Page 1 G E N U I N E C H E V R O L E T...
Page 2 Limited Warranty Courtesy ransportation 1...
Page 3 Wearing a si uelt and your passengers can Thls 110. information about safety belt usage, alr I _ . I things you II pro1 first vehicle is adjust the seats. Depl able do this manually or with pa zr Read through these pages learn m*r* cooling, defogging and defrosting...
Page 6 This section tells you when to perform vehicle maintenance and what fluids and lubricants use. 8- 1 Customer Assistance Information This section tells you how to contact Chevrolet for assistance and how to get service and owner publications. It also gives you information on “Reporting Safety Defects” on page 8-10. Index Here’s an alphabetical listing of almost every subject in this manual.
Page 7 We reserve the right to make changes in the product after that time without further notice. For vehicles first sold in Canada, substitute the name For Canadian Owners Who Prefer a “General Motors of Canada Limited” for Chevrolet Motor Division whenever appears in this manual. French Language Manual:...
Page 8 Chevrolet. Louis Chevrolet, the other half of the team, the wheel of his experimental “Classic Six, which entered production in 1912. ” That year 2999 vehicles were produced.
Page 9 The legacy America's favorite sportscar began in 1953, when 319 hand-assembled In I932 Chevrolet white Corvettes introduced the launched the Synchro-Mesh first use of a transmission and Jiberglass body in ofered a host a production cal: accessories including such niceties as a clock!
Page 10 1957 Chevy started a romance with the American public and was powered by an available fiel-injected V8. Your new Chevrolet continues a tradition of quality and value.
Page 11 How to Use this Manual Many people read their owner’s m a n u a l from beginning to end when they f i s t receive their new vehicle. If you- do this, will help you learn about the features and These mean there is something that could hurt controls for your vehicle.
Page 12 Vehicle Damage Warnings In the notice area, we tell you about something that can damage your vehicle. Many times, this damage Also, in this book you will find these notices: w a r r a n t y , would not be covered by your and it could be costly.
Page 13 Vehicle Symbols the symbols you may find on your vehicle. These are some of For example, These symbols These symbols These symbols These symbols Here are some these symbols are important have to do with are on some are used on other symbols are used on an for you and...
Page 14 Section 1 Seats and Seat Restraints Here you’ll find information about the seats in your Chevrolet and how to use your safety belts properly. You can also learn about some things you should do with air bags and safety belts.
Page 15 Seats and Seat Controls This how to section tells about the seats adjust them and also about reclining seatbacks and head restraints. Manual 5 a t s You can lose control of the vehicle if you try adjust a manual driver's seat while the vehicle is moving.
Page 16 Move the seat higher by lifting and holding the bottom 6-Way Power Seat Equipped) of the button. Lower the seat by pushing and holding the top of the button. To move the seat forward, push rear of the button forward. To move the seat backward, push the front of the button rearward.
Page 17 Reclining Front Seatbacks To adjust the seatback, lift the lever on the outer side the seat and move the seatback to where you want it. But don’t have a seatback reclined if your vehicle is moving. Release the lever and ensure the handle returns to the original position and the seatback is securely locked.
Page 18 Rear Seats r*ArTTION: Folding Rear Seat Sitting in reclined position when your vehicle is in motion can be dangerous. Even if you buckle safety up, your belts can’t do their job when you’re reclined like this. The shoulder belt can’t do its job because it won’t be against your body.
Page 19 ’ To close push the split folding rear seat, the seatback click. Then pull on the until you hear seatback to make CAUTION: secure. sure it Safety Belts: They’re for Everyone It is extremely dangerous to ride in cargo area, inside or outside of a vehicle.
Page 20 Why Safety Belts Work Your vehicle has a light ’ that comes on as a reminder When you ride in or on anything, you go as fast as to buckle up. (See “Safety it goes. Belt Reminder Light” in the Index.) In most states and Canadian provinces, the law says to wear safety belts.
Page 21 someone on it. up to speed. Then stop the vehicle. The rider doesn't stop.
Page 22 The person keeps going until stopped by something. or the instrument panel In a real vehicle, could be the windshield...
Page 23 Here Are Questions Many People Ask About Safety Belts and the Answers @’ Won’t I be trapped in the vehicle after an accident if I’m wearing a safety belt? You could be whether you’re wearing a safety belt or not. But you can unbuckle a safety belt, even if you’re upside down.
Page 24 e.’’ If I’m a good driver, and I never drive far from How to Wear Safety Belts Properly home, why should I wear safety belts? Adults You may be an excellent driver, but if you’re in an This part is only for people of adult size. accident even one that isn’t your fault you and...
Page 25 If the belt stops before it reaches the buckle, tilt the 3. Pick up the latch plate and pull the belt across you. Don’t let it get twisted. latch plate and keep pulling until you can buckle the belt. The shoulder belt may lock if you pull the belt across Pull up on the latch plate to make sure it is secure.
Page 26 5. To make the lap part tight, pull down on the buckle The lap part of the belt should be worn low snug end of the belt as you pull up on the shoulder belt. the hips, just touching the thighs. In a crash, this applies force to the strong pelvic bones.
Page 27 button move To move it down, squeeze the release Shoulder Belt Height Adjuster the adjuster to the desired position. You can move Before you begin drive, move the shoulder belt adjuster up just by pushing up on the shoulder belt adjuster to the height that is right for you.
Page 28 e.’ What’s wrong with this? You can be seriously hurt if your shoulder belt too loose. a crash, you would move forward too much, which could increase injury. The shoulder belt should fit against your body. The shoulder belt is too loose. It won’t give nearly as much protection this way.
Page 29 Q . ' wrong What's with this? CAUTION: You can be seriously injured if your belt is this. In a crash, buckled in the wrong place like the belt would go up over your abdomen. The belt forces would be there, not the pelvic bones.
Page 30 What's wrong with this? can be seriously injured if you wear the shoulder belt under your arm. In crash, your too far body would move forward, which would increase the chance of head and neck injury. Also, the belt would apply too much force to the ribs, which aren't as strong as shoulder bones.
Page 31 What's wrong with this? UTION: You can be seriously injured by a twisted belt. I a crash, you wouldn't have the full width of the belt to spread impact forces. If a belt is twisted, make it straight so it can work properly, or ask your dealer to fix it.
Page 32 Safety Belt Use During Pregnancy Safety belts work everyone, including pregnant women. Like all occupants, they are more likely to be seriously injured if they don’t wear safety belts. To unlatch the belt, just push the button on the buckle. The belt should go back out of the way.
Page 33 to protect the fetus is to protect the Here are the most important things to know about the The best When a safety belt is worn properly, it’s more bag system: mother. likely that the fetus won’t be hurt in a crash. For pregnant women, as for anyone, the key to making safety belts effective is wearing them properly.
Page 34 ontinue CAUTI-”: And, for unrestrained occupants, reduced-force very Children who are up against, or close to, air bags may provide less protection in frontal air bag when it inflates can be seriously injured crashes than more forceful air bags have or killed.
Page 35 How the Air Bag System Works There is an air bag readiness light on the instrument panel, which shows the air bag symbol. The system checks the air bag electrical system for malfunctions. The light tells you if there is an electrical problem.
Page 36 same.thhg is between an occupant n d an air bag, the bagmight aot inflate properly might force the object into that person. The path of an inflating air bag must be kept clear. Don’t put anything between an occupant and an air bag, and don’t attach or put anything on the steering wheel hub or on or near any other air bag covering.
Page 37 When should an air bag inflate? What makes an air bag inflate? An air bag is designed to inflate in a moderate to severe impact of sufficient severity, the air bag sensing system detects that the vehicle is in a crash. The sensing frontal or newfrontal crash.
Page 38 What will you see after an air bag inflates? In many crashes severe enough to inflate an air bag, windshields are broken by vehicle deformation. After an air bag inflates, it quickly deflates, so quickly Additional windshield breakage may also occur from the that some people may not even realize the air bag right front passenger air bag.
Page 39 Servicing Your Air Bag-Equipped Vehicle NOTICE: bags affect how your vehicle should be serviced. There are parts of the air bag system in several places If you damage the covering for the driver’s or the around your vehicle. You don’t want the system to right front passenger’s air bag, the bag may not inflate while someone is working on your vehicle.
Page 40 Rear Seat Passengers It’s very important for rear seat passengers to buckle up! Accident statistics show that unbelted people in the rear seat are hurt more often in crashes than those who are wearing safety belts. Rear passengers who aren’t safety belted can be thrown out of the vehicle in a crash.
Page 41 If the belt stops before it reaches the buckle, tilt the 3. To make the lap part tight, pull down on the buckle latch plate and keep pulling until you can buckle it. end of the belt as you pull up on the shoulder part. Pull up on the latch plate to make sure it is secure.
Page 42 slide under the lap belt. If you slid under it, the belt would apply force at your abdomen. This could cause serious or even fatal injuries. The shoulder belt should go over the shoulder across the chest. These parts of the body are best able to take belt restraining forces.
Page 43 There is one guide for each outside passenger position in the rear seat. To provide added safety belt comfort for children who have outgrown child restraints and smaller adults, the comfort guides may be installed on the shoulder belts. Here’s how to install a comfort guid and use the safety belt: To unlatch the belt, just push the button on the buckle.
Page 44 3. Be sure that the belt is not twisted and it lies flat. 2. Slide the guide under and past the belt. The elastic The elastic cord must be under the belt and the guide cord must be under the belt. Then, place the guide over the belt, and insert the two edges of the belt into on top.
Page 45 To remove and store the comfort guides, squeeze the belt edges together so that you can take them out from the guides. Pull the guide upward to expose its storage clip, and then slide the guide onto the clip. Rotate the guide and clip inward and in between the seatback and the interior body, leaving only the loop of elastic...
Page 46 Lap Belt To make the belt shorter, pull its free end as shown until the belt is snug. When you sit in the center seating position, you have a Buckle, position and release it the same way as the lap lap safety belt, which has no retractor.
Page 47 Smaller Chil4ren m d Babies Children Everyone in a vehicle needs protection! That includes infants and all children smaller than adult size. Neither CAUTION: the distance traveled the age and size of the traveler changes the need, for everyone, to use safety restraints. Children who are up against, or very to, an In fact, the law in every state in the United States and in...
Page 48 Infants need complete support, including support for the head and neck. This is necessary because an infant’s CAUTION: neck is weak and its head weighs so much compared with the rest of its body. In crash, an infant in a Smaller children and babies should always be rear-facing restraint settles into the restraint, so the crash restrained in a child or infant restraint.
Page 49 mph (40 kmh), a 12-1b. only (5.5 kg) baby will suddenly become a 2404b. (110 kg) force on your arms. The baby would be almost impossible to hold. Secure the baby in an infant restraint. CAUTION: Never hold a baby in your arms while riding in a vehicle.
Page 50 Child Restraints Every time infants and young children ride vehicles, they should have protection provided by appropriate restraints. What are the different types of add-on child restraints? Add-on child restraints are available in four basic types. When selecting a child restraint, take into consideration not only the child’s weight and size, but also whether or not the restraint will be compatible with the niotor vehicle in which it will...
Page 51 A rear-facing infant restraint (B) positions an infant to face the rear of the vehicle. Rear-facing infant restraints are designed for infants of up to about 20 lbs. (9 kg) and about one year of age. This type of restraint faces the rear so that the infant’s head, neck and body can have the support they need in a crash.
Page 52 A forward-facing child restraint (C-E) positions a child upright to face forward in the vehicle. These forward-facing restraints are designed to help protect children who are from 20 to 40 lbs. (9 to 18 kg) and about 26 to inches (66 to 102 cm) in height, or up to around four years of age.
Page 53 A booster seat (F, G) is designed for children who are about 40 to 60 lbs. (18 to 27 kg) and about four to eight years of age. It’s designed to improve the fit of vehicle’s safety belt system. Booster seats with shields use lap-only belts;...
Page 54 When choosing a child restraint, be sure the child restraint is designed to be used in a vehicle. If it is, it will have a label saying that it meets Federal Motor Vehicle Safety Standards. A child in a rearfacing child restraint can be Then follow the instructions for the restraint.
Page 55 If you need to have an anchor installed, you follow the instructions that came with the child can ask your Chevrolet dealer to put it in for you. If you restraint. Secure the child in the child restraint when want to install an anchor yourself, your dealer can tell as the instructions say.
Page 56 2. Pick up the latch plate, and run the lap and shoulder portions of the vehicle’s safety belt through or around the restraint. child restraint instructions will show you how. 3. Buckle the belt. Make sure the release button is positioned you would be able to unbuckle the safety belt quickly if you ever had to.
Page 57 To remove the child restraint, just unbuckle vehicle’s back all the way. The safety belt safety belt let it for an adult will move freely again and be ready to work or larger child passenger. Securing a Child Restraint in the Center Rear Seat Position You’ll be using the lap belt.
Page 58 1. Make the belt as long as possible by tilting the latch Buckle the belt. Make sure the release button plate and pulling it along the belt. positioned so you would be able to unbuckle the safety belt quickly if you ever had to. 2.
Page 59 6. Push and pull the child restraint in different directions to be sure it is secure. CAUTION: To remove the child restraint, just unbuckle the vehicle’s safety belt. It will be ready to work for an adult or larger A child in a rear-facing child restraint can be child passenger.
Page 60 Tilt the latch plate adjust the belt if needed. 4. Buckle the belt. Make sure the release button is positioned so you would be able to unbuckle the If the shoulder belt goes in front of the child’s face or safety belt quickly if you ever had neck, put it behind the child restraint.
Page 61 5. To belt, pull up on while tighten the the shoulder belt you push down on the child restraint. You may find it helpful to use your knee to push down on the child restraint as you tighten the belt. 6.
Page 62 If you have the choice, a child should sit next to a Larger Children can wear a window so the child lap-shoulder belt and get the additional restraint a shoulder belt can provide. Accident statistics show that children safer if they are restrained in the rear seat.
Page 63 Never do this. Here two children are wearing the same belt. The belt can’t properly spread the impact forces. In a crash, the two children can be crushed together and seriously injured. A belt must be used by only one person at a time. What if‘...
Page 64 Never this. Here a child is sitting in seat that has lap-shoulder belt, but the shoulder part is behind the child. If the child wears the belt in this way, a crash the child might slide under the belt. The belt’s force would then be applied right on the child’s abdomen.
Page 65 Replacing Restraint System Parts Safety Belt Extender After a Crash If the vehicle’s safety belt will fasten around you, should use it. If you’ve had a crash, do you need new belts? But if a safety belt isn’t long enough to fasten, your After a very minor collision, nothing may be necessary.
Page 66 Section 2 Features and Controls Here you can learn about the many standard and optional features on your vehicle, and information on starting, shifting and braking. Also explained are the instrument panel and the warning systems that tell you if everything is working properly and what to do if you have a problem.
Page 67 Keys Leaving young children in a vehicle with the ignition key is dangerous for many reasons. A child or others could be badly injured or even killed. They could operate power windows or other controls or even make the vehicle move. Don't leave the keys in a vehicle with young children.
Page 68 One key is used for the key code on it that tells your dealer or a Each tag has ignition and all other locks. qualified locksmith how to make extra keys. Keep the tag in a safe place. If you lose your keys, you’ll be able to have one made easily using this tag.
Page 69 outside, use your key Keyless Entry Door Locks From System, if your vehicle has this option. Unlocked doors can be dangerous. Passengers especially children can easily out. When a door is open the doors and fall inside locked, the handle won’t open it. Outsiders can easily enter through an unlocked door when you slow down or stop your vehicle.
Page 70 Power Door Locks (If Equipped) Rear Door Security Locks With the power door locks, Your vehicle is equipped you can unlock or lock all with rear door security of the doors of your vehicle locks that help prevent from the driver or front passengers from opening passenger door lock switch.
Page 71 from rear Keyless Entry System (If Equipped) doors your vehicle cannot be opened the inside when this feature is in use. If you want to If your vehicle has this option, you can lock and unlock open a rear door when the security lock is on: your doors or unlock your trunk from about 3 feet (1 m) 1.
Page 72 This device complies with RSS-210 of Industry Canada. Check the location. Other vehicles or objects may be Operation is subject to the following two conditions: blocking the signal. Take a few steps to the left or (1) this device may not cause interference, and (2) this right, hold the transmitter higher, and try again.
Page 73 Battery Replacement Matching Transmitter(s) To Your Vehicle remote Under normal use, the battery in your keyless Each remote keyless entry transmitter is coded to entry transmitter should last about two years. prevent another transmitter from unlocking your vehicle. If a transmitter is lost or stolen, a replacement can be You can tell the battery is weak if the transmitter won’t purchased through your dealer.
Page 74 4. Check the operation of the transmitter with your vehicle. If the transmitter does not work, try synchronizing the transmitter with the receiver. Synchronization Your keyless entry system is equipped with a security system that prevents anyone from recording and playing back your signal.
Page 75 Remote Trunk Release I’runk from the outside, insert the key and unlock the trunk Press the remote trunk turn the trunk lock cylinder. release button, located on the lower left side of the instrument panel, to release the trunk lid. Make sure the lockout feature is not activated.
Page 76 Theft Vehicle theft is big business, especially in some cities. Although your vehicle has a number of theft-deterrent features, we know that nothing we put on it can make it impossible to steal. However, there are ways you can help. Key in the Ignition If you leave your vehicle with the keys inside, it's an easy target for joy riders or professional thieves...
Page 77 Lock all the doors except the driver’s. is running, a problem has been detected and the system may need service. See your dealer for service. In an emergency, call the Chevrolet Roadside Assistance Center at 1-800-CHEV-USA (1-800-243-8872). (In Canada, call 1-800-268-6800.)
Page 78 Ignition Positions New Vehicle “Break-In” NOTICE: Your vehicle doesn’t need an elaborate “break-in.” But it will perform better in the long run if you follow these guidelines: Don’t drive at any one speed fast or slow for the first miles (805 km).
Page 79 ACC (Accessory) (B): This position unlocks the Starting Your Engine transaxle. It also lets you use things like the radio and Move your shift lever to PARK (P) or NEUTRAL (N). windshield wipers when the engine is not running. To Your engine won’t start in any other position -- that’s a use ACC, push in the key and turn it to the right.
Page 80 Starting Your 2.4 Liter Engine 3. If your engine still won’t start (or starts but then stops), it could be flooded with too much gasoline. Try 1. With your foot off the accelerator pedal, turn your pushing your accelerator pedal all the way to the floor ignition key to START.
Page 81 Starting Your 3100 Engine 2. If your engine won’t start (or starts but then stops), it could be flooded with too much gasoline. 1. Without pushing the accelerator pedal, turn your pushing your accelerator pedal all the way to the ignition key to START.
Page 82 Engine Coolant Heater (If Equipped) 3100 Engine In very cold weather, 0 "F 18°C) or colder, the engine Engine 2 . 4 L coolant heater can help. You'll get easier starting and fuel economy during engine warm-up. Usually, better the coolant heater should be plugged in a minimum of four hours prior to starting your vehicle.
Page 83 To Use the Engine Coolant Heater How long should you keep the coolant heater plugged The answer depends on the outside temperature, the 1. Turn the engine. kind of oil you have, and some other things. Instead of 2. Open the hood and unwrap the electrical cord.
Page 84 PARK (P): This locks your front wheels. It’s the best Ensure the shift lever is fully in PARK (P) range before starting the engine. Your vehicle has a position to use when you start your engine because your vehicle can’t move easily. Brake-Transaxle Shift Interlock.
Page 85 (N): NEUTRAL In this position, your engine doesn’t (D): This position is for AUTOMATIC OVERDRIVE connect with the wheels. To restart when you’re normal driving. If you need more power for passing, already moving, use NEUTRAL (N) only. Also, use and you’re: NEUTRAL (N) when your vehicle is being towed.
Page 86 FIRST (1): This position gives you even more power THIRD (3): This position is also used for normal (but lower fuel economy) than SECOND (2). You can driving, however, it offers more power and lower fuel economy than AUTOMATIC OVERDRIVE (D). Here use it on very steep hills, or in deep snow or mud.
Page 87 Second-Gear Start To release the parking brake, hold the regular brake pedal down with your right foot. Push down Your vehicle is equipped with a second-gear start parking brake pedal with your left foot. If the parking feature. Place the shift lever in SECOND gear to drive, a brake is not released when you begin to...
Page 88 Shifting Into PARK (P) CAUTION: It can be dangerous to get out of your vehicle if the shift lever is not fully in PARK (P) with the parking brake firmly set. Your vehicle can roll. If you have left the engine running, the vehicle can move suddenly.
Page 89 Leaving Your Vehicle With the Torque Lock Engine Running If you are parking on a hill and you don’t shift your transaxle into PARK (P) properly, the weight of the vehicle may put too much force on the parking pawl in the transaxle.
Page 90 Shifting Out of PARK (P) Parking Over Things That Burn Your vehicle has a Brake-Transaxle Shift Interlock. You have to apply your regular brake before you can shift from PARK (P) when the ignition is in the ON position. See "Automatic Transaxle" the Index.
Page 91 Running Your Engine While Engine Exhaust You’re Parked It’s better not to park with the engine running. But if you ever have to, here are some things to know. Engine exhaust can kill. contains the gas carbon monoxide (CO), which you can’t see or smell.
Page 92 Power Windows (If Equipped) can be dangerous to get out of your vehicle if the shift lever is not fully in PARK with the parking brake firmly set, Your vehicle can roll. Don’t leave your vehicle when the engine is running unless you have to.
Page 93 Auto-Down Switch Wheel Tilt The driver's window switch has an auto-down feature. This switch is labeled AUTO. Push the top of the switch partway, and the driver's window will open a small amount. If the switch is pushed all the way, the window will go all the way down.
Page 94 f i r n and Lane Change Signals Turn SignaVMultifunction Lever The turn signal has two upward (for right) and two downward (for left) positions. These positions allow you to signal a turn or a lane change. To signal a move the lever a l l the way up or down.
Page 95 Windshield Wipers If a bulb is burned out, replace it to help avoid an accident. If the arrows don’t go on at all when you signal a turn, check for burned-out bulbs and then check the fuse (see “Fuses and Circuit Breakers” in the Index). Headlamp High/Low Beam To change the headlamps from low-beam to...
Page 96 Remember that damaged wiper blades may prevent you from seeing well enough to drive safely. To avoid damage, be sure clear and snow from the wiper blades before using them. If they’re frozen to the windshield, carefully loosen or thaw them. If your blades do become damaged, get new blades or blade inserts.
Page 97 Windshield Washer CAUTIGJ: In freezing weather, don’t use your washer un the windshield is warmed. Otherwise the washe fluid can form ice on the windshield, blocking your vision. When you release the button, the washers will stop, but th wipers will continue to wipe for about three times or wi stop or will resume the speed you were using before.
Page 98 off. Cruise Control (If Equipped) When you apply your brake, the cruise control shuts CAUTION: Cruise control can be dangerous where you can’t drive safely at a steady speed. So, don’t use your cruise control on winding roads or in heavy traffic. Cruise control can be dangerous on slippery roads.
Page 99 press the cruise control ACCEL RESUME button Setting Cruise Control about half a second. your You’ll go right back up to chosen speed and stay there. If you press the ACCEL RESUME button longer th If you leave your cruise control switch on when half a second, the vehicle will keep going faster until you’re not using cruise, you might hit a button you release the switch or apply the brake.
Page 100 Reducing Speed While Using Cruise Control Using Cruise Control on Hills There are two ways to reduce your speed while using How well your cruise control will work on hills depends cruise control: upon your speed, load and the steepness of the hills. When going up steep hills, you may have to step on the Push the SET DECEL button until you reach the accelerator pedal to maintain your speed.
Page 101 Rotate the turn signal lever end cap up two positions to Exterior Lamps turn on: Headlamps Parking Lamps Sidemarker Lamps Taillamps License Plate Lamps Instrument Panel Lights Rotate the switch to to turn all of the lamps off. ..j* ,..,.: Lamps On Reminder i-2: If you open the driver’s door and turn off the...
Page 102 Automatic Light Control Daytime Running Lamps (DRL) When it is dark enough outside, your Automatic Light Daytime Running Lamps can make it easier for ( L C ) others to see the front of your vehicle during the day. Control will turn your headlamps at the DRL can...
Page 103 Fog Lamps (If Equipped) Interior Lamps The button for your fog Instrument Panel Intensity Control lamps is the instrument You can brighten or dim the panel, to the left of the instrument panel cluster steering wheel, beside lights by rotating the switch the instrument panel located on the instrument intensity control.
Page 104 When any interior lamp (trunk, reading, footwell or If the ignition has been off for less than two minutes, glove box) is left on when the ignition is turned off, the the lamps inside your vehicle will stay on for about battery saver system will automatically shut the lamp off 15 seconds after your key is removed from the ignition after 20 minutes.
Page 105 Manual 1 !mote Control Mirror Power Remote Control Mirror (If Equipped) The outside rearview mirror should be adjusted can just see the side of your vehicle when you are sitting in a comfortable driving position. Adjust the driver’s side outside mirror with the control lever on the driver’s door.
Page 106 Convex Outside Mirror Center Console Storage Area Your passenger’s side mirror is convex. A convex mirror’s surface is curved so you can see more from the driver’s seat. ’ CAUTION: A convex mirror can make things (like other vehicles) look farther away than they really are. If you cut too sharply into the right lane, you could hit a vehicle on your right.
Page 107 Instrument Panel Cupholder The lower area can be used to store cassette tapes or compact discs. To open the lower compartment, pull up The instrument panel cupholder is located to the left on the armrest. the steering wheel. To use it, pull it out until the rubber insert is revealed.
Page 108 Rear Seat Cupholder NOTICE: Pull down the door the rear of the center console to use the rear seat cupholder. can use it to hold cup. Don’t put papers and other things that burn into Convenience Net (If Equipped) your ashtrays. If you do, cigarettes or other smoking materials could set them on fire, Your vehicle may have a convenience net.
Page 109 Outlet Accessory Power Sunvisors To block out glare, you can swing down the visors. You The accessory power outlet can also swing them to the side. is located to the right of the ashtray. Visor Vanity Mirror Lift the cover to expose the vanity mirror. Illuminated Visor Vanity Mirror (If Equipped) This mirror is located on the passenger’s side visor.
Page 110 In both the vent and full open positions, the air flow Garment Hook can be adjusted for driving comfort by pushing and holding the switch forward until the sunroof moves to a Pull down on the outer ring desired position. to use the garment hook.
Page 111 Instrument Panel...
Page 112 Your instrument panel is designed to let you know at a glance how your vehicle is running. You’ll know how fast you’re going, how much fuel you’re using, and many other things you’ll need to drive safely and economically. The main components of your instrument panel are: K.
Page 113 Instrument Panel Cluster Your vehicle is equipped with this cluster or one very similar. It includes indicator warning lights and gages that are explained on the following pages. Be sure to read them. WASH THEFT SYSTEM CHECK I W U 2-48...
Page 114 Your odometer shows how far your vehicle has been driven, in either miles (used in the United States) or kilometers (used in Canada). Your Chevrolet has a tamper resistant odometer. The digital odometer will read 999,999 if someone tries to turn it back.
Page 115 Tachon- Warning Lights, Gages and Indicators This part describes the warning lights and gages that may be on your vehicle. The pictures will help you locate them. Warning lights and gages can signal that something wrong before it becomes serious enough to cause an expensive repair or replacement.
Page 116 When one of the warning lights comes on and stays on Air Bag Readiness Light when you are driving, or when one of the gages shows There is an air bag readiness light on the instrument there may be a problem, check the section that tells you panel, which shows the air bag symbol.
Page 117 Charging System Indicator Light Brake System Warning Light Your vehcle’s hydraulic brake system is divided into The charging system two parts. If one part isn’t working, the other part can indicator light will come on still work and stop you. For good braking, though, you when you turn on the need both parts working well.
Page 118 you are driving, If the light and chime come on while Anti-Lock Brake System Warning Light pull off the road and stop carefully. You may notice that With the anti-lock brake the pedal is harder to push. Or, the pedal may go closer system, this light will come to the floor.
Page 119 Engine Coolant Temperature Gage Low Coolant Warning Light & I This gage shows the engine This light comes on briefly coolant temperature. If the when you turn your gage pointer moves into the red area, the light comes on and you hear a chime, your engine is too hot! It means that your engine coolant has overheated.
Page 120 Malfunction Indicator Lamp NOTICE: (Check Engine Light) Your vehicle equipped If you keep driving your vehicle with this light with a computer which on, after a while, your emission controls may not monitors operation of the work well, your fuel economy may not be fuel, ignition and emission good and your engine may not run as smoothly.
Page 121 This light should come on, as a check to show you it is remains If the light stops flashing and on steady, see “If working, when the ignition is on and the engine is not the Light Is On Steady” following. running.
Page 122 Have you recently changed brands of fuel? Oil Pressure Warning Light If so, be sure to fuel your vehicle with quality fuel (see If you have a low engine oil “Fuel” in the Index). Poor fuel quality will cause your pressure problem, this light engine not to run as efficiently as designed.
Page 123 Check Oil Light (If Equipped) If your vehicle equipped with a 3 100 engine. then Don’t keep driving if the oil pressure is low. If CHECK will have :CHECK you do, your engine can become so hot that it OIL light in your instrumen panel cluster.
Page 124 Cruise Light (If Equipped) The oil level monitoring system only checks oil level during the brief period between key on and engine The CRUISE light comes crank. It does not monitor engine oil level when the on whenever you set your engine is running.
Page 125 Service Vehicle Soon Light Fuel Gage fuel This light will come on Your gage tells you briefly when you turn about how much fuel you SERVICE on the ignition. have left, when the ignition VEHICLE is on. When the indicator nears (E) EMPTY, the light SOON will come on and you will...
Page 126 NOTES...
Page 127 NOTES...
Page 128 Section 3 Cornfort Controls and Audio Systems In this section, you’ll find out how to operate the comfort control and audio systems offered with your vehicle. Be sure to read about the particular systems supplied with your vehicle. Cornfort Controls 3 -7 AM-FM Stereo AM-FM Stereo with Cassette Tape Player and...
Page 129 Comfort Controls Fan Knob This section tells you how to make your air system The left knob selects the force of air you want. Turn the work for you. The climate control system with air knob to the right to increase fan speed and to the left to conditioning uses ozone-friendly R- 134a refrigerant.
Page 130 It is not recommended to use this button in the FLOOR FLOOR: In this position most of the airflow mode with heat. It is useful to quickly cool the vehicle comes through the floor outlet. The rest of the air comes on hot days.
Page 131 Defogging and Defrosting Windows For quick cool-down on very hot days, use vent with the temperature knob all the way in the blue area and the Your system has two settings for clearing the front and N C and recirculation buttons pressed. If this setting is side windows.
Page 132 Rear Window Defogger (If Equipped) NOTICE: The rear window defogger uses a warming grid to Don’t use a razor blade or anything else sharp on remove fog from the the inside of the rear window. If you do, you rear window. could cut or damage the warming grid, and the repairs wouldn’t be covered by your warranty.
Page 133 To prevent circulation of outside air, press the recirculation button. This will close all outside ven Audio Systems Your Delco Electronics audio system has been design to operate easily and give years of listening pleasure. You will get the most enjoyment out of it if acquaint yourself with it first.
Page 134 AM-FM Stereo Finding a Station AM-FM: Press the lower knob to switch between AM and FM. The display shows your selection. TUNE: Turn the lower knob to choose radio stations. SEEK: Press the right or left arrow to go to the next higher or lower station and stay there.
Page 135 PUSHBUTTONS: The four numbered pushbuttons let 3. Press any two adjoining pushbuttons at the same time, within five seconds. The sound will mute. you return to your favorite stations. You can set up to 14 stations (seven AM and seven FM). Just: When it returns, release the buttons.
Page 136 and wind noise as you drive. Set the volume at the AM-FM Stereo with Cassette Tape Player desired level. Move the control ring behind the upper and Automatic Tone Control (If Equipped) knob to the right to adjust the SCV. Then, as you drive, SCV automatically increases the volume, as necessary, to overcome noise at any particular speed.
Page 137 PUSHBUTTONS: The six numbered pushbuttons let P.SCAN or one of the pushbuttons again to stop you return to your favorite stations. You can set up to scanning. P.SCAN will be displayed whenever the tune is in the P.SCAN mode. The channel number (Pl-P6) 18 stations (six AM, six FM1 and six FM2).
Page 138 Playing a Cassette Tape AUTO TONE: This feature allows you to choose preset bass and treble equalization settings designed for Your tape player is built to work best with tapes that country/western, classical, news, rock, pop and jazz 30 to 45 minutes long on each side. Tapes longer than stations.
Page 139 PREV (1): Press this button or the left SEEK arrow to (4): Press this button to reverse the tape rapidly go to the previous selection on the tape if the current Press it again to return to playing speed. The radio will selection has been playing for less than eight seconds.
Page 140 EJECT Press this button to remove the tape. The radio CD Adapter Kits will play. EJECT may be activated with either the It is possible to use a CD adapter kit with your cassette ignition or radio off. Cassettes may be loaded with the tape player after activating the bypass feature on your radio off if this button is pressed first.
Page 141 and wind noise as you drive. Set the volume at the :-FM Stereo with Compact Disc Player desired level. Move the control ring behind the upper Automatic Tone Control (If Equipped) knob to the right to adjust the SCV. Then, as you drive, SCV automatically increases the volume, as necessar to overcome noise at any particular speed.
Page 142 PUSHBUTTONS: The six numbered pushbuttons let P.SCAN or one of the pushbuttons again to stop scanning. P.SCAN will be displayed whenever the tuner you return to your favorite stations. You can set up to is in the P.SCAN mode. The channel number (Pl-P6) 18 stations (six AM, six FM1 and six FM2).
Page 143 AUTO TONE: This feature allows you to choose Playing a Compact Disc preset bass and treble equalization settings designed Insert a disc partway into the slot, label side up. country/western, classical, news, rock, pop and jazz player will pull it in. The disc should begin playing. The stations.
Page 144 AM-FM: Press this button to play the radio when a di (2): Press this button to hear the tracks in random, is in the player. The letters CD will go off the display. rather than sequential, order. RANDOM will show on the display.
Page 145 PREV (1): Press PREV or the SEEK down arrow Remote Cassette Tape Player (If Equipped) to search for the previous selection. A minimum Playing Cassette Tape three-second blank gap is needed for the player to stop at the beginning of the selection. The tape direction arrow will blink during the SEEK operation and the sound will mute in this mode.
Page 146 PROG: Press this button on the remote cassette player The THEFTLOCK feature for the radio may be used or ignored. If ignored, the system plays normally and the to go from one side of the tape to the other. radio is not protected by the feature. If THEFTLOCK CDPLAY: After a cassette tape and a CD have been is activated, your radio will not operate if stolen.
Page 147 3. Turn the radio off. Unlocking the Theft-Deterrent Feature After a Power Loss 4. Press the 1 and 4 buttons together. Hold them down until shows on the display. Next you will use the Enter your secret code as follows; pause no more than secret code number which you have written down.
Page 148 Disabling the Theft-Deterrent Feature To unlock a secured radio, see “Unlocking the Theft-Deterrent Feature After a Power Loss” Enter your secret code as follows; pause no more than earlier in this section. 15 seconds between steps: Understanding Radio Reception 1. Turn the ignition to ACC or ON. Turn the radio off.
Page 149 help avoid hearing loss or damage: Care of Your Cassette Tape Player Adjust the volume control to the lowest setting. A tape player that is not cleaned regularly can cause reduced sound quality, ruined cassettes or a damaged Increase volume slowly until you hear comfortably mechanism.
Page 150 You may also choose a non-scrubbing action, wet-type When using a scrubbing action, non-abrasive cleaning cleaner which uses a cassette with a fabric belt to cle cassette, it is normal for the cassette to eject because the tape head. This type of cleaning cassette will not your unit is equipped with a cut tape detection feature eject on its own.
Page 151 Care of Your Compact Discs Fixed Mast Antenna The fixed mast antenna can withstand most car wash Handle discs carefully. Store them in their original cases without being damaged. If the mast should ever become or other protective cases and away from direct sunlight and dust.
Page 152 Section 4 Your Driving and the Road Here you’ll find information about driving on different kinds of roads and in varying weather conditions. We’ve also included many other useful tips on driving. Defensive Driving 4- 19 City Driving Drunken Driving 4-20 Freeway Driving Control of a Vehicle...
Page 153 Defensive driving really means “be ready for anything.” On city streets, rural roads or freeways, it means “always expect the unexpected.” Assume that pedestrians or other drivers going to be careless and make mistakes. Anticipate what they might do. Be ready for their mistakes. Rear-end collisions are about the most preventable of accidents.
Page 154 The obvious way to solve this highway safety problem Drunken Driving is for people never to dnnk alcohol and then drive. But Death and injury associated with drinking and driving is what if people do? How much is “too much” if the a national tragedy.
Page 155 Since alcohol is carried in body water, this means that woman generally will reach a higher BAC level than a man of her same body weight when each has the sam number of drinks. The law in many U.S. states sets the legal limit at a BAC of 0.10 percent.
Page 156 The body takes about an hour to rid itself of the alcohol one drink. No amount of coffee or number of cold CAI-’ION: showers will speed that up. “I’ll be careful” isn’t the right answer. What if there’s an emergency, a need to Drinking and then driving is very dangerous.
Page 157 Control of Vehicle %raking Braking action involves perception time and You have three systems that make your vehicle where you want it to go. They are the brakes, the steering and reaction time. the accelerator. All three systems have to do their work First, you have to decide to push on the brake pedal.
Page 158 Anti-Lock Brakes (ABS) Avoid needless heavy braking. Some people drive in spurts heavy acceleration followed by heavy Your vehicle has anti-lock brakes (ABS). ABS is an rather than keeping pace with traffic. This is a braking advanced electronic braking system that will help mistake.
Page 159 The anti-lock system can change the brake pressure faste computer is programmed to than any driver could. make the most of available tire and road conditions. Here’s how anti-lock works. Let’s say the road is wet. You’re driving safely. Suddenly an animal jumps out in front of you.
Page 160 Remember: Anti-lock doesn’t change the time you need Steering Tips to get your foot up to the brake pedal or always decrease Driving on Curves stopping distance. If you get too close to the vehicle in front of you, you won’t have time to apply your brakes It’s important to take curves at a reasonable speed.
Page 161 What should you do if this ever happens? Ease up on the Steering in Emergencies accelerator pedal, steer the vehicle the way you want it There are times when steering can be more effective than to go, and slow down. braking.
Page 162 Off-Road Recovery You may find that your right wheels have dropped off the edge of a road onto the shoulder while you’re driving. An emergency like this requires close attention and a quick decision. If you are holding the steering wheel at the recommended 9 and 3 o’clock positions, you can turn full...
Page 163 Passing Do not get too close to the vehicle you want to pass while you’re awaiting an opportunity. For one The driver of a vehicle about to pass another on a thing, following too closely reduces your area two-lane highway waits for just the right moment, vision, especially if you’re following a larger accelerates, moves around the vehicle ahead, then goes vehicle.
Page 164 Check your mirrors, glance over your shoulder, and In any emergency, don’t give up. Keep trying to steer and start your left lane change signal before moving out constantly seek an escape route or area of less danger. of the right lane to pass. When you are far enough Skidding ahead of the passed vehicle to see its front in your...
Page 165 Of course, traction is reduced when water, snow, ice, Driving at Night gravel or other material is on the road. For safety, you’ll want to slow down and adjust your driving to these conditions. It is important to slow down on slippery surfaces because stopping distance will be longer and vehicle control more limited.
Page 166 down on glare from headlamps, but they also make a lot Here are some tips on night driving. of things invisible. Drive defensively. You can be temporarily blinded by approaching Don’t drink and drive. headlamps. It can take a second or two, or even several Adjust your inside rearview mirror to reduce the seconds, for your eyes to readjust to the dark.
Page 167 Driving in Rain and on Wet Roads Rain and wet roads can mean driving trouble. On a road, you can't stop, accelerate or turn as well because your tire-to-road traction isn't as good as on dry road And, if your tires don't have much tread left, you'll ge even less traction.
Page 168 Wet brakes can cause accidents. They won’t work as well in a quick stop and may cause pulling to one side. You could lose control of the vehicle. After driving through a large puddle of water or a car wash, apply your brake pedal lightly until your brakes work normally.
Page 169 Hydroplaning Driving Through Deep Standing Water Hydroplaning is dangerous. So much water can build up under your tires that they can actually ride on the water. NOTICE: This can happen if the road is wet enough and you’re going fast enough. When your vehicle is hydroplaning, If you drive too quickly through deep puddles o it has little or no contact with the road.
Page 170 City Driving Here are ways to increase your safety in city driving: Know the best way to get to where you are going. Get a city map and plan your trip into an unknown part of the city just as you would for a cross-country trip.
Page 171 Freeway Driving At the entrance, there is usually a ramp that leads to the freeway. If you have a clear view of the freeway as you drive along the entrance ramp, you should begin to T r y check traffic. to determine where you expect to blend with the flow.
Page 172 Of course, time to avoid a major storm system? you’ll find experienced and able service experts in Maps: Do you have up-to-date maps? Chevrolet dealerships all across North America. They’ll be ready and willing to help if you need it.
Page 173 Highway Hypnosis Hill and Mountain Roads Is there actually such a condition as “highway hypnosis”? C a l l Or is it just plain falling asleep at the wheel? highway hypnosis, lack of awareness, or whatever. There is something about an easy stretch of road with the same scenery, along with the hum of the tires on the road, the drone of the engine, and the rush of the wind against the vehicle that can make you sleepy.
Page 174 If you drive regularly in steep country, or if you’re planning to visit there, here are some tips that can make your trips safer and more enjoyable. Keep your vehicle in good shape. Check all fluid i n NEUTRAL (N) or with the Coasting dow levels and also the brakes, tires, cooling system ignition off is dangerous.
Page 175 Winter Driving Include an ice scraper, a small brush or broom, a supply of windshield washer fluid, a rag, some winter outer clothing, a small shovel, a flashlight, a red cloth and a Here are some tips for winter driving: couple of reflective warning triangles.
Page 176 Driving on Snow or Ice What’s the worst time for this? “Wet ice.” Very cold snow or ice can be slick hard to drive on. But wet Most of the time, those places where your tires meet ice can be even more trouble because it may offer the road probably have good traction.
Page 177 Your anti-lock brakes improve your vehicle’s stability If You’re Caught in a Blizzard when you make a hard stop on a slippery road. Even though you have the anti-lock braking system, you’ll want to begin stopping sooner than you would on dry pavement.
Page 178 Tie a red cloth to your vehicle to alert police that you’ve been stopped by the snow. CAUTION: extra clothing or wrap a blanket around you. If you have no blankets or extra clothing, make body Snow can trap exhaust gases under your vehicle. insulators from newspapers, burlap bags, rags, floor This cause deadly CO (carbon monoxide) gas...
Page 179 Run your engine only as long as you must. This saves Towing Your Vehicle from the Front fuel. When you run the engine, make it go a little faster There two ways to tow your vehicle from the front, than just idle. That is, push the accelerator slightly. This uses less fuel for the heat that you get and it keeps the battery charged.
Page 180 Module, Cluster. See “Instrument Panel Fuse Block” To tow your vehicle with all four wheels on the ground, in the Index for location of the fuses. follow these steps: 5. Turn the ignition switch to ACC. 6. Shift your transaxle to NEUTRAL (N). 7.
Page 181 Towing Your Vehicle from the Rear Loading Your Vehicle i" TIRE-LOADING INFORMATION OCCUPANTS VEHICLE CAP. WT. CTR. FRT, TOTAL LBS. MAX. LOADING & GVWR SAME AS VEHICLE CAPACITY WEIGHT COLD TIRE TIRE SIZE PRESSURE SPEED PSI/KPa FRT. SPA. IF TIRES ARE HOT, ADD 4PSIi28KPa SEE OWNER'S MANUAL FOR ADDITIONAL INFORMATION Two labels on your vehicle show how much weight it...
Page 182 And, if you do have a heavy load, you should spread it out. Don’t carry more than 132 lbs. (60 kg) in BY GENERAL MOTORS CORP your trunk. DATE GVWR GAWR F R I GAWR RR CAUTION: THIS VEHICLE CONFORMS TO ALL APPLI- MOTOR CABLE U.S.
Page 183 Towing a Trailer CAUTION: CAUTION: Things you put inside your vehicle can strike and injure people in a sudden stop turn, or in ’ If you don’t use the correct equipment and drive a crash. properly, you can lose control when you pull Put things in the trunk of your vehicle.
Page 184 If You Do Decide To Pull A Trailer Your vehicle can tow a trailer if it is equipped with the proper trailer towing equipment. To identify what the If you do, here are some important points: vehicle trailering capacity is for your vehicle, you There are many different laws, including speed limit should read the information in “Weight of the Trailer”...
Page 185 Vehicle” in the Index for more information about your vehicle’s maximum load capacity. You can ask your dealer for our trailering information or advice, or you can write us at: Chevrolet Motor Division Customer Assistance Center P.O. Box 7047 Troy, MI 48007-7047...
Page 186 Total Weight on Your Vehicle’s Tires Be sure your vehicle’s tires are inflated to the upper limit for cold tires. You’ll find these numbers on the Certification label at the rear edge of the driver’s door or see “Loading Your Vehicle” in the Index. Then be sure you don’t go over the GVW limit for your vehicle, including the weight of the trailer tongue.
Page 187 Safety Chains Driving with a Trailer You should always attach chains between your vehicle Towing a trailer requires a certain amount of experien Before setting out for the open road, you’ll want to ge and your trailer. Cross the safety chains under the tongue of the trailer so that the tongue will not drop to the road to know your rig.
Page 188 Following Distance Making Turns Stay at least twice as far behind the vehicle ahead as you would when driving your vehicle without a trailer. This NOTICE: can help you avoid situations that require heavy braking and sudden turns. Making very sharp turns while trailering could Passing cause the trailer to come in contact with the vehicle.
Page 189 Turn Signals When Towing a Trailer Driving On Grades When you tow a trailer, your vehicle may need additional wiring. Check with your dealer. The green NOTICE: arrows on your instrument panel will flash whenever you signal a turn or lane change. Properly hooked up, Do not tow on steep continuous grades exceeding the trailer lamps will also flash, telling other drivers 6 miles (9.6 km).
Page 190 Parking on Hills When You Are Ready to Leave After Parking on a Hill really should not park your vehicle, with a trailer attached, on a hill. If something goes wrong, your rig 1. Apply your regular brakes and hold the pedal down could start to move.
Page 191 Maintenance When Trailer Towing Engine Cooling When Trailer Towing Your vehicle will need service more often when you’re Your cooling system may temporarily overheat during pulling a trailer. See the Maintenance Schedule for more severe operating conditions. See “Engine Overheating” in the Index.
Page 192 Section 5 Problems on the Road Here you’ll find what to do about some problems that can occur on the road. Hazard Warning Flashers 5- 15 Cooling System 5 -2 Other Warning Devices 5-22 If a Tire Goes Flat Jump Starting 5-22 Changing a Flat Tire Towing Your Vehicle...
Page 193 Hazard Warning Flashers Press the switch once to turn your hazard flashers on. The switch will flash when activated. Your hazard warning flashers work no matter what position your key is in, and even the key isn’t in. To turn off the flashers, press the switch again. When the hazard warning flashers are on, your turn signals won’t work.
Page 194 Jump Starting NOTICE: If your battery has run down, you may want to use another vehicle and some jumper cables to start your Ignoring these steps could result in costly damage vvehicle. But please follow the steps here to do to your vehicle that wouldn’t be covered by it safely.
Page 195 2. Get the vehicles close enough so the jumper cables NOTICE: can reach, but be sure the vehicles aren’t touching each other. If they are, it could cause a ground connection you don’t want. You wouldn’t be able to If you leave your radio on, it could be badly start your vehicle, and the bad grounding could damaged.
Page 196 5. Find the positive 6. Check that the jumper cables don’t have loose or and negative terminals on missing insulation. If they do, you could get a shock. each battery. The vehicles could be damaged, too. Before you connect the cables, here are some things should know.
Page 197 8. Don’t let the other end touch metal. Connect it to the positive terminal of the good battery. Use a remote positive terminal if the vehicle has one. 9. Now connect the black negative cable to the good battery’s 7. Connect the positive cable to the positive negative terminal.
Page 198 13. Remove the cables in reverse order to prevent electrical shorting. Take care that they don't touch each other or any other metal. " 1 I - B Attach the cable at least 18 inches (45 cm) away from the dead battery, but not near engine parts that move.
Page 199 That your vehicle has front-wheel drive. Towing Your Vehicle The make, model and year of your vehicle. Try to have a Chevrolet dealer or a professional towing service tow your vehicle. They can provide the right Whether you can still move the shift lever.
Page 200 CA TION: A vehicle can fall from a car carrier if it isn’t To help avoid inpry to you or others: adequately secured. This can cause a collision, Never let passengers ride in a vehicle that is serious personal injury and vehicle damage. The being towed.
Page 201 Front Towing NOTICE: (Continued) Towing a vehicle over rough surfaces could damage a vehicle. Damage can occur from vehicle to ground or vehicle to wheel-lift equipment. To help avoid damage, install a towing dolly and raise vehicle until adequate clearance is obtained between the ground and/or wheel-lift equipment.
Page 202 Rear Towing NOTICE: (Continued) Towing a vehicle over rough surfaces could damage a vehicle. Damage can occur from vehicle to ground or vehicle to wheel-lift equipment. To help avoid damage, install a towing dolly and raise vehicle until adequate clearance is obtained between the ground and/or wheel-lift equipment.
Page 203 If Steam Is Coming From Your Engine Engine Overheating You will find a coolant temperature gage on your vehicle’s instrument panel. See “Engine Coolant Temperature Gage” in the Index. You will also find a low coolant level warning light on your vehicle’s instrument panel.
Page 204 NOTICE: I f your engine catches fire because you keep Steam from an overheated engine can burn you driving with no coolant, your vehicle can be badly, even if you just open the hood. Stay away badly damaged. The costly repairs would not be from the engine if you see or hear steam coming warranty.
Page 205 No Steam Is Coming From Your Engine If you no longer have the overheat warning, you can drive. Just to be safe, drive slower for about If you get the overheat warning but see or hear no 10 minutes. If the warning doesn’t come back on, you steam, the problem may not be too serious.
Page 206 Cooling System When you decide it’s safe to lift the hood, here’s what see: you’ll 3100 Engine A. Coolant Surge Tank with Pressure Lap B. Electric Cooling Engine Fans 2.4L Engine...
Page 207 ‘JTTION: An electric engine cooling fan under the hood can start up even when the engine is not running and can injure you. Keep hands, clothing and tools away from underhood electric the coolant inside the coolant surge tank is boiling, don’t do anything else until it cools down.
Page 208 How to Add Coolant to the Coolant Surge Tank If you haven’t found a problem yet, but the coolant leve Heater and radiator hoses, and other engine isn’t at FULL COLD mark or slightly higher, add a parts, can be very hot. Don’t touch them. If you 50/50 mixture of clean water (preferably distilled) and do, you can be burned.
Page 209 CAUTION: Adding only plain water to your cooling system can be dangerous. Plain water, or some other liquid like alcohol, can boil before the proper coolant mixture will. Your vehicle's coolant warning system is set for the proper coolant mixture. With plain water or the wrong mixture, your engine could get too hot but you wouldn't get the overheat warning.
Page 210 NOTICE: In cold weather, water can freeze and crack the engine, radiator, heater core and other parts. So use the recommended coolant. CAUTION: You can be burned if you spill coolant on hot engine parts. Coolant contains ethylene glycol and it will burn if the engine parts are hot 1.
Page 211 3. Then fill the coolant surge tank with the proper 2. Then keep turning the pressure cap slowly, and mixture, up to FULL COLD mark or slightly higher. remove it. 5-20...
Page 212 4. With the coolant surge tank pressure cap off, start the 5. Then replace the pressure cap. Be sure the pressure engine and let it run until you can feel the upper cap is tight. radiator hose getting hot. Watch out for the engine Check the level in the surge tank when the cooling cooling fans.
Page 213 Changing a Flat Tire If a Tire Goes Flat If a tire goes flat, avoid further tire and wheel damage It’s unusual for a tire to “blow out” while you’re driving, especially if you maintain your tires properly. If air goes by driving slowly to a level place.
Page 214 Removing the Spare Tire and Tools ....................................... Lift and remove the cover. (See “Compact Spare Tire” later in this section for more information about the compact spare.) You will find the jacking instructions label on the underside of the tire cover. The following steps will tell you how to use the jack and change a tire.
Page 215 T u r n the wing nut to the left and remove it. Then lift off the adapter and remove the spare tire. Remove the jack and wheel wrench from the trunk. Your vehicle's jack and wheel wrench are stored in a foam tray.
Page 216 Removing the Flat Tire and Installing the Spare Tire 1. On vehicles equipped with steel wheel covers, completely loosen the wheel nut caps but do not try to remove the caps from the cover. 3. Some models are equipped with aluminum wheels. Remove the cover plate to find the wheel nuts.
Page 217 4. Then use the wheel wrench to loosen all the wheel 5. Position the jack and raise the jack head until it fits nuts. Don’t remove them yet. firmly into the notch in the vehicle’s frame nearest the flat tire. Put the compact spare tire near you.
Page 218 CAUTION: Getting under a vehicle when it is jacked up is dangerous. If the vehicle slips off the jack, you could be badly injured or killed. Never get under a vehicle when it is supported only by a jack. CAUTION: Raising your vehicle with the jack improperly 6.
Page 219 9. Remove any rust or dirt from the wheel bolts, mounting surfaces and spare wheel. Never use oil or grease on studs or nuts. If you do, the nuts might come loose. Your wheel could fall off, causing a serious accident. 10.
Page 220 12. Tighten the wheel nuts firmly in a criss-cross sequence, as shown. LUTION: 11. Lower the vehicle by turning the wheel wrench to Incorrect wheel nuts or improperly tightened the left. Lower the jack completely. wheel nuts can cause the wheel to become loose and even come off.
Page 221 Storing the Flat Tire and Tools NOTICE: CAUTION: Improperly tightened wheel nuts can lead to F - - brake pulsation and rotor damage, To avoid expensive brake repairs, evenly tighten the wheel Storing a jack, a tire or other equipment in the nuts in the proper sequence and the proper passenger compartment of the vehicle could...
Page 222 Storing the Spare Tire and Tools CAUTION: Storing jack, a tire or other equipment in the passenger compartment of the vehicle could cause injury. In a sudden stop or collision, loose equipment could strike someone. Store all these in the proper place. The compact spare is for temporary use only.
Page 223 Compact Spare Tire Although the compact spare tire was fully inflated wh your vehicle was new, it can lose air after a time. Chec the inflation pressure regularly. It should be 60 psi kPa). (420 ‘ F After installing the compact spare on your vehicle, yo should stop as soon as possible and make sure your spare tire is correctly inflated.
Page 224 If You’re Stuck: In Sand, Mud, Don’t use your compact spare on other vehicles. Ice or Snow And don’t your compact spare tire or wheel with other wheels or tires. They won’t fit. Keep your spare What you don’t want to do when your vehicle is stuck is tire and its wheel together.
Page 225 Rocking Your Vehicle To Get It Out NOTICE: First, turn your steering wheel left and right. That wi clear the area around your front wheels. Then shift b Spinning your wheels can destroy parts of your and forth between REVERSE (R) and a forward gear, vehicle as well as the tires.
Page 226 Section 6 Service and Appearance Care Here you will find information about the care of your vehicle. This section begins with service and fuel information, and then it shows how to check important fluid and lubricant levels. There is also technical information about your vehicle, and a part devoted to its appearance care.
Page 227 If you want to do some of your own service work, you’ Your dealer knows your vehicle best and wants you to want to use the proper Chevrolet Service Manual. It tells be happy with it. We hope you’ll go to your dealer for you much more about how to service your vehicle th all your service needs.
Page 228 Fuel Use regular unleaded gasoline rated at 87 octane or higher. At a minimum, it should meet specifications You can be injured and your vehicle could be ASTM D4814 in the United States and CGSB 3.5-M93 in Canada. Improved gasoline specifications have been damaged if you try to do service work on a developed by the American Automobile Manufacturers vehicle without knowing enough about it.
Page 229 If this occurs, return use these gasolines if they comply with the to your authorized Chevrolet dealer for diagnosis to specifications described earlier. determine the cause of failure. In the event it is...
Page 230 Filling Your Tank Fuels in Foreign Countries If you plan on driving in another country outside the United States or Canada, the proper fuel may be hard to find. Never use leaded gasoline or any other fuel not recommended in the previous text on fuel. Costly repairs caused by use of improper fuel wouldn’t be covered by your warranty.
Page 231 To remove the cap, turn it slowly to the left The cap is behind a hinged door on the right side of your vehicle. To open the door, insert your finger into the (counterclockwise). The cap has a spring in it; if you let go of the cap too soon, it will spring back to the right.
Page 232 When you put the cap back on, turn it to the right Filling a Portable Fuel Container (clockwise) until you hear a clicking sound. Make sure you fully install the cap. The diagnostic system can determine if the fuel cap has been left off or improperly installed.
Page 233 Checking Things Under the Hood Hood Release To open the hood, first pull the hood release handle CAL IION: inside the vehicle. An electric fan under the hood can up and start injure you even when the engine is not running. Keep hands, clothing and tools away from any underhood electric fan.
Page 234 Lift the hood, release the hood prop rod from its retainer and put the hood prop into the slot marked PROP ROD. Before closing the hood, be sure all the filler caps are on properly. Then let the hood drop from about Then go to the front of the vehicle and lift the secondary 8 to 12 inches (20 to 30 cm).
Page 235 2.4L (CODE T) Engine When you open the hood, you’ll see: D. Power Steering Fluid Reservoir G. Battery A. Engine Coolant Surge Tank E. Brake Fluid Reservoir B. Engine Oil Fill Cap H. Windshield Washer Fluid Reservoir F. Air Cleaner C.
Page 236 3100 (CODE M) Engine When you open the hood, you’ll see: Engine Coolant Surge Tank D. Engine Oil Dipstick G. Battery Power Steering Fluid Reservoir E. Brake Fluid Reservoir H. Windshield Washer C. Engine Oil Fill Cap F. Air Cleaner Fluid Reservoir...
Page 237 Engine Oil The engine oil dipstick on the 2.4L engine is If your vehicle is equipped with the 3 100 engine, you located at the rear of have a CHECK OIL light on the instrument panel. the engine. If the CHECK OIL light on the instrument panel comes CHECK on, it means you need to...
Page 238 Checking Engine Oil The engine oil dipstick on the 3100 engine is Pull out the dipstick and clean it with a paper towel or located in front of cloth, then push it back in all the way. Remove it again, the engine.
Page 239 When to Add Engine Oil If the oil is at or below the ADD line, then you’ll need to add at least one quart of oil. But you must use the right kind. This part explains what kind of oil to use. For crankcase capacity, see “Capacities and Specifications”...
Page 240 The engine oil fill cap for the 3 100 engine is located on the front of the engine. Be sure to fill it enough to put the level somewhere in the proper operating range. Push the dipstick all the way back in when you’re through.
Page 241 What Kind of Engine Oil to Use RECOMMENDED SAL VISCOSITY GRADE ENGINE OILS Oils recommended for your vehicle can be identified by FOR BEST FUEL ECONOMY AND COW STARTING, SELECT THE LOWEST looking the “Starburst” symbol. This symbol SAE VISCOSITY GRADE OIL FOR THE EXPECTEO TEMPERATURE RANGE. indicates that the oil has been certified by the American (MI).
Page 242 Engine Oil Additives As shown in the chart, SAE 5W-30 is best for your S A E vehicle. However, you can use 1OW-30 if it’s going Don’t add anything to your oil. Your dealer is ready to to be 0°F C ) or above.
Page 243 Air Cleaner If none of them is true, use the long triphighway maintenance schedule. Change the oil and filter every 7,500 miles (12 500 or 12 months whichever occurs first. Driving a vehicle with a fully warmed engine under highway conditions causes engine oil to break down slower.
Page 244 See “Scheduled Maintenance Services” in the Index. transaxle fluid leak is the only reason for fluid loss. If a leak occurs, take the vehicle to your Chevrolet dealership Service Department and have it repaired as soon as possible. You may also have your fluid level checked by your dealer or service center when you have your oil changed.
Page 245 wilk A 50/50 mixture of water and DEX-COOL@ coolant NOTICE: Give freezing protection down to -34°F (-37’C). Give boiling protection up to 265 We recommend you use only fluid labeled Protect against rust and corrosion. DEXRON@-III, because fluid with that label is made especially for your automatic transaxle.
Page 246 What to Use NOTICE: Use a mixture of one-half clean water (preferably distilled) and one-half DEX-COOL@ coolant which I f you use an improper coolant mixture, your won’t damage aluminum parts. If you use this mixture, engine could overheat and be badly damaged. don’t need to add anything else.
Page 247 Checking Coolant Thrning the surge tank pressure cap when the engine and radiator are hot can allow steam and scalding liquids to blow out and burn you badly. Never turn the surge tank pressure cap even a little when the engine and radiator are hot. When your engine is cold, the coolant level should be at the FULL COLD mark or slightly higher.
Page 248 Adding Coolant Surge Tank Pressure Cap If you need more coolant, add the proper DEX-COOL' coolant mixture at the surge tank, but only when the NOTICE: engine is cool. Your pressure cap is an 15 psi (105 kPa) / A \ UTION: pressure-type cap and must be tightly installed to prevent coolant loss and possible engine damage...
Page 249 How To Check Power Steering Fluid Power Steering Fluid When the engine compartment is cool, wipe the cap and the top of the reservoir clean, then unscrew the cap and wipe the dipstick with a clean rag. Replace the cap and completely tighten it.
Page 250 Windshield Washer Fluid NOTICE: What to Use When using concentrated washer fluid, When you need windshield washer fluid, be sure to read follow the manufacturer’s instructions for the manufacturer’s instructions before use. If you will be operating your vehicle in an area where the temperature adding water.
Page 251 Brakes goes back up. The other reason is that fluid is leaking ou of the brake system. If it is, you should have your brake Brake Fluid later your system fixed, since a leak means that sooner brakes won’t work well, or won’t work at all. So, it isn’t a good idea to “top off’...
Page 252 What to Add When you do need brake fluid, use only DOT-3 brake P a r t fluid such as Delco Supreme 11 BRAKE No. 12377967). Use new brake fluid from a sealed container only. Always clean the brake fluid reservoir cap and the area around the cap before removing it.
Page 253 Brake Wear NOTICE: Your vehicle has front disc brakes and rear d r u m brakes. Disc brake pads have built-in wear indicators that make Using the wrong fluid can badly damage high-pitched warning sound when the brake pads are worn brake system parts.
Page 254 Some driving conditions or climates may cause a brake Brake Pedal Travel squeal when the brakes are first applied or lightly See your dealer if the brake pedal does not return to applied. This does not mean something is wrong with normal height, or if there is a rapid increase in pedal your brakes.
Page 255 Contact your dealer to learn how to prepare your vehicl for longer storage periods. Every new Chevrolet has an ACDelco Freedom@ Also, for your audio system, see “Theft-Deterrent battery. You never have to add water to one of these. Feature” in the Index.
Page 256 This section describes bulb changing procedures for some of your interior and exterior lamps. For bulb sizes, see “Replacement Bulbs” in the Index. For any bulbs not listed in this section, contact your Chevrolet dealer service department. Halogen Bulbs CAUTION Halogen bulbs have pressurized gas inside and can burst if you drop or scratch the bulb.
Page 257 Headlamp and Front n r n Signal Lamp Bulb Replacement 1. With the hood open and the engine off, pull the fastener out of the plastic splash shield covering the top of the headlamp assembly and remove it. 3. Remove the lamp assembly from the vehicle by pulling forward.
Page 258 7. Replace the lamp to its original position by carefully lining up the lamp to the mounting balls. 8. Press down on the two latches. Replace the splash shield by pushing down on the retainer. Center High-Mounted Stoplamp (CHMSL) 1. Open the trunk and locate the CHMSL housing on the underside of the rear window shelf.
Page 259 TaiYStopFIhrn SignaVBack-Up Lamps Rear Exterior Lamps 1. Unscrew the fastener located on the inside of the trunk at the rear of the vehicle. 2. Gently pull back the trunk trim. A. Back-up Lamp Taillamp/Stop Lamp T u r n C . Rear Signal Lamp 6-34...
Page 260 3. Remove the three plastic wingnuts. 4. Pull out the taillamp assembly to expose the backplate.
Page 261 Reverse the steps to reassemble the backplate and attach the taillamp assembly to the vehicle. Make sure that all four tabs of the backplate are securely fastened to the taillamp assembly before installing it on the vehicle. When securing the lamp assembly back into place, align the assembly so that the trunk lid doesn’t contact it.
Page 262 Your new vehicle comes with high-quality tires made by a leading tire manufacturer. If you ever have questions about your tire warranty and where to obtain service, see your Chevrolet Warranty booklet for details. CAUTION: Poorly maintained and improperly used tires are dangerous.
Page 263 NOTICE: tires are Overinflated more likely Don’t let anyone tell you that underinflation or cut, punctured broken by sudden overinflation is all right. It’s not. I f your tires impact such as when you hit a pothole. don’t have enough air (underinflation), you can Keep tires the recommended pressure.
Page 264 The purpose of regular rotation is to achieve more When to Check uniform wear for all tires on the vehicle. The first Check your tires once a month or more. rotation is the most important. See “Scheduled Don’t forget your compact spare tire. It should be at Maintenance Services”...
Page 265 After the tires have been rotated, adjust the front and rear When It’s Time for New Tires inflation pressures as shown on the Tire-Loading One way to tell when it’s Information label. Make certain that a l l wheel nuts are time for new tires is to ‘Wheel Nut Torque”...
Page 266 Buying New Tires To find out what kind and size of tires you need, look at the Tire-Loading Information label. Mixing tires could cause you to lose control while The tires installed on your vehicle when it was new had driving.
Page 267 Uniform Tire Quality Grading Treadwear The treadwear grade is a comparative rating based on The following information relates to the system the wear rate of the tire when tested under controlled developed by the United States National Highway conditions on a specified government test course. For Traffic Safety Administration, which grades tires by example, a tire graded 150 would wear one and a half treadwear, traction and temperature performance.
Page 268 Temperature A, B, C Wheel Alignment and Tire Balance The temperature grades are A (the highest), B, and C , The wheels on your vehicle were aligned and balanced representing the tire’s resistance to the generation of carefully at the factory to give you the longest tire life heat and its ability to dissipate heat when tested under and best overall performance.
Page 269 Chevrolet model. chain clearance to the body and chassis. See “Changing a Flat Tire” in the Index for more information.
Page 270 rire Chains and instructions. And always open your doors or windows when you’re cleaning the inside. Never use these to clean your vehicle: NOTICE: Gasoline Use tire chains only where legal and only when Benzene you must. Use only SAE Class “S” type chains Naphtha that are the proper size for your tires.
Page 271 Cleaning the Inside of Your Vehicle Using Multi-Purpose Interior Cleaner on Fabric Use a vacuum cleaner often to get rid of dust and loose dirt. Wipe vinyl or leather, plastic and painted surfaces Vacuum and brush the area to remove any loose with a clean, damp cloth.
Page 272 Special Fabric Cleaning Problems Cleaning Vinyl Use warm water and a clean cloth. Stains caused by such things as catsup, coffee (black), egg, fruit, fruit juice, milk, soft drinks, vomit, urine and Rub with a clean, damp cloth to remove dirt. You blood can be removed as follows: may have to do it more than once.
Page 273 Cleaning the Top of the Instrument Panel Cleaning Glass Surfaces Use only lnild soap and water to clean the top surfaces Glass should be cleaned often. GM Glass Cleaner (GM of the instrument panel. Sprays containing silicones or Part No. 1050427) or a liquid household glass cleaner waxes may cause annoying reflections in the windshield will remove normal tobacco smoke and dust films on and even make it difficult to see through the windshield...
Page 274 of the sun. Grime from the windshield will stick to the wiper blades Don’t wash your vehicle in the direct rays and affect their performance. Clean the blade by wiping Don’t use strong soaps or chemical detergents. Use soaked vigorously with a cloth in full-strength windshield liquid hand, dish or car washing (mild detergent) soaps.
Page 275 Exterior painted surfaces are subject to aging, weathe Your vehicle has a “basecoat/clearcoat” paint finish. and chemical fallout that can take their toll over a peri clearcoat gives more depth and gloss to the colored of years. You can help to keep the paint finish looking basecoat.
Page 276 Cleaning Tires Sheet Metal Damage To clean your tires, use a stiff brush with a tire cleaner. If your vehicle is damaged and requires sheet metal repair or replacement, make sure the body repair shop applies anti-corrosion material to the parts repaired or NOTICE: replaced to restore corrosion protection.
Page 277 At least every spring, flush these materials from the Although no defect in the paint job causes this, Chevrolet will repair, at no charge to the owner, the underbody with plain water. Clean any areas where surfaces of new vehicles damaged by this fallout and other debris can collect.
Page 278 Appearance Care Materials Chart PART NUMBER SIZE DESCRIPTION USAGE 994954 23 in. x 25 in. Polishing; Cloth Treated Exterior polishing cloth 1050172 emoves tar, road oil and asphalt (0.473 L) Tar and Road Oil Remover 1050173 Use on chrome, stainless steel, nickel, copper and brass (0.473 L) Chrome Cleaner and Polish...
Page 279 Engine Identification Vehicle Identification Number (VIN) The 8th character in your VIN is the engine code. This code will help you identify your engine, specifications and replacement parts. Service Parts Identification Label SAMPLE4UXWM072675 You’ll find this label on your spare tire cover. It’s very E N G I N E A 9 9 8 ASSEMBLY CODE...
Page 280 Headlamp Wiring Electrical System The headlamp wiring is protected by fuses, one for each Add-on Electrical Equipment headlamp, in the fuse block. An electrical overload will cause the lamps to turn off. If this happens, have your headlamp wiring checked right away. NOTICE: Windshield Wipers Don’t add anything electrical to your vehicle...
Page 281 Instrument Panel Fuse Block Fuses and Circuit Breakers The wiring circuits in your vehicle are protected from The instrument panel fuse short circuits by a combination of fuses, circuit breakers blocks are located at each and fusible thermal links in the wiring itself. end of the instrument panel.
Page 282 Instrument Panel Fuse Block Left Usage In the left instrument panel fuse block, there are spare Power Mirrors fuses and a fuse puller. Air Bag Body Function Control Module Powertrain Control Module B. WIPER MICRO C. TRUNK REURFA TRUNK REL TURN L P S Door Locks E.
Page 283 Instrument Panel Fuse Block Right Fuse Usage Instrument Panel Lights, Dimmer OTHER Cruise Control CAP FOR FUSE PUUER AND SPARE FUSES Climate Control System A. INST B. CRUISE Cruise Control HVAC BLOWER D. CRUISE FOG LPS F. INT LPS Fog Lamps G .
Page 284 Engine Comnartment Fuse Block Usage Fuse Maxi-Fuses The engine compartment fuse block is located on Ignition Switch the driver’s side of the engine compartment, near the air cleaner. Left Hand Electrical Center-Power Seats, Power Mirrors, Door Locks, Trunk Release and Remote Lock Control Left Hand Electrical Center-Stop Lamps, Hazard Lamps, Body...
Page 285 Fuse Usage Usage Fuse Right Hand Electrical Center-Fog Automatic Light Control Lamps, Radio, Body Function Control Horn Module, Interior Lamps Daytime Running Lamps Ignition Switch Mini-Fuses Not Used Spare Fuse Holder Anti-Lock Brakes Rear Defog Cooling Fans Accessory Power Outlets, Cigar Mini-Relays Lighter Defog...
Page 286 Replacement Bulbs Fuse Usage Parking Lamps Outside Lamps Bulb ....High-Beam Headlamp 9005 Rear Defog, Daytime Running Lamps, Climate Control System .
Page 287 Capacities and Specifications 2.4L Engine Specifications Engine Crankcase ......VIN Engine Code ....2.4L Engine 4 quarts (3.8 L) ........Type ....4.5 quarts (4.3 L) 3 100 Engine ......
Page 288 Normal Maintenance Vehicle Dimensions Replacement Parts ....Length 190.4 inches (483.7 cm) ....Width 69.4 inches (176.3 cm) Air Cleaner Element...
Page 289 NOTES...
Page 290 NOTES 6-65...
Page 291 NOTES 6-66...
Page 292 Section 7 Maintenance Schedule This section covers the maintenance required for your vehicle. Your vehicle needs these services to retain its safety, dependability and emission control performance. 7- 2 Introduction 7- 7 Short TripKity Maintenance Schedule How This Section is Organized 7- 21 Long TripMighway Maintenance Schedule 7- 4...
Page 293 Have you purchased the GM Protection Plan The Plan supplements your new vehicle warranties. See your Warranty and Owner Assistance booklet, or your Chevrolet dealer for details.
Page 294 “Part B: Owner Checks and Services” tells How This Section is Organized you what should be checked and when. It also explains five The remainder of this section is divided into parts: what you can easily do to help keep your vehicle in good condition.
Page 295 Part A: Scheduled Maintenance The proper fluids and lubricants to use are listed in P a r t D. Make sure whoever services your vehicle uses Services these. All parts should be replaced and a l l necessary repairs done before you or anyone else drives the vehic Using Your Maintenance Schedule These schedules are for vehicles that: We at General Motors want to help you keep your...
Page 296 Maintenance Schedule Short Trip/City Intervals Trip/City Short Definition Follow the Short TripKity Maintenance Schedule if any Every 3,000 Miles (5 000 km): Engine Oil and Filter Change (or 3 months, whichever occurs first). one of these conditions is true for your vehicle: Every 6,000 Miles (10 000 km): Tire Rotation.
Page 297 Maintenance Schedule Long Trip/HiPhwav Intervals Follow this maintenance schedule only if none of the Every 7,500 Miles (12 500 km): Engine Oil and Filter Change (or every 12 months, whichever occurs firs conditions from the Short Trip/City Maintenance Schedule is true. Do not use this schedule if the vehicle Tire Rotation.
Page 298 Short Trip/City Maintenance Schedule The services shown in this schedule up to 100,000 miles Footnotes (166 000 k m ) should be performed after 100,000 miles The U.S. Environmental Protection Agency or the (1 66 000 at the same intervals. The services shown California Air Resources Board has determined that the at 150,000 miles (240 000 k m )
Page 299 Short TripKity Maintenance Schedule 3,000 Miles (5 000 km) DATE Change engine oil and filter (or every 3 months, whichever occurs E‘ MILEAGE An Emission Control Service. 6,000 Miles (10 000 km) DATE Change engine oil and filter (or every 3 months, whichever occurs first). MILEAGE An Emission Control Service.
Page 300 Short TripKity Maintenance Schedule 12,000 Miles (20 000 km) DATE Change engine oil and filter (or every 3 months, whichever occurs first). ACTUAL SERVICED BY: MILEAGE An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information.
Page 301 Short TripKity Maintenance Schedule 21,000 Miles (35 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. 24,000 Miles (40 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). MILEAGE An Emission Control Service.
Page 302 Short TripKity Maintenance Schedule Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote”f) Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information.
Page 303 Short TripKity Maintenance Schedule 39,000 Miles (65 000 km) DATE Change engine oil and filter (or every 3 months, whichever occurs first). MILEAGE An Emission Control Service. 42,000 Miles (70 000 km) I T E Change engine oil and filter (or every 3 months, whichever occurs first). MILEAGE An Emission Control Service.
Page 304 Short TripKity Maintenance Schedule Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote 50,000 Miles (83 000 km) DATE Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside temperature regularly reaches 90°F C) or higher.
Page 305 Short TripKity Maintenance Schedule 54,000 Miles (90 000 km) DATE Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote 57,000 Miles (95 000 km) DATE Change engine oil and filter (or every 3 months, whichever occurs fist).
Page 306 Short TripKity Maintenance Schedule Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote?.) Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information.
Page 307 Short Trip/City Maintenance Schedule 72,000 Miles (120 000 km) DATE Change engine oil and filter (or every 3 months, whichever occurs first). ACTUAL SERVICED BY: MILEAGE An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information.
Page 308 Short Trip/City Maintenance Schedule 81,000 Miles (135 000 km) DATE Change engine oil and filter (or every 3 months, whichever occurs first). ACTUAL SERVICED BY: MILEAGE An Emission Control Service. 84,000 Miles (140 000 km) DATE Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
Page 309 Short TripKity Maintenance Schedule 000 km) (Continued) 90,000 Miles (150 Replace air cleaner fiiter. An Emission Control Service. Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote?.) Rotate tires.
Page 310 Short TripKity Maintenance Schedule 99,000 Miles (165 000 km) DATE Change engine oil and filter (or every 3 months, whichever occurs first). ACTUAL SERVICED BY: MILEAGE An Emission Control Service. 100,000 Miles (166 000 km) DATE Inspect spark plug wires (except 2.4L Code T engine). ACTUAL SERVICEDBY: MILEAGE...
Page 311 Short Trip/City Maintenance Schedule 150,000 Miles (240 000 km) DATE Drain, flush and refill cooling system (or every 60 months since last service, MILEAGE whichever occurs first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck.
Page 312 Long Tripmighway Maintenance Schedule The services shown in this schedule up to 100,000 miles Footnotes (166 000 k m ) should be performed after 100,000 miles The U.S. Environmental Protection Agency or the (166 000 at the same intervals. The services shown California Air Resources Board has determined that the at 150,000 miles (240 000 should be performed at...
Page 313 Long Tripmighway Maintenance Schedule 7,500 Miles (12 500 km) DATE CI Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote 15,000 Miles (25 000 km) DATE Change engine oil and filter (or every 12 months, whichever occurs first).
Page 314 Long Tripmighway Maintenance Schedule 30,000 Miles (50 000 km) DATE Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote Replace air cleaner filter.
Page 315 Long TripMighway Maintenance Schedule 45,000 Miles (75 000 km) DATE Change engine oil and filter (or every 12 months, whichever occurs first). MILEAGE An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote 50,000 Miles (83 000 km) DATE Change automatic transaxle fluid and filter if the vehicle is mainly driven...
Page 316 Long Trip/Highway Maintenance Schedule 60,000 Miles (100 000 km) Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote Inspect engine accessory drive belt.
Page 317 Long Trip/High& Maintenance Schedule 75,000 Miles (125 000 km) DATE Change engine oil and filter (or every 12 months, whichever occurs first). MILEAGE An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote 82,500 Miles (137 500 km) DATE Change engine oil and filter (or every 12 months, whichever occurs first).
Page 318 Long Tripmighway Maintenance Schedule 97,500 Miles (162 500 km) DATE Change engine oil and filter (or every 12 months, whichever occurs first). ACTUAL SERVICEDBY: MILEAGE An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information.
Page 319 Long Trip/Highway Maintenance Schedule 150,000 Miles (240 000 km) DATE Drain, flush and refill cooling system (or every 60 months since last service, whichever occurs first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap.
Page 320 Part B: Owner Checks and Services Engine Coolant Level Check Check the engine coolant level and add DEX-COOL@ Listed below are owner checks and services which coolant mixture if necessary. See “Engine Coolant” in should be performed at the intervals specified to help the Index for further details.
Page 321 At Least Twice a Year Automatic Transaxle Inspection Check the transaxle fluid level; add if needed. See Restraint System Check “Automatic Transaxle” in the Index. A fluid loss Make sure the safety belt reminder light and all your may indicate a problem. Check the system and repai belts, buckles, latch plates, retractors and anchorages are if needed.
Page 322 Brake-Transaxle Shift Interlock (BTSI) Check Starter Switcr :heck CAUTION: CAUTION: When you are doing this check, the vehicle could When you are doing this check, the vehicle could move suddenly. If it does, you or others could be move suddenly. If it does, you or others could be injured.
Page 323 Park on a fairly steep hill, with the vehicle facing Ignition Transaxle Lock Check downhill. Keeping your foot on the regular brake, set the try to tum While parked, and with the parking brake set, parking brake. the ignition key to OFF in each shift lever position. The key should turn only when the shift lever is in...
Page 324 Part C: Periodic Maintenance Exhaust System Inspection Inspections Inspect the complete exhaust system. Inspect the body near the exhaust system. Look for broken, damaged, Listed below are inspections and services which should missing or out-of-position parts as well as open seams, be performed at least twice a year (for instance, each holes, loose connections or other conditions which could spring and fall).
Page 325 Brake System Inspection Throttle System Inspection Inspect the complete system. Inspect brake lines and Inspect the throttle system for interference or binding, and for damaged or missing parts. Replace parts as hoses for proper hook-up, binding, leaks, cracks, needed. Replace any components that have high effort chafing, etc.
Page 326 Part D: Recommended Fluids USAGE FLUIDLUBRICANT and Lubricants Power Steering GM Power Steering Fluid (GM System 1 pint, NOTE: Fluids and lubricants identified below by name, Part No. 1052884 part number or specification may be obtained from 105001 7 1 quart, or equivalent). your dealer.
Page 327 Part E: Maintenance Record Services” or “Periodic Maintenance” can be added o After the scheduled services are performed, record the the following record pages. Also, you should retain all date, odometer reading and who performed the service in the boxes provided after the maintenance interval. maintenance receipts.
Page 328 Maintenance Record ODOMETER SERVICED BY MAINTENANCE PERFORMED DATE READING...
Page 329 Maintenance Record 7-38...
Page 330 Maintenance Record...
Page 331 Maintenance Record 7-40...
Page 332 Section 8 Customer Assistance Information Here you will find out how to contact Chevrolet if you need assistance. This section also tells you how to obtain service publications and how to report any safety defects. Customer Satisfaction Procedure 8- 10...
Page 333 Chevrolet dealers have the facilities, trained technicia Customer Satisfaction Procedure and up-to-date information to promptly address any concerns you may have. However, if a concern has no been resolved to your complete satisfaction, take the following steps: STEP ONE Discuss your concern with a member of dealership management.
Page 334 In the Dominican Republic: 1-800-751-4135 cannot be resolved by the dealership without further (English) or 1-800-75 1-41 36 (Spanish) help, contact the Chevrolet Customer Assistance In the Bahamas: 1-800-389-0009 Center by calling 1-800-222- 1020. In Canada, GM of contact Canada Customer Communication...
Page 335 We encourage you to call us so we can give your inquiry Assistance Center. Any TTY user can communicate with prompt attention. However, if you wish to write Chevrolet by dialing: 1-800-833-CHEV. (TTY users in Chevrolet, address your inquiry to: Canada can dial 1-800-263-3830.)
Page 336 To enhance Chevrolet’s strong commitment customer satisfaction, Chevrolet is excited to announce the establishment of the Chevrolet Roadside Assistance Center. As the owner of a 1998 Chevrolet, membership in Roadside Assistance is free.
Page 337 Plus: the Bumper to Bumper New Vehicle Limited Warrant FREE Non-Warranty Towing (to the closest dealer to eligible purchasers of 1998 Chevrolet passenger car from a legal roadway) and light duty trucks. (Please see your selling dealer for details...
Page 338 Please refer to the Roadside Assistance brochure For complete program details, see your Chevrolet dealer inside your owner information portfolio for full to obtain a Roadside Assistance Center brochure. program details. The Roadside Assistance Center uses companies that will provide you with quality and priority service. When...
Page 339 Courtesy Transportation Chevrolet Courtesy Transportation is not part of the Bumper to Bumper New Vehicle Limited Warranty Chevrolet offers Courtesy Transportation for customers Chevrolet reserves the right to make any changes needing warranty service. Courtesy Transportation will discontinue Courtesy Transportation at any time be offered in conjunction with the coverage provided by without notification.
Page 340 LINE BBB AUTO Both Chevrolet and your Chevrolet dealer are committed Council of Better Business Bureaus, Inc. to making sure you are completely satisfied with your new 4200 Wilson Boulevard vehicle. Our experience...
Page 341 General Motors. or in the courts. For further information, contact the BBB at 1-800-955-5100 or the Chevrolet Customer To contact NHTSA, you may either call the Auto Safety Assistance Center at 1-800-222- 1020. Hotline toll-free at 1-800-424-9393 (or 366-0123 in the Washington, D.C.
Page 342 In addition to notifying NHTSA (or Transport Canada) in a situation like this, we certainly hope you’ll notify us. Please call us at 1-800-222- 1020 or write: Chevrolet Motor Division Chevrolet Customer Assistance Center P.O. Box 7047 Troy, MI 48007-7047 8-11...
Page 343 1998 CHEVROLET SERVICE PUBLICATIONS ORDERING INFORMATIO The following publications covering the operation and servicing of your vehicle can be purchased by fil the Service Publication Order Form in this book and mailing it in with your check, mone or credit card information to Helm, Incorporated (address below.)
Page 344 Orders will be mailed within 1O.days of receipt. Please allow ade uate time for postal ORDER TOLL FREE service. If further information needed, write to the address s own below or call (NOTE: For Credit Card Holders Only) 1-800-782-4356. Material cannot be returned for credit without packing slip w 1-800-782-4356 information within 30 days of delivery.
Page 345 NOTES...
Page 346 Section 9 Index ............Appearancecare 6-45 Accessory Power Outlet 2-44 ......... Appearance Care Materials 6-53 Adding Equipment to Your Vehicle ............
Page 356 ........TopStrap 1-42 Transaxle ..............TorqueLock 2-24 Automatic 6-19 ........... Torque. Wheel Nut 5.29. 6.62 Ignition Lock Check 7-32 ....Towing Transmitters. Keyless Entry System .
Page 357 ............Windshield Washer 2-32 w a r n i n g Devices ..........Fluid 2.32.
Page 360 Crankcase (Engine Change) Filter 2.41 Enaine nelght...
Page 361 needs battery no wate See Page 6-30...

Chevrolet MALIBU 1998 Manual

Quick Links

Related Manuals for Chevrolet MALIBU 1998

Summary of Contents for Chevrolet MALIBU 1998

Table of Contents