Subscribe to Our Youtube Channel
Summary of Contents for Tomofree MEGA Series
- Page 1 MEGA Series Electric Dirt Bike Manual CONTACT YOUR DIRECT SELLER of your purchase for after-sale service Email: support@tomofree.com YouTube Video for Assembly & Official Website: tomofree.com Troubleshooting...
- Page 3 Thank you for choosing Tomofree Before you use your Tomofree it is important that you read this manual carefully. If there is anything you do not understand completely, please contact us. Please observe traffic regulations, and do not lend your e-bike/ scooter to anyone who is unfamiliar with it.
-
Page 4: Table Of Contents
CONTENTS IMPORTANT SAFETY NOTICE IMPORTANT SAFETY NOTICE...2 Read all warnings and instructions in this manual, as well as all safety labels, before operating your ebike. The MODEL M3 is a high-performance Overview...3 ebike and must be handled with extreme caution. Persons unwilling or unable to take responsibility for their actions should Specification...4 not use this motorcycle. -
Page 5: Overview
Overview Rear Wheel Front Wheel LCD Display Light Button Brake Level Brake Level Throttle Power ON/OFF Speed Switch Turn Signal Horn Button Switch Button Battery: 72V/30AH Seat Headlight Rear Light Front Fork Motor A- Total Length 68.5” Disc Brake B- Handlebar Height 44”... -
Page 6: Specification
Specification Model Suspensions Full Suspensions Adjustable X60 Aluminum Alloy Front Fork Motor Magnet Motor Front Fork with Travel Distance of 80mm-160mm Rear Shock Torque 120 N.m 100mm Travel Distance Battery Removable Li-ion Battery Headlight 2000 Lumens LED Light Voltage(V) Taillight Integrated Taillight Battery Capacity 30Ah... -
Page 7: Assembly
ASSEMBLY Step 3. Adjust and Secure the Bolts: Tighten the bolts on the handlebar stem, but do not fully tighten them yet, as you may need to fine-tune the angle. Test the positioning and adjust the handlebars to your preferred angle. Once you have determined the best position, completely tighten all the bolts on the stem. -
Page 8: Rear Shock Installation
◆ Rear Shock Installation Step 2. Loosen the Fork Bolts: Use a hex wrench to loosen the four hex bolts on both sides of the front fork. Step 1. Initial Setup: The rear shock is not pre-installed. Instead, a steel rod NOTE：Do not remove the bolts entirely—just loosen them. -
Page 9: Front Fender Installation
◆ Front Fender Installation ◆ Taillight Installation Put the screws through the bike frame and fender in order. Then install the Step 1. Mount the Taillight: Insert the bolts on the integrated taillight through washer and tighten the nut. the mounting holes at the rear of the bike.Once inserted hand-tighten the nuts from the inside, then use a wrench to securely tighten them. -
Page 10: Battery Installation And Removal
SAFETY ATTENTION AGAIN ◆ Battery Installation and Removal The battery comes pre-installed on your bike and features a quick-release ◆ Before Riding mechanism, allowing for easy removal for charging or direct charging while installed. • Ensure you understand all instructions, safety notes, and warnings. Battery Installation: •... -
Page 11: Safety Checklist
Safety Checklists Safety Check Basic Steps • Test both front and rear brakes to ensure proper function. • Ensure brake pads are not worn out and are correctly positioned in relation to the rims. Brakes • Make sure brake control cables are lubricated, properly adjusted, and show no signs of damage. •... -
Page 12: Operation
You can use the throttle and pedal assist simultaneously or ride the e-bike using only the throttle. The throttle control is located on the right-side handlebar. ◆ Pedal-Only Mode In this mode, the Tomofree ebike functions like a regular bicycle, requiring no Press and hold the POWER motor assistance. -
Page 13: Display
These faults will appear on the screen as error codes. The chart below explains the meaning of each error code. Contact your Direct Seller for Technical Support or email to support@tomofree.com with ORDER NUMBER Code Error Brake Lever Fault Throttle Fault Status Undervoltage Protection Status... -
Page 14: Troubleshooting
Unauthorized dismantling of the battery will void the three- For additional troubleshooting, please contact your direct Seller for support. pack policy and may result in battery heating, smoking, fire, or explosion. Or email us at: support@tomofree.com... -
Page 15: Maintenance
◆ Cleaning Instructions essential to safety. Improper handling can lead to a risk of fire. Never use a charger other than the one provided with your Tomofree ebike. Always charge the battery in a well-ventilated area, away from flammable materials. -
Page 16: Warranty
Warranty Time Warranty Scope At Tomofree, we take great pride in the quality and durability of our products. We are confident that you will be impressed as well, and we stand behind all of The battery shall be guaranteed for our products. -
Page 17: Warranty Exclusions
• Non-Warranty Work: Any additional repairs or replacements not covered by the BUYER has received the PRODUCT. the warranty will be subject to standard parts and labor fees. • Tomofree will not cover any third-party repairs or part replacements unless pre-approved. ◆ Shipping Damage Claims •... -
Page 18: Activate Warranty
ORDER NUMBER in email title. 3. Fill in the form 4. This is to Activate your Tomofree Official Warranty. If you do so, you don't need be worried of losing of Purchase proof and other materials needed for warranty.
Need help?
Do you have a question about the MEGA Series and is the answer not in the manual?
Questions and answers