Chamberlain LiftMaster 50-BATBOX-FDCL Manual

WARNING
APPLICATION
CAUTION
This accessory is intended for Chamberlain Liftmaster FDCL
Operators only. Additionally, it will be necessary to ensure that the
operator is equipped with the CHARGING CIRCUIT BOARD. To
determine if the operator is equipped with this CHARGING
CIRCUIT BOARD, refer to the operator's user manual or call the
service department for additional information and how to order
charging circuit board upgrade kits.
FUNCTION
The function of the remote battery box is to provide a convenient
means to house the batteries for the operator at a separate,
nearby location. This accessory provides the flexibility to install
the operator above a drop ceiling or other difficult to access
location, retaining access to perform routine maintenance on the
battery power source for the operator.
FIGURE 1
Battery Bracket
Cover
Retaining Nut
Battery
Bracket
Grounding
Screw and
Washer
TOOLS NEEDED
Drill
Drill Bits
3/16", 5/16"
and 5/32"
Wire Cutters & Strippers
Torque Screwdriver
Terminal
Remote Battery
Block
Box Enclosure
Black
Battery
Harness (-)
Red
Battery
Harness (+)
Pencil
Wire Crimpers
REMOTE BATTERY BOX
To reduce the risk of SEVERE INJURY or DEATH:
• ANY maintenance to the operator or in the area near the
operator MUST not be performed until disconnecting the
electrical power and locking-out the power via the operator
power switch. Upon completion of maintenance, the area
MUST be cleared and secured. At that time the unit may be
returned to service.
• ALL electrical connections MUST be made by a qualified
individual.
• DO NOT install any wiring or attempt to run the operator
without consulting the wiring diagram.
• ALL power and control wiring MUST be run in separate
conduit.
• The Remote Battery Box MUST be mounted on the same
side of the firedoor that the Operator is mounted to.
• The sealed lead-acid batteries in the Remote Battery Box
contain materials that are harmful to personnel and to the
environment. DO NOT handle or utilize batteries that are
damaged in any way. RECYCLE or DISPOSE of old or
damaged batteries within the guidelines established by
LOCAL LAW.
Flexible Conduit
Tie Wraps
Philips Head Screwdriver
Adjustable End Wrench
Hammer
1
50-BATBOX-FDCL
WARNING
WARNING
Conduit Connector
Red Conduit
Wire
Green Conduit
Wire
Positive Operator
Harness (Red)
Negative Operator Harness (Black)
Fuse Assembly
Battery Retainer
Pliers
Flathead Screwdriver
Sockets and Wrench
1/2", 5/8", 7/16", 9/16"
and 1/4"
Black
Conduit Wire