RV meets or exceeds the safety standards and applicable codes in effect at the time it is built. All required safety items are carefully installed to protect you and the...
Page 24 Occupant Safety Pet Safety Emergency shelters could refuse to admit pets due to health or space reasons. The survival of a beloved pet often depends on the careful plans their owner has made in advance. • Prepare an emergency plan for pets that includes a 3-day supply (at least) of dry food and fresh water.
Page 25: Fire Safety
911 from a safe location. • In a fire emergency, execute your Family Safety Plan. NOTIFY • Make sure everyone knows to Stop, Drop & Roll Grand Design RV Immediately if their clothes catch fire. if you feel that product failure if you feel that product failure ◦...
Page 26: Fire Extinguisher
Occupant Safety Fire Extinguisher A fire can spread very fast. BEFORE using the fire extinguisher, CAUTION remember that safe escape is the most important part of any fire response plan. If there is a fire in or around your RV: AVOID inhaling the dry •...
Page 27: Emergency Egress Window
Occupant Safety Disposal Please check the local laws BEFORE disposing of your used (non-refillable) dry chemical fire extinguisher. Contact your local fire, sanitation or environmental protection department for rules on disposal. Emergency Egress Window An emergency egress window The Emergency Egress Window (or exit window) is your is identified with secondary exit, if the RV's entrance door becomes blocked an "EXIT"...
Page 28: If The Smoke Alarm Sounds
Occupant Safety Smoke Alarm The smoke alarm is located on the ceiling in the main living area of your RV. It is intended to help reduce injury or loss of life in a fire. Proper use can give you time to escape, but they are not foolproof.
Page 29: Carbon Monoxide (Co)
Occupant Safety Battery The smoke alarm will NOT function if the battery is: WARNING • Missing, Disconnected, or Dead. • Installed incorrectly. The Smoke Alarm does NOT operate • The wrong type. without working batteries. DO NOT disconnect the battery to silence the smoke alarm. REPLACE the 9-volt battery in your Smoke Alarm when it chirps Removing the batteries, or failure to replace them at...
Page 30: Carbon Monoxide (Co) Alarm
Occupant Safety Carbon Monoxide (CO) Alarm The CO alarm will sound if Carbon Monoxide (CO) in the air inside your RV reaches dangerous levels. If you hear this alarm, evacuate the RV immediately and stay outside in fresh air until the CO alarm ceases.
Page 31 Occupant Safety Test the CO alarm weekly TEST the CO alarm at least once EVERY WEEK to make sure that WARNING it is working properly. Stand at arm’s length from the alarm when testing. The alarm horn is loud and may be harmful TEST Carbon Monoxide to your hearing.
Page 32 Occupant Safety Propane Gas (LP) Alarm, Continued • Register your SAFE-T-ALERT product online at: mtiindustries.com/product-registration/ High temperatures can activate glue and adhesive vapors. If your RV is closed on a hot day, the chemicals used in its construction may be detected, even months after the vehicle was built. See page 27-30, Indoor Air Quality, Chemical Sensitivity &...
Page 33: Indoor Air Quality
Occupant Safety Battery or converter power source The propane gas alarm runs on a small amount of 12-volt DC from the converter or auxiliary battery. This slight current draw can still drain your auxiliary battery during an extended storage period. The Low Voltage Warning will sound if the charge drops below 8 volts.
Page 34 Occupant Safety Indoor Air Quality, Continued • CLEAN & VACUUM often to get rid of dust and pet fur which can irritate your nose and throat. • DO NOT use bug spray inside your trailer. • DO NOT smoke inside your RV. In addition to causing damage to your RV, tobacco smoke releases formaldehyde and other air pollutants.
Page 35 Occupant Safety Chemical Sensitivity & Outgassing When you first purchase your new RV, or after it has been closed for an extended time, you may notice a chemical odor due to outgassing. This is normal, and not a defect. Outgassing (or offgassing) is the release of a chemical gas that was dissolved, trapped, frozen or absorbed in a material.
Page 36: Effects Of Prolonged Occupancy
(MDF), and plywood which are commonly used throughout the Recreational Vehicle Industry. As mandated by the RV Industry, Grand Design RV recreation vehicles contain composite wood products (hard- wood plywood, particle board, and MDF) that comply with the California Air Resource Board (CARB) formaldehyde emission standards under California Code of Regulations §...
Page 37 Occupant Safety Tips for controlling condensation To reduce moisture in the air inside your RV, use these tips: If the tips presented here for controlling • Allow excess moisture to escape to the outside when condensation are bathing, washing dishes, hair drying, laundering and NOT effective, it may be necessary for you using appliances and non-vented gas burners.
Page 38 Occupant Safety Where There is Moisture, There May Be Mold Molds are microscopic organisms that can live in virtually any indoor or outdoor environment. Mold growth requires a source of moisture (high humidity, wet/damp materials, standing water) and a temperature between 40° and 100° Fahrenheit. According to the Center for Disease Control, exposure to damp and moldy environments may cause a variety of health defects, or none at all.
Page 39: Cold Weather Use
• To avoid damage to parts, CHECK the outside of the RV for ice BEFORE operating the: slideouts, compartment doors, locks, windows, vents etc. If you have further questions, please contact your dealer or Grand Design RV Customer Service.
Page 40 Grand Design RV has no control and for which Grand Design RV assumes no respon- sibility: Grand Design RV shall have no liability for any loss or injury caused, in whole or in part, by its actions, omissions or negligence, or for any contingencies beyond its control in procuring, compiling or delivering any information.
Page 41: Additional Safety Precautions
External or third party links may be provided for the convenience of the users of that website. Grand Design RV is not responsible for the availability or content of these external or third party sites...
Page 42: Passenger Safety
Occupant Safety Additional Safety Precautions, Continued Loading & Weight Distribution • Distribute cargo weight evenly throughout your vehicle. • NEVER exceed your RV's Cargo Carrying Capacity or Gross Vehicle Weight Rating. • Place heavy items in the center of your vehicle, on the floor. •...
Page 43: Pre-Travel Information
Grand Design will tow your RV with one that you already own. Discuss the RV recreational vehicle as a GVWR, size and type of RV that you will be towing.
Page 44: Vehicle Labels
• Ratings are maximum limits, NEVER to be exceeded. potential damage, may void a warranty, may complicate These limits are established by Grand Design RV and our an insurance claim, and in component manufacturers in the design of the vehicle.
Page 45: Weight Labels
Vehicle weight labels are affixed to your RV to help you make an informed decision before your purchase. DO NOT REMOVE THESE LABELS. If the labels are missing, contact your dealer or Grand Design RV Customer Service for replacements. Federal Certification Label This label specifies the maximum capacities for GVWR, GAWR and tires.
Page 46 / rear cap if not equipped or installed with a bumper. Recreational vehicle overall length excludes some RV accessories as defined by Grand Design RV, including but not limited to: • Safety-Related Equipment, (Signal, Clearance, or Identification Lamps;...
Page 47: Cargo Capacities
• Unloaded Vehicle Weight is calculated with empty LP bottles. • Cargo Carrying Capacity is calculated including the weight of full LP bottles. CCC = GVWR - (UVW - LP gas weight) If you have further questions, please contact your dealer or Grand Design RV Customer Service.
Page 48: Loading Your Rv
Pre-Travel Information Loading Your RV Evenly distribute your cargo side-to-side for safe travel. WARNING • The weight on each tire must not exceed one-half of the GAWR (Gross Axle Weight Rating) for either axle. ONLY store items in the areas designated for storage. DURING A SUDDEN STOP, free-standing furniture or DO NOT store anything in the areas reserved for...
Page 49 Pre-Travel Information To weigh your Tow Vehicle and RV BEFORE you begin, read through all the weighing instructions. WARNING Your RV must be weighed FULLY LOADED (i.e., with food, water, clothing, supplies, propane, fuel, etc.). Exceeding the established weight ratings for the 1.
Page 50: Tire Safety Information
Pre-Travel Information Tire Safety Information This portion of the Owner’s Manual contains tire safety inform- ation as required by 49 CFR 575.6(4) and is based in part on the National Highway Traffic Safety Administration’s (NHTSA) brochure titled Tire Safety, Everything Rides On It. It is available as a free download on the NHTSA website: https://rosap.ntl.bts.gov/view/dot/16477 Studies of tire safety show that the most important things...
Page 51: Maximum Load Rating
Pre-Travel Information Maximum Load Rating The Maximum Load Rating indicates the maximum load in kilograms and pounds that can be carried by the tire. Maximum Permissible Inflation Pressure Because tires are designed to be This number is the greatest amount of air pressure that should used on more than one type of vehicle, ever be put in the tire under normal driving conditions.
Page 52: Checking Tire Pressure
Pre-Travel Information Checking Tire Pressure It is important to check the cold inflation pressure of your WARNING RV’s tires at least once per month for the following reasons: • Most tires will lose air naturally over time. Always check tire pressure when tires are cold.
Page 53: Steps For Determining Correct Load Limit
Pre-Travel Information How Overloading Affects Your RV & Tires DANGER • OVERLOADING your RV can have serious consequences for passenger safety. If the total weight of the RV exceeds the GVWR, • OVERLOADING your RV can make your tow vehicle the trailer is overloaded.
Page 54: Tire Safety Tips
Pre-Travel Information Tire Safety Tips Preventing tire damage • DO NOT run over curbs or foreign objects in the roadway or when parking. • SLOW WAY DOWN if you can not avoid a pothole or other object in the road. Tire safety checklist 1.
Page 55: Speed Rating
• The last two-digit number is the diameter in inches of the wheel or rim. For further information, please contact a tire dealer or Grand Design RV Customer Service. Speed Rating • Typical ST tires have a speed rating designation of "L", which is 75 mph (under normal inflation and load conditions).
Page 56: Tire Tread
Pre-Travel Information Tire Tread The tire tread provides the gripping action and traction that prevent your vehicle from slipping or sliding, especially when the road is wet or icy. In general, tires are not safe and should be replaced when the tread is worn down to 1/16 of an inch. Tread wear bars are raised sections built into the bottom of a tire's tread grooves that show how much tread is remaining.
Page 57: Spare Tire
Pre-Travel Information Spare Tire The spare tire is secured below your RV. Use your spare tire if a trailer tire is damaged, flat, or loses air pressure. The spare tire/wheel may differ from the original equipment, and is intended for temporary use ONLY. To lower the spare tire: •...
Page 58: Wheel Nut Torque
Pre-Travel Information Wheel Nut Torque WARNING • The lug nuts on your RV wheels require frequent torque maintenance. Always torque the wheel • Torque is the amount of rotating force applied nuts to the specifications of the wheel manufacturer. to a fastener, such as a lug nut. Over or under-torqued wheel nuts can cause the wheel to separate from the...
Page 59: Roadside Emergency
Pre-Travel Information Roadside Emergency A roadside emergency can happen at any time. ALWAYS carry an emergency kit with three red warning signs (or indicators) to display if necessary. If you must make an emergency roadside stop: • Pull off the road as far as possible. •...
Page 60: Tire Linc
Tire Linc is a Tire Pressure and ® Temperature Monitoring System (TPMS). The TPMS issues an alert via the Grand Design Compass Connect app or the Alert Indicator ® when a trailer’s tire(s) Banded Internal TPMS Sensor Banded Internal TPMS Sensor detects pressure or temperature outside of the programmable range.
Page 61: Sensor Pairing
Pre-Travel Information Tire Linc LCD Display ® Pairing, Configuration NOTE: Pair Mode is usually not necessary for the display to pair to the repeater. Pair Mode is needed only when attempting to pair the display to the repeater and more than one repeater is located nearby.
Page 62 This page is intentionally blank.
Page 63: Towing & Leveling
Towing & Leveling Towing & Leveling To improve safe driving and help protect against injury, WARNING please follow these recommendations: • Keep the RV and tow vehicle tires properly inflated, and DO NOT leave children REPLACE the tires BEFORE they are excessively worn. or pets unsupervised in or around the RV (even if children are secured by...
Page 64 Towing & Leveling RV Driving Schools & Seminars If you have any concerns about driving while towing a RV, consult an expert for specific RV driver education. There are private RV schools and some RV owner's organizations that offer driving seminars. The schedules and locations of the various RV driver education seminars and schools can be researched through RV-related publications and websites.
Page 65: Battery Isolator
Towing & Leveling Battery Isolator (Customer Supplied) You may want to install a battery isolator on your tow vehicle. WARNING A battery isolator is a device that: Be certain there is enough • Receives current from the tow vehicle alternator to “slack”...
Page 66: Abs - Anti-Lock Braking System
Towing & Leveling ABS - Anti-Lock Braking System (If So Equipped) Operation Pair System Pair System 1. OPEN the OneControl app’s Add And Manage tab (Fig. 1) and PRESS the arrow to the right of Safety Systems (Fig. 1A). 2. LOCATE the device’s QR code (Fig. 2) on a peel-off label placed in an interior cupboard or on support documentation.
Page 67 Towing & Leveling NOTE: The password from the QR code label will be needed in order for the phone to connect. 7. PRESS Continue (Fig. 7A) in order to enter RV information. 8. ENTER the RV details, including year, manufacturer and model (Fig. 8). 9.
Page 68 Towing & Leveling LIPPERT ANTI-LOCK BRAKING (ABS) SYSTEM ASSEMBLY AXLES Brake Magnet Power ABS Sensor ABS Hub Sensor Connection Connect to 7-Way Connector Brake Magnet Ground Wire Power Harness Sealed Wire Connectors Sensor Harness Control Module Web: - https://support.lci1.com/documentation/ - Ph: 432-LIPPERT (432-547-7378) - Email: customerservice@lci1.com Rev: 04.23.22 CCD-0004490...
Page 69 Towing & Leveling Unpair Unpair System System 1. To unpair the system, press the arrow by the Anti-Lock Braking System (Fig. 11A) listed under the Safety Systems tab. 2. PRESS the UNPAIR button (Fig. 12A). 3. SELECT OK (Fig. 13A) if electing to unpair the system. The contents of this manual are proprietary and copyright protected by Lippert Components, Inc.
Page 70: Safety Chains
Towing & Leveling Safety Chains Safety chain requirements vary from state to state. Your RV is WARNING equipped with chains to meet SAE standard requirements for maximum gross trailer weight. ALWAYS use safety chains when • ALWAYS have the safety chains attached when towing. towing your RV.
Page 71 TT / tow vehicle combination. to the RV frame. • Grand Design RV cannot • BEFORE selecting a hitch, you must know the GVWR be responsible for the tow and HITCH WEIGHT of your RV.
Page 72: Hitch Height & Hitch Ball
Towing & Leveling Hitch Height & Hitch Ball To determine your RV hitch height, make sure the RV is level. When the loaded trailer is hitched to the tow vehicle, check the hitch ball height by measuring the distance from the center of the hitch ball to the ground.
Page 73: Weight Distributing System
Towing & Leveling Weight Distributing System (Customer Supplied) Aftermarket weight distributing hitch systems provide a more WARNING stable tow vehicle/travel trailer towing combination. This system will spread the weight evenly to distribute it to the front and rear NEVER allow anyone to tow vehicle axles and the trailer axle.
Page 74: Road Conditions
Towing & Leveling Towing the RV Braking & Stopping Distance WARNING Towing an RV greatly increases your stopping distance. Practice braking in a large parking lot (where it is permissible) to become Towing items behind RV familiar with your RV’s stopping distance before driving in traffic. or overloading the rear will void the warranty and •...
Page 75: Turning Corners
Towing & Leveling Passenger Safety • DO NOT allow anyone to ride inside as a passenger while your RV is in motion. • This practice is against the law in several states. Turning Corners WARNING While making a turn: • When making a turn, •...
Page 76 Also see page 96. • Please read the Compass Connect manual found ® in your Owner Information Package before downloading and using the Grand Design Compass Connect App. ® The Grand Design Compass Connect Application is based ®...
Page 77: Leveling The Rv
Towing & Leveling Leveling the RV BEFORE operating the leveling system: Please read the Ground Control 3.0 System Owner’s Manual (beginning on page 73) for instructions on how to level your RV with the manual LCD Touch Pad. Follow all safety precautions, instructions, and preventative maintenance.
Page 78 Towing & Leveling Leveling Instruction Label The manufacturer’s instruction label (below) is mounted on the back wall of the front compartment or inside of the forward, off-door side compartment. DO NOT remove this label from your RV:...
Page 79: System Information
Towing & Leveling Ground Control ® TT Leveling System with LCD Touch Pad System Information With the push of a button, the Ground Control TT Leveling ® System levels and stabilizes your travel trailer quickly and accurately, enhancing your overall camping experience. It can take up to an hour to get a travel trailer level with manual jacks, chocks and wedges.
Page 80: Basic Jack Operation
Towing & Leveling Basic Jack Operation The power tongue jack can be operated at any time using the WARNING buttons on the front of the tongue jack motor enclosure or by pressing the “FRONT” button (Fig. 1H) of the touch pad in Failure to act in standard mode.
Page 81: Auto Level
Towing & Leveling Unhitching From Tow Vehicle 1. PARK travel trailer on level ground. 2. CHOCK all tires. 3. MAKE SURE battery power is on. 4. DISCONNECT any wires, chains, or sway control that may be equipped between the tow vehicle and travel trailer. Unlatch the travel trailer coupler.
Page 82: Auto Level Sequence
Towing & Leveling Auto Level Sequence NOTE: Sequence may vary slightly based on the height of the travel trailer coupler prior to leveling. 1. When the Auto Level Sequence begins, the front of the travel trailer will seek a position near a level state using a combination of the tongue jack and front jacks.
Page 83 Towing & Leveling Reconnecting To Tow Vehicle 1. PRESS the “ON/OFF” button to turn panel on (Fig. 5B). 2. PRESS the “UP ARROW” (Fig. 5A) button on the touch pad until “AUTO HITCH HGT, ENTER TO BEGIN” is displayed on the LCD. Press the “ENTER” button (Fig. 5C). 3.
Page 84: Troubleshooting
Towing & Leveling Troubleshooting NOTE: For ease of manual override it is recommended to unplug the power harness to the motor prior to performing the manual override procedure. NOTE: Use of a 12-18 volt cordless screw gun or pneumatic screw gun is acceptable to manually override the jacks. •...
Page 85 Towing & Leveling 5K Jack - Top of Jack Motor Override: Tools needed: 3/8” drive ratchet and extension (no socket) 1. FIND the port on the top of the jack motor (Fig. 10A). 2. REMOVE the rubber plug (Fig. 11A). 3.
Page 86: Touch Pad Error Codes
Towing & Leveling Touch Pad Error Codes NOTE: To clear an error from the touch pad, repair or otherwise correct the issue, then press “ENTER.” If the error is still present, the message will be displayed again. Touch Pad Error Codes LCD Error Codes What’s Happening? What Should Be Done?
Page 87: Special Jack Error Codes
Towing & Leveling Special Jack Error Codes To clear one of the error codes listed below: 1. CORRECT or otherwise REPAIR the issue (see the table below). • NOTE: In order to clear the special jack error code the jacks need to be “homed.” In order to “home” jacks, each jack MUST be able to retract a minimum of 6 inches.
Page 88: System Settings
Towing & Leveling System Settings Zero Point Calibration The “Zero Point” is the programmed point that the travel trailer will return to each time the Auto Level feature is used. The “Zero Point” must be programmed prior to using the Auto Level feature to ensure the proper operation of the system.
Page 89: Electrical Systems
Electrical Systems Electrical Systems Your Reflection Travel Trailer is equipped with two independent WARNING electrical systems. One system is 120-volt 60hz AC power, the other system is 12-volt DC power. The electrical equipment and associated circuitry are engineered into a dedicated system Use caution when using specific to your RV.
Page 90: Connecting The Power Cord
Electrical Systems 50-Amp Power Cord, Continued Connecting the power cord WARNING 1. Turn OFF the load center main 120-volt circuit breaker. • DO NOT hook up the power 2. Carefully extend the entire length of the power cord from cord to any receptacle until the electric cable hatch to the external power source.
Page 91: Volt Circuit Breakers
Electrical Systems Power to your 50 amp, 120-volt 60hz AC electrical system WARNING can be supplied by the 120-volt 60hz utilities found at RV campgrounds or by a generator. A campground's electrical For 50 amp systems only: service may occasionally experience high or low voltage. Make certain the external power source that you •...
Page 92 Electrical Systems Converter The Power Converter changes 120-volt AC power to usable 12-volt DC power when the shore power cord is connected to an external power source. Bladed fuses are built into the converter to protect it from battery reversal. Overheating is usually caused by the converter operating above its maximum power output for an extended time period, or with too little air flow.
Page 93: General Operation
Electrical Systems General Operation The INTELI-POWER series converter will supply "clean" power CAUTION from input voltages that range from 105-130 VAC. DO NOT use to recharge Flooded Lead Acid (Green LED) flooded lead/acid batteries When charging the battery, the converter will sense voltage while in either Lithium (Blue) or AGM (White) mode.
Page 94: Inspection And Maintenance
Electrical Systems Converter, Continued Features Selectable Charge Profiles - allow you to select the right CAUTION profile for the battery being charged. The unit can also provide a constant output voltage for special needs. If the reverse battery GFCI Protection - INTELI-POWER converters have the lowest protection fuses are blown ground fault leakage.
Page 95: Volt Dc System
Electrical Systems Test all GFCI receptacles monthly • PUSH IN the TEST button. This should pop out the RESET button, indicating the GFCI receptacle has been tripped. This will interrupt the 120-volt power. • PUSH IN the RESET button. This should restore the 120-volt power.
Page 96: Volt Fuse Panel
Electrical Systems 12-Volt Fuse Panel The label inside the 12-volt fuse panel indicates the fuse sizes, positions and components powered. The fuse panel label WARNING should be kept permanently affixed to your RV. • Inspect all 12-volt fuses at the beginning of each camping Replacement fuses must be of the same voltage, season, and replace as needed.
Page 97 Electrical Systems For accuracy, test the auxiliary battery voltage using a volt-ohm meter. A fully charged auxiliary battery will read 12.7 volts DC and 1.265 specific gravity at 80°F (32°C). The auxiliary battery is considered discharged at 11.8 volts, and dead at 11.65 volts. Permanent damage may occur when voltage drops below those levels.
Page 98 Electrical Systems 7-Way Battery Power Control Box The 7-Way Battery Power Control Box provides a central location to control the power connections for your 12V needs, your vehicle- to-trailer power, and your lighting connections. This product features the use of Spring Lever and Screw Compression Lug connections eliminating the need for adding terminal ends to wires along with proper circuit protection for the needs of Battery, Solar, Inverter and Auxiliary 12V inputs and outputs.
Page 99 Electrical Systems Approximate Electrical Load Ratings Use the actual amperage of the appliance when possible. (Watts ÷ Volts) 120 Volt System Air Conditioner 14-18 amps Coffee Maker 6-12 amps Converter (Each) 8-11 amps Curling Iron or Hair Dryer 10-14 amps DVD / Blu-ray System 3 amps Microwave...
Page 100: Replacing Light Bulbs
(customer supplied) to the solar system. Please contact Please contact Charge Controller your Grand Design RV Dealer or GDRV Customer Service your Grand Design RV Dealer or GDRV Customer Service for more information and ordering a compatible inverter for more information and ordering a compatible inverter.
Page 101: Plumbing Systems
Plumbing Systems Plumbing Systems There are two separate water systems equipped on your RV, the Fresh Water System and the Waste Water System. • The Fresh Water System consists of the Fresh Water Holding Tank, Fresh Water Connections, Water Heater, Water Pump, Faucets, Shower/Tub, Outside Spray Port, and if so equipped, a Water Purification System.
Page 102: Monitor Panel
RV. Also see page 70. • Please read the Compass Connect manual found ® in your Owner Information Package before downloading and using the Grand Design Compass Connect app. ® The Grand Design Compass Connect Application is based ®...
Page 103 Plumbing Systems Water Pressure Regulator (Customer Supplied) In some RV parks (especially in mountain regions), excessive NOTICE pressure from water supply systems may be encountered. • A Water Pressure Regulator (available for purchase from Not using a water pressure regulator when using city your RV dealer) will help to protect your plumbing system water may cause the against damage from a high pressure water supply.
Page 104: Controller Operation
Plumbing Systems Water Heater, Furrion Tankless It is important to know which type of Water Heater is installed in your RV. Read all safety and operating information provided both here and in the manufacturer’s manual before using the water heater. Based on the hot water demand, the tankless water heater will heat incoming cold water to a desired output temperature by monitoring key sensors to regulate the thermal energy released over a large heat exchanger.
Page 105: Safe Operation
Plumbing Systems The temperature can be selected to operate in two different methods: Method 1: WARNING Point of use mixing: Set the controller temperature to a desired output temperature, typically elevated above comfortable bathing If the information in the temperatures, i.e., 115°F (46°C). Turn ON the hot water, once hot, manufacturer instructions add cold water to achieve desired temperature.
Page 106 Plumbing Systems Water Heater - Furrion Tankless, Continued WARNING Winterizing the Furrion Tankless Water Heater Both automotive antifreeze See page 126, Winterize - Nautilus P4 User Instructions. , Winterize - Nautilus P4 User Instructions. page 126 (ethylene glycol) and Also see Also see page page 110 110, Winterizing the Plumbing System...
Page 107: High Altitude Use
Plumbing Systems After Winterizing is complete 12. OPEN then CLOSE kitchen hot water faucet to release pressure in water line. 13. REMOVE the water heater drain plug and allow RV antifreeze to drain. 14. DO NOT replace drain plug / SAVE drain plug for re-use. DO NOT USE YOUR WATER HEATER WHILE THE SYSTEM IS WINTERIZED.
Page 108: Antifreeze Function
Plumbing Systems Water Heater - Furrion Tankless, Continued CAUTION Antifreeze Function (for FWH09AFA models only for FWH09AFA models only) PRODUCT DAMAGE • The water heater can be used in freezing conditions, by DUE TO FROST CONDITION operating a burner sequence program to keep the water liquid.
Page 109: Routine Inspection
Plumbing Systems Routine Inspection CAUTION Routine inspection is critical for maintaining proper operation of your appliance. Unless specified, review the following items Always wear protective yearly or before each season: gear such as gloves, eyewear and clothing 1. Inspect the gas system and installation every two years, to avoid injuries during or otherwise specified by your RV coach manufacturer, installation and servicing...
Page 110: Filter Cleaning
Plumbing Systems Water Heater - Furrion Tankless, Continued 10. Turn on the power to the water heater and open a hot water faucet to inspect the flame of the burner. The flame should be of the normal bluish appearance that indicates proper combustion.
Page 111 Plumbing Systems Pressure Safety Valve Maintenance 1. The unit is equipped with a water pressure safety valve. The pressure safety valve needs to operate once each year to ensure this safety device is effective. 2. The pressure relief valve is a safety component and must not be removed for any reason other than replacement.
Page 112: Shutoff Valves
• Please also refer to the manufacturer’s manual. Shutoff Valves Your Reflection Travel Trailer has been equipped with convenient waterline Shutoff Valves at the Kitchen and Bathroom Sinks, Shower, Toilet and the Washer hookup.
Page 113 Plumbing Systems Faucets The faucets inside your RV operate much the same way as the faucets in your home. • CHECK that the amount of water available is sufficient, and If dry camping, Turn ON the 12-volt Water Pump. • To OPEN the faucets, turn ON the hot and cold knobs, then ADJUST the temperature to your comfort level.
Page 114: Draining The Fresh Water System
Plumbing Systems Water Control System Your Reflection Travel Trailer is equipped with a Nautilus P4 Water Control System. To understand the operation of your water control system, see page 116-130, Nautilus P4 User Instructions included in this manual. Draining and winterizing If the RV is to be stored over the winter months, the water heater must be winterized to prevent damage from freezing.
Page 115: Sanitizing The Fresh Water System
Plumbing Systems Sanitizing the Fresh Water System Use the following procedures to sanitize your Fresh Water System (or Potable Water System) when it is new, becomes contaminated, or has NOT been used for a period of time. • PREPARE a chlorine solution using one (1) gallon of water and one-quarter (1/4) cup of household bleach (5% Sodium Hypochlorite solution).
Page 116: Winterizing The Plumbing System
Plumbing Systems Winterizing the Plumbing System Important: Winterizing method varies depending on the Winterizing method varies depending on the type of Water Heater installed in your RV. Also see : type of Water Heater installed in your RV. Also see : WARNING •...
Page 117 Plumbing Systems When you are done adding RV antifreeze 9. BLOW OUT the black tank flush line at the outside connection with compressed air (max 70 PSI). WARNING 10. To prevent staining, CLEAN any RV antifreeze from the sinks, shower (or tub), and toilet using a soft, dry cloth. NEVER travel with full black or grey water holding tanks.
Page 118 Plumbing Systems Toilet, Continued To help prevent a toilet blockage: • Before use: FLUSH the toilet several times, releasing enough water to cover the bottom of the holding tank. • ALWAYS maintain four to six inches (10-15 cm) of water in the toilet for better performance. •...
Page 119 Plumbing Systems Emptying the Black & Grey Water Tanks The black tank and grey tank drain valves (or dump valves) NOTICE are located near the Sewer Outlet Connection, under the RV on the off-door side, and/or in the utility center. It is important to prevent •...
Page 120 Plumbing Systems Vents & Vent Pipes For the plumbing system to drain properly: • The vents and vent pipes must release air from the grey and black water holding tanks. • ALWAYS keep the exterior vent cap on the roof clear of any obstructions.
Page 121 Plumbing Systems Black Tank Flusher CAUTION The black tank flusher is designed to rinse the interior of the Black (waste) Tank. A separate water hookup is located in the docking station. Also see TANK FLUSH, page 129-130, DO NOT use the tank flush Nautilus P4 Manual.
Page 122: Nautilus P4 Manual
Nautilus P4 Manual Nautilus P4 Manual This page is intentionally blank. -3 HANDLE USER INSTRUCTIONS Congratulations on purchasing an RV equipped with the most advanced water management system available today! Be sure to read all Instructions on the Nautilus Panel and in your Owner's Manual before performing any operation using the Nautilus Panel System.
Page 123 Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS IMPORTANT!! NEVER push check valve on "CITY WATER" connection with pressure in line. This WILL cause irreparable damage to the check valve function. 58471 Fir Road, Mishawaka, IN 46544 Phone: (574) 259-7838 Fax: (574) 259-7939 www.bandbmolders.com...
Page 124 Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS The Nautilus P4 Panel System will allow you to perform the following functions: 1. Power fill your fresh water tank for remote or dry camping 2. Use your pump to supply water to fixtures from fresh water tank 3.
Page 125 Nautilus P4 Manual -3 HANDLE INSTALLATION INSTRUCTIONS TALLA N INSTRU USER INSTRUCTIONS Nautilus P4 Handle Position and Valve Routing Information : Receives water from water inlet on front of panel WHITE HANDLE Sideways - water goes to pump inlet Down – water goes into blue handled diverter : Receives water from the white handle valve/water inlet on front of panel BLUE HANDLE Sideways - water goes to fixtures (cold)
Page 126 Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS CONNECTING COAX FOR CABLE AND/OR SATELLITE 1. For cable TV connection, connect the threaded coax from the source to the "CABLE" connection. 2. For satellite TV connection, connect the threaded coax from the satellite dish to the "SAT" connection. 3.
Page 127 Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS Power Filling Fresh Water Tank "PowerFILL Tank" 1. Connect garden hose to inlet labeled "CITY WATER." 2. Turn handles to PowerFILL Tank position as shown. diverter handle should be facing down. BLUE diverter handle should be facing down. WHITE diverter handle should be facing left.
Page 128 SANITIZE Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS Fill or Sanitize Fresh Water Tank via Pump "SANITIZE" 1. Connect garden hose to inlet labeled "CITY WATER." 2. Turn handles to '"SANITIZE" position as shown. diverter handle should be facing down. BLUE diverter handle should be facing right.
Page 129 Nautilus P4 Manual -3 HANDLE Fill or Sanitize Fresh Water Tank via Pump "SANITIZE" USER INSTRUCTIONS 5. Pump should be running and fresh water tank should begin to fill. NOTE: Consult your Owner's Manual for tank capacity. DO NOT OVERFILL TANK! 6.
Page 130 Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS Using Pump to Supply Water from Fresh Tank "DRY CAMPING" 1. Make sure fresh water tank has necessary supply of water. 2. Turn handles to "DRY CAMPING" position as shown. diverter handle should be facing left. BLUE diverter handle should be facing down.
Page 131 Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS Using System from Pressurized Water Source "CITY WATER" 1. Connect garden to hose to inlet "CITY WATER." 2. Turn handles to "CITY WATER" position. diverter handle should be facing left. BLUE diverter handle should be facing down. WHITE diverter handle should be facing left.
Page 132 Winterize for cross Ref. Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS Winterizing Plumbing Lines and Fixtures "WINTERIZE" 1. Turn handles to "POWERFILL" position as shown. diverter handle should be facing down. BLUE diverter handle should be facing down. WHITE diverter handle should be facing left. GREEN NOTE: Contact the manufacturer to see how and if you NOTE: Contact the manufacturer to see how...
Page 133 Nautilus P4 Winterize pg2 Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS Winterizing Plumbing Lines and Fixtures "WINTERIZE" 5. Using "CITY WATER" inlet or low point drain, blow out plumbing lines (40 PSI max) with handles still at 45 degree angle as shown. This will ensure any trapped water in plumbing harness is removed.
Page 134 Nautilus P4 Winterize pg3 Winterizing Nautilus P4- 3 Handle Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS Winterizing Plumbing Lines and Fixtures "WINTERIZE" 9. Place other end of garden hose in container 10. Push "PUMP" switch to turn pump on. holding approved winterizing solution. NOTE: LED indicator light below the pump switch will be lit if pump has power.
Page 135 Tank Flush Nautilus P4 - 3 Handle Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS Rinsing the Waste Tank "TANK FLUSH" 2. Open black waste holding tank valve and 1. Connect flexible sewer hose to 4" dump leave open to allow black tank to drain. outlet on unit.
Page 136 Nautilus P4 Manual -3 HANDLE USER INSTRUCTIONS Rinsing the Waste Tank "TANK FLUSH" 5. Fully open faucet at water supply source (40 psi minimum). Flush tank until water 6. Completely close faucet at the appears clear in 4" discharge hose. water supply source.
Page 137: Propane System
Maintenance perform the 6-step procedure in the red box Although both Grand Design RV and your selling dealer care- at the bottom of this page. fully test the propane system for leaks, travel vibrations can loosen fittings. Have the RV's propane system checked at all connections soon after your purchase.
Page 138 Propane System Propane Gas Cylinders While under pressure in the cylinder, propane gas is compressed WARNING into its liquid form. Propane will not run through the appliances in its liquid state. As the fuel is released from the cylinder to operate Propane cylinders should an appliance, it changes from liquid to gas.
Page 139: Propane Leak Test
Propane System Max output is 200,000 BTU/hr. It is used to connect propane WARNING cylinders to regulators, hoses and other fittings. It is not for use on gas grills and other low pressure devices. BEFORE entering a propane or fuel service station Servicing or filling make sure ALL pilot lights Have the RV checked for leaks at the connections on the...
Page 140: Propane Gas Alarm
Propane System Propane Gas Alarm Your RV is equipped with a propane alarm. Please read and WARNING follow the component manufacturer instructions supplied in your Owner Information Package. Test Propane Gas Alarm operation after the RV has For detailed information on this alarm, See page 25-27, been in storage, before Propane Gas (LP) Alarm.
Page 141: Propane Regulator
Propane System • If you do experience a propane freeze up, CLOSE the WARNING main valve and wait at least fifteen (15) minutes before trying again. For more information, refer to the regulator All propane connections manufacturer’s operator manual. should be checked periodic- ally as vibrations from travel •...
Page 142: Cooking With Propane
Propane System Propane System Hoses, Tubes, Pipes & Fittings The hoses, pipes, tubes and fittings used in your propane system are designed to withstand pressures exceeding those of the pro- pane system. However, because environment and time can both contribute to the deterioration of these components, they must be inspected for wear at regular intervals.
Page 143: Using The Propane System
Propane System Using the Propane System After the RV is completely set up and you are prepared for WARNING camping enjoyment, use the following steps for propane operation: DO NOT operate the gas appliances while 1. CLOSE ALL burner valves, controls and pilot light valves. your RV is in motion.
Page 144 Propane System Calculating Propane Use Your Reflection Travel Trailer's furnace, water heater and range (if applicable) all may use propane to operate. Use the BTU rating of each appliance to determine how long your propane supply will last. Propane consumption depends on their individual use and the length of time operated.
Page 145: Appliances
RV. • If you have any questions contact your dealer or Grand Design RV Customer Service. These manuals are found in your Owner Information Package. If there have been modifications or replacements made to your RV, then these instructions may not apply.
Page 146: In Case Of A Grease Fire
Appliances Cooking with Propane For additional safety instructions, See page 131-138, WARNING Propane System. DO NOT turn the gas In Case Of A Grease Fire range burner controls ON and allow propane gas to escape before lighting. Grease is flammable. Wipe any spills immediately. NEVER allow grease to collect around the top burners or on the cook top surface.
Page 147: Range Hood
Appliances Range Hood The range hood has both a light and fan control switch on the WARNING front panel. The 8” x 8” aluminum mesh grease filter (located on the underside range hood) can be gently hand-washed using NEVER leave cooking mild soap and water.
Page 148 This page is intentionally blank.
Page 149: Electronics
Electronics Electronics CAUTION The following is a basic overview of the audio/visual (A/V) The TV power supply electronics operation. The information in this section is written should be turned OFF when connecting and/or for original factory-installed equipment usage. Refer to the disconnecting the cables manufacturer’s user guides included in your Owner Information to the power supply and...
Page 150 Electronics Cable/Satellite Outlet Both Cable and Satellite connection outlets are found in the outside utility center. • The Cable input connects to an RG6 cable run through in-line splitters to provide service at multiple locations. • The Satellite inputs connect to RG6 cables run directly to specific locations (no splitters).
Page 151 Electronics TV Roof Antenna To watch local TV stations, turn ON power to both the TV and the TV Roof Antenna. For a list of all DTV signals available at your location, go to: https://www.fcc.gov/media/engineering/dtvmaps Winegard AIR 360 Operation • You must run a Channel Scan on your TV in order to receive maximum programming.
Page 152 • A Travlfi Journey XTR Quick Start Guide is included in your Owner Information Package. • View plans at: travlfi.com/plans • Please contact your Grand Design RV Dealer • Please contact your Grand Design RV Dealer for more information and ordering. for more information and ordering.
Page 153: Heating & Cooling
Heating & Cooling Heating & Cooling The following section contains an overview of the original factory-installed heating and cooling components. For more For more information on each specific component, please refer to the information on each specific component, please refer to the manufacturer’s operating instructions found in your Owner manufacturer’s operating instructions found in your Owner Information Package.
Page 154 • DO NOT store anything in the furnace compartment. cause unsafe furnace operation. For your safety, If you have any questions, contact your dealer or only OEM factory authorized Grand Design Customer Service. parts are to be used on your furnace. Fireplace (If So Equipped) Please read and understand your fireplace's manufacturer own- er's manual BEFORE using.
Page 155: Roof Vents
Heating & Cooling Roof Vents NOTICE The roof vents allow fresh air to circulate through your RV. They may be electric (12-volt DC) and/or manual. To prevent Roof Vents unexpected weather damage, make sure that roof vents are The roof vents allow fresh closed while traveling and when you will be away from the RV.
Page 156 Heating & Cooling Patio Awning WARNING To operate the door-side Patio Awning: PINCH HAZARD. • LOCATE the Awning switch (Fig. 3) on the Command Center. Keep CLEAR of arm assemblies while closing • PRESS and HOLD Patio Awning switch until the awning awning.
Page 157 Awning Heating & Cooling Idler Head This page is intentionally blank. Assembly Fabric Awning Rail Drive Head Assembly Pinch Points Pinch Points Pinch Points Roll Tube End Cap Pinch Points Support Arm Assembly Fig. 3 Fig. 4 - Complete Extension Fabric Valance Seam Roll...
Page 158: Fabric Care
Heating & Cooling Patio Awning, Continued Adjusting Pitch - All Solera Awnings CAUTION NOTE: The awning will pitch itself to purge the pooling of excess water and may dump a significant amount of water without notice. Tying down the roll tube once the awning is 1.
Page 159: Manual Override
Heating & Cooling • Liberally slosh the mixture on the top of the fabric WARNING and roll up the awning for 5 minutes. • This will apply the mixture to the bottom of the fabric DO NOT attempt any repairs to any awning.
Page 160 This page is intentionally blank.
Page 161: Slideout Systems
Slideout Systems Slideout Systems Slideout rooms are designed to provide you additional living WARNING space during stationary camping. The slideout room and mechanism are a potential BEFORE operating your slideout system: crush hazard. Disconnect the auxiliary battery to ◦ Check that you have sufficient power available. disable power to the slideout(s) before working ◦...
Page 162 • Clean and dry the outside surfaces of the room and mechanism as much as possible. NOTICE Contact your dealer or Grand Design RV Customer Service For long-term storage, it for troubleshooting and/or repair of your slideout system: is recommended that the slide rooms be closed •...
Page 163: Manual Operation
Slideout Systems Lippert Electric Slideout System Extending and retracting the slideout room is powered by the CAUTION Lippert Through Frame Electric Slideout System. It is a rack and pinion guide system with a motor driven ball screw actuator. Always disconnect battery The actuator is equipped with an automatic clutching system.
Page 164: Service And Ad Just Ments
Slideout Systems Lippert Electric Slideout System, Continued • When operating the Lippert electric slideout system in harsh environments (i.e., road salt, ice buildup, etc.) keep all moving parts clean, washing them as needed, with mild soap and water. • Grease or lubrication is NOT necessary. It could even harm the long-term dependability of the slideout system.
Page 165 Slideout Systems Manually push the slide room in override 1. LOCATE the circuit board. 2. UNPLUG both motors from circuit board. (this will release the motor brake) 3. PUSH or PULL slide room in as desired; ◦ Larger rooms may require several people to push. ◦...
Page 166: Checking Fuses
Slideout Systems Troubleshooting the Schwintek Slideout System Error codes During operation, when an error occurs the board will use the LED’s to indicate where the problem exists. • For motor specific faults, the GREEN LED will blink once for motor 1, and blink twice for motor 2. •...
Page 167 Slideout Systems Only one (1) side moving The Schwintek slide system has a separate motor to operate each side of the room. If only one side of the room moves a short distance (2 to 4 inches) and stops; • Will non-moving side move with help? If only one (1) side of the room is moving, with someone’s assistance, push the non-moving side in the appropriate direction while pressing the switch to extend or retract...
Page 168: Extending The Slideout Room
Slideout Systems SlimRack Auto-Programmable Slideout ® (If So Equipped) ® The Auto-Programmable SlimRack Slideout System combines seamless flush-floor style and no step up. BEFORE using your Lippert SlimRack Slideout: ® Please read and understand the full Auto-Programmable SlimRack ® Slideout manufacturer‘s Owner’s Manual. To download an electronic copy, SCAN the QR Code, left, with your tablet or smartphone.
Page 169 Slideout Systems NOTE: Once the room has stopped moving, it is not necessary to press the switch a second time. 8. If equipped, turn “off” the on/off switch or key. Retracting the Slideout Room 1. The engine or generator must be running, or the unit must be plugged into the shore power.
Page 170 Slideout Systems ® Troubleshooting the SlimRack Slideout (If So Equipped), Continued Fig. 2 Fig. 4 NOTE: For major faults, the controller will automatically enter Emergency Jog mode when motor movement is not detected by the controller in either direction during slideout room activation. When in Emergency Jog mode, the controller will jog both motors in the direction the rocker switch is pressed (IN or OUT).
Page 171: Manual Override Mode
Slideout Systems Manual Override Mode In the event that power is lost to the SlimRack ® slideout motor(s) or when the Electrical Override Mode does not work, the slideout room can be manually retracted by following these steps. 1. Gain access from either the inside or outside of the unit to the vertical channel assembly by removing the OEM trim and flange pieces on the slideout room box.
Page 172: Furniture
Furniture Furniture Converting the Tri-Fold Sofa to a Bed (If So Equipped) 1. Remove the seat back cushions. 2. Lift up and out on the front edge of the sofa, uncovering the legs. 3. Fully extend the legs on both sides. Lift Front of Sofa Extend...
Page 173 Furniture 4. Pull the sofa forward and place the legs flat on the floor. 5. Pull the sofa back forward, and lay flat. Pull Forward (5.) & Lay Flat Lift here while Pulling Forward (4.) Sofa Converted to Bed. Sofa Back Folded Down...
Page 174: Interior Care
Interior Care Interior Care Cleaning the Interior To keep the value of your RV, perform regular maintenance using the proper materials and procedures. • Check the component manufacturer’s information for the recommended cleaning agent. DO NOT use flammable liquids or sprays to clean your RV. Using the wrong cleaner may result in damage to the surfaces in your RV.
Page 175: Solid Surface Countertops
Interior Care Paneling • To clean, use a mild solution of soap and lukewarm water with a soft sponge or cloth. • DO NOT use abrasive cleaners as they could cause the vinyl to scratch and turn dull. • Grease spots and stubborn dirt can be cleaned off with an all-purpose spray cleaner.
Page 176: Vinyl Flooring
Interior Care Flooring • ALWAYS test cleaning agents for colorfastness in a hidden or inconspicuous area. Carpet Vacuum regularly with a vacuum cleaner with a revolving brush or beater bar. Be sure the vacuum does not have teeth, combs or rough edges as they may damage the carpet. It is important to remove loose soil and debris while it is on the surface.
Page 177: Furniture Upholstery
Interior Care Furniture Upholstery Maintaining your furniture upholstery and keeping the interior clean will help to retain the value of your RV. • Vacuum the furniture regularly using a soft brush attachment to remove any loose dirt or debris. Fabric Fabric should be professionally cleaned if it becomes stained or soiled.
Page 178 Interior Care Theater Seating (If So Equipped) Similar to a residential recliner, the Theater Seats allow you Some, but not all, to recline the individual sections. To return the section back recliner loveseats to the upright position, gently apply pressure to the recliner have storage in the leg rest.
Page 179 Interior Care Shower Walls & Base Use a mild detergent soap and warm water to clean the shower wall and base. DO NOT use gritty or abrasive particle soaps or scouring compounds. Sink & Shower Fixtures • Use mild dish soap and water to clean these fixtures. DO NOT use harsh chemicals or sprays.
Page 180: Exterior Care
Exterior Care Exterior Care Many different materials comprise the RV exterior including; glass, fiberglass gel-coat, plastics, aluminum, automotive grade paint finishes, and sealant. • The chance of damage to the exterior finish increases the longer a foreign substance remains on the surface. •...
Page 181: During Cold Weather
Exterior Care AVOID forcing water inside the RV. This could damage component parts. EXTREME CAUTION should be used with any type of pressure sprayer around all attachments, doors, windows, appliance vents, etc. NOTE: Some types of hot water washing equipment apply HEAT and HIGH PRESSURE to the RV.
Page 182 Exterior Care Cleaning the Exterior, Continued Waxing your RV NOTICE Wax your RV once or twice a year, or when painted surfaces do not shed water well. Use a soft cloth to apply a small amount DO NOT use a buffer and of wax to the painted surfaces.
Page 183: Exterior Roof
Exterior Care Exterior Roof To Maintain Your Roof Warranty: WARNING PLEASE NOTE: ONLY THE CORRECT, RECOMMENDED ALPHA SYSTEMS SEALANTS SHOULD COME IN CONTACT As with the surface of any WITH YOUR ALPHA ROOF MEMBRANE. (See below) roof, a rubber roof can be very slippery, especially With the AlphaPly Roof Membrane - Use ONLY: With the AlphaPly Roof Membrane - Use ONLY:...
Page 184: Roof Ladder
Exterior Care Sealants Sealants perform a very important function and should be inspected closely and regularly maintained. We incorporate many different types of sealants, including butyl/putty, black butyl-encapsulated foam, silicone (clear and colored), roof sealant and foam. In gen- eral, sealants do not have a "set" lifetime. Varying environmental factors affect the pliability and adhesiveness of sealants.
Page 185: Rear Bumper
Exterior Care Rear Bumper • The rear bumper of your RV is NOT designed NOTICE to carry cargo. • Extra weight behind the trailer’s axles may reduce the DO NOT add items to the RV rear bumper. Add-on Hitch Weight (leading to adverse handling conditions items will eventually from wind gusts and passing traffic).
Page 186 Exterior Care Winterizing / RV Storage Preparation To help prevent problems, prepare your RV for extended periods Please review of non-use. This will also make it easier to get your RV ready for the winterizing the next camping trip or season. instructions for your water heater •...
Page 187: Maintenance
Maintenance Maintenance Suggested Maintenance Checklist Here is a quick reference list of suggested areas for regular maintenance. Review all manufacturer’s operators manuals supplied with your RV to perform the maintenance items listed. Prior to first trip • INSPECT and reseal as needed. •...
Page 188: Required Maintenance Schedule
Required Maintenance Required Maintenance Schedule Procedure to be Performed: Maintenance schedules are minimum minimum Maintenance requirements. Extended use, extreme Item temperatures, high humidity or other extreme conditions will require more frequent maintenance. • • Check settings & adjustments per manufacturers guide. •...
Page 189 Required Maintenance Required Maintenance Schedule Procedure to be Performed: Maintenance schedules are minimum minimum Maintenance requirements. Extended use, extreme Item temperatures, high humidity or other extreme conditions will require more frequent maintenance. Check for damage and wear. • • Hitch / Coupler Clean and Lubricate (with grease) •...
Page 190: Basic Troubleshooting
Basic Troubleshooting Basic Troubleshooting WARNING WORKING WITH Air Conditioner (Roof) ELECTRICAL APPLIANCES CAN BE EXTREMELY Will not operate DANGEROUS. • CHECK that the unit is turned ON. Always have your dealer or a certified professional • CHECK circuit breakers in coach. perform all repairs to your appliances and/or RV •...
Page 191: Interior Lights
Basic Troubleshooting Furnace WARNING Furnace does not ignite and/or cycles frequently • CHECK that propane tank is full. DO NOT attempt to repair or adjust • REMOVE any obstruction over furnace exhaust. the furnace. Turn off the thermostat and • INSPECT exhaust tube for any obstructions. furnace gas control valve, then contact your dealer or •...
Page 192: Outside Receptacle
Basic Troubleshooting Monitor Panel No lights on panel when switch is pressed • CHECK battery voltage and condition. • CHECK fuse at the battery; if fuse is good have a dealer or certified RV technician check the condition of panel. Holding tank lights deliver false readings (i.e., 1/3 or 2/3 indication) •...
Page 193 Basic Troubleshooting Range or oven burner won’t light or stay lit • CHECK position of top burners and flash tubing. • CLEAN clogged burner ports with a toothpick. • See the oven manufacturer’s instructions for proper care and maintenance. Gas smell •...
Page 194 Basic Troubleshooting Propane Gas Smell gas in or around unit DANGER • Propane tanks may be overfilled. IF YOU SMELL PROPANE GAS IF YOU SMELL PROPANE STOP! 1. EXTINGUISH any open flames, pilot lights and Quickly and carefully perform the 6-step all smoking materials.
Page 195: Running Lights
Basic Troubleshooting Running Lights Running lights not working • Blown fuse. Replace fuse with one of the same ampere rating. • Bad bulbs. Replace the bulbs with new. Slideout Room moves in and out very slowly, binds or squeaks • Lubricate the slideout tubes and rollers with light spray lube.
Page 196: Termination Valve
Basic Troubleshooting Termination Valve Termination valve leaks • Debris keeps valve from seating. CLEAR debris from and around valve O-ring set. • Bad gasket. Have your dealer or a certified RV technician replace gasket with new. TV Antenna Poor TV reception •...
Page 197 Basic Troubleshooting To remove the hydrogen sulfide (rotten egg) odor: 1. TURN OFF your main water supply; that is, your pump or your water hookup source. 2. DRAIN your water lines and water heater. ◦ Drain & Blow Out Water Lines, then ◦...
Page 198: Water Pump
Basic Troubleshooting Water Pump Pump will not start • CHECK that house battery disconnect switch is ON. • CHECK pump switch at monitor panel. • CHECK fuse in power center. • CHECK to see if water is frozen. Will not prime, sputters (no discharge, but the motor runs) •...
Page 199: Glossary
Glossary Glossary AC ELECTRICITY – Alternating current also known as shoreline power. For purposes of this manual, it refers to 120-volt AC (abbreviated 120 VAC). AMP – Short for ampere, the electric current unit of measure. RV sites with electric hookup will specify the maximum amps supported, which generally come in units of 20, 30, or 50 amps.
Page 200 12-volt DC (abbreviated 12 VDC). DEALER – For purposes of this manual, this refers to the independent dealer authorized to sell and/or service your camper by Grand Design RV. This term will be used in this context unless specified otherwise.
Page 201 Glossary DRY CAMPING – Camping when there is no city water hookup or shore power (i.e., using only the water and power available in the camper and not from any other source). DRY WEIGHT – The actual weight of a vehicle or trailer containing standard equipment without fuel, fluids, cargo, passengers, or optional equipment.
Page 202 Glossary GALLEY – The kitchen in an RV. GENERATOR – An engine powered device fueled by gasoline or diesel fuel, and sometimes propane, for generating 120-volt AC power. GENSET – Abbreviation for generator set. GOOSENECK – A trailer and hitch configuration connected to the tow truck directly above the rear axle by way of a standard ball hitch in the truck bed and a vertical, slender arm on front of the trailer.
Page 203 Glossary HIGH PROFILE – A fifth-wheel trailer with a higher-than-normal front to allow more than 6 feet of standing room inside the raised area. HITCH – The fastening unit that joins a movable vehicle to the vehicle that pulls it. HITCH WEIGHT –...
Page 204 Glossary JACKKNIFE – 90% angle obtained from turning/backing fifth wheel or travel trailer with tow vehicle. Jackknifing a short bed truck towing a fifth wheel without the use of a slider hitch or extended fifth wheel pin box can result in damage to the truck cab or breaking out the back window of the truck cab from the truck and fifth wheel "colliding".
Page 205 Glossary PATIO MAT – Carpet or woven mat for use on ground outside of RV. Used whether or not a concrete patio pad is available where camping. PAYLOAD CAPACITY – The maximum allowable weight that can be placed in or on a vehi- cle, including cargo, passengers, fluids and fifth-wheel or conventional hitch loads.
Page 206 Glossary SANITIZATION – Refers to the camper’s fresh water system that has been sanitized with chlo- rine bleach before use or after storage. SHORELINE POWER CORD – This is the electrical power cord that runs from the camper to the campsite shore power outlet. SLEEPING CAPACITY WEIGHT RATING (SCWR) –...
Page 207 Glossary TRAILER BRAKES – Brakes that are built into the trailer axle systems and are activated either by electric impulse or by a surge mechanism. The overwhelming majority of RVs utilize electric trailer brakes that are actuated when the tow vehicle's brakes are operated, or when a brake controller is manually activated.
Page 208 Glossary WEIGHT & LOAD – These terms are generally used interchangeably. • For the purposes of understanding RV applications: Vehicles have WEIGHT, which impart LOADS to tires, axles and hitches. Scale measurements taken when weighing, are LOADS carried by the tires. The measured "loads"...
Page 209: Index
Index Index 7-Way Wire Harness ....... 12-Volt DC System ....... . 12-Volt Water Pump .
Page 210 Index Electrical Load........Electrical Load Ratings ......Electrical Systems .
Page 211 Index Maintenance Checklist, Suggested ..... . . Maintenance Schedule, Required ..... 182-183 Maximum Load Rating .
Page 212 Index Thermostat ........Tire And Loading Information Label .
Page 213 Customer Notes...
Page 214: Maintenance Record
Maintenance Record Maintenance Record Date : Work Performed : Next Service :...
Page 215 This page is intentionally blank.
Page 216 Corporate Office 11333 County Road 2 Middlebury, IN 46540 (574) 825-8000 www.granddesignrv.com Copyright © 2023 Grand Design RV, All rights reserved. Part # 960905 Printed in the USA Rev. 07/2024...

Grand Design REFLECTION TRAVEL TRAILER Owner's Manual

Quick Links

Troubleshooting

Need help?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Grand Design REFLECTION TRAVEL TRAILER

Summary of Contents for Grand Design REFLECTION TRAVEL TRAILER

Table of Contents